Gtech HT05 Plus User manual

OPERATING MANUAL
Cordless Hedge Trimmer
Model number: HT05 Plus

2
IMPORTANT SAFEGUARDS:
IMPORTANT: READ ALL INSTRUCTIONS BEFORE USE.
RETAIN INSTRUCTIONS FOR FUTURE REFERENCE.
Do not use in rain or leave outdoors whilst raining.
WARNING: Basic safety precautions should always be observed when
using an electrical appliance to reduce the risk of re, electrical shock or
serious injury.
The term “power tool” in all of the warnings listed below refers to your
battery-operated (cordless) power tool.
Personal Safety:
• Only use the product in the manner
intended and for the functions
described in this manual.
• Keep out of reach of children and
animals at all times.
• Only use in daylight.
• Always be sure of your footing
on ladders, slopes or in slippery
conditions.
• Do not over-reach or use on
excessive slopes.
• Check the hedge and area where the
trimmer is being used for any objects,
such as wire fences, that could
damage or jam the trimmer blade.
• Pay special attention to the hazards
posed to third parties by the
increased reach when the extension
tube is extended.
• Stay alert, watch what you are
doing and use common sense when
operating a power tool.
• Do not use power tools while you are
tired or under the inuence of drugs,
alcohol or medication. This may result
in serious personal injury.
• Always be aware of your
surroundings and stay alert for
possible hazards.
• Use protective equipment such as
safety glasses, non-skid safety shoes,
sturdy gloves and hearing protection
to reduce the risk of personal injury.
• Do not operate when barefoot or
wearing open toed shoes.
• Dress appropriately. Do not wear
loose clothing or jewellery and keep
hair, clothing and gloves away from
moving parts.
• Avoid accidental starting. Ensure the
switch is in the off position before
connecting to the battery pack,
picking up or carrying the tool.
• Do not run with the power tool.
• When operating the power tool
ensure that both hands are correctly
positioned on the handle.
• Do not operate the tool if it is
incomplete or has unauthorised
modications.
• Keep all body parts, especially hands
and feet, away from the blade at all
times.
• Warning, the blade will continue to
move after the motor is switched off.
• Ensure that the motor has fully
stopped before cleaning, clearing a
blockage, checking, or carrying out
maintenance on the power tool.
• Carry the hedge trimmer by the
handle with the blade stopped.
• When transporting or storing
the hedge trimmer always t the
protective blade cover.

3
• The operator or user is responsible
for accidents or hazards occurring to
other people at their property.
• Never operate the power tool with
damaged guards or without the
guards in place.
• This appliance is not intended for use
by persons (including children) with
reduced physical, sensory or mental
capabilities or lack of experience or
knowledge.
• Keep the product and all accessories
away from hot surfaces.
• Never modify the trimmer in any way.
Electrical safety:
• Do not operate power tools in
explosive atmospheres, such as in
the presence of ammable liquids,
gases or dust. Power tools create
sparks, which may ignite the dust and
fumes.
• Do not use the product when a
thunderstorm is approaching.
• Avoid body contact with earthed or
grounded surfaces, such as pipes.
There is an increased risk of electric
shock if your body is earthed or
grounded.
• Do not expose power tools to rain
or wet conditions. Water entering a
power tool will increase the risk of
electric shock.
• Do not handle the charger or the
power tool with wet hands.
• Before charging check the power
supply and charger cables for signs
of damage or ageing.
• Do not overload the trimmer. Forcing
the trimmer to cut may damage the
motor. For safety the trimmer will
automatically cut out if the motor
becomes overloaded. If this occurs,
wait a few seconds for the cut out to
reset and the use lighter cuts to trim
the hedge in stages.
Battery safety:
• Disconnect the battery pack from
the power tool before making any
adjustments, changing accessories or
storing power tools.
• Do not attempt to use the charger
with any other product or to charge
this product with any other charger.
• This product contains Li-Ion batteries.
Do not incinerate batteries or expose
to high temperatures, as they may
explode.
• Do not charge the battery when the
surrounding air temperature or the
battery pack is below 0°C or above
45°C.
• After heavy use or in high
temperatures the battery may
become warm. Allow the product to
cool for 30 minutes before charging.
• Use only with the battery pack
supplied.
• When the battery pack is not in use,
keep away from other metal objects
that can make a connection from one
terminal to another.
• Shorting the battery terminals may
cause burns or re.
• Leaks from battery cells can occur
under extreme conditions. If the liquid
gets on your skin wash immediately
with soap and water. If the liquid
gets into your eyes, ush them
immediately with cold water for a
minimum of 10 minutes and seek
urgent medical attention.

