Grange GRW550e User manual

value
•
quality
•
service
Grange Product Range
Wrapping Equipment
Bandsaws
Food Processors
Juicers
Light Kitchen Equipment
Mincing Equipment
Mixers
Slicers
Benchtop Wrapper
Model GRW550e
USER MANUAL

SAFETY PROCEDURES
NEVER ATTEMPT TO OPERATE THIS MACHINE
WITHOUT READING THE OPERATING MANUAL
 •NEVERtouchthismachinewithouttrainingandauthorisationfromyoursupervisor.
 •MachineMUSTBEonsolid,levelbench/table.
 •GuardsMUSTBEinplacebeforeplugginginandturningonmachine.
 •ALWAYSusethethree-prongedplugprovided.
 •NEVERuseyourhandtoholdfoodstuffsinplaceontheproducttray.
 •NEVERtouchtheHotBarorHotPlatewithunprotectedhands.
 •KEEPhands,arms,hairandlooseclothingCLEARofallmovingparts.
 •SWITCHOFFANDUNPLUGthemachinefromitspowersourcebeforecleaning,
sanitisingorservicing.
 •USEONLYtheattachmentsprovidedbythemanufactureranddesignedforthismachine.
 •Thismachineheatsandmeltsplasticsaspartofitsnormaloperation.
WeSTRONGLYRECOMMENDthatasuitablereextinguisherbelocatedcloseby.
YOUR SAFETY IS OUR PRIMARY CONCERN

Introduction
Overview
 ThisOperationandSafetyManualhasbeenpreparedtointroduceyoutotheGrangeModelGRW550e
benchtopwrapper.Itexplainstheoperation,cleaningandmaintenanceofthewrapperinsimple,clear
termsandwithanemphasisonyoursafety.
ThroughouttheManualproceduresaresupportedbyillustrationsshowingthepartsinvolvedandthe
recommendedsafemethodofhandlingthoseparts.
Attention
 MakesurethatyoureadthisManualcarefullysothatyouarefamiliarwiththefeaturesandproceduresthat
areuniquetothebenchtopwrapper.
Conventions and Symbols used in this Manual
 Toreduceconfusion,andtohighlightimportantpointsandsafetymatters,wehaveestablishedsome
standardtermsandsymbols:
 •“wrapper”Wheneverwetalkaboutthewrapper,wemeantheGrangeModelTW-550Ebench
topwrapperthatiscoveredinthisManual.
 •“foodstuff”Weusetheword“foodstuff”torefertoanykindofmeatorotherfoodthatisusually
slicedonaslicer.
•“producttray”Thisisthetrayonwhichyouplacethefoodstufftobewrapped.
 •“hotbar”Thehotbaristheheatedelementthatcutsthewrappinglm.
 •“hotplate”Thehotplateheatshrinksthewrappinglmandsealsthepackage.
 •TheSpecialNoteagThisisanupside-downtrianglewithanexclamationmarkinsideit.Itappears
intheleftmarginofthepage,likethis,wheneverwewanttodrawyourattentiontoanimportantpoint.
 •The“NoHands”warningagThisisacirclewiththeoutlineofahandandablackbarthroughthe
hand.Itappearswhereverwewanttowarnyouthateither:youshouldn’tputyourhandsinornearapar-
ticularcomponent;orthatyoumustwearsteelmeshprotectiveglovestocarryoutaparticularprocedure.
 •The“Power”warningagsTherearetwopowerwarningags.Therst,alightningboltinsidean
upside-downtriangle,isusedwheneverwewanttoremindandwarnyouthattheslicerisconnected
tothemainspowersupply.Thesecondwarningagisacirclewiththeoutlineofalightningboltand
ablackbarthroughthebolt.Itappearstoremindyouthataparticularproceduremust
becarriedoutwiththepowertotheslicerturnedoffatthepowerpointandtheslicer’s
powerplugdisconnectedfromthepowerpoint.
 •The“Water”warningagsThisisacirclewiththeadiagramofawaterhosespraying:you
shouldneverhosedownorspraywithwateranycomponentofthismachineoritsenvironment.
 •The“WaterImmersion”warningagsThisisacirclewiththediagramofahand
droppingamachineintowater:youshouldneverimmersethemachineintowater.

