Flight Display Systems FD151CV-LP User manual

FD151CV-LP
Installation and Operation Manual
15.1” Low Prole LCD
TECHNICAL SUPPORT
678-867-6717, or
www.FlightDisplay.com
All manuals and user guides at all-guides.com
all-guides.com

!
Revision!D,!November!2008!
FD151CV-LP
15.1" Low Profile LCD
© 2006 Flight Display Systems. All Rights Reserved.
Flight Display Systems
1765 Grassland Parkway
Alpharetta, GA 30004
678-867-6717 Phone
678-867-6742 Fax
[email protected]
www.flightdisplay.com
For the most current copy of all product manuals, please visit our website at
www.flightdisplay.com
All manuals and user guides at all-guides.com

!
!
Revision!D,!November!2008!
Table of Contents
General Information!
Front View......................................................................................................1!
Additional Information ................................................................................1!
Specifications..................................................................................................... 2!
Installation Instructions!
Power ..............................................................................................................2!
Video Wiring Suggestions .............................................................................. 3!
S-Video/Composite and Audio Wiring..................................................... 3!
VGA Wiring ...................................................................................................4!
Power and Ground Wiring ..........................................................................5!
Pinout for High Density DB-15......................................................................6!
Wiring Diagram.............................................................................................6!
Operation Instructions!
Button Controls ................................................................................................. 7!
Remote Control.................................................................................................. 8!
Troubleshooting!
Video Noise........................................................................................................ 9!
VGA Shadowing............................................................................................9!
Snow or Sweeping Lines .............................................................................. 9!
No power to Monitor, or No video Input .....................................................9!
Color Distortion ................................................................................................ 10!
Remote Control Inoperable............................................................................. 10!
Technical Support!
Instructions for Continued Airworthiness!
Warranty Information ...................................................................................... 11!
Assembly Drawing ........................................................................................... 12!
Index!
Log of Revisions................................................................................................15!
All manuals and user guides at all-guides.com

FD151CV-LP! ! General!Information!
!
1!
Revision!D,!November!2008!
General Information
The FD151CV-LP is a 15.1" Low Profile LCD which has features that allow
installation in the smallest of mounting areas with the minimum of interface
equipment. Built with retrofit aircraft integration in mind, this display can switch
between three video input sources using an infrared remote.
Front View
Additional Information
The FD151CV-LP utilizes a state of the art digital video decoding chipset for the
analog video input. The video sources in order of picture quality are VGA
(computer graphics like moving maps), and Composite Video (DVD, camera or
VCR). Both NTSC and PAL formats are auto-detected.
The FD151CV-LP can also be connected to existing video switchers and just
take a composite video input from a selector interface box. In this case multiple
input sources can be selected and displayed on the monitor. You would only
use the IR remote to set up the screen during installation.
The FD151CV-LP is made of all metal components. DO-160D testing has been
completed and is available upon request.
The LCD is protected with a .060” Lexan lens. The purpose of this lens is to
prevent scratching of the LCD.
All manuals and user guides at all-guides.com

2!
Revision!D,!November!2008!
Specifications
Display Type
15” TFT Color LCD
Display Color
16.7 Million Colors
Pixel Pitch
0.3 mm x 0.3 mm
Screen Resolution
VGA 1024 x 768
Brightness
400 cd/m²
Dimensions
14.14”(W) x 11.95”(H) x 1.1”(D)
Display Size
11.89”(W) x 8.91”(H)
Weight
5 lbs 14 oz
Power
28VDC @ 1.5 AMPS
PC & Video Input
One High Density DB-15 Connector
Video Type Supported
VGA, Composite NTSC/PAL
Screen control
On Screen Display Menu
Remote Control
IR
Materials
Aluminum
DO-160E testing
Section 21 Category B
Installation Instructions
All cabin entertainment equipment, such as the FD151CV-LP, should be
installed on a non-essential bus and have a dedicated circuit breaker. It is a
requirement that a switch be installed in the cockpit so that the pilot can de-
energize the entertainment system should it become necessary.
For mounting specifications refer to drawing at the back of the manual.
(NOTE: Removing the front cover does not void the warranty.)
Power
This is a 28VDC monitor that requires 1.5 Amps (42 Watts) of power to operate.
The unit turns on automatically upon power application.
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
3!
Revision!D,!November!2008!
Video Wiring Suggestions
All shields should be grounded to the connector at the source, and floating at the
display.
Avoid routing video wiring parallel to:
•AC wiring
•Strobe wiring
•DC motor supply cables
•Inverter cabling
•Or any other potential noise source.
S-Video/Composite and Audio Wiring
Recommended cable for s-video/composite and audio purposes is PIC 75 Ohm
Coax, P/N V75268. This is a lightweight, flexible, and low signal loss cable which
meets FAA flammability requirements of FAR 23.1359(d), FAR 25.853(a) and
FAR 25.869(a)(4).
Similar aviation coaxial cable can be used from other vendors, as well.
Some aircraft are prone to AC noise - we recommend adding to the composite
source a 75Ohm video isolation transformer such as Deerfield Laboratory, Inc.
Part No. 162-1 (www.deerfieldlab.com, [phone]). In most cases this
should be added to the video output of the source.
All manuals and user guides at all-guides.com
all-guides.com

