Heatilator A36R User manual
1
WOODBURNING FIREPLACE
Fire Risk.
WARNING
For use with solid wood fuel only.
Model(s): • DO NOT-
• DO NOT
-
WARNING: If the information in these
or explosion may result causing property
damage, personal injury, or death.
Owner’s Manual
Operation and Care
WARNING
HOT SURFACES!
Hot glass will cause burns.
• DO NOT
materials.
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
Contact your dealer with questions on installation, operation, or service.
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
A36R, A36RH
A42R, A42RH
2
Safety Alert Key:
• DANGER!
• WARNING!
• CAUTION!
• NOTICE:
Table of Contents
1 Welcome
2
3 Important Safety and Operating Information
4Maintenance and Service
5 Troubleshooting
6 Reference Materials
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
A. Congratulations
Listing Label Information/Location
1
1 Welcome
________________________________________________ ___________________________
__________________________________________ __________________________
Fireplace Information:
Local Dealer Information
DEALER: Fill in
your name, address,
phone and e-mail
information here and
below.
____________________________________________________________
Grate
Fireplace
Model
Serial
Number
SERIAL NO./NUMERO DESERE
MODEL/MODELE
MFG. DATE
WARNING: RISK OF FIRE DAMAGE. REPLACE GRATE
WITH HEARTH & HOME
TECHNOLOGIES
FIREPLACE ALSO FOR USE IN
MANUFACTURED/MOBILE HOMES
WITH SOLID FUEL ONLY
YES NO
CLEARANCE TO
COMBUSTIBLES:
FIREBOX/
FOYER
IN.
MIN.
FAN KIT/
KIT DU VENTILATUER
MODEL NO.
AMP.
IF INSTALLATION OR OPERATING INSTRUCTIONS ARE MISSING
CONTACT:
HEARTH & HOME TECHNOLOGIES,
7571 215th Street West, Lakeville, MN 55044.
P.N. 4021-954E
FIRE CHAMBER INTENDED FOR USE WITH HEARTH & HOME TECHNOLOGIES
LISTED FIREPLACE PARTS AND GLASS DOOR KITS. SEE INSTALLATION AND
OPERATING INSTRUCTIONS FOR THIS MODEL.
GRATE MODEL/GRILLE MODELE
DEGAGEMENT DES
MATEIAUX COMBUSTIBLES:
MM
MIN.
AVERTISSEMT:RISQUE DE DOMMAGE PARINCENDIE, REMPLACEZ LA GRILLE AVEC
HEARTH & HOME TECHNOLOGIES
CHIMNEY/CHEMNEE
2 IN. MIN.
51 MM
RATED AT/CAPACITE
115 VOLTS, 50/60 HZ
CAN/ULC-S610
USE HHT SL SERIES CHIMNEY
UTILISER DU CARBURANT
SOLIDE SEULEMENT
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
-
-
-
B. LIMITED LIFETIME WARRANTY
Hearth & Home Technologies LLC
LIMITED WARRANTY
Hearth & Home Technologies LLC (“HHT”) extends the following warranty for HHT gas, wood, pellet and electric hearth appliances
!"#
WARRANTY COVERAGE:
!$
% ' % # *
$ ' % !
#!+
%#!%'
- % ++'
#!%.+#
WARRANTY PERIOD:
%''#*%''+/
0"!#%'
12'!'
#
Page 1 of 2
4021-645N 12/23
Component
Parts Labor Gas Pellet Wood Electric Component Parts Covered by this Warranty
XAllpartsexceptascoveredbyWarrantyConditions,WarrantyExclusions,andWarranty
Limitationslisted
XX
Glass, Electrical components limited to heating element/igniters, Top feed auger assembly,
Blowers, Junction Box, Remotes/Wall switches, linear actuator, power cord, vacuum switch,
snap disc, wire harnesses and thermocouple
XElectrical components limited to modules, remotes/wall switches, valves, pilots, blowers,
junction boxes, wire harnesses, transformers and lights (excluding light bulbs)
XX Cement Refractory Panels, Glass Liner Panels
XFirepots, burnpots, Harman mechanical feeders
XX Catalysts, Vented and Vent Free burners and logs
10 years 1 year XBurners, logs and metal/fiber refractory components of HHT manufactured fireplaces or stoves,
venting due to poor workmanship
10 years 3years XX Castings, Medallions & Baffles, FlexBurn® System (engine, inner cover, access cover and
fireback), Firebox and heat exchanger, HHT Chimney & Terminations, Manifolds
20 years 3 years XFirebox and heat exchanger
1 Year None XXXX All purchased replacement parts and optional accessories
3 years
5 years
All purchased replacement parts and optional accessories
2 Years
Warranty Period HHT Manufactured Appliances and Venting
All parts including handles, external enameled components and other material except as
covered by Warranty Conditions, Warranty Exclusions, and Warranty Limitations listed
1 Year XXX
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
5
WARRANTY CONDITIONS:
4 5!-"%
'!"6!"
