Frico Thermowarm TWT100 (IP44) User manual

Thermowarm TWT/TWTC
.... 4
EN .... 6 SE
Original instructions
.... 8
NO .... 10 DE ....12 FR
.... 14
NL ....16
FI .... 18 ES .... 20 RU .... 22 PL

Thermowarm TWT
2
TWT
Minimum distances
+
_20°C
0°C
35°C
__
min 50 min 10 0min 300
min 70
Thermostat TWTC
205
345/465/765
123
PR 18,6
47
242/362/662
150

Thermowarm TWT
3
Thermowarm TWT100 (IP44)
Thermowarm TWTC (IP54)
Item no Type Output
[W]
Voltage
[V]
Length
[mm]
Weight
[kg]
11396 TWTC30521 500 230V~ 465 2,0
11398 TWTC31021 1000 230V~ 765 3,0
Wiring diagram
Item no Type Output
[W]
Voltage
[V]
Length
[mm]
Weight
[kg]
6982 TWT10521 500 230V~ 465 2,0
6987 TWT11021 1000 230V~ 765 3,0
1234
abc d
L
230V
N
L
230V
N
TWT TWTC

Thermowarm TWT
4
EN
Installation and operating instructions
General Instructions
Read these instructions carefully prior to
installation and use. Keep this manual for
future reference.
The product may only be used as set out in
the assembly and operating instructions. The
guarantee is only valid should the product be used
in the manner intended and in accordance with
the instructions.
Application
Thermowarm TWT is a series of easily installed
convectors designed for heating installations
of a more technical nature such as offshore,
service areas, utility rooms and vehicles. TWTC
can also be used in corrosive and aggressive
environments.
Enclosure class TWT: IP44, TWTC: IP54.
Mounting
The appliance is supplied with a pre-installed
wall bracket for attaching horizontally to the
wall using four screws. There is a template
for placing the screws on the bottom of the
carton. Stick a sharp instrument through the
marks on the carton to mark where to place
the screws. The top two holes are “keyholes”.
See the dimensions on the introductory pages.
For minimum distance, see diagrams on
introductory pages.
Connection
TWT100 is designed for permanent installation.
The installation, which should be preceded by
an isolator switch with a contact separation
of at least 3 mm, should only be wired by a
competent electrician and in accordance with
the latest edition of IEE wiring regulations.
TWTC is equipped with a cord and plug for
connection to earthed outlet sockets.
Replacement of cable
If the cable is damaged the unit must be sent to
Frico for replacement. Contact Frico Technical
Support.
Start-up
When the unit is used for the rst time or after
a long period of non-use, smoke or an odour
may result from dust or dirt which has collected
on the element. This is completely normal and
disappears after a short time.
Maintenance
In all electrical heating appliances, small
clicks can occur due to movement when the
material expands and contracts with changes in
temperature.
As the components are maintenance-free, no
maintenance other than cleaning is necessary.
The frequency of cleaning can vary depending
on local conditions, although it should be at
least twice a year. Grilles and elements can
be vacuum cleaned or wiped using a damp
cloth. Use a brush when vacuuming to prevent
damaging sensitive parts.
Avoid strong solvents such as acetone or
similar, as well as alkaline or acidic detergents.
The plastic end covers must not be exposed to
oily substances.
Overheat protection
The convector is tted with overheat protection.
TWT100: The overheat protection can be reset
by pushing the button on the end plate of the
heater.
TWTC: The overheat protection is reset by
pressing the button located under a threaded
cover at the side of the heater. The cover can
be removed by a screwdriver.
Control
Thermowarm features an integrated
thermostat with setting range 0 – +35 °C. On
TWTC the thermostat is concealed to make it
dicult for unauthorised persons to change
the temperature setting. TWT100 has a circuit
breaker.
Packaging
Packaging materials are chosen with
consideration to the environment and are
therefore recyclable.
TWT100: A Celsius scale is marked on the side
of the thermostat dial. The dial is on the right
side of the heater. The scale of the thermostat
dial can be turned to calibrate the thermostat
to the actual room temperature.
TWTC: The thermostat is protected under a
threaded cover on the right side of the heater.
The cover can be removed by a screwdriver.
The thermostat is set by turning the notch to
the desired temperature. See the introduction
pages.

Thermowarm TWT
5
EN
Handling of product at end of working
life
This product may contain substances necessary
for the functionality of the product but
potentially dangerous for the environment. The
product should not be disposed of mixed with
general household waste but delivered to a
designated collection point for environmental
recycling. Please contact the local authority
for further details of your nearest designated
collection point.
Safety
• For all installations of electrically heated
products a residual current circuit breaker
300 mA for re protection should be used.
• Keep the areas around the air intake and
exhaust grilles free from possible obstructions!
• The unit must not be fully or partially covered as
overheating can result in a re risk!
• This appliance can be used by children aged
from 8 years and above and persons with
reduced physical, sensory or mental capabilities
or lack of experience and knowledge if they
have been given supervision or instruction
concerning use of the appliance in a safe way
and understand the hazards involved. Children
shall not play with the appliance. Cleaning and
user maintenance shall not be made by children
without supervision.
• Children of less than 3 years should be kept
away unless continuously supervised.
• Children aged from 3 years and less than 8
years shall only switch on/off the appliance
provided that it has been placed or installed
in its intended normal operating position and
they have been given supervision or instruction
concerning use of the appliance in a safe way
and understand the hazards involved.
• Children aged from 3 years and less than 8
years shall not plug in, regulate and clean the
appliance or perform user maintenance.
CAUTION — Some parts of this product can
become very hot and cause burns. Particular
attention has to be given where children and
vulnerable people are present.

Main offi ce
Frico AB Tel: [phone]
Industrivägen 41
SE-433 61 Sävedalen [email protected]
Sweden www.frico.net
For latest updated information and information
about your local contact: www.frico.se
2021-04-29 CH