Flybar 1752490 User manual

12V RIDE ON BUMPER CAR
ITEM #1752490
YEARS
ATTENTION
This product is packed with the battery
disconnected. Connect the battery before use.
ATTENTION
Adult asssembly required.
WARNING
This manual contains important safety and
use information. Keep this manual forfuture
reference.
• An adult must read this entire manual
• Adult supervision is required at all times
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 1Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 1 7/13/23 10:35 AM7/13/23 10:35 AM

IMPORTANT SAFETY INFORMATION
DANGER (ELECTRICAL HAZARD)
* To prevent electric shock, do not immerse in water; wipe clean with a damp cloth.
WARNING
PREVENT FIRE
• Never modify the electrical system. Alterations could cause a re resulting in
serious injury and could also ruin the electrical system.
• Use of the wrong type of battery or charger could cause a re or explosion resulting
in serious injury.
• Use of Flybar® components in products other than Flybar® vehicles could cause
overheating, re or explosion.
• The battery must be handled by adults only. The battery is heavy and contains
sulfuric acid (electrolyte). Dropping the battery could result in serious injury.
• Never allow children to charge the battery. Battery charging must be done by adults
only. A child could be injured by the electricity involved in charging the battery.
• Never lift or carry the battery by the wires or connector. This can damage the battery
and possibly cause a re resulting in serious injury. Lift and carry the battery by the
case only.
• Read the safety instructions on the battery.
• Examine the battery, charger and their connectors for excessive wear or damage
each time you charge the battery. If damage or excessive wear is detected, do not use
the charger or the battery until you have replaced the worn or damaged part.
• Hot motors. Handle carefully.
WARNING
PREVENT INJURIES AND DEATHS
• Direct adult supervision required
• Never ride at night
• Keep children within safe riding areas.
These areas must be:
- Away from swimming pools and other bodies of water to prevent drownings
- Generally level to prevent tip overs
- Away from steps, steep inclines, cars, roads and alleys
Riding rules:
Make sure children know and follow these rules for safe driving and riding.
- Always sit on the seat
- Always wear shoes.
- Only 1 (one) rider at a time
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 2Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 2 7/13/23 10:35 AM7/13/23 10:35 AM

SAFETY INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USE
• To protect against electrical shock, do not immerse charger/transformer, battery or
the product in water or other liquid. Do not use outside if raining or snowing.
• Only use the included charging adapter provided.
• This toy is not intended for children less than 18 months.
• Adult supervision is necessary when your children are using this product.
• Disconnect the battery if this toy won’t be used for a long time.
• Personal protective equipment such as a helmet is needed when using this toy.
• Do not use this toy on a public road, by a swimming pool or near any stairs.
• Do not use this toy on a slippery surface, sand or mud.
• Always keep hands, hair and clothing away from moving parts.
• Maximum weight of child is 66 lbs / 30 kg.
• Only one child should ride on this toy at a time.
• Do not change, modify or add any electrical wiring on this toy.
• Do not use this toy in the dark. Only operate during daytime or well lit areas.
• For your child’s safety, please make sure to fasten the seat belt when using this toy.
PRODUCT SPECIFICATIONS
Motor:
2 @ 15 Watts
Battery:
2 @ 6 Volts DC, 4 Ah
Charger:
14.5 Volts 500 Ma
Max Speed:
1.7 mph (2.8 km/h)
Suitable Age:
18 Months to 4 Years
Maximum user weight:
66 Lbs (30 Kg)
Dimensions:
25.7” x 25.7” x 15.7”
Battery charge time:
8-12 hours (maximum charge time: 20 hours)
*ATTENTION: Battery is partially charged upon purchase.
You must fully charge battery before use.
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 3 7/13/23 10:35 AM

PARTS AND FEATURES
1. Bumper car body
2. Seat cover
3. Seat belt
4. Control Joysticks
5.
6. Charging port
7. Charger
8. Remote
1
2
4
5
6
7
8
3
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 4 7/13/23 10:35 AM