!#
4 !%'#
4 !%!"
"#
4 ' % # * '
!"#7$'
%'#
4 8!'##'
'%#$
''#!''%#
WARRANTY EXCLUSIONS:
!%'9
4 '0#7''+
0#!:%#
4 ;' 0'
+/#
4 <.'%#!
9'$0$':'='#
4 >+'#!
%#
4 ;' ' 9 ?
' ' ' 0 6 1
'6@''62
'B
6D-'/''
F$G'+6I
0 6J
+"!6K0+
"!'6BM:
#
4 8G!'.#
4 7G+'0'#
4 !O'%+O#*
' # '
0''#
This warranty is void if:
4 ! G0 : ''
#PG0'0B'
'$'0#
4 !.'#
4 !''
'#
LIMITATIONS OF REMEDIES AND LIABILITY:
• EXCEPT TO THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED
!""
"#"#$%#'()"#$%#'()"$$
##$##'()$*
$##'++$*
"##!#-
also have other rights which vary from State to State. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF
/'++0!112+'%301456351''7%147'508%++
#"##
Page 2 of 2
4021-645N 12/23
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
2
2
Warning! Risk of Fire!
For use with solid wood fuel only.
(i.e. carbon monoxide).
B. Vented Gas Log Sets, Unvented Gas Log
Sets, Gas or Wood Inserts and Gas Log
Lighters
Unvented Gas Logs
CAUTION! I
-
WARNING! Do Not
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
-
-
A. Fireplace Safety
-
3
3 Important Safety and Operating Information
WARNING! Risk of Fire!
disclaims any responsibility for, and the warranty and
DO NOT:
• install any component not approved by Hearth & Home
• install parts or components not Listed or approved
components
Improper installation, adjustment, alteration, service or
1. Clear Space
-
WARNING! Risk of Fire! Keep combustible materials,
DO NOT:
48 in. (1219 mm)
Clear Space
Front of Fireplace
12 in. (305 mm)
Clear Space
Sides of Fireplace
(from the FP
opening)
43-1/2 in. (1105mm)
Clear Space
Bottom of Fireplace
to Lower Edge of
Mantel or Trim
g)
g)
f
r
S
f
r
1
2 in.
(
305 mm
)
C
lear
S
pac
e
S
ides o
f
Fire
p
lac
e
(f
rom the FP
opening)
43-1/2 in.
C
lear
B
ottom o
f
to Lowe
r
M
a
nt
e
l
g)
f
r
48 in.
(
1219 mm
)
C
lear
Sp
ac
e
Front of Fire
p
lac
e
Figure 3.1 Clear Space
WARNING: This product and the fu-
els used to operate this product (wood
and wood pellets), and the products of
combustion of such fuels, can expose
you to chemicals including carbon black,
which is known to the State of California
to cause cancer and carbon monoxide,
which is known to the State of California to
cause birth defects or other reproductive
harm. For more information go to: www.
P65Warnings.ca.gov.
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
8. Chimney Fire
NFPA 211
Level 2
WARNING! Risk of Fire! -
-
7. Over-Firing Your Fireplace
WARNING! Risk of Fire!
• overload with wood
•
2. Grate
WARNING! Risk of Fire! Use only the factory-sup-
3. Refractory
WARNING! Risk of Fire! DO NOT -
out refractory. Use only refractory supplied by Hearth &
4. Firescreen
WARNING! Risk of Fire or Burns!
out.
• Screen pulls or handles may be hot.
