Fleetwood Pace Arrow 2005 User manual

.... ~.: ;:rFLEElWOOD.
Driven to Explore
©2004 by Fleetwood Enterprises, Inc. All rights reserved. No part of this publicatiou may be reproduced or
transmitted in any [onn or by any means, electronic or mechanical, including photocopying, recording, 01' by any
infonnation storage or retrieval system without written pennission from Fleetwood Enterprises.
Inc.
Manufacturing subsidiaries of Fleetwood Enteq)rises, Inc. build the following motor homes, travel trailers and truck campers:
Pace Arrow. Southwind • Stann. Bounder. Bounder Diesel. Discovery. Excursion· Providence· Flair· Fiesta· Terra· Tioga
Jamboree. American Eagle· American 'Heritage. American Tradition. Expedition· Revolution· Pioneer· Prowler· Teny •
Wilderness. Mallard. Park Trailer. Plide • Triumph. Elkhorn. Gearbox

NTR0DUCTION ..................... .01-1
Inspect and Maintain ................... 01-2
Planning and Preparation ................ 01-2
Owner's Information Package
............ 01-2
Chassis and Vehicle Identification
........ 01-3
Suspension Alignment and Tire Balance
.... 01-3
After-Market Steeling Aid Devices
........ 01-4
Warnings, Terms and Concepts for
Safe Operation
of Your Motor Home .... 01-4
Event Data Recording Device
(If Equipped)
....................... 01-6
WARRANTY ....... .- ................. .02-1
Coverage Provided ........... : ........ 02-1
Owner's Obligations
................... 02-1
Dealer's Obligations
................... 02-1
When the Dealer Does Not
Resolve the Problem
................. 02-1
Manufacturer's Obligations
.............. 02-1
What
is Not Covered by This Warranty .... 02-2
Warranties
........................... 02-3
Warranty Service
...................... 02-4-
Reporting Safety Defects. __ . _. ___ . __ .. _.02-4
IMPORTANT NOTICES ............... .03-1
PACE ARROW INFORMATION ........ .04-1
Lamps and Bulbs ...................... 04-1
Driver's Controls
...................... 04-2
Hood Latch
...... _ ................... 04-4
ON THE ROAD . ...................... .05-1
Motor Home Loading ............... _ .. 05-1
Responsibilityfor Proper Loading
...... 05-1
Some Definitions First . ............... 05-1
Towing a Vehicle or Trailer .
........... 05-2
Cargo Carrying Capacity Label
........ 05-3
Cargo Carrying Capacity and Load
Distribution
...................... 05-4
How to Weigh
Your Loaded Motor Home .05-4
Dangers
of Overloading .............. 05-6
1
----
---
TABLE OF CONTENTS
Loading Tips ....................... 05-6
Tires
................................ 05-7
Tire Inflation ....................... 05-7
Air Pressure
........................ 05-8
Underinflation
...................... 05-8
Air Pressure Check
.................. 05-8
Tire Replacement .................... 05-9
If You Get a Flat Tire . ................ 05-9
Changing a Flat Tire "
............... 05-9
Seats, Seat Belts and Air Bags
(IfEquipped)
....................... 05-9
Air Bag Supplemental Restraint
System (SRS) .................... 05-10
Combination Lap and Shoulder Belts " .05-10
Safety BeltMaintenance ............. 05-10
Safety Restraintsfor Children ......... 05-10
Safety Beltsfor Children ............. 05-11
Child Seat Tethers
.................. 05-11
Driving and Vehicle Control
............ 05-12
Using the Engine
to Slow the
Motor Home .
.................... 05-12
Maneuvering in Traffic
................ 05-12
Rear View Video Monitor (If Equipped)
... 05-13
Body Undercoating
................... 05-14
Fuel and Fuel Systems
................. 05-14
Safe Refueling Guidelines ............ 05-14
Fuel Types and Driveability Issues
..... 05-15
API Refueling Advisory ............... 05-15
Engine Fan
...... " .................. 05-16
Exhaust System Heat
.................. 05-16
Engine Temperature Gauges
............ 05-16
Carbon Monoxide Safety Precautions
..... 05-16
Carbon Monoxide Detector/Alarm
..... 05-17
Emergency Towing
................... 05-17
LIVING WITH YOUR MOTOR HOME
... 06-1
Leveling System (If Equipped) ., ......... 06-1
Power Entry Step (IfEquipped) .......... 06-1
Entry and Screen Doors
................. 06-1
Patio Awning (If Equipped) .............. 06-1
00-1

