Haier HI6LMK User manual



Model#HI6LMK
IssueDate:April2013
120V,60Hz
MadeinChinaHaierAmerica
NewYork,NY10018
©2013HaierAmericaTrading,LLC.
www.HaierAmerica.com

P/N0060517641RevA
IceMakerUserManual
HI6LMK



TABLE OF CONTENTS
SAFETYINFORMATION
ImportantSafetyInstrucons
SETUP&CARE
SuppliesRequiredforInstallaon
ToolsRequiredforInstallaon
PartsIncluded
InstallaonInstrucons
WaterSupplyConnecon
IceMakerOperaon
Tips&Care
NormalOperangSounds
TROUBLESHOOTING&WARRANTY
IceMakerFillAdjustment
CustomerService
Troubleshoong
LimitedWarranty

3

4
4
4
5‐8
9
10
10
10

11
11
12
13
PRODUCT REGISTRATION
ThankyouforpurchasingourHaier
product.Thiseasy‐to‐usemanualwill
guideyouingengthebestuseofyour
product.
Remembertorecordthemodelandserial
numbers.Theyarelocatedonalabelon
theicemaker.
Stapleyourreceipttoyourmanual.Youwillneedittoobtainwarrantyservice.

ModelNumber


DateofPurchase

P/N0060517641RevA
PAGE15●NOTES


PAGE14●NOTES

P/N0060517641RevA
IMPORTANT SAFETY INSTRUCTIONS

TOAVOIDELECTRICALSHOCK,WHICHCANCAUSEDEATHORSEVERE
PERSONALINJURY,DISCONNECTTHEPOWERSUPPLYBEFORE
CONNECTINGAWATERSUPPLYLINETOTHEREFRIGERATOR.
!WARNING
!WARNING
DONOTPLACEFINGERSORHANDONTHEAUTOMATICICEMAKING
MECHANISMWHILETHEREFRIGERATORISPLUGGEDIN.
THISWILLHELPPROTECTYOUFROMPOSSIBLEINJURYASWELLAS
PREVENTINTERFERENCEWITHMOVINGPARTSOFTHEEJECTOR
MECHANISMANDTHEHEATINGELEMENTTHATRELEASESTHECUBES.
TOAVOIDPROPERTYDAMAGE:
 Coppertubingisrecommendedforthewatersupplyline.Water
supplytubingshouldbe1/4".Plascisnotrecommendedsinceit
greatlyincreasesthepotenalforwaterleaks.
 Donotinstallwatersupplytubinginareaswherethetemperature
fallsbelowfreezing.
 Connecttheicemakertoadrinkablewatersourcethatisnot
connectedtoawatersoeningsystem.Chemicalsfromthesoener
maydamagetheicemaker,causingittomalfuncon.
SAVE THESE INSTRUCTIONS
HOUSEHOLD USE ONLY
PAGE3●SAFETYINFORMATION
PROFESSIONALINSTALLATIONISRECOMMENDED.



SUPPLIES REQUIRED FOR INSTALLATION
Thefollowingitemsarerequiredtoinstalltheicemaker.
 ¼‐inchcoppersupplylinewithshutoffvalve.
 ¼‐inchbrasscompressionnutandferrule(sleeve).
NOTE:Thecoppertubingandshut‐offvalveshouldbeavailableatyourlocal
hardwareorplumbingsupplystore.Coilenoughtubinginthebackof
theunittoallowmovementoftherefrigeratorforcleaningand
service.
¼‐inchCompression
Nut
¼‐inchFerrule
¼‐inchCopper
SupplyLine
TOOLS REQUIRED FOR INSTALLATION
 1/4‐inchsocketwrenchornutdriver
 Phillips&Flatheadscrewdriver
 Adjustablewrench
 Pliers
PARTS INCLUDED
PAGE4●SETUP&CARE
IceBucket
Installaon
Checklist
UserManual
IceMakerWaterSupply
Clamp
HexHeadScrews
Qty:2
MounngScrew
Washer