5. Flue Damper
WARNING! Risk of Fire and Asphyxiation! Open
into the room.
6. Glass Doors
WARNING! Risk of Fire!
WARNING! Risk of Fire and Smoke! Fireplace
doors fully open or doors fully closed. If doors are left
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
B. General Operating Parts
WARNING! DO NOT -
WARNING
Hot glass will cause burns.
•DO NOT
HOT SURFACES!
Open Close
Close Open
Flue Damper
Control
Section 2.F.
Outside Air Kit
Control
Section 2.I.
Figure 3.2 General Operating Parts
CAUTION!
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
3. Glass Doors
1. Flue Damper
FULLY OPEN
CORRECT
PARTLY CLOSED
INCORRECT
PARTLY OPEN
INCORRECT
FULLY CLOSED
CORRECT
Figure 3.3 Operating Positions of Bi-fold Doors
2. Outside Air (Optional)
CAUTION! Outside air control handle may be warm.
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
11
WARNING! Risk of Fire!
• DO NOT
• Wet, unseasoned wood can cause accumulation of
creosote.
C. Fuel
1. Hardwood vs. Softwood
-
-
-
-
-
-
-
-
-
-
2. Moisture content
-
-
WARNING! For use with solid wood fuel only.
carbon monoxide).
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
12
5. Burning Process
6. Creosote Formation and Need for Removal
-
-
7. Processed Solid Fuel Firelogs
-
-
3. Seasoning
NOTICE:
conditions.
4. Storing Wood
D. First Fire
.
-
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
WARNING! Risk of Fire! Keep combustible materials,
DO NOT:
E. Lighting Instructions
NOTICE:
-
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
4
4
Maintenance and Service
WARNING! Hot Surfaces!
down. DO NOT
please contact your dealer for a ser-
vice appointment.
A. Chimney Inspection
Frequency:
By:
-
WARNING! Risk of Asphyxiation and Fire! Annual
• condition of doors, surrounds and fronts
• obstructions of combustion and ventilation air
• obstructions of termination cap
WARNING! Risk of Fire!
HOT. Prevent creosote buildup.
B. Creosote (Chimney) Cleaning
Frequency: -
By:
Tools -
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
15
Figure 4.1 Chimney & Termination Cap Cleaning
C. Grate
Frequency:
By:
D. Glass Cleaning
Frequency:
By:
Tools Needed
F. Refractory
Frequency:
By:
E. Ash Removal
Frequency:
By:
Tools Needed
WARNING! Risk of Fire! DO NOT remove ashes until
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
Chimney
Remove 4 screws
and lift top pan off.
Cap
Slip
Section
ST375
Square
Termination Cap
Cap
Remove screws,
lift top cover.
Top Cover
TR344/TR342
Round
Termination Cap
Chase
Cap
1. Remove the 4 screws.
2. Remove the screen.
3. Remove the baffle.
TS345/TS345P
Square
Termination Caps
TCT375
Terra Cotta
Termination Cap
Remove 2 screws from
the front and back and
lift the top off.
Remove 8 screws
and lift top.
DTO/DTS Series
Termination Cap
Screw
Top
Top
Screw
5
5 Troubleshooting
Start Fire Problems Possible Cause Solution
large
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
A. FAQs
-
-
-
-
-
-
-
-
-
-
Contact your dealer for additional informa-
tion regarding operation and troubleshoot-
dealer.
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
Another appliance in
home also exhausting
air (furnace, fan,
dryer, etc.)?
Air register from
furnace near
fireplace?
Doors opening
and closing?
Window closed
for start-up?
Outside air
closed?
Overhead fan
operating?
Overhanging
tree?
Bird's nest
or leaves in
termination
cap?
Structural
changes in
chimney area?
Creosote buildup
in flue?
S
t
r
o
n
g
w
i
n
d
s
a
r
o
u
n
d
c
h
i
m
n
e
y
t
e
r
m
i
n
a
t
i
o
n
?
Unsealed
can lights?
