HP Kayak XU 04xx User manual

Mini-Tower
PC Workstations
HP Kayak XU PC Workstation (up to 333 MHz) 6-1
6
6
HP Kayak XU PC Workstation
(up to 333 MHz)
Models and Accessories
Product
Number
Processors Hard
Drive
Video
Controller
Std.
RAM
Multi-
media
LAN OS
Kayak XU PC Workstation
HP Kayak XU 6/266 MHz (CPL: 9/97 )
D4691N Single
Pentium II
with 512 KB
of L2 cache
memory
2.1 GB,
7.2k rpm,
SCSI
Matrox
Millenium II
AGP, 4 MB
on board,
upgradeable
to 16 MB
32 MB
SDRAM
ECC
24✕IDE
CD-ROM.
Audio chip
(AD1816) is
integrated
on the
system
board.
10BT/
100TX
NT
4.0
WS
D4692N 4.5 GB,
7.2k rpm,
SCSI
64 MB
SDRAM
ECC
HP Kayak XU 6/300 MHz (CPL: 9/97 )
D4693N Single
Pentium II
with 512 KB
of L2 cache
memory
2 x 4.5 GB,
10k rpm,
SCSI with
HP
FastRAID
Matrox
Millenium II
AGP, 4 MB
on board,
upgradeable
to 16 MB
64 MB
SDRAM
ECC
24✕IDE
CD-ROM.
Audio chip
(AD1816) is
integrated
on the
system
board.
10BT/
100TX
NT
4.0
WS
D4694N Dual
Pentium II
with 512 KB
of L2 cache
memory
4.5 GB
10k rpm,
SCSI
D4695N Single
Pentium II
with 512 KB
of L2 cache
memory
D4701N 4.5 GB,
10k rpm,
SCSI with
HP
FastRAID
D4702N 9.1 GB,
10k rpm,
SCSI
128 MB
SDRAM
ECC
ka_sh_1.bk : xu-k.fb4 Page 1 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
6-2 HP Kayak XU PC Workstation (up to 333 MHz) Mini-Tower
PC Workstations
6
Note
All models are supplied with a 1.44 MB (D2035B) Flexible Disk Drive, two
integrated SCSI controllers (one Ultra Wide 16-bit SCSI and one Ultra Narrow 8-
bit SCSI), and an integrated IDE controller.
HP Kayak XU 6/333 MHz (CPL: 3/98 )
D4705N Single
Pentium II
with 512 KB
of L2 cache
memory
4.5 GB,
10k rpm,
SCSI with
HP
FastRAID
Matrox
Millenium II
AGP, 4 MB
on board,
upgradeable
to 16 MB
64 MB
SDRAM
ECC
24✕IDE
CD-ROM.
Audio chip
(AD1816) is
integrated
on the
system
board.
10BT/
100TX
NT
4.0
WS
Product
Number
Processors Hard
Drive
Video
Controller
Std.
RAM
Multi-
media
LAN OS
ka_sh_1.bk : xu-k.fb4 Page 2 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
Mini-Tower
PC Workstations
HP Kayak XU PC Workstation (up to 333 MHz) 6-3
6
Supported Accessories
1. Dual Processor Kits include: processor, voltage regulator module and heatsink.
2. Only one 1.6-inch hard disk drive is supported in the Kayak XU PC Workstation (on the
lower internal shelf).
32 MB ECC SDRAM upgrade kit D5365A
64 MB ECC SDRAM upgrade kit D5366A
128 MB ECC SDRAM upgrade kit D5367A
4 MB memory upgrade for Matrox Millenium II AGP video controller D5487A
HP FastRAID Accessory Kit D5480A
User’s Guide Manual Kit D4700A
Dual Processor Kits1
Pentium II 266 MHz containing 512 KB internal L2 cache D5483A
Pentium II 300 MHz containing 512 KB internal L2 cache D5484A
Pentium II 333 MHz containing 512 KB internal L2 cache D6526A
Input Devices
HP mouse C3751B
HP scrolling mouse C4736A
Video Displays
All current HP Displays (see the HP Kayak Accessory Service Handbook)
Mass Storage
4.5 GB UW-SCSI hard disk 7.2k rpm D5368A
4.5 GB UW-SCSI hard disk 10k rpm D5481A
9.1 GB UW-SCSI hard disk 7.2k rpm (1.6-inch high)2D5369A
9.1 GB UW-SCSI hard disk 10k rpm (1-inch high) D6520A
Flexible disk 3.5-inch 1.44 MB (1-inch high) D2035B
IDE 24✕CD-ROM drive D4383A
Rail kit (3.5-inch) D3566A
Rail kit (5.25-inch) 5063-7961
ka_sh_1.bk : xu-k.fb4 Page 3 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
6-4 HP Kayak XU PC Workstation (up to 333 MHz) Mini-Tower
PC Workstations
6
System Board, BIOS and Memory
Internal speaker
AUX
CD
Audio Front Panel
Microphone
Multimedia Front Panel Connector
(Headphone Out and Volume Control)
16-bit SCSI
Processor 1
Processor 2
AGP Slot
PCI Slots
RAIDport
IDE Connector
8-bit SCSI
Fan
Status Panel
Power
Fan
Switches
FDD
External
Battery
VRM 1 VRM 2
External Start
Memory Modules
ISA Slots
Fan
(airflow guide)
Video Board
LAN Board
UP
ka_sh_1.bk : xu-k.fb4 Page 4 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
Mini-Tower
PC Workstations
HP Kayak XU PC Workstation (up to 333 MHz) 6-5
6
System Board Switches
Setup and BIOS History
For the latest BIOS, the flasher utility program, and the BIOS history refer to the
HP World Wide Web site. The BIOS is in the form HB1xxxyy.FUL, where xxx is
the version number and yy is the language number.