SAFETY WARNINGS
 Thisisanelectricaldevicethatusesmains(singlephase240Voltpower).Youmustbecarefulinhowyou
handlethewrapperatalltimes.Thefollowingspecialwarningsmustbecompliedwithforyourownsafety
andthesafetyofothers.
  THEREARENOUSER-SERVICEABLEELECTRICALCOMPONENTSINTHIS
WRAPPER.ALLELECTRICALCOMPONENTSAREELECTRICALLYISOLATEDTO
EARTHANDARESEALEDFORYOURSAFETY.YOUMUSTNOTATTEMPTTO
TOUCHANYELECTRICALCOMPONENTSORWIRES–YOUMAYEXPOSE
YOURSELFTOTHERISKOFSERIOUSINJURYBYELECTROCUTION.
  UNLESSOTHERWISEINDICATED,ANYCLEANINGORMAINTENANCEPROCEDURE
MUSTBEPERFORMEDWITHTHEPOWERTOTHEWRAPPERSWITCHEDOFF
ANDTHEWRAPPER’SPOWERCORDDISCONNECTEDFROMTHEPOWERPOINT.
FAILURETOTURNOFFANDDISCONNECTPOWERMAYRESULTINSERIOUS
INJURYCAUSEDBYTHEWRAPPERBEINGACCIDENTLYTURNEDONDURING
CLEANINGORMAINTENANCE.
TheTopWrapperGRW550e
 TheGrangeModelGRW550ebenchtopwrapperisforuseinBakeries,Greengrocers,Butchers,
Hospitalsandallotherfoodpackagingareas.Thiswrapperisaversatileandreliablemethodof
displayingyourgoodstotheirbestadvantage.Itissimpletouse,requiresverylittlemaintenance
andisalwaysreadywhenyouneedit.
 TheGrangeModelGRW550ebenchtopwrapperwrapsandheatsealsfoodstuffsinpolythene
lmforcustomerconvenience.Aheatedelementbar(the“hotbar”)instantlycutsthelmatthe
requiredlength.Ahotplateelementcanalsobeusedwherefoodstuffsarebeingpackedintrays
toheatshrinkthelmtocreateastrongerseal.
  •Plugsdirectintoany240vPoweroutlet
  •Separateswitchesforhotplateandcutting
  •Internallyfusedforfullprotection
  •Stainlesssteelconstructionforfoodhygiene
  •3monthswarranty,fullbackupservice,withallpartsreadilyavailable
  •Easytouse
  •Minimisespackagingtime
  •Maximisesoutput

Operatingmethod
 1.Pushthepowersupplyplug(1)intothepowersocket,turnonthepowerandthensetswitch(12)
andknob(16)totheonpositiontostartheatingthecutter(8)andheatingboard(9).
2.Bothofthedisplaylamps(13)and(15)fortheheatingboardandcuttershouldbelit.
 3.Operationcanstartafterpre-heatingthemachinefor1–2minuteswhentheworkingtemperature
oftheheatingboardisbetween100 –160degreesgenerally.
 4.Placethelmintothesupportroller(3)insideoftherearchamber,bucklethebeltsonbothends,liftup
theuppercover(workingdesk)(4),pullthelmbetweenthelowerguideroller(11)andtherearguide
roller(10)andfeeditbetweenbothfrontandrearclamprollers(6)(5),lowertheuppercovertonormal
positionandadjustthetensionhandle(2)toensurethelmtensionisadequateforpacking.
 5.Placethefoodorcontainertobepackedontheuppercover,carefullygriptheedgesofthewrap
lm,liftitclearofthegripandpullitupandto-wardsyouuntilthereissufcientlmtocompletely
coverthefoodstuff,andallowingagenerousexcessoflmeithersideofthefoodstuff.Foldit
overthetopofthefoodstuff.
 6.Liftthefoodstufffromtheproducttrayandpullittowardsyou,drawingoutmorelmatthesame
time.Atthesametimeasyoupullthefoodstufftowardsyou,foldtheexcesslmeithersideof
thefoodstuffundertheproduct.
 7.Wrapthefoodstuffwiththelm,drawthepackagedownsothatthestretchedlmcomesinto
contactwiththecutter.Thecutterwillheatcutthelmatthepointofcontact.
 8.Placethepackageontheheatingboard(9)forsealing,endingthepackingoperation.
 9.Turnonthecutterswitch(12)andturnoffthecontrollerswitchforheating(16)ifonlythecutteris
neededinoperation.
Caution
 •Donotusethesealerinaplaceclosetoammablematerials
 •DonotoperatetheswitchorpluginoroutthePSplugwithwethands
 •Incaseofthedisplaylampnotbeinglitorthecutterheatingboardnotheating,
stopoperationandturnoffthepowertocheckandtroubleshoot
 •Makesuretoreplacethefuse(14)withtheoriginalratedone(2A).
 •Cleanwithadryclothincasethereisdirtadheredonthecutterortheheatingboard
anddonotuseanymetaloranyhardmatterincaseitwilldamagethesurfacecoating
 •Attheendofoperation,takeoutthepowersupplyplugensuringnottopullitout
byholdingthecord.

value
•
quality
•
service
New South Wales
and Victoria
ReliableFoodEquipment
0296204944
[email protected]
Queensland
ChopologyFoodEquipment
0418194597
[email protected]
South Australia
GaPSolutions
0884088150
[email protected]
Tasmania
QualityEquipment
0362348300
quality[email protected]
Western Australia
MBLFoodServices
0893349600
[email protected]
‘more than service –
it’s customer satisfaction’
ComponentsoftheBenchWrapper
Thefollowingpictureillustratesthemaincomponentsofthewrapper.
 1. Powersupplyplug
 2. Tension-adjusthandle
 3. Supportrollerforfreshness-reservinglm
 4. Uppercover(workingdesk)
 5. Rearclamproller
 6. Frontclamproller
 7. Cutterguardstand
 8. Cutter
 9. Heatingboard
 10. Rearguideroller
 11. Lowerguideroller
 12. Powersupplyswitchforcutter
 13. Displaylampforcutter
 14. Safety
 15. Displaylampforheatingboard
 16. Controllerswitchforheatingboard