P/N0060517641RevA
In‐HomeService‐Whatiscoveredandforhowlong?
Thiswarrantycoversalldefectsinworkmanshipormaterialsoftheautomacicemakerfora
periodof:
12monthslabor
12monthsparts
Thewarrantycommencesonthedatetheitemwaspurchasedandtheoriginalpurchasereceipt
mustbepresentedtotheauthorizedservicecenterbeforewarrantyrepairsarerendered.
Whatiscovered?
1.Themechanicalandelectricalparts,whichserveasafunconal,purposeofthiskitfora
periodof12months.
Whatwillbedone?
1.Wewillrepairorreplace,atourdiscreonanymechanicalorelectricalpartwhichprovestobe
defecveinnormalusageduringthewarrantyperiodsospecified.
2.Therewillbenochargetothepurchaserforpartsandlaboronanycovereditemsduringthe
inial12monthperiod.
3.Contactyournearestauthorizedservicecenter.Forthenameofthenearestservicecenter
pleasecall1‐877‐337‐3639
THISWARRANTYCOVERSWITHINTHECONTINENTALUNITEDSTATES,PUERTO
RICOANDCANADA.ITDOESNOTCOVERTHEFOLLOWING:
−Damagesfromimproperinstallaon.
−Damagesinshipping.
−Defectsotherthanmanufacturing.
−Damagefrommisuse,abuse,accident,alteraon,lackofpropercareandmaintenanceor
incorrectcurrentorvoltage.
−Damagefromotherthanhouseholduse.
−Damagefromservicebyotherthananauthorizeddealerorservicecenter.
−Transportaonandshipping.
−Improperinstallaon.Ifyouhaveaninstallaonproblem,contactyourdealerorinstaller.You
areresponsibleforprovidingadequateelectrical,plumbingandotherconnecngfacilies,
includingthewaterlinetotheicemakerandthewaterlineinstallaon.
−Replacementofhousefusesorresengofcircuitbreakers.
−Failureoftheproductifitisusedforotherthanitsintendedpurposeorusedcommercially.
−Damagetoproductcausedbyaccident,fire,floodsorActsofGod.

WARRANTORISNOTRESPONSIBLEFORCONSEQUENTIALDAMAGES.THISLIMITED
WARRANTYISGIVENINLIEUOFALLOTHERWARRANTIES,EXPRESSEDOR,INCLUDING
THEWARRANTIESOFMERCHANTABILITYANDFITNESSFORAPARTICULARPURPOSE.
Theremedyprovidedinthiswarrantyisexclusiveandisgrantedinlieuofallotherremedies.This
warrantydoesnotcoverincidentalorconsequenaldamages,sotheabovelimitaonsmaynot
applytoyou.SomeStatesdonotallowlimitaonsonhowlonganimpliedwarrantylasts,sothe
abovelimitaonsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrights,andyoumay
haveotherrights,whichvary,fromstatetostate.
HaierAmerica
NewYork,NY10018
LIMITED WARRANTY
PAGE13●TROUBLESHOOTING&WARRANTY


PAGE12●TROUBLESHOOTING&WARRANTY
TROUBLESHOOTING
PROBLEMCAUSE/SOLUTION
Noiceproduced
Ensurethatrefrigeratorispluggedintopower
source
Wirecontrolarmisfullyraised.SeePage9.
Checkthaticemakerispluggedintoelectricalsocket
inrearoffreezercompartment.SeePages5‐6.
Watersupplyisturnedoffordisconnected.
Disconnectrefrigeratorfrompowersource,remove
rearaccesscover,thenchecktoseethatwatervalve
ispluggedintowiringharnessinrearboom
compartment.
Checkwaterconneconsonwatervalve.SeePage8.
Low/slow
iceproducon
Adjustfreezertemperaturetocolderseng.See
RefrigeratorUserManualforinstrucons.
Checkforleaksorkinksinwatertubingonrearof
refrigerator.
Increasewaterfillamount.SeePage11.
SmallicecubesIncreasewaterfillamount.SeePage11.
Waterleakinfreezer
Checkthatfilltubeisalignedintofillcuponrearof
icemaker.SeePage7.
Decreasewaterfillamount.SeePage11.
Checkforleaksinwatertubingonrearof
refrigerator.
Disconnectrefrigeratorfrompowersupply,remove
rearcompartmentcover,thencheckwater
conneconsonwatervalve.
Waterleakunder
refrigerator

