Empire MILLIVOLT DVCP42BP30KN-4 User manual

Page 1
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
— Do not store or use gasoline or other
ammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch;
do not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier
from a neighbor’s phone. Follow
the gas supplier’s instructions.
• If you cannot reach your gas
supplier, call the re department.
— Installation and service must be
performed by a qualied installer,
service agency or the gas supplier.
HOT GLASS
DO NOT TOUCH
NEVER
WILL
CAUSE BURNS.
GLASS
UNTIL COOLED.
ALLOW CHILDREN
TO TOUCH GLASS.
WARNING
A barrier designed to reduce the risk of burns from the
hot viewing glass is provided with this appliance and shall
be installed for the protection of children and other at-risk
individuals.
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
state or local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless
a certied kit is used.
DIRECT VENT ZERO
CLEARANCE GAS FIREPLACE
HEATER SERIES MODELS:
MILLIVOLT (MV)
DVCP42BP30K(N,P)-4
INTERMITTENT PILOT (IP)
DVCP42BP70K(N,P)-4











GAS-FIRED

INSTALLATION INSTRUCTIONS

41354-0-0120
TABLE OF CONTENTS
SECTION PAGE
 
 4-5
 6
 7
 7
 
 9
 
 
 14
 15
 16
 17
 
 19
 19
 
 
 
 
 
 
 
 
 
 
 
 
 
 41
 
 
 44-45
 46
 47
 
 49
 
 
 54
 55-56
 57
 
 
 59

41354-0-0120 
ATTENTION INSTALLER:
Fireplace Installation Checklist
Use this checklist in conjunction with the instructions in this manual.
Customer: _____________________________________
Lot/Address: ___________________________________
_______________________________________________
Model: ________________________________________
Serial # ________________________________________
Date Installed: __________________________________
Fireplace Location: ______________________________
Installer: _______________________________________
Dealer Phone #: _________________________________
_______________________________________________
Empire recommends the following:
• 
• 
Comments: 
___________________________________________________________________________________________________________
 __________________________________________  ______________________
FIREPLACE INSTALLATION COMMENTS
 o____________________
 o____________________
VENTING/CHIMNEY HEAT DISTRIBUTION
 o____________________
 o____________________
 o____________________
 o____________________
 o____________________
 o____________________
ELECTRICAL (pgs. 19-21)
 o____________________
GAS (pgs. 17-18)
 o____________________
 oYes o No
 o____________________
FINISHING (pg. 24)
 o____________________
 o____________________
 o____________________
 o____________________
 o____________________
FIREPLACE SETUP
 o____________________
 o____________________
 o____________________
 o____________________
 o____________________

 o____________________
 o____________________

41354-0-0120Page 4
BEFORE YOU START











Sample Warnings and Denitions:
DANGER
Indicates a hazardous situation which, if not avoided, will
result in death or serious injury.
WARNING
Indicates a hazardous situation which, if not avoided,
could result in death or serious injury.
CAUTION
Indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.
NOTICE: 
____________________________________________________
Read all instructions before starting installation and
follow them carefully to ensure safety. Failure to follow
the instructions will void the warranty and may cause a
re hazard.


• 
• 
• 
• 

• 
• 



See Page 3.
Unpacking The Fireplace
 
 
 

 
 
Television Considerations

41354-0-0120 Page 5
BEFORE YOU START (CONT’D)
Accessories





Preparation





• 
• 

• 
 
 

 



• 



• 




Planning the installation



• 
(See Pages 31-38)




• (See pipe
size and specs on Page 17).
• 
 
• 
 (See Page 22)
• 


(See Page 24)


41354-0-0120Page 6
CARTON CONTENTS
123
4
LP
56
7
9
8
10
INDEX
NUMBER DESCRIPTION
QUANTITY SUPPLIED
DVCP42BP3
SERIES
DVCP42BP7
SERIES
1 1 1
  1
  1
4(See Page 30) 1 1
5  
6  
7  4
   1
9 4 4
See Parts Lists on pages 48 - 51

NOTICE:

41354-0-0120 Page 7
INTRODUCTION


Instructions to Installer
 
 

 
Notes to Installer
• 
 

 
• 





• 



• 
• 

WARNING
Any change to this replace can be dangerous. Improper
installation or use can cause serious injury or death from
re, burns, explosion or carbon monoxide poisoning.
Fireplace Certication











Qualied Installing Agency













High Altitude (USA)





High Altitude (CANADA)






41354-0-0120
SPECIFICATIONS
DVCP42NAT DVCP42LP
  
  
  
  
  
  
  
NOTICE:
       

GAS SUPPLY PRESSURES
GAS TYPE MAXIMUM MINIMUM MANIFOLD
   
   
Remote Control Options
And Accessories Description Models Used On
  
  
  
  
  

 
  
  
Venting Options Description
 
 
 
 
 
Conversion Kits Description Used On
  
  
  
  

41354-0-0120 Page 9
DVCP42 Description


 
 
 
 
 
REQUIRED
 (See Page 58)



ACCESSORIES

41354-0-0120
FIREPLACE DIMENSIONS
INDEX
LETTER DIMENSION DESCRIPTION DVCP42
(Inches)
  
B 
  
  
  
  
  
  
J 
  
L 
  
  
  
P 
  
  
G
I
J
C
GAS LINE
ACCESS
R
B
E
D
Q
VENT COLLAR
NAILING
FLANGES
BARRIER SCREEN ASSEMBLY
&
GLASS FRAME ASSEMBLY
GAS LINE
ACCESS
RATING PLATE AND
LABELS INSIDE
GAS CONTROL AND
SWITCHES INSIDE
A
K
L
LEFT VIEW
FRONT VIEW
TOPVIEW
RIGHT VIEW
P
M
GAS LINE
ACCESS
N
O
SIDE STANDOFF
TOPSTANDOFF