Everlast 16805990380 User manual

CustomerService1-888-707--1880 DyacoCanadaInc.2018
OWNER’S
MANUAL
MODEL NO.
16805990380
Assembly
Adjustments
Parts
Warranty
CAUTION
You must read and
understand this
owner’s manual
before operating
unit.
FITNESS TRAMPOLINE

CustomerService1-888-707--1880 DyacoCanadaInc.2018
SAFETY PRECAUTIONS
Thank you for purchasing our product. Even though we go to great efforts to ensure the quality
of each product we produce, occasional errors and/or omissions do occur. In any event should
you find this product to have either a defective or a missing part please contact us for a replacement.
This product has been designed for home use only. Product liability and guarantee conditions
will not be applicable to products being subjected to professional use or products being
used in a gym centre.
This exercise equipment was designed and built for optimum safety. However, certain
precautions apply whenever you operate a piece of exercise equipment. Be sure to read
the entire manual before assembly and operation of this product. Also, please note the
following safety precautions:
1. Read the OWNER’S OPERATING MANUAL and all accompanying literature and
follow it carefully before using your mini trampoline.
2. It is the responsibility of the owner to ensure that all users of this equipment are informed of all
precautions.
3. If dizziness, nausea, chest pains, or any other abnormal symptoms are experienced while
using this equipment, STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Inspect your exercise equipment prior to exercising to ensure that the legs are tightened, all
springs are securely attached to the frame and mat and the cover is installed before each use.
5. The mini trampoline must be regularly checked for signs of wear and damage. Any part found
defective, the part must be replaced with new spare part from the manufacturer.
6. Fitness equipment must always be installed on a flat surface, do not place the unit on a loose
rug or uneven surface. This will help prevent the unit from moving while it is being used, which
could possibly scratch or damage the surface of your floor.
7. No changes must be made which might compromise the safety of the equipment.
8. It is recommended to have a minimum of 1’ safe clearance around the exercise equipment
while in use. Never allow more than one person on the mini trampoline at a time.
9. Keep children and pets away from this equipment at all times while exercising.
10. Warm up 5 to 10 minutes before each workout and cool down 5 to 10 minutes afterward.
This allows your heart rate to gradually increase and decrease and will help prevent you from strainin
g
muscles.
11. Never hold your breath while exercising. Breathing should remain at a normal rate in
conjunction with the level of exercise being performed
12. Always wear suitable clothing and footwear while exercising. Do not wear loose fitting clothing
that could become entangled with the moving parts of your mini stepper.
13. Step on and off the mini trampoline. Do not jump on or off the mini trampoline.
14. Never use the mini trampoline as a springboard to other objects.
15. Secure the mini trampoline against unauthorized use and unsupervised use.
16. Do not use the mini trampoline while under the influence of alcohol or drugs.
17. User weight should not exceed 198 lbs.
WARNING: Before beginning any exercise program consult your physician.
This isespecially important for individuals over the age of 35 or persons with pre-
existing health problems. Read all instructions before using any fitness
equipment. We assume no responsibility form personal injury or property
damage sustained by or through the use of this product.

CustomerService1-888-707--1880 DyacoCanadaInc.2018
Prior to assembling
Please refer to the parts list for part descriptions and numbers. The assembly steps use these
descriptions and numbers as reference for your convenience.
Make sure that you have all parts listed. If you find any missing or defective parts, please call our
customer service number at 1-888-707-1880 toll free to obtain the needed parts.
Note: It takes two people to assemble the mini trampoline.
PARTS LIST
Key
Number Part number Description Quantity
1 9903801
Trampoline Mat, stitched with 15 V-
Rin
g
s1
2 9903802 Safety Pad 1
3 9903803 Top Rail with leg socket 5
4 9903804 Leg w/ rubber foot 5
5 9903805 Spring 30
6 9903806 New Spring loading tool 1
Step 1
All parts with the same part number are interchangeable and have no “right” or “left” orientation.
To connect the parts, simply slide a section of tubing that is smaller on one end into the adjacent
section that has a larger opening. These joints are called “connector points”. Lay out all parts
according to the diagram.
Push top rail pieces together as shown in the diagram below.
Note: Ensure that the slots for the springs are facing up.
1

CustomerService1-888-707--1880 DyacoCanadaInc.2018
STEP 2
Lay out the trampoline mat inside the frame.
There are 15 v-rings on the mat that line up with 30 corresponding slots on the top rail frame. For
every v-ring you will attach two springs. Select an arbitrary point on the top rail frame. Attach one
spring to one v-ring and to one slot on the top rail. Skipping one slot, continue to attach one spring
to every v-ring until you have completed 15 springs. Attach a second spring to a v-ring and to the
corresponding skipped slot. Continue this method until every slot on the frame has a spring and
every v ring has two springs.
SPRING LOADING INSTRUCTION
1. Use the special spring loading tool included.
2. Hold and align spring so the hook of the spring lines up with hole on the steel frame.
3. Hold spring loading tool underhand and push spring hook towards V-Ring as shown, drop hook into
V-Ring until it latches on completely.
Note: The tension applied by the springs will hold the trampoline rail together.

CustomerService1-888-707--1880 DyacoCanadaInc.2018
STEP 3
The safety pad is equipped with five holes to correspond with the leg sockets on the top rail.
Line up one hole of the safety pad to one of the leg sockets. Pull the safety pad over the frame to
cover the top rail and the springs.
Continue to cover the top rail frame ensuring that the holes from the safety pad slips over each of the
remaining leg sockets.

CustomerService1-888-707--1880 DyacoCanadaInc.2018
STEP 4
Attach the leg with rubber foot to each of the leg sockets.
Your fitness trampoline is now fully assembled.

CustomerService1-888-707--1880 DyacoCanadaInc.2018
LIMITED WARRANTY
Dyaco Canada Inc. warrants this unit, to the original purchaser, to be free from defects in material
and workmanship for the period of time listed below. Warranty time begins at the time of purchase.
Normal wear and user’s abuse are not covered in the warranty. Weather damage and other such acts
of nature are not covered by the Manufacturer’s warranty. Commercial use and/or transfer of
ownership voids the warranty.
Frame 1 Year
Mat Fabric 1 Year
Springs 90 days
Safety Pad 90 days
For warranty service contact our Customer Service Dept.:
1-888-707-1880 (toll free)
Monday-Friday
8:30 A.M. to 5:00 P.M.
Eastern Standard Time
LIABILITY
While every attempt is made to embody the highest degree of safety in all equipment we cannot,
however, guarantee freedom from injury. The user assumes all risk of injury due to use. All
merchandise is sold on this condition, that no representative of the Company can waive or change.
This equipment is intended for residential use only. This equipment is not to be used in places of
public assembly such as schools, nurseries, day care centre, churches and parks. Dyaco Canada Inc.
cannot assume any liability for such use. Any commercial, institutional or public use of this equipment
will void the warranty.
SP-17-16805990380-DY-18001

Please visit us online for information about our other brands and products manufactured and
distributed by Dyaco Canada Inc.