P/N0060517641RevA
INSTALLATION INSTRUCTIONS
4.Removeelectricalsocketcoverbygraspingbothsidesofcoverandpulling
lesidetowardsfrontofrefrigerator.
(Donotdiscardelectricalplugcover)
11
2
1.Moverefrigeratorawayfromwallandunplug.
2.Removefreezershelfbyliingupandslidingitoutoffreezercompartment.
PAGE5●SETUP&CARE
3.Removeplascplugaboveelectricalsocketbygraspingfirmlyandpulling
endofplugdown.
FreezerShelf


PAGE6●SETUP&CARE
INSTALLATION INSTRUCTIONS CONT.
6.Inserticemakerelectricalplugintosocketusingnotchesinsocketandplug
tohelpwithalignment,thenpressfirmly.
7.Re‐installelectricalplugcoverbypushingcoverdownonplug,inserngtab
intoslotonrearcoverandthensnappingfrontprongsintosquareholes.
5.Posionicemakerharnessinicemakerhookasshownbelow:
IceMaker
Harness
Hook
AlignmentNotchAlignmentNotch
Tab
Slot
FrontProng
SquareHole

P/N0060517641RevA
PAGE11●TROUBLESHOOTING&WARRRANTY
CUSTOMER SERVICE
IMPORTANT
DONOTRETURNTHISPRODUCTTOTHESTORE
Ifyouhaveaproblemwiththisproduct,pleasecontactthe
HaierCustomerSasfaconCenterat1‐877‐337‐3639
DATEDPROOFOFPURCHASE,MODELNUMBERANDSERIAL
NUMBERREQUIREDFORWARRANTYSERVICE
CUSTOMER
SERVICE
SERVICIO
AL CLIENTE
Hotline
1-877-337-3639
1.Useflatheadscrewdrivertopryfrontcoveroficemaker.Donotdiscard
frontcover.
2.UseaPhillipsscrewdrivertoturnfilladjustmentscrewclockwiseto
DECREASEwaterfillamount.Turnscrewcounter‐clockwisetoINCREASE
waterfillamount.
FillAdjustment
Screw
ICE MAKER FILL ADJUSTMENT
Ifyouricemakerismakingsmallicecubesorisn’tproducingasasfactory
amountofice,itispossibletoimprovethisbyadjusngtheamountofwater
usedtofilltheicecubetrayintheicemaker.
3.Replacefrontcoveroficemaker.
NOTE:Increasingthewaterfillamountcouldcausewatertooverflowoutof
theicemaker.Makehalf‐turnadjustmentsunlicecubesizeorice
produconamountissasfactory.Besuretocloselymonitorthefreezer
compartmentforwateroverflowaeradjusngthefilladjustment
screw.
IceMakerBoom
THESEINSTRUCTIONSSHOULDONLYBEUSEDIFTHEHOMEHASUNUSUALLY
LOWWATERPRESSURETHATRESULTSINLOWICEPRODUCTIONORSMALL
ICECUBESIZE.CHANGESTOHOMEPLUMBINGCOULDAFFECTICEMAKERFILL
AMOUNTANDRESULTINOVERFLOWEDWATERINTHEFREEZER
COMPARTMENT.