4!
Revision!D,!November!2008!
VGA Wiring
Recommended cable for VGA purpose is ECS P/N 453005. This is a single
shielded cable containing 5 separate coaxial cables, color-coded to match the
functions of the wires.
We recommend coax cables be terminated using solder sleeve coaxial cable
terminators such as Raychem Part Number CWT-4174-W122-5/9.
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
5!
Revision!D,!November!2008!
Power and Ground Wiring
This is a 28VDC monitor that requires 1.5 amps of power to operate. To operate properly
this monitor requires an input voltage of 18-29VDC.
The rated current of the equipment and associated voltage drop should be taken into
consideration when selecting wire gauge. The following example is based on an install with
a 28VDC power system and a total of 50 feet of wire between the circuit breaker, monitor
and ground.
Example: 22awg wire has 16.2 Ohms per 1000 feet, this equates to .81 Ohms for 50 feet.
1.5 Amps of current on .81 Ohms will drop 1.22 Volts.
Resistance of Wire Type M22759/16-**
(** = Gauge)
Gauge (AWG)
OHMS/1000’
24
26.20
22
16.20
20
9.88
16
4.81
12
2.02
10
1.26
8
.701
Also, use short heavy gauge wire and a clean tight connection for ground.
It is the installer's responsibility to understand the product's requirements to install the
product in compliance with industry standards and safety.
All manuals and user guides at all-guides.com

6!
Revision!D,!November!2008!
Pinout for High Density DB-15
There is one High Density DB-15 on the rear of the display, which connects
Power, Composite Video #1, Composite Video #2 and VGA connections.
Part Numbers for DB-15 connectors, manufactured by Tyco or Amp.
High density, D-sub, 15 contact receptacle (female) P/N 748565-1
HD15F pins P/N M39029/57-354
Wiring Diagram
Pin Number
Description
1
28VDC Power
2
28VDC Ground
3
Composite Video 1 - Signal
4
Composite Video 1 - Shield
5
Composite Video 2 - Signal
6
Composite Video 2 - Shield
7
N/C
8
N/C
9
Red Video (Pin 1 on Standard VGA)
10
Green Video (Pin 2 on Standard VGA)
11
Blue Video (Pin 3 on Standard VGA)
12
Red Ground (Pin 6 on Standard VGA)
13
Green Ground (Pin 7 on Standard VGA)
14
Horizontal Sync (Pin 13 on Standard VGA)
15
Vertical Sync (Pin 14 on Standard VGA)
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
7!
Revision!D,!November!2008!
Operation Instructions
The FD151CV-LP is continuously on but can be de-energized by removing
power from the entertainment system. No pilot or aircrew action is necessary
during flight or ground operation.
The passengers will be able to change the video output from the FD151CV-LP
using the video source select button on the display, or remotely throughout the
cabin with the included IR remote. Point the IR remote at the top of the LCD to
make changes.
When applying 28VDC power, the display will turn on and look for a valid input
on the last known source. If no input is found, the display will go to standby
mode. Pressing the Select button will select new video input.
Button Controls
Located on the bottom of the FD151CV-LP are 5 buttons.
From right to left (fan inwards), the functions are as follows:
BUTTON
DESCRIPTION
POWER
Pressing will turn the monitor ON or OFF from Standby
mode.
SOURCE
Select video source with the following order: Composite
1, Composite 2 and RGB (PC).
UP
Press while in menu- Adjust selection UP.
Press out of menu - Brightness (Use up or down to
change.)
DOWN
Press while in menu- Adjust selection DOWN.
Press out of menu – Contrast (Use up or down to
change.)
MENU
Opens the menu, changes between selections.
All manuals and user guides at all-guides.com