Combustion
air control
Figure 5.1 Factory-built Fireplaces: Troubleshooting
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
6
6 Reference Materials
A. Service Parts
Service Parts
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
1 Starter Section SRV22069 Y
2 Qty 4 req. SRV4044-111
3 Upper Face SRV30567BK
4 Left and Right Column SRV29899BK
5 Lower Face SRV29231BK
6 Hearth Filler SRV30331BK
7 Grate, 21.75”F x 12.29”D x 13.03”B GR18 Y
Grate Clip Qty 2 req. SRV28062
Hang Down Damper Kit Order for rod replacement SRV28380
Damper Weight Order when rod is not
being replaced
SRV19785
Damper Blade 30558
Door Pivot Clip Qty 2 req. SRV31527
Firescreen Assembly Qty 2 req. 26053 Y
Firescreen Handle Qty 2 req. SRV10002
Firescreen Rod Qty 2 req. SRV12052 Y
Nailing Flange Qty 4 req. SRV31190
Drywall Flange 29238
Outside Air Kit AK22
Refractory Retainer Qty 3 req SRV11847
Smoke Diverter 30559
Strip Protector Qty 2 req. SRV18320
Smoke Shield 31191
Upper Door Track SRV15425BK
Installation Manual 4017-259
Owner’s Manual 4017-260
Additonal Service parts on following page. 10/23
A36R, A36RH
Accelerator Woodburning
Fireplaces
Beginning Manufacturing Date: June 1998
Ending Manufacturing Date: Active
1
2
3
4
5
6
7
Service Parts
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Traditional Refractory (A36R)
5.1
30.90”F x 18”D x 17.08”B Pre Week 34/98 29244
Hearth Refractory 30.50”F x 18.44”D x 19.80”B Week 34/98 thru SN# AK672454 SRV29993
30.50”F x 18.44”D x 19.80”B Post SN# AK672454 SRV4010-017
5.2
17.06”W x 22.50”H Pre Week 34/98 29245
Back Refractory 20”W x 22.50”H Week 34/98 thru SN# AK672454 SRV29992
20”W x 22.50”H Post SN# AK672454 SRV4010-059
5.3 Side Refractory(Left/right) 18”W x 22.50”H Pre SN# AK672454 SRV28393
18”W x 22.50”H Post SN# AK672454 SRV4010-058
Herringbone Refractory (A36RH)
6.1 Hearth Refractory 30.55”F x 18.44”D x 19.80”B SRV4010-017
6.2 Back Refractory 20”W x 22.50”H Pre SN# AK652532 4010-012
Post SN# AK652532 SRV4010-063
6.3 Left Hand Refractory 18”W x 22.50”H Pre SN# AK652532 4010-010
Post SN# AK652532 SRV4010-061
6.4 Right Hand Refractory 18”W x 22.50”H Pre SN# AK652532 4010-009
Post SN# AK652532 SRV4010-062
Beginning Manufacturing Date: June 1998
Ending Manufacturing Date: Active
A36R, A36RH
6.3 6.4
6.2
6.1
5.3 5.3
5.1
5.2
#5 Traditional Refractory
#6 Herringbone Refractory
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
Service Parts
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
1 Starter Section SRV22069 Y
2 Qty 4 req. SRV4044-111
3 Upper Face SRV30566BK
4 Left and Right Column SRV29899BK
5 Lower Face SRV28377BK
6 Hearth Filler SRV30332BK
7 Grate, 27.75”F x 12.29”D x 19.39”B GR19 Y
Grate Clip Qty 2 req. SRV28062
Hang Down Damper Kit Order for rod replacement SRV28380
Damper Weight Order when rod is not
being replaced
SRV19785
Damper Blade 30558
Door Pivot Clip Qty 2 req. SRV31527
Firescreen Assembly Qty 2 req. 29246 Y
Firescreen Handle Qty 2 req. SRV10002
Firescreen Rod Qty 2 req. SRV4010-102 Y
Nailing Flange Qty 4 req. SRV31190
Drywall Flange 28388
Outside Air Kit AK22
Refractory Retainer Qty 3 req. SRV11847
35329
35330
Smoke Shield 35221
Strip Protector Qty 2 req. SRV18320
Upper Door Track SRV15427BK
Installation Manual 4017-259
Owner’s Manual 4017-260
Additonal Service parts on following page. 10/23
A42R, A42RH
Accelerator Woodburning
Fireplaces
Beginning Manufacturing Date: June 1998
Ending Manufacturing Date: Active
1
2
3
4
5
6
7
Service Parts