PAGE10●SETUP&CARE
NOTE:Ittakesapproximately24hoursfortheicemakertoproduceice.
Newplumbingmaycauseicediscoloraonandpoorflavor.
Discardicemadeinthefirst24hours.
ICE MAKER OPERATION
Tostoptheicemaker,lithewirearmunlitclicksandlocksintheOFF
(raised)posion.TheicemakerturnsOFFautomacallywhentheice
containerisfull.Ifyourmodelhasanadjustablefreezershelf,placetheshelf
sothatwhentheicecontainerisfull,theicewillhitthewirecontrolarm.
 Waterqualitydeterminesicequality.Donotconnecttheicemakertowater
thatissoened.Chemicalsfromamalfunconingsoenercandamagethe
icemaker.
 Icestoredtoolongmaydevelopanoddflavor.Emptythecontainerand
makesurethewirearmisintheON(lowered)posion.Theicemakerwill
thenproduceice.
 KeepthewirearminOFFposionunltherefrigeratorisconnectedtothe
watersupplyorwheneverthewatersupplyisturnedOFF.
CAUTION:
 Donotwashtheicebucketinyourdishwasher.
 Besuretostoptheicemakerwhencleaningthefreezeroronvacaon.
 IftheicemakerhastobeturnedOFFforalongperiodofme,turnthe
watersupplyvalvetotheclosedposion.
 Donotstoreanythingontopoforintheicemakerortheicebucket.
TIPS & CARE
NORMAL OPERATING SOUNDS
Thefollowingsoundsarenormalwhentheicemakerisoperang:
 Motorrunning(insidefreezercompartment)
 Icedroppingintoicebucket(insidefreezercompartment)
 Runningwater(insidefreezercompartment)
 Watervalveopeningorclosing(clickingfromrearofrefrigerator)

P/N0060517641RevA
PAGE7●SETUP&CARE
9.Hangicemakerfrommounngposts.
8.Posionfilltubeintoslotinrearoficemakerfillcup.
FillTube
FillCup
10.Usehexheadscrewandwashertosecuretabonboomoficemakerto
insideoffreezer.
INSTALLATION INSTRUCTIONS CONT.



INSTALLATIONINSTRUCTIONSCONT.
PAGE8●SETUP&CARE
15.Insertsupplylinefullyintowatervalveinlet.Slideferrule(sleeve)intovalve
inletandfinger‐ghtencompressionnutontovalvebeingcarefulnotto
cross‐thread.Tightenanotherhalf‐turnwithawrench.Donotover‐ghten.
DonotuseTeflontapeonthreads.
ValveInlet
WaterSupplyLine
14.Locatewatervalveonrearofrefrigerator.Valveprotrudesslightlythrough
rearcompartmentcover.
13.Re‐installfreezershelfonlowestrailasshownandplaceicebucketunder
theicemaker.RaisewirecontrolarmonicemakertoOFFposion.
WireControlArm
LowestRail

P/N0060517641RevA
PAGE9●SETUP&CARE
1.Turnoffwatersupplyatshut‐offvalve.
2.Connectcopperwatersupplylinetohouseholdwatersystem.
3.TurnONwatersupplyandghtenanyconneconsthatleak.
4.Coilexcesswatersupplylinebehindrefrigerator,asshownbelowandarrangecoils
sotheydonotvibrateorwearagainstothersurfaces.Usewatersupplyclampand
hexheadscrewtosecurewatersupplylinetorearofrefrigerator.
WaterSupply
Clamp
HexHead
Screw
6.Reconnectrefrigeratortopowersupply.
7.MoverefrigeratorbackintoplaceandlevelitusinginstruconsinUserManual.
8.TurnicemakerONbyloweringwirecontrolarm.
WireControlArm
WATER SUPPLY CONNECTION

Thiswatersupplyinstallaonisnotcoveredunderwarrantyby
therefrigeratororicemakermanufacturer(s).Followtheseinstrucons
carefullytominimizetheriskofexpensivewaterdamage.
!WARNING
SuppliesRequiredforInstallaon:
Accesstoahouseholdcoldwaterlinewithwaterpressurebetween20psiand120psi.
Awatersupplylinemadeof1/4‐inchOutsideDiameter,coppertubing.Todetermine
thelengthofthecoppertubingneeded,youwillneedtomeasurethedistancefrom
theicemakerwatervalveatthebackoftherefrigeratortoyourcoldwaterline.Then
addapproximately7feetfortherefrigeratortobemovedoutforcleaningand
service.
Ashut‐offvalvetoconnectthewatersupplylinetoyourhouseholdwatersystem.
NOTE:Donotuseaself‐piercingtypeshut‐offvalve.
Acompressionnutandferrule(sleeve)forconnecngthewatersupplylinetotheice
makerinletvalve.Seepage4forpicture.