USER INSTRUCTIONS
BEFORE USE
• Remove the two screws from the seat cover and lift out the cover.
• Connect the battery terminal. You must connect the same color wires together: black
connector to the black terminal, red terminal to the red connector. Make sure they are
connected with the correct polarity.
• Replace the seat cover with the two screws and tighten.
CHARGING THE BATTERY
• Plug the charger into a standard 120v wall outlet and the
wire end into the charger port.
• Fully charge the battery for 8-12 hours.
• Do not charge the battery for more than 12 hours.
• Check the battery and charger for any signs of wear or damage
before use and do not use if damaged.
OPERATING THE VEHICLE
• Press the power switch down or up to turn the vehicle on. Note, down position (-) is
low speed. Upward postion (=) is high speed.
• Bumper car is equiped with slow start function for safety. When starting out bumper
car will take 4 seconds to get up to full speed.
• Push or pull the control joysticks to move the vehicle
• Release both control joysticks to stop the vehicle completely
WARNING: Close supervision is required when child is operating the vehicle.
Power On/O/Speed switch
High-speed
Low Speed
Charging
port
O
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 5Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 5 7/13/23 10:35 AM7/13/23 10:35 AM

REMOTE CONTROL
REMOTE FUNCTIONS
CONNECTING REMOTE TO BUMPER CAR
1. When batteries are inserted the remote is active and the indicator light will blink
constantly. Turn bumper car power switch on. The remote will connect to bumper car
automatically. When connected the remote indicator light will pause and stay on, then
continue to blink again.
SPEED REGULATION
2. Press the (M) speed regulation button on the remote to control three bumper cars
-
the speed.
Three Speeds:
Low: .9 mph (1.5 km/h)
Medium: 1.2 mph (2 km/h)
High: 1.7 mph (2.8 (km/h)
CONTROL
3. When using the remote control the riders manual use of the driving
joysticks on bumper car will override the remote control function. Once
driver stops using driving joysticks remote control function will resume.
WARNING!: Only use remote when bumper car is visible to human eye.
Forward
Reverse
Left
Brake
Speed Regulation
M P
Right
Speed
indicator
light
NOTE: Batteries not included. Please unscrew battery compartment on backside of
remote and insert qty 2 (AAA) batteries.
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 6 7/13/23 10:35 AM

CARE AND MAINTENANCE
• Check for any broken or cracked plastic parts.
plastic to a shine. Do not use abrasive cleaners.
• Do not wash the toy with a hose or immerse any parts in water.
TROUBLESHOOTING
PROBLEM POSSIBLE REASON SOLUTION
Fuse protection Replace with a new fuse
connected battery
Reconnect the battery
Contact customer service
Old battery Replace battery if
necessary
Old battery Replace battery if
necessary
harsh environment harsh environment
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 7 7/13/23 10:35 AM
Always purchase the correct size and grade of battery most suitable for the intended use.
Replace all batteries of a set at the same time.
Clean the battery contacts and also those of the device prior to battery installation.
Ensure the batteries are installed correctly with regard to polarity (+ and -).
Remove batteries from equipment that is not to be used for an extended period of time.
Remove used batteries promptly.
Always replace the whole set of batteries at one time, taking care not to mix old and new
ones or batteries of different types. When batteries of different brand or type are used
together, or new and old batteries are used together, some batteries may be over
-discharged due to a difference of voltage or capacity. This can result in venting, leakage,
and rupture and may cause personal injury.

PROBLEM POSSIBLE REASON SOLUTION
Vehicle needs a push
to go forward
Poor wire connection
Check if the battery
connectors are rmly con-
nected. Contact customer
service if necessary
“Dead spot” on motor Contact customer service
Loud grinding sound or
clicking sound fro the
motor or gear box
Damaged motor or
gear box Contact customer service
Battery does not charge
Disconnected / badly
connected charger Reconnect the battery
Disconnected / badly
connected charger
Make sure the charger
is rmly plugged into the
power source and
connected to the
charging port
Charger not working Contact customer service
Charger feels warm with
charging Normal
FCC INFORMATION
WARNING
Any changes or modications to this unit not expressly approved by the party respon-
sible for compliance could void the user’s authority to operate the equipment.
NOTE
This equipment has been tested and found to comply with the limits for a Class B
digital device, pursuant to part 15 of the FCC Rules. These limits are designed to
provide reasonable protection against harmful interference in a residential installation.
This equipment generates, uses and can radiate radio frequency energy and, if not
installed and used in accordance with instructions may cause harmful interference
to radio communications. However, there is no guarantee that interference will not
occur in a particular installation. If this equipment does cause harmful interference to
radio or television reception, which can be determined by turning the equipment o
and on, the user is encouraged to try to correct the interference by one or more of the
following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit dierent from that to which
the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 8Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 8 7/13/23 10:35 AM7/13/23 10:35 AM