4
Service:
• Do not use the power tool if the
switch does not turn it on or off. Any
power tool that cannot be controlled
by the switch is dangerous and must
be repaired or replaced.
• Check for misalignment or binding
of moving parts, breakage of parts
and any other condition that may
affect the power tools operations.
If damaged, have the power tool
repaired or replaced.
• Check that the blade is clean
and without damage. If the blade
becomes worn, a replacement should
be tted before use.
• Wear protective gloves when handling
or cleaning the blade.
• Before using the machine and after
any impact, check for signs of wear
and damage and repair or replace as
necessary.
• Always ensure that the ventilation
openings are kept clear of debris.
• Have your power tool serviced by
a qualied repair person using only
genuine replacement parts. This will
ensure that the safety of the power
tool is maintained.
• Do not attempt to repair any
damaged parts on the product unless
you are qualied to do so.
Intended Use:
• This product is intended for
DOMESTIC USE ONLY.

5
Read instruction
manual before use
Do not use in rain
or leave outdoors
whilst raining.
Risk of fatal injury due to electric shock!
Keep at least 10 m away from electricity
lines.
General hazard
safety alert.
Wear eye protection
when using this
product.
Measured sound power level: 84 dB(A)
Guaranteed sound power level: 95dB(A)
Note: Measured noise values determined according to
2000/14 EC (1.60m height, 1.0m distance away).
dB
LWA
95
Warning Label Descriptions

6
Thank you for choosing a Gtech HT05 Plus
“I started Gtech to create sensible, easy to use products, which do a great job. Your opinion
is important to us. Please take the time to write a review of the HT05 Plus by emailing us
at support@greytechnology.co.uk. We will use your feedback to improve our products and
services and let other people know what it’s like to be part of the Gtech family.”
Register your warranty now at:
www.gtech.co.uk/warrantyregistration or call 08000 518353
Keep your receipt with this manual. You will need it if you ever have a warranty claim.
Nick Grey – Inventor, Owner of Gtech
Main unit
Charger
Visor
Visor screw
1
2
3
4
What’s in the box
1
3
4
2

7
Assembly
Screw protective blade guard securely
in place.
Place the protective blade guard onto the
cutting head.
PRODUCT SERIAL NUMBER:
You can nd this on the side of your product

8
Push the safety button in from one side and press the trigger. Keep holding the trigger and
release the safety button.
Firmly grip the head of the trimmer and press and hold the button marked PUSH.
Rotate the head to your chosen angle.
Operation
Rotating the head
1
2

9
WARNING: Ensure the trimmer is switched off and the blade has stopped before
adjusting the cutting head.
Extending the tube
Lift the latch to extend the length
of the tube. Extend the extension
tube to the desired length.
Firmly push the latch closed to
lock the extension tube in place.

10

11
Using your hedge trimmer
Hold the trimmer away from your body using both hands and stand on a solid and
secure surface.
The double edge blade allows you to cut with either a side to side or up and
down motion:
When cutting move slowly and steadily so that stems are fed directly into the blade.
Cut the sides of the hedge rst and then the top. To keep the sides of the hedge at
cutting upwards with the growth is recommended.
WARNING: Risk of electric shock. Pay attention to the position of overhead cables.

12
Recharging
Plug the charger in and connect it to the battery on the rear handle.
The charger light will turn red when the
battery is charging.
After 3 hours the light will turn green and
charging is complete.

13
Product Care
To ensure that your HT05 Plus gives you long and reliable service, carry out the following
maintenance regularly:
• Check for obvious defects such as loose, dislodged, worn or damaged blades, loose
xings, and worn, damaged, or loose parts.
• Check that covers and guards are correctly tted and undamaged.
• Always clean the cutting blade after use and apply a lubricating oil or spray
before storage.
• During longer cutting periods it is recommended to lubricate the blade. This will improve
cutting performance and maximise the run time.
• Before use check the condition of the cutting edges of the blade and that the blade
xings are secure.
• Do not use water, solvents, or polishes to clean the trimmer. Wipe clean with a dry cloth.
• Do not use abrasive materials to clean the product, and do not immerse it in water.
• Store in a secure, dry place. Do not expose to moisture.
PLEASE NOTE: If the product needs to be repaired or replaced only use replacement
parts which are approved by the manufacturer.
Spare parts can be purchased from Grey Technology Ltd:
tel : 01905 345 891 www.gtech.co.uk