1. UP=OFF, DOWN=ON (refer to the diagram on page 4 of this chapter for switch
positioning).
2. Refer to “Recovery Boot Active Procedure” in Appendix B for the detailed recovery
procedure.
1. PL Bus Frequency is 66 MHz
PCI Bus Frequency is 33 MHz
ISA Bus Frequency is 8.25 MHz
2. UP=OFF, DOWN=ON (refer to the diagram on page 4 of
this chapter for switch positioning).
Switch Function Default
1-5 — Processor frequency, see following table —
6UP
1Retain configuration in EEPROM, normal position UP
DOWN Clears EEPROM
7 UP Enables User and Administrator passwords UP
DOWN Clears User and Administrator passwords
8UP Disables power on using keyboard DOWN
DOWN Enables keyboard power on
9UP Fan speed controlled by internal temperature
sensors. UP
DOWN Fan speed set at maximum.
10 UP Normal operation UP
DOWN Recovery boot active (force BIOS flashing)2
Switch Processor
Frequency1
12345
UP2UP DOWN DOWN DOWN 233 MHz
UP UP DOWN UP UP 266 MHz
UP DOWN UP DOWN UP 300 MHz
UP DOWN UP UP DOWN 333 MHz
http://www.hp.com/go/kayaksupport
ka_sh_1.bk : xu-k.fb4 Page 5 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
6-6 HP Kayak XU PC Workstation (up to 333 MHz) Mini-Tower
PC Workstations
6
Installing a Dual Processor / Replacing a processor
HP Kayak XU 6/xxx PC Workstations are supplied with dual processor slots and
either one or two processors installed. Single processor models can be
upgraded to dual processor systems by installing the second processor
accessory in the vacant slot.
The second processor must be a Pentium II processor of the same speed and
level-2 cache memory capacity as the first. It is installed by gently sliding the
processor into the vacant processor connector slot until the two plastic clips at
the sides engage to lock the processor into place.
Every processor that is installed, or replaced, must be accompanied by the
voltage regulator module (VRM) that was supplied with it. Each VRM is specific
to the processor with which it was supplied, and should only be used with that
processor.
After installation of a second processor, the operating system must be
reinstalled.
Cache Memory
512 KB of level-two cache memory is integrated in the Pentium II processor
package.
Plastic clips
Heat-sink
Bracket pillars
ka_sh_1.bk : xu-k.fb4 Page 6 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
Mini-Tower
PC Workstations
HP Kayak XU PC Workstation (up to 333 MHz) 6-7
6
Main Memory
The PC Workstation has four DIMM slots on the system board for installing
main memory; slots A, B, C and D. Models are supplied with 32, 64 or 128 MB of
main memory. If additional memory is required, up to 512 MB may be installed.
Memory upgrades are available in single 32 MB, 64 MB or 128 MB ECC SDRAM
modules. A serial EEPROM on the DIMM contains data on the memory speed.
This information is read at each power on, and access time settings are set
accordingly.
Video Memory
There is 4 MB of video memory already supplied on the graphics controller
board. Memory may be upgraded to a maximum of 16 MB by installing a
memory module of 4 MB, 8 MB or 12 MB onto the board. No switch or jumper
settings need to be changed (all jumpers should be left in the positions in which
they were set by the manufacturer).
ka_sh_1.bk : xu-k.fb4 Page 7 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
6-8 HP Kayak XU PC Workstation (up to 333 MHz) Mini-Tower
PC Workstations
6
Part Numbers
ka_sh_1.bk : xu-k.fb4 Page 8 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
Mini-Tower
PC Workstations
HP Kayak XU PC Workstation (up to 333 MHz) 6-9
6
Parts List for HP Kayak XU 6/xxx PC Workstation (up to 333 MHz)
Item Description Repl.
