Empire LS35TINF Quick start guide

�
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
— Do not store or use gasoline or other
ammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas supplier,
call the re department.
— Installation and service must be
performed by a qualied installer,
service agency or the gas supplier.
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
WARNING
If not installed, operated and maintained
in accordance with the manufacturer’s
instructions, this product could expose you
to substances in fuel or from fuel combustion
which can cause death or serious illness.
NOTICE: Ceramic logs may differ in appearance
from those shown in this manual.
LOG SET MODEL
LS35TINF
For Use With DVCT35CBN-1
Fireplace Inserts
GAS-FIRED
INSTALLATION INSTRUCTIONS
AND OWNER’S MANUAL

38463-0-1117Page 2
LOG IDENTIFICATION
PART
NO. DESCRIPTION DVCT35 LOG SET
FRONT TOP
38450
EMBER
BED
(A)
38451
REAR
LOG
(B)
38452
LOWER
RIGHT
LOG
(C)
38453
RIGHT
LOG
(D)
38454
UPPER
RIGHT
LOG
(E)
38455
LOWER
LEFT
LOG
(F)
38456
LEFT
LOG
(G)

38463-0-1117 Page 3
LOG IDENTIFICATION
PART
NO. DESCRIPTION DVCT35 LOG SET
FRONT TOP
38457
UPPER
LEFT
LOG
(H)
38458
LEFT
CROSSOVER
LOG
(I)
38459
CENTER
LOG
(J)
38460
CENTER
CROSSOVER
LOG
(K)
38461
LEFT
FRONT
LOG
(L)
38462
RIGHT
FRONT
LOG
(M)
15496
GLOWING
EMBERS
PACKET
36747 COALS
(APPROX.100)

38463-0-1117Page 4
NOTICE: Install liners before logs. See separate Liner Installation
instructions for details.
CAUTION
Do not handle these logs with your bare hands. Always
wear gloves to prevent skin irritation from ceramic bers.
After handling the logs, wash your hands gently with soap
and water to remove any trace of bers.
Accessing the Interior of the Fireplace
See Installation Manual for instruction on how to remove the
barrier screen and glass door.
Log Set Installation
Proper positioning of the logs is critical to the safe and clean
operation of this replace. Improper log placement may cause
sooting and other problems in the replace. Please refer to
Figure 1 and the following warning to complete log placement.
For pin numbering see Figure 2. For step-by-step log placement
instructions, see pages 5 - 18.
WARNING
Failure to position the parts in accordance with this diagram
or failure to use only parts approved for this replace may
result in property damage or personal injury.
Figure 1
1
23
45
Figure 2
Glowing Embers Information
1. Carefully separate the ember material into small amounts
(no larger than “quarter-size” pieces).
a. Fluffed up pieces of ember material one layer thick
will produce the best ember glow. Do not place more
than one layer of ember material onto the burner.
Excess ember material will decrease the ember
glow effect.
b. Save any remaining ember material for future
applications (as needed).
NOTICE: You may place logs A & B prior to adding glowing
embers on burners.
Figure 3
Coal Information
1. Coals may be placed along the front burner (gray area) as
shown in Figure 4. Do not place coals over burner ports.
Figure 4
LOG AND EMBER PLACEMENT

38463-0-1117 Page 5
LOG AND EMBER PLACEMENT
1. Place Ember Bed (A) between burner using Pins 2 and 3 as shown. You may elect to place glowing embers along the back burner
at this time.
TOP VIEW
FRONT VIEW

38463-0-1117Page 6
LOG PLACEMENT
2. Place Rear Log (B) onto burner Pins 4 and 5 as shown.
TOP VIEW
FRONT VIEW

38463-0-1117 Page 7
LOG PLACEMENT
3. Place Lower Right Log (C) onto pin on Ember Bed (A) as shown.
TOP VIEW
FRONT VIEW

38463-0-1117Page 8
LOG PLACEMENT
4. Place Right Log (D) on right side of Rear Log (B) as shown.
TOP VIEW
FRONT VIEW

38463-0-1117 Page 9
LOG PLACEMENT
5. Place Upper Right Log onto pin in Lower Right Log (C) as shown.
TOP VIEW
FRONT VIEW

38463-0-1117Page 10
LOG PLACEMENT
6. Place Lower Left Log (F) onto pin in Ember Bed (A) as shown.
TOP VIEW
FRONT VIEW