Troubleshooting
If this doesn’t solve your problem don’t worry, we will help.
Go to www.gtech.co.uk or call 01905 345 891
Trimmer fails to operate
Cutting blade will not cut
Blade will not move
Cutting time has reduced
Trimmer stops when cutting
No light showing on charger
Recharge battery.
Check switch. It will click if
operating correctly.
Blade is either worn or damaged.
Replace blade.
Clean and lubricate blade.
Replace blade.
Use lighter cutting action and cut
in several stages.
Fully discharge and recharge
battery.
Clean and lubricate blade.
Replace blade.
What for automatic cut out to
reset. Use lighter cutting action.
Check blade and remove
any debris.
Charge battery.
Check connections.
Check socket.
1.
2.
1.
1.
2.
1.
2.
3.
4.
1.
2.
3.
1.
2.
14

15
HT05 PLUS TECHNICAL SPECIFICATION
Blade length
Blade cutting width
No load speed
Battery
Charging period
Battery charger output
Battery charger input
Battery charger type
Measure sound power level, LpA,d
Guaranteed sound power level, LwA,d
Weight
Vibration
246mm
12mm
1200rpm
14.4V DC, 1.9Ah Li-In
3 hours
17.0V DC, 600mA
100-240V - 50/60Hz
JY15 - 170m - 060
LpA = 81db(A) 1c = 3dB(A)
95dB(A)
1.7kg
3m/s2K = 1.5m/52

16
The symbol indicates that this product is covered by legislation for waste electrical
and electronic products (EN2002/96/EC)
When the product has reached the end of its life please do not dispose of it with general
household waste. Consider the environment and take it to a recognised recycling facility.
The product contains a Li-Ion battery which should not be disposed of with general
household waste. The battery should be disposed of properly with the product at a
recycling facility.
Call your local council, civic amenity site, or recycling centre for information on the
disposal and recycling of electrical products.
Alternatively visit www.recycle-more.co.uk
for advice on recycling and to nd your
nearest recycling facilities.
Environmental and Product Recycling

17
WARRANTY – TERMS AND CONDITIONS
If your Gtech HT05 Plus breaks, don’t worry, we’re here to help.
Go to www.gtech.co.uk or call 01905 345 891 for assistance.
To qualify for your 1-year warranty, register your HT05 Plus within 3 months of
purchase at:
www.gtech.co.uk/warrantyregistration
or call 08000 518353
WHAT ISN’T COVERED
Gtech does not guarantee the repair or replacement of the product as a result of:
• Normal wear and tear.
• Accidental dam age, faults caused by negligent use or care, misuse, neglect, careless
operation or handling of the hedge trimmer which is not in accordance with the HT05
Plus operating manual.
• Battery is a consumable item and is not covered by this guarantee.
• Use of the hedge trimmer for anything other than normal domestic garden purpose.
• Use of parts and accessories which are not Gtech genuine components.
• Faulty installation (except where installed by Gtech).
• If it is modied in any way.
• Repairs or alterations carried out by parties other than Gtech or its authorised agents.
• If you are in doubt as to what is covered by your warranty, please call the Gtech
Customer Care Helpline on 01905 345 891.
SUMMARY
• The guarantee becomes effective at the date of purchase (or the date of delivery if this
is later).
• You must provide proof of delivery/purchse before any work can be carried out on the
hedge trimmer. Without this proof, any work carried out will be chargeable. Please keep
your receipt or delivery note.
• All work will be carried out by Gtech or its authorised agents.
• Any parts that are replaced will become the property of Gtech.
• The repair or replacement of your hedge trimmer is under guarantee and will not extend
the warranty period.
• The guarantee provides benets which are additional to and do not affect your statutory
rights as a consumer.

18

19
EC Declaration of Conformity
We, manufacturer/importer
Grey Technology Ltd
1&2 Cupola Court
Spetchley
Worcestershire
WR5 1RL
declare that the product
HT05 Plus Cordless Hedge Trimmer
complies with the essential health and safety requirements of the following directives:
2004/108/EC - EMC Directive.
2006/42/EC - Machinery Directive
2006/95/EC - Low Voltage Directive
2000/14/EC - Noise emission in the environment by equipment for use outdoors Directive.
- Conformity assessment procedure as per ANNEX VI.
- Measured Sound Power Level = 81 dB(A) K = 3dB(A)
- Declared Guaranteed Sound Power Level = 95 dB(A)
- Notied Body: Intertek Testing & Cercation Ltd, Davy Avenue, Knowlhill,
Milton Keynes, MK5 8NL
Technical documentation holder: Grey Technology Ltd, WR5 1RL
Standards and technical specications referred to:
Parts of EN 60745-1
Parts of EN 60745-2-15
EN ISO 10517
EN55014-1
EN55014-2
EN61000-3-2
EN61000-3-3

Grey Technology Limited
Cupola Court, Spetchley, Worcestershire WR5 1RL
email: support@greytechnology.co.uk
telephone: 01905 345891
www.gtech.co.uk
CPN000274
Table of contents
Other Gtech Trimmer manuals