Heatilator ECO CHOICE WOOD STOVE User manual

July 28th, 2011
WOOD STOVE
SERVICE MANUAL
Shock and Smoke Hazard
• Allowtheappliancetocompletelycoolbefore
servicingormakingrepairs.
• Smokespillageintoroomcanoccurifappliance
ventingisnotproperlyinstalled.
• Riskofshockifappliancenotunpluggedbefore
servicingappliance.
CAUTION
• Installationanduseofanydamagedappliance.
• Modicationoftheappliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installationand/oruseofanycomponentpartnotapproved
byHearth&HomeTechnologies.
• Operating appliance without fully assembling all
components.
• Operatingappliancewithoutlegsattached(ifsuppliedwith
unit).
• DoNOTOverre
Or any such action that may cause a re hazard.
WARNING
Hearth&HomeTechnologiesdisclaimsany
responsibilityfor,andthewarrantywillbe
voidedby,thefollowingactions:
FireRisk.
NOTE: Hearth&HomeTechnologies,manufacturerof
thisappliance,reservestherighttoalteritsproducts,
theirspecicationsand/orpricewithoutnotice.
Shockhazard.
• DoNOTremovegroundingprongfromplug.
• Plugdirectlyintoproperlygrounded3prong
receptacle.
• Unplugcordbeforedoinganychecksorrepairs.
• DoNOTtouchwireswhileunitispluggedin.
CAUTION

TABLE OF CONTENTS
SECTION PAGE
STARTINGAFIRE
BASICUNITINSPECTION
COMBUSTIONAIRPATHWAYS
PROPERBAFFLEPLACEMENT
CHIMNEYLOCATIONS
CHIMNEYDRAFTBASICS
HOWTOMANAGECOALBEDS
HOWTOINSTALLNEWGLASSGASKET
HOWTOINSTALLNEWDOORROPEGASKET
HOWTOADJUSTTHEDOORHANDLE
HOWTOADJUSTTHEDOORHINGE
GENERALSPECIFICATIONS
BLOWERTROUBLESHOOTING
HOWTOREPLACETHERHEOSTAT
3
4
5
6
7
8
9
10
11
12
13
14
15
16-17
PAGE2

ECO CHOICE WOOD STOVE SERVICE MANUAL
STARTING A FIRE
PAGE3
UNIT IS READY FOR NORMAL
OPERATION.
123
4 5
67
FIRSTFIREITEMSNEEDED:10PIECESOFNEWSPAPER,10-20PIECESOFDRY
KINDLINGANDAFEWPIECESOFDRYSPLITWOOD.
LOAD WOOD ADD NEWSPAPER
ADD KINDLING
OPENTHEFIREBOXDOOR
ABOUTA1/2INCHUNTILTHE
DRAFTISESTABLISHED.
WARNING
(DO NOT LEAVE UNATTENDED)
ADD MORE WOOD
LIGHT THE PAPER
OPEN AIR
CONTROL
REDUCE AIR
CONTROL

ECO CHOICE WOOD STOVE SERVICE MANUAL
BASIC UNIT INSPECTION
PAGE4
WOOD UNIT MAINTENANCE
1445 North Highway
Colville, Wa 99114 www.quadrare.com
7014-XXX January 14, 2009 Page 1 of 1
BAFFLE PLACEMENT INSPECT FIREBRICKS & ASH GRATE
(AFTER EACH CLEANING)
CHIMNEY & CAP INSPECTION DOOR & LATCH CHECK
Firebrick is designed to protect your rebox. Replace
rebricks that are crumbling, cracked, or broken. If
you have an optional ash door, check to make sure
the door is closing properly.
Bafe & blanket placement is critical to heat output,
efciency and overall life of the unit. Make sure the
bafe is pushed all of the way to the back of the
rebox and the blanket is laying at.
Keeping the door & glass gas-
ket in good shape will main-
tain good burn times on a low
burn setting.
Check the glass frame for
loose screws to prevent air
leakage.
Check the door latch for proper adjustment. This
is very important especially after the door rope has
formed to the stove face.
The chimney and chimney cap
must be inspected for soot
& creosote during the burn
season. This will prevent pipe
blockage, poor draft, and chim-
ney res.
Always burn dry wood to help
prevent cap blockage & creo-
sote build-up.
Start the rst inspection of your unit after the rst 2 months of use or if performance changes and adjust
your schedule accordingly. Maintenance is required for safe operation and must be performed to maintain
your warranty.