Part Number
Exchange
Part Number
1 Box assembly:
a I/O Guide + Fan + Speaker assembly
b Cover lock assembly
c Status panel kit
d Multimedia control panel
e Bumper foot
5064-1860
5063-3351
5062-5590
5064-3353
5064-1832
5042-2479
—
—
—
—
—
—
2 Logo HP Kayak XU PC Workstation 5042-2428 —
3 Filler panel 3.5-inch 5042-1405 —
4 Filler panel 5.25-inch 5042-1178 —
5 Multimedia bezel 5042-2452 —
6 Upper Front Fan 5064-3352 —
7UW-SCSI Hard disk drive (standard)1:
2.1 GB, 7.2k rpm
4.5 GB, 7.2k rpm
4.5 GB, 10k rpm
9.1 GB, 7.2k rpm
9.1 GB, 10k rpm
D5140-63001
D5141-63001
D4625-63001
D4629-63001
D4627-63001
D5140-69001
D5141-69001
D4625-69001
D4629-69001
D4627-69001
8 5.25-inch tray 5002-1946 —
9 3.5-inch tray Part of Box Assembly
10 Power supply unit 0950-3212 —
11 Flexible disk drive D2035-60152 —
12 CD-ROM drive (standard):
24✕IDE D4383-63001 D4383-69001
13 Rail kit (3.5-inch) D3566A —
14 Rail kit (5.25-inch) 5063-7961 —
15 Internal ATA33 IDE cable2(for CD-ROM) 5183-2708 —
16 Headset 5064-2673 —
17 CD-ROM to audio cable 5182-1857 —
18 Airflow guides:
a) Rear fan + Airflow guide assembly
b) Processor Retainer Airflow guide
5064-3316
5042-2427
—
—
19 Flexible disk cable 5183-0746 —
20 System board See system board parts list
21 Graphics board
Millennium II AGP (4 MB)
4 MB Memory upgrade kit
5064-1873
D5487-63001
D4690-69501
—
22 HP 10/100 BT PCI -LAN board 5064-1897 D3999-69001
ka_sh_1.bk : xu-k.fb4 Page 9 Tuesday, June 23, 1998 11:54 AM

HP Kayak XU PC Workstation (up to 333 MHz)
6-10 HP Kayak XU PC Workstation (up to 333
MHz)
Mini-Tower
PC Workstations
6
1. For optional disk drive information, refer to the Accessories section of this Service
Handbook.
2. This is a specific IDE cable with the master connector on one end and the slave connector
in the middle of the IDE cable.
3. Where “xx” is the code for your national keyboard (refer to the Accessories section of this
Service Handbook.
1. Heat-sink is integrated in the Pentium II processor package.
23 SCSI cables (including SCSI terminator)
a) 8-bit SCSI
b) 16-bit SCSI
5183-0747
5183-2765
—
—
24 Processor terminator 5064-2680 —
25 3-button mouse C4728-60101 —
26 FastRAID (Adaptec ARO) card with
SIMM 16 MB memory
5064-1874 D4580-69001
27 CPU guide 5042-0569 —
28 Internal LAN cable 5183-0758 —
Not
Shown
Keyboards
Enhanced keyboard
Windows 95 keyboard - Japan
Windows 95 keyboard - Korea
C4734-601xx3
C4729-60224
C4730-60121
—
—
—
I/O blank panel 45935-00004 —
External battery tbd
System Board Parts List for HP Kayak XU 6/xxx
PC Workstation (up to 333 MHz)
Description Repl.
Part Number
Exchange
Part Number
System board: D4690-63001 D4690-69001
Processors1:
Intel Pentium II 266 MHz, 512 KB cache 5064-2652 —
Intel Pentium II 300 MHz, 512 KB cache 5064-3330 —
Intel Pentium II 333 MHz, 512 KB cache 5064-3697 —
Voltage regulator module (VRM) 0950-3310 —
Main memory modules:
1 ✕32 MB main memory ECC SDRAM
1 ✕64 MB main memory ECC SDRAM
1 ✕128 MB main memory ECC SDRAM
D5365-63001
D5366-63001
D5367-63001
D5365-69001
D5366-69001
D5367-69001
Parts List for HP Kayak XU 6/xxx PC Workstation (up to 333 MHz)
Item Description Repl.
Part Number
Exchange
Part Number
ka_sh_1.bk : xu-k.fb4 Page 10 Tuesday, June 23, 1998 11:54 AM