Table of Contents
Windows ............................ 06-2
Emergency Exit Window(s) ............ 06-2
Remote Mirror Control (IfEquipped) ...... 06-2
Sun Visors (If Equipped) ............... 06-2
Window Shades (If Equipped) ........... 06-2
Day/Night Shades (If Equipped) ....... .06-3
Mini-Blinds .......................... 06-3
Storage .............................. 06-3
Exterior Compartments . .............. 06-3
Interior Storage ..................... 06-4
Slide-Out Rooms (If Equipped) ......... .06-4
Interior and Furnishings ................ 06-4
Dinette Conversion (with Built-in Table) . .06-4
Dinette Conversion
(with Free-Standing Table)
........... 06-5
Sofa Conversion (If Equipped) ......... 06-5
Sleeper Sofa Conversion (If Equipped) ... 06-5
Folding Doors/Privacy Curtain
Dividers '" ...................... 06-5
Folding Chairs (If Equipped) .......... 06-5
Free-Standing Furniture (If Equipped) .. .06-5
Interior Lighting .................... 06-6
Overhead Vents ..................... 06-6
Monitor Panel ........................ 06-6
Effects of Permanent Occupancy ......... 06-7
Condensation and How to Control It .. , .06-7
Dripping Ceiling Vents ............... 06-9
Important Information ................. .06-9
What the RV Owner Can Do .......... 06-10
Fire Safety .......................... 06-10
Fire Safety Precautions .............. 06-11
Smoke Detector/Alarm . .............. 06-12
PLUMBING SYSTEMS
AND HOLDING TANKS ............... 07-1
Fresh Water System .................... 07-1
External Fresh Water Hookup . ......... 07-1
Filling the On-Board Water Tank ...... .07-1
Draining the Fresh Water Tank . ........ 07-2
Water Pump . ....................... 07-2
Water Pump Filter . ................. .07-2
Low Point Drains ................... 07-3
00-2
Troubleshooting the Fresh Water System •.07-3
Leaks
............................. 07-3
Sanitizing the Fresh Water System ...... 07-3
Exterior Shower (If Equipped) ...... : .. 07-4
Whole Coach Water Filter System
(If Equipped) ..................... 07-4
Waste Water System ................... 01-4
Toilet ......................•...... 07-4
Draining the Holding Tanks ............ 07-5
Black Tank Flush System (If Equipped) .. 07-6
Holding Tank Care .................. 07-6
Cold Weather Usage .. ... , ........... 07-7
ELECTRICAL SySTEMS ............... 08·1
Chassis 12- Volt Electrical System ... , ..... 08-1
Chassis Bulbs and Fuses .............. 08-1
Fleetwood 12- Volt House and Automotive
System
................ , .,',' .....• .. Q8-1
Batteries ........................... 08-1
Battery Disconnect (If Equipped) ....... 08-1
Battery Inspection and Care ........... 08-2
Battery Charging .................... 08-2
Solar Panel (If Equipped) ............. 08-3
Selecting a Replacement Battery ....... .08-3
Auxiliary Start System (If Equipped) ..... 08-3
120-
Volt System ...................... 08-3
Power Converter .......................... 08-4
Ground Fault Circuit Interrupter (GFCI) .08-4
Generator (If Equipped) .............. 08-4
Generator Fuel Supply ............... 08-5
LP Generator (If Equipped) ........... 08-5
Generator Operations ................ 08-5
Generator Operating Safety Precautions .. 08-5
Energy Management System 50 AMP ..... 08-6
Electrical Wiring Diagrams .............. 08-6
Motor Home Fuses and Circuit Breakers ... 08-6
LP GAS SySTEM ...................... 09·1
LP Gas Safety Precautions .............. 09-1
System Components ................... 09-2
Hoses . ......... , ...... , ........... 09-2
LP Gas Regulator ................... 09-2
Accessory LP Gas Supply ............. 09-2