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or
distributor. Hearth and Home Technologies does not sell directly to consumers. Provide
model number and serial number when requesting service parts from your dealer or distributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Traditional Refractory (A42R)
5.1 Hearth Refractory 35.98”F x 18”D x 22.96”B Pre SN# AK672478 SRV28391
Post SN# AK672478 SRV4010-018
5.2 Back Refractory 23.06”W x 22.50”H Pre SN# AK672478 SRV28394
Post SN# AK672478 SRV4010-060
5.3 Pre SN# AK672478 SRV28393
Post SN# AK672478 SRV4010-058
Herringbone Refractory (A42RH)
6.1 Hearth Refractory 35.98”F x 18”D x 22.96”B SRV4010-018
6.2 Back Refractory 23.06”W x
22.50”H
Pre SN# AK652487 4010-011
Post SN# AK652487 SRV4010-064
6.3 Left Hand Refractory 18”W x
22.50”H
Pre SN# AK652487 4010-010
Post SN# AK652487 SRV4010-061
6.4 Right Hand Refractory 18”W x 22.50”H Pre SN# AK652487 4010-009
Post SN# AK652487 SRV4010-062
Beginning Manufacturing Date: June 1998
Ending Manufacturing Date: Active
A42R, A42RH
5.3 5.3
5.1
5.2
6.3 6.4
6.2
6.1
#5 Traditional Refractory
#6 Herringbone Refractory
Heatilator • A36/42R, A36/42RH Owners Manual • 4017-260 • Rev R • 1/24
Other manuals for A36R
7
This manual suits for next models
3
Table of contents
Other Heatilator Indoor Fireplace manuals
Heatilator
Heatilator HB36A Installation instructions
Heatilator
Heatilator Wood Burning Fireplace ST36D User manual
Heatilator
Heatilator NBV30-IFT User manual
Heatilator
Heatilator CONSTITUTION C-40 User manual
Heatilator
Heatilator Birmingham BIR42 User manual
Heatilator
Heatilator I60 User manual
Heatilator
Heatilator Reveal RBV4236I User manual
Heatilator
Heatilator NB3630 User manual
Heatilator
Heatilator Wood Burning Fireplace EL36 Series User manual
Heatilator
Heatilator NA36AI User manual
Heatilator
Heatilator BIR36-B User manual
Heatilator
Heatilator Direct Vent Gas Appliance CNXT4236IT User manual
Heatilator
Heatilator CST42A User manual
Heatilator
Heatilator SC60 User guide
Heatilator
Heatilator CRAVE4836-C User manual
Heatilator
Heatilator Novus GNRC33 Manual
Heatilator
Heatilator Novus NDV3630 User manual
Heatilator
Heatilator CB4236IR User manual
Heatilator
Heatilator CRAVE4836 User manual
Heatilator
Heatilator CONSTITUTION C-40 User manual
Popular Indoor Fireplace manuals by other brands
Osburn
Osburn Stratford Installation and operation manual
kozy heat
kozy heat 932 Installation and operating manual
EWT
EWT Opti-V Fire Single manual
Multiglow Fires
Multiglow Fires Classic II Installation, servicing & user instructions
Valor Fires
Valor Fires 754 Installer and owner guide
Monzana
Monzana DBHK005 manual
Travis Industries
Travis Industries 864 TRV GS Operation and maintenance manual
Lennox Hearth Products
Lennox Hearth Products Brentwood SP Installation & operation manual
Desa
Desa Vanguard VSGF28NTE OWNER'S OPERATION AND INSTALLATION MANUAL
EQUATION
EQUATION EQI-80R Installation, use and maintenance instructions
Monessen Hearth
Monessen Hearth Direct Vent BLDV400 Product specifications
Wonderfire
Wonderfire 963 Installer and owner guide
Faber
Faber e-MatriX mood 800/500 RD installation manual
Majestic
Majestic TRILLIANT25IN installation manual
Osburn
Osburn Bay Vista Installation and operating instructions
Hargrove
Hargrove GAS LOGS Installation and operation guide
Trimline Fires
Trimline Fires 70 SL installation instructions
Nordpeis
Nordpeis Salzburg L Convection installation manual