8!
Revision!D,!November!2008!
Remote Control
The remote control included with the FD151CV-LP contains the same
functionality available on the display buttons, to include power, source, menu,
and directional arrows.
All manuals and user guides at all-guides.com
all-guides.com

FD151CV-LP! ! !
9!
Revision!D,!November!2008!
Troubleshooting
Video Noise
Check for an incorrect ground in the installation wiring. See specific examples of
video noise below, or visit http://flightdisplay.com/Grounding.pdf
VGA Shadowing
Most of shadowing problems are due to shielding on the wire. Locate the point
where all of the shields are connected. Cut away the shields, one at a time, while
viewing the display on the screen to observe which shield is causing the noise.
Cutting away one shield at a time will allow you to focus and isolate the video
noise issue.
•Twisted pair wiring is prone to video noise. ECS VGA Wire (Detailed
under “Video Wiring Suggestions”) is recommended.
Snow or Sweeping Lines
Lines that slowly sweep up and down are a result of AC noise. This AC noise
can be generated by a power cart on the aircraft. Take the power cart off of the
aircraft. Be careful of inverter wiring, which can also cause noise. Stand off the
wires, if necessary.
If snow or sweeping lines persist, it is possible that the ground is at an incorrect
point in the aircraft. Try moving the ground to another location.
No power to Monitor, or No video Input
•Verify correct wiring. Check the base receptacle connectors for possibly
damaged pins.
•Check that the video source is:
1. Powered on,
2. In Play mode, and
3. Displaying video.
All manuals and user guides at all-guides.com

10!
Revision!D,!November!2008!
Color Distortion
•Adjust brightness and contrast settings using the buttons on the monitor.
Remote Control Inoperable
•Confirm that the infrared eye on the LCD screen is visible.
•Replace battery in remote control.
Technical Support
Should you have any questions concerning this product or other Flight Display
Systems products, please contact our Product Support representatives at (678)
867-6717.
Flight Display Systems
1765 Grassland Parkway
Alpharetta, GA 30004
Phone: [phone]
Fax: [phone]
Email: [email protected]
For further product information, technical data and sample wiring diagrams,
please click on the Dealers section of our web site at www.flightdisplay.com
Instructions for Continued Airworthiness
The FD151CV-LP is designed not to require regular general maintenance.
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
11!
Revision!D,!November!2008!
Warranty Information
Flight Display Systems warrants the FD151CV-LP against material or
manufacturing defects for a period of one year from the date of installation.
If product support is required, please call our Technical Support team at 678-
867-6717 to obtain assistance. If the return of the unit to the factory is required,
an RMA number will be issued at that time. Flight Display Systems will, upon
receipt of the failed hardware, remanufacture or replace the unit at our
discretion.
Flight Display Systems will pay Ground Shipping charges for warranted items.
Charges for express shipment will be the responsibility of the sender.
This warranty is not transferable. Any implied warranties expire at the expiration
date of this warranty. We shall not be liable for incidental or consequential
damages.
This warranty does not cover a defect or failure that has resulted from improper
or unreasonable installation, use or maintenance, as determined by Flight
Display Systems. This warranty is void if there is any attempt to disassemble or
open this product without factory authorization.
Any labour charges associated with the removal of product or related
troubleshooting by a firm other than Flight Display Systems or its designee will
not be covered.
All manuals and user guides at all-guides.com

12!
Revision!D,!November!2008!
Assembly Drawing
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
13!
Revision!D,!November!2008!
All manuals and user guides at all-guides.com
all-guides.com

14!
Revision!D,!November!2008!
Index
Button Controls .................................7
Coaxial Cable..................................... 3
Color Distortion ..............................10
Continued Airworthiness.............. 10
DB-15 ..................................................6
DO-160E .........................................1, 2
Flammability......................................3
Lexan................................................... 1
Noise ................................................... 9
Power.............................................. 2, 9
Remote Control .................................8
Shadowing ......................................... 9
Shields ............................................3, 9
Support......................................... 9, 10
VGA .................................................... 4
Warranty .......................................... 11
Weight ................................................ 2
Wiring................................................. 3
Diagram.............................................. 5
Power and Ground ........................... 5
Wiring Diagram ................................ 6
All manuals and user guides at all-guides.com

FD151CV-LP! ! !
15!
Revision!D,!November!2008!
Log of Revisions
Rev
Date
Page
Description
A
01/25/2007
---
---
B
05/21/2007
7
Added remote control information.
C
03/05/2008
6
Changed button order.
D
11/26/2008
---
Updated VGA, Power & Ground, Pinout and Assembly
drawings
All manuals and user guides at all-guides.com