Using LP Gas System at Low
Temperatures
....................... 09-3
Filling LP Gas Tanks ................... 09-3
LP Gas System Check .................. 09-3
LP Gas Leak Detector/Alarm ............ 09-3
Lighting LP Gas Appliances ............. 09-4
.PPLIANCES ........................ .10-1
Water Heater ........................ .1 0-1
Water Heater Bypass Valve ........... .10-1
Refrigerator ......................... .10-1
Furnace .............................1 0-1
Range .............................. .10-2
Range Exhaust Hood .................. .1 0-2
Air Conditioner(s) (If Equipped) ......... .10-2
Additional 12- Volt Equipment .......... .10-3
Video Equipment ......... : ........... .10-3
Video Control Center ................... 10-3
TV Antenna ......................... .10-3
Antenna Operating Instructions ........... 10-3
Satellite Dish Antenna (If Equipped) ..... .10-4
Telephone Jack ....................... 10-4
Microwave Oven
(If Equipped) ......... .10-4
WasherlDryer-Ready Option ............. 10-4
Miscellaneous Appliances .............. .10-4
VlAINTENAN CE ...................... .11-1
Exterior ............................. 11-1
Stains . ............................ 1l-1
Exterior Graphics Care . .............. 11-2
Windows, Doors, Vents and Locks . ...... 11-2
TPO Roof System .................... .11-2
Table of Contents
Cleaning . .......................... 1l-2
Care . ............................. 1l-2
Sealant Renewal .................... 11-2
Door, Window, Roof Component
and Molding Resealing
............. 1l-3
Acrylic Assist Handles (If Equiped) ...... .11-3
Interior
.............................. 1l-3
Fabrics ............................ 11-3
Solid Surface Top Care (If Equipped) '" .1l-4
Laminate Top Care (If Equipped) ....... 11-4
Walls and Ceiling Panels . ............. 1l-4
Attaching Accessories to Your
Motor Home .
..................... 1l-4
Plastic/Fiberglass Shower Stall . ........ 1l-4
Floors and Carpeting ................ 1l-4
Wood Floor (If Equipped) ............ .11-4
Engine Access ...................... 11-5
Exterior Sealants ..................... .11-5
Generator Filters
..................... .11-5
Trailer Hitch Connector Wiring .......... .11-5
Maintenance Guideline
................. 11-6
STORAGE ........................... .12-1
Storage Checklists .................... .12-1
Short-Term Storage (Less than 60 days) .. 12-1
Long-Term Storage (Over 60 days) ..... 12-2
Winterization ........................ .12-2
Water System Winterizing ............ .12-3
Reactivating the Motor Home
After Storage
...................... .12-4
GLOSSARY .......................... .13-1
00-3
I
t----
I

This. page intentionally blank.

Welcome to the recreational vehicle life-style
and the growing family
of motor home owners.
We sincerely thank you for choosing a
Fleetwood motor home!
.1'1
NOTE 1
This manual describes many features of your RVand
includes some instructions for its safe
use. This man-
ual, including photographs andillustrations, is of a gen-
eral nature only. Some equipment and features
described
or shown in this manual may be optional or
because of the continuous program of productchange
conducted by Fleetwood, it is possible that recent
product changes may not be included.
NOTE J
Throughout this manual the term "RV" represents a
"Recreational Vehicle" as defined by the NFPA
11921ANSI A 119.2 code. This includes motor homes,
fifth wheel trailers, travel trailers, camping trailers,
recreational park trailers, and truck campers.
Your motor home has been designed to provide
you with years
of carefree, pleasant traveling
and vacationing.
It confOlIDs with, or exceeds,
applicable American National Standards
Institute (ANSI), National Fire Protection
Association (NFPA), Canadian Standards
Association (CSA) (units built for Canada only),
Federal Motor Vehicle Safety Standards
(FMVSS), Environmental Protection Agency
(EPA) and California Air Resources Board
(CARE) regulations. The seal attached just out-
side the entry door indicates compliance with
ANSIor CSA standards.
INTRODUCTION
Like all equipment, your motor home will require
care and regular maintenance in order to deliver
maximum value and performance. The dealer will
give you basic operating and maintenance instruc-
tions. However, supplement this by reading all
instmctional material(s) furnished with the motor
home in the Owner's Inforlllation Package and
the motor home Chassis Operator's!
Owner's Guide!Manual. This information out-
lines impOitant areas
of operation and mainte-
nance for you to follow for safe, trouble-free serv-
ice from your motor home. Study these materials
carefully. A good working knowledge
of your
motor home and how to care for it will help you
enjoy many miles and years
of recreational living.
Please pay close attention to these statements
while you read this Owner's Manual.
In this manual, statements preceded by the fol-
lowing words are
of special significance:
A WARNING
indicates a potentially hazardous situation which, if
not avoided, could result in death or serious injuty.
A CAUTION
indicates a potentially hazardous situation which,
if not avoided, may result in minor or moderate
lllJury.
CAUTION
indicates a potentially hazardous situation
which, if not avoided, may result in damage to
the component or vehicle.
.1'1 NOTE
indicates points of particular interest for more
efficient and convenient operation.
01-1
1-----
~