LIMITED WARRANTY TERMS
One Year Limited Warranty on 12-Volt Bumper Car Ride-on product
Six-Month limited warranty on battery
Flybar, Inc. warrants this product to the original retail purchaser as follows: The ride-on
product (except for the battery) is warranted against defective materials or workman-
ship for one year from the date of original purchase. The battery is warranted against
defective materials or workmanship for six months from the date of original purchase.
An original receipt is required to validate your warranty. Flybar, Inc. will, at its option,
provide replacement parts or replace this product. Flybar, Inc. reserves the right to
substitute if the part or model has been discontinued. To make a claim under this
warranty you must contact us directly. Proof of purchase is required, and shipping/
transportation charges are the responsibility of the consumer.
What does this Limited Warranty cover?
This Warranty covers all parts of the electric ride-on toy to be free from defects in
workmanship and materials. This Warranty is only eective if:
• The ride-on toy is used under normal conditions for its intended purposes,
by a person that properly ts and is capable of controlling the vehicle.
• The ride-on toy receives all necessary maintenance and adjustments.
What is not covered by this Limited Warranty?
This Warranty does not include labor and transportation charges. You, the original
purchaser will be responsible for labor or transportation charges associated with the
repair or replacement of any parts found to be eligible for warranty coverage. This
Warranty does not cover any damage caused by crash, collision, misuse, abuse, ne-
glect, improper assembly, improper maintenance, lack of maintenance, alteration, or
any similar damage to the ride-on toy. For personal use only. Not for commercial use.
This Warranty will be void if the ride-on product is ever:
• Installed with a motor or modied in any other way.
• Used in a manner contrary to the instructions in the manual included
with this product.
• Flybar, Inc. will not be liable for incidental or consequential loss or damage,
due directly or indirectly from use of this product.
How do you make a claim under this Limited Warranty?
Warranty claims should be submitted via Flybar’s online portal at www.ybar.com/
pages/contact-us or via email at info@ybar.com. Please have your proof of purchase
available before calling to validate your claim.
Limitation of Damages:
The warranty and remedies as set forth are exclusive and in lieu of all others, oral or
written, expressed or implied. In no event will Flybar, Inc. or the dealer selling this
product be liable to you for any damages, including incidental or consequential dam-
ages, arising out of the use or inability to use this product. Some states do not allow
limitations as the exclusion or limitation of incidental or consequential damages, so
the above limitation may not apply to you.
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 9Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 9 7/13/23 10:35 AM7/13/23 10:35 AM

Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 11Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 11 7/13/23 10:35 AM7/13/23 10:35 AM

SHOP FLYBAR.COM
INSTAGRAM: @FLYBARINC
FACEBOOK: @FLYBAR
PINTEREST: @FLYBAR,INC
LET’S CONNECT!
FOR ANY QUESTIONS, REPLACEMENT PARTS, OR ISSUES, PLEASE CONTACT:
FLYBAR CUSTOMER SUPPORT
Email: info@ybar.com Phone: [phone]
www.ybar.com
CONFORMS TO CPSC AND ASTM F963 SAFETY REQUIREMENTS.
COLORS AND CONTENTS MAY VARY FROM ILLUSTRATIONS
FLYBAR, INC.
PISCATAWAY, NJ 08854
MADE IN CHINA ©2023 FLYBAR, INC.
Distributed by:
Costco Wholesale Corporation
P.O. Box 34535
Seattle, WA 98124-1535
USA
1-800-774-2678
www.costco.com
Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 12Flybar_V1_12V_Bumper_car_manual_Costco_USA.indd 12 7/13/23 10:35 AM7/13/23 10:35 AM