Halsey Taylor XP8WQ 1D Series User manual

XP8WQ*1D
PAGE 1 0000001091 (Rev. A - 02/16)
FLOOR MOUNT WATER COOLER
Owners Manual

XP8WQ*1D
PAGE 20000001091 (Rev. A - 02/16)
Uses HFC-134A refrigerant
Note: Danger! Electric shock hazard. Disconnect power before servicing unit.
FIG. 1
1, 2
31
15, 18
26
27
32
21
33
25
23
29
30
28
6
8
20
12
19
13, 14
SEE FIG. 3
4, 7, 16
17
22
3

XP8WQ*1D
PAGE 3 0000001091 (Rev. A - 02/16)
FIG. 2
E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO
WALL. ASEGURE UNA VENTILACIÓN ADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.) DE HOLGURA ENTRE LA REJILLA DE VENTILACIÓN DEL MUEBLE Y LA PARED
ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.) ENTRE LES ÉVENTS DE L’ENCEINTE ET LE MUR.
F = WALL SCREW HOLES AGUJEROS DE TORNILLOS DE PARED TROUS DE VIS DU MUR G = 2 X 4 BLOCKING
BLOQUEO DE 2 X 4 BLOC 2 X 4
FINISHED FLOOR PISO ACABADO PLANCHER FINI
LEGEND/LEYENDA/LÉGENDE A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB 1-1/2 IN. (38mm) OUT
FROM WALL SHUT OFF BY OTHERS
SE RECOMIENDA UBICAR EL TUBO CORTO DE CONEXIÓN AL TUBO DE COBRE SIN CHAPAR DE 3/8" DE DIÁM. EXT. A 1-1/2"
(38mm) FUERA DE LA LLAVE DE PASO EN LA PARED COLOCADA POR TERCEROS.
EMPLACEMENT RECOMMANDÉ D'ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5 mm) D.E.
CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38mm) DEPUIS LE ROBINET D'ARRÊT FOURNI PAR D'AUTRES.
B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4” O.D. DRAIN
UBICACIÓN RECOMENDADA PARA EL DRENAJE DE SALIDA DE AGUA, DE 1¼” DE DIÁMETRO. EMPLACEMENT RECOMMANDÉ POUR LE DRAIN DE D.E. 1-1/4" DE SORTIE D’EAU.
C = 1-1/4 TRAP NOT FURNISHED**
PURGADOR DE 1¼ NO PROPORCIONADO** SIPHON 1-1/4 NON FOURNI**
D = ELECTRICAL OUTLET LOCATION
UBICACIÓN DE LA TOMA DE ELECTRICIDAD EMPLACEMENT DE LA PRISE DE COURANT

XP8WQ*1D
PAGE 40000001091 (Rev. A - 02/16)
6
24
9
1110
5
ADJUST THIS SCREW TO ELIMINATE VALVE LEVER "FREE PLAY"
OR CONTINUOUS FLOW FROM BUBBLER
STREAM HEIGHT
ADJUSTMENT SCREW
CORRECT STREAM HEIGHT
FIG. 5
PUSH BUTTON VALVE ADJUSTMENT
FIG. 3
FIG. 4
CONDENSER WATER VALVE ADJUSTMENT
The condenser water valve is factory preset for a condenser water outlet temperature of 95° to 105° F.
If actual temperature varies greatly from this, readjust water ow rate at the valve using the following procedures.
1. START UP COMPRESSOR
This can be accomplished by depressing the cooler push button (See Fig. 1 - Item 2). Keep water
running during the entire readjustment procedure.
2. ADJUSTMENT CONDENSER WATER VALVE
Adjust valve by rotating adjustment stem. Rotating stem clockwise will increase water ow.
Counterclockwise rotation will decrease water ow. Increasing water ow will result in a lower
condenser outlet temperature, while decreasing water ow will result in a higher outlet temperature.
Proper adjustment is attained when condenser outlet temperature is 95° to 105° F.

XP8WQ*1D
PAGE 5 0000001091 (Rev. A - 02/16)
FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR VISIT OUR WEBSITE WWW.HALSEYTAYLOR.COM
2222 CAMDEN COURT
OAK BROOK, IL 60523
630.574.3500
PRINTED IN U.S.A.
PARTS LIST 115V
DESCRIPTION
1
2
3
4
5
6
7
8
9
10
11
12*
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
NS
Stem Bushing
Push Button Assy
Brkt - Conduit Support
Drain Plug
Kit - Regulator/Holder/Nut
Kit - Bubbler/Nipple/Gaskets
Strainer Plate
Basin
Regulator Lever
Pivot Bracket
Regulator Retaining Bracket
Compressor Service Pak
Overload
Relay
Cold Control Assy
Kit - Drain/Gasket/Adapter/Nut/Seal
Gasket
Electrical Box-Cold Control
Kit - Heat Exchanger/Drier
Electrical Box-Power Connection
Tailpipe Assy
Poly Tubing (Cut To Length)
Kit - Union - 1/4 (3 Pack)
Regulator Mounting Bracket
Right Panel
Left Panel
Strainer
Condenser Assy
Elbow - 3/8
Drier - Note: for individual sale & also included in Item #19
Kit - Evaporator Replacement
Kit - Tee - 1/4 (3 Pack)
Check Valve
Front Panel
101452331870
601451151550
28368C
102639931640
98531C
98533C
160270508640
28461C
26860C
26861C
26862C
36220C
35797C
35803C
600793851550
98683C
75589C
45340C
0000000240
45347C
45448C
56092C
1000002162
55880C
401536242830
401536342830
55996C
66798C
75561C
66202C
1000003361
1000001994
75494C
507442830
PART NO.ITEM
*INCLUDES RELAY & OVERLOAD. IF UNDER WARRANTY, REPLACE
WITH SAME COMPRESSOR USED IN ORIGINAL ASSEMBLY.
NOTE: All correspondence pertaining to any of the above water cool-
ers or orders for repair parts MUST include Model No. and Serial No. of
cooler, name and part number of replacement part.