ECO CHOICE WOOD STOVE SERVICE MANUAL
COMBUSTION AIR PATHWAYS
Combustionairowsthroughthebackofthepedestalintothe
combustionairchannel.Thisairthenowstothecombustion
airinletareasonthesideoftheunit.
UPPER AIR INLET (AIRWASH)
LOWER AIR INLET
TUBE CHANNEL AIR INLET
COMBUSTION AIR FROM PEDESTAL
PAGE5

ECO CHOICE WOOD STOVE SERVICE MANUAL
PROPER BAFFLE PLACEMENT
PAGE6
Fiberbaffle
Ceramicblanket
Thistabsitsbehindthefronttube.
Baffle
protection
Channelsits
Inbetween
Fronttubeand
Fiberbaffle.
Side view
Front, looking into unit

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE7
SUGGESTEDCHIMNEYLOCATIONSFOROPTIMUMPERFORMANCE.

ECO CHOICE WOOD STOVE SERVICE MANUAL
CHIMNEYDRAFTBASICS
PAGE8
Hasthechimneyhaseverworkedproperly?Thiswillhelpindeterminingif
theproblemiswiththelocationofthechimneywhenitwasinstalledorifitis
aproblemwiththechimneybeingrestricted.
Items to look at:
***Isthechimneycapclean?
***Isthechimneyfreeofcreosote?
***Isthehomeownerburningdrywood?
***Isthestovebafeinthecorrectposition?
***Checkforfansrunninginthehousethatwilleffectdraft.
***Canhotairescapeabovethechimneytermination?
 (Thiswillreducedraft)
***Istheentirechimneysystem6inchindiameter?
***Isthechimneyprotectedfromgettingtoocold?
Ifthedraftinthechimneyisworking,butitisnotquitepullingenoughair
throughit,addasectionofchimneytothesystem.Eachadditionalvertical
sectionofchimneywillincreasedraft.
Chimneysneedtostaywarmatalltimesorthedraftcanbelost. 6inch
CLASSAPIPE
CLEAN
CHIMNEY
CAP
DRYWOOD
PROPERBAFFLE&BLANKETPLACEMENT

ECO CHOICE WOOD STOVE SERVICE MANUAL
HOW TO MANAGE COAL BEDS
1)Rakethecoalsfromthebackofthereboxforward.
2)Putonemediumsizesplitpieceofwooddirectlyontopofthecoals.
3)Shutthedoorandturntheburnratecontroltohigh.Allowthewoodtoburnthecoalsdown.
4)Repeatthepreviousstepsuntilthecoalshaveburneddown.
5)Spreadremainingcoalsevenlyacrossthereboxoorandloadatleastthreeseparatesplit
piecesofwood.
6)Setburnratecontroltodesiredlevel.
FIREBOXWITHA
LARGECOALBED.
EXAMPLEOFRAKINGTHE
COALSFORWARD.
ASH RAKE
PAGE9

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE10
TESTCORDCONNECTEDTOTHEBLOWER
HOWTOINSTALLNEWGLASSGASKET
1)REMOVEGLASSRETAINERFROMTHE
DOOR.
2)CAREFULLYREMOVETHEGLASS.
3)REMOVEOLDGASKETANDCLEANTHE
GLASS.
4)INSTALLNEWGLASSGASKETSTARTING
ATTHEBOTTOMCORNER.MAKESURETHE
GASKETISEVENONBOTHSIDESOFTHE
GLASS.
5)CAREFULLYPLACETHEGLASSBACKINTO
THEDOORFRAME.KEEPTHECUTEDGEOF
THEGASKETTOWARDSTHEBOTTOMHINGE
SIDEOFTHEDOOR.
6)REINSTALLTHEGLASSRETAINERAND
SCREWS.DONOTOVERTIGHTENTHE
SCREWS.

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE11
HOWTOINSTALLNEWDOORROPEGASKET
1)REMOVEOLDDOORGASKETANDCLEAN
THEGASKETGROOVEAREA.REMOVEAS
MUCHOFTHEOLDSILICONEASPOSSIBLE.
2)PUTABEADOFNEWHIGHTEMPRED
SILICONEINTOTHEGASKETGROOVE.
3)PREPTHEDOORROPECUTENDBY
TUCKINGTHELOOSEENDSBACKINTO
ITSELF.
4)STARTINSTALLINGTHEROPEONTOTHE
DOORSTARTINGATTHEHINGESIDE.
5)AFTERTHEDOORROPEHASBEENSUC-
CESSFULLYREPLACED,REINSTALLDOOR
ONTHEUNITANDALLOWTODRYFOR12
HOURSBEFOREBURNINGTHESTOVE.