Introduction
If you have any questions regarding operation,
maintenance, or service, please contact your
dealer immediately so he can assist you. Your
dealer's Service or Sales Department will han-
dle any normal problems which might occur.
Some equipment and features described or
shown in this manual may be optional
or not
available on some models.
Because of the continuous program of product
improvement conducted by Fleetwood, it is pos-
sible that recent product changes may not be
included in this manual. Specifications may
change without notice. Product information,
illustrations and photography included in this
Owner's Manual were as accurate as possible at
the time
of publication, and are representative of
function and mayor may not be specific in their
depiction
of actual equipment, fabrics, interior
or exterior decor or design options as installed
on or in your recreational vehicle.
The instructions included in this manual are
intended
as a guide, and in no respect extend the
responsibilities
of the manufacturing subsidiary,
parent company or affiliates beyond the stan-
dard written warranty
as presented in this man-
ual.
Fleetwood has designed its recreational vehicles
to provide a variety
of uses for its customers.
Each vehicle features optimal seating, sleeping,
storage and fluid capacities. The user
is respon-
sible for selecting the proper combination
of
loads to ensure that the recreational vehicle's
capacities are not exceeded.
INSPECT AND MAINTAIN
Follow a consistent schedule of inspection and
maintenance for your motor home. Your contin-
uing safety and comfort depend on it. This man-
ual includes a section outlining maintenance
intervals.
If you follow the maintenance guide-
lines, you will minimize the possibility of fail-
ure
of any important system or part of your
motor home.
01-2
PLANNING AND PREPARATION
Each year millions of Americans embark on
trips using some type of recreational vehicle.
Proper planning
of your trip will ensure a pleas-
urable experience. A thorough knowledge
of
your RV is important if you are going to get the
most out
of the convenience and safety items
built into your motor home. Be
as familiar with
it
as you are with your personal car or truck. If
you have trouble or have questions, please con-
sult your dealer.
OWNER'S INFORMATION
PACKAGE
This package contains valuable documents about
your motor home and its equipment and systems.
This Owner's Manual and the Chassis
Operator's Manual are in the package. Since this
manual does not cover every possible detail
of
equipment and options installed on or in your
motor home, there are booklets and instructional
material in the package that will help you safely
operate, maintain and troubleshoot those items.
Be sure you readallthis information and
undersmndthe safety and operating instructions
inclndedin the paclmge. Additionally, you must
follow all maintenance instructions to insure full
wan'anty coverage.
If you decide to sell or trade
your motor home, be sure the new owner
receives all the material in this package.
./1 NOTE I
Ifyour Owner's Information Package does not con-
tain these
items, even if you purchased your motor
home
"used," please call or write Fleetwood and
request
the desired ormissing information.
Fleetwood
Motor Home Service
P.O. Box 59933
Riverside,
CA 92517
[phone]

