Empire LS30TINF Quick start guide

�
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
— Do not store or use gasoline or other
ammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas supplier,
call the re department.
— Installation and service must be
performed by a qualied installer,
service agency or the gas supplier.
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
WARNING
If not installed, operated and maintained
in accordance with the manufacturer’s
instructions, this product could expose you
to substances in fuel or from fuel combustion
which can cause death or serious illness.
NOTICE: Ceramic logs may differ in appearance
from those shown in this manual.
LOG SET MODELS
LS30TINF
For Use With DVCT30CBN-1
Fireplace Inserts
GAS-FIRED
INSTALLATION INSTRUCTIONS
AND OWNER’S MANUAL

38105-0-0817Page 2
LOG IDENTIFICATION
PART
NO. DESCRIPTION DVCT30 LOG SET
FRONT TOP
38392
EMBER
BED
(A)
38393
REAR
LOG
(B)
38394
RIGHT
EMBER
CHUNK
(C)
38395
LEFT
EMBER
CHUNK
(D)
38396
RIGHT
LOG
(E)
38397
RIGHT
CENTER
LOG
(F)
38398
LEFT
CENTER
LOG
(G)

38105-0-0817 Page 3
LOG IDENTIFICATION
PART
NO. DESCRIPTION DVCT30 LOG SET
FRONT TOP
38399
LEFT
LOG
(H)
38400
LEFT
LOG
CHUNK
(I)
38401
TOP
CENTER
LOG
(J)
38402
CENTER
FRONT
EMBER
LOG
(K)
38403
LEFT
FRONT
EMBER
LOG
(L)
15496 Glowing
Embers
36747 Coals
(100)

38105-0-0817Page 4
NOTICE: Install liners before logs. See separate Liner Installation
manual for details.
CAUTION
This replace is supplied with a set of twelve ceramic
ber logs. Do not handle these logs with your bare hands.
Always wear gloves to prevent skin irritation from ceramic
bers. After handling the logs, wash your hands gently with
soap and water to remove any trace of bers.
Accessing the Interior of the Fireplace
See Homeowners Manual for instruction on how to remove the
barrier screen and glass door.
Log Set Installation
The positioning of the logs is critical to the safe and clean
operation of this replace. Sooting and other problems may result
if the logs are not properly and rmly positioned in the replace.
Please refer to (Figure 1) and the following WARNING when
completing log placement instructions. For step by step log
placement instructions, See Pages 5 - 17 or reference (Figure 2).
WARNING
Failure to position the parts in accordance with this diagram
or failure to use only parts specically approved with this
replace may result in property damage or personal injury.
Figure 1
A
B
C
D
E
F
G
H
I
J
K
L
Figure 2
Glowing Embers Information
1. Carefully separate the ember material into small amounts
(no larger than “quarter-size” pieces).
a. Fluffed up pieces of ember material one layer thick
will produce the best ember glow. Do not place more
than one layer of ember material onto the burner.
Excess ember material will decrease the ember
glow effect.
b. Save any remaining ember material for future
applications (as needed).
NOTICE: You may place logs A & B prior to adding glowing
embers on burners.
Figure 3
Coal Information
1. Coals may be placed along the front burner as shown in
Figure 4. Coals may not be placed over burner ports.
Figure 4
LOG AND EMBER PLACEMENT

38105-0-0817 Page 5
LOG AND EMBER PLACEMENT
TOP VIEW
FRONT VIEW
1. Place the large charred Ember Bed (A) onto burner base log assembly

38105-0-0817Page 6
LOG PLACEMENT
FRONT VIEW
TOP VIEW
2. Place Rear Log (B) onto burner pins as shown.

38105-0-0817 Page 7
LOG PLACEMENT
FRONT VIEW
TOP VIEW
3. Place Right Ember Chunk (C) on the front burner and onto pin on Ember Bed (A).

38105-0-0817Page 8
LOG PLACEMENT
TOP VIEW
FRONT VIEW
4. Place Left Ember Chunk (D) onto pin shown on Ember Bed (A).

38105-0-0817 Page 9
LOG PLACEMENT
5. Place Right Log (E) along wall as shown.
TOP VIEW
FRONT VIEW

38105-0-0817Page 10
LOG PLACEMENT
6. Place Log (F) on the right rear of the burner base. Align with the angle of the burner tube.