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE12
HOWTOADJUSTTHEDOORHANDLE
Dooradjustmentmaybenecessaryaftertheunithasbeenburnedorifthedoorrope
sealhasbeenreplaced.
Toadjustthedooreithertighterorlooser,followtheinstructionsbelow:
1)Removethelocknut,latchcam,andsquarekey.Note:Iftheunithasbeenused
forawhile,soakthenutinoiltoassistwithremoval.
2)Ifthedooristootight,addaspacingwasherbetweenthedoorframeandlatch
cam.Ifmorethantwospacingwashersareneeded,verifythattheproperdoorrope
isinstalledandreplaceifneeded.
3)Ifthedooristooloose,removeaspacingwasherfrombetweenthedoorframe
andlatchcam.Ifnospacingwashersarepresent,thedoorwillneedtobere-roped.

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE13
HOW TO ADJUST THE DOOR HINGE
EXAMPLEOFAUNITWITHWELDEDHINGES

ECO CHOICE WOOD STOVE SERVICE MANUAL
GENERAL SPECIFICATIONS
PAGE14
WATTS:
CONVECTIONBLOWER
GRAMS PER HOUR
BURN TIME ON LOW
BTU:
MINIMUM DRAFT NEEDED:
LOWSETTING
HIGHSETTING
BLOWER CFM:
CONVECTION
GLASSTYPE
BRICK TYPE
MAX LOG LENGTH
WS18 WS22
60 60
AMPS:
CONVECTIONBLOWER .52 1.3
2.6 2.7
CERAMIC CERAMIC
PUMICE PUMICE
150 150
41,800 55,600
-.04inchesWC
-.10inchesWC
-.04inchesWC
-.10inchesWC
8HOURS
18 22
12HOURS
WOOD MOISTURE CONTENT 16%TO20% 16%TO20%
NOTE: Hearth&HomeTechnologies,manufacturerof
thisappliance,reservestherighttoalteritsproducts,
theirspecicationsand/orpricewithoutnotice.
NOTE: Specications are approximate.

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE15
BLOWERTROUBLE-SHOOTING
1)Checkforpowerfromthepowercord.
2)Ifpowerispresent,checkthebypassswitch.
3)Iftheswitchisworking,checkthesnapdisc.
4)Checkforpowerattheblower.
Shockhazard.
• DoNOTremovegroundingprongfromplug.
• Plugdirectlyintoproperlygrounded3prong
receptacle.
• Unplugcordbeforedoinganychecksorrepairs.
• DoNOTtouchwireswhileunitispluggedin.
CAUTION

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE16
HOWTOREPLACETHERHEOSTAT
RHEOSTATPART#842-0370 BLOWERPOWERCORDPART#SRV7000-194
STEP 1) UNPLUGTHE
POWERCORD.REMOVE
THE4SCREWSONTHE
BACKOFTHEBOX.
STEP 2)REMOVETHEKNOB
FROMTHERHEOSTAT.A
SMALLSETSCREWINTHE
KNOBHOLDSITINPLACE.
STEP 3)REMOVERHEOSTAT
ANDCUTTHEWHITEAND
BLACKWIRE.
HIGH OFF
LOW
FAN
AUTO
MANUAL
HIGH OFF
LOW
FAN
AUTO
MANUAL
HIGH OFF
LOW
FAN
AUTO
MANUAL

ECO CHOICE WOOD STOVE SERVICE MANUAL
PAGE17
HOWTOREPLACETHERHEOSTAT
STEP 4) REMOVETHE
PLASTICCOVERFROMTHE
REPLACEMENTRHEOSTAT.
STEP 5) INSTALLNEWCONNECTORS
TOTHEWHITEANDBLACKWIRES
ANDREINSTALLTHERHEOSTAT
BACKINTOTHEBOX.
STEP 6) REINSTALLTHERHEOSTATCONTROL
KNOBANDINSTALLTHEBACKCOVERPLATE.