CHASSIS AND VEHICLE
IDENTIFICATION
Several numbers are used to identify the vehicle
andcomponents used on the vehicle.
The V.I.N.
or Vehicle Identification Number is
assigned by the chassis manufacturer and is the
number used for vehicle registration. The V.lN.
is found on the Federal Certification Tag attached
in the driver's compartment. Refer to this infor-
mation when ordering parts from the chassis
manufacturer or chassis dealer service center.
The F.I.N.
or Fleetwood Identification Number
is located on the tag justoutside the main entty
door or on the outside left front side
of the motor
home. Use this number when ordering parts
through your Fleetwood dealer or Service Center.
(Example)
FEDERAL CERTIFICATION TAG
MFDBY:
DATE MFD:
INC VEH MFD BY:
DATE OF VEH MFD:
GVWR: KGS ( LBS)
FRONTGAWR:
KGS ( LBS)
WITH:
RIMS
TIRES AT: KPA COLO SINGLE
( PSI)
INTERMEDIATE
KGS ( LBS)
GAWR: WITH: RIMS
TIRES AT:
KPA COLD DUAL
(
PSI)
GAWR REAR: KGS ( LBS)
WITH:
RIMS
TIRES AT: KPA COLD SINGLE
(
PSI)
GAWR COMBINED
INTERMEDIATE
AND REAR: KGS ( LBS)
This vehicle conforms to all applicable U.S. Federal Motor
Vehicle Safety Standards in effect on the date of manufacture
shown above:
V.i.N.
TYPE VEHICLE: MULTI·PURPOSE PASSENGER VEHICLE
The tires and wheels with sizes and ratings designated above
have been equipped with this vehicle by Fleetwood. Any
replacement tires installed must me!)t the same specifications
and minimum load requirements.
W15·0016
Located in the driver's compartment.
Introduction
SUSPENSION ALIGNMENT
AND TIRE BALANCE
The front suspension and steering system of this
vehicle was accurately aligned at the factory
before delivery to the dealership. However, after
you have fully loaded the vehicle according to
your personal needs, have the alignment
checked and adjusted,
if necessary. To help pre-
vent uneven tire wear, check the front-end align-
ment periodically.
Please note thatfront-end alignmentafter
retail delivery is the owner's responsibility and
is notcovered under the warranty.
(Example)
FLEETWOOD.
MOTOR HOMES
OF
PLAN APPROVAL NO.
- F.i.N.
MFD.ID. NO.
DATE OF MFA. MO:
INC.
MODEL
YR:
Located on the exterior left front side
of the motor home.
-F.I.N. (Fleetwood Identification No.)
01-3
1--
~

Introduction
Excessive or abnormal tire wear may indicate
worn or misaligned suspension or steering com-
ponents, unbalanced or improperly inflated
tire(s)
or some other tire/suspension problem.
Alignment can be affected by worn steering/sus-
pension parts or road hazards such as hitting a
curb, pothole, railroad track, etc. Improper
alignment can cause tires to roll at an angle and
wear unevenly.
It may also cause the vehicle to
"pull" to the right or left.
Out-of-balance tires will not roll smoothly and
will cause annoying vibrations and uneven tread
wear such as cupping
or flat spots. If you see
uneven tire tread wear
or if the vehicle ride
comfort decreases, the tires may need to be
balanced.
See the Chassis Operator's/Owner's Guide/
Manual for more information.
AFTER-MARKET STEERING AID
DEVICES
Fleetwood does not sanction or condone the
installation
of any steering aid device that is not
approved by our chassis manufacturer's. Any
add-on device of this type may void the chassis
manufacturer's warranty on the item or items
affected.
WARNINGS, TERMS AND
CONCEPTS FOR SAFE
OPERATION OF YOUR MOTOR
HOME
Vehicle Crash
01-4
Like any other vehicle you may drive, your
motor home can be involved in a vehicle
crash, including a rollover. The motor home
will be damaged and you and others can be
injured or killed. Drive defensively at all
times. DO
NOT drive ifyou are tired, have
been drinking alcoholic beverages, are under
the influence
of any controlled substance, or
are taking any medication or
dlUgS that may
impair your sight, hearing, judgment or coor-
dination. Pull offthe road and park in a safe
area until you can drive safely.
Vehicle Handling
Your motor home is longer, wider and
higher than a typical car or tlUck you may
be accustomed to driving. Keep this in
mind as you become familiar with driving
your motor home. New motor home own-
ers shol.lld take special care to learn the
driving and handling characteristics
of your
vehicle in safe and familiar
sUiTOundings.
The distribution of the weight of your
motor home is designed so it will handle
safely while being driven.
• When loading the motor home, balance
the loadfront-to-rear
and side-to-side.
• Load and secure heavier items lower in
the storage areas than lighter items.
If you fail to properly load your belongings and
supplies, you will defeat the load distribution
design of the motor home, possibly leading to
handling problems and a vehicle crash.
Vehicle Response
When you, the driver, accelerate, brake or
steer the motor home, it responds to these
inputs.
If you are faced with an emergency
while driving, the way you respond to the
emergency and the way the motor home
responds becomes more critical.
If you
load, alter or maintain your motor home
improperly, it will not respond as it did
when you first received it in an unloaded
condition. Improper loading, alteration,
mainteuance
and improper driver
responses
to emergency conditions can
leadto handling
proble11ls and vehicle
crashes.
Vehicle Towing
Your motor home can be equipped with a
hitch designed to allow you to tow vehicles
1---
}-------