Hussmann Impact D5EE User manual

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
CD
E
F
A
B
P/N 0407200A.
Merchandisers
®
Note: Changed items have been underlined.
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
A. 9W Fan Assembly (1)
0047000 Fan Motor, Evaporator
0315470 Fan Blade
embossing toward motor
B. 0404551 Fan,Ambient (2)
C. 0411744 Standard Non-adjustable (3)
Defrost Thermostat
D. 0137880 Optional Adjustable (4)
Refrigeration Thermostat
Item Part # Description Wiring Item #
LAMPS AND BALLASTS
E. 0376409 Ballast, Electronic, 2 lamps (5)
F. Fluorescent Lamp (6)
Replace with like fixtures
D5ELE / D5EE
Data Sheet Set
P/N 0407200A
NSF®Certified
May, 2003

2 of 6 D5ELE / D5EE Data Sheet Set
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Engineering
Plan Views
Multi-deck Dairy &
Delicatessen
End Case
D5EE / D5ELE
General
Case Length . . . . . . . . . . . . . . . . 93 5/8(2378)
Maximum O/S dimension of case
back to front (includes bumper) . . .46 1/2(1181)
Back of case to
front of splashguard . . . . . . . . . 37 3/4(959)
Back of case to O/S edge of
front base rail . . . . . . . . . . . . . 28 1/2 (724)
Width of base rail . . . . . . . . . . . . . 2 1/8 (54)
Front of splashguard to O/S
edge of front base rail . . . . . . . . 8 1/2 (216)
Stub-up area between front
base rail and splashguard . . . . . 7 5/8(194)
Electrical Service
(Electrical Field Wiring connection point)
LH End of case to
center of first knockout . . . . . . . 6 3/4 (171)
Back O/S edge of case
to nearest knockout . . . . . . . . . 33 1/2 (851)
Length of electrical raceway . . . . 35 5/8 (903)
Waste Outlet
Back O/S of case to
center of waste outlet . . . . . . . 26 3/8 (670)
LH End of case to center of
waste outlet . . . . . . . . . . . . . . . . . . 51 (1295)
Water Seal
Edge of water seal to center of
waste outlet . . . . . . . . . . . . . . . . . . 11 (279)
Outside diameter of the drip pipe . 1 1/2 (38)
Refrigeration Outlet
Back of case to center of
refrigeration outlet . . . . . . . . . 31 5/8 (803)
LH end of case to center of
refrigeration outlet . . . . . . . . . 70 9/16 (1792)
84 3/8
(2142)
19
(483)
81 1/4
(2062)
Front View
D5ELE
D5EE
04-2003
Access Area
(Gray )
Waste
Outlet
26
3/8
(670 )
C
L
Electrical
Refrigeration
Outlet
78
(1981)
39
(991)
93 5/8
(2378 )
Front
31 1/2
(802)
51
(1295)
29
3/8
(746 )
28
1/8
(714 )
33
1/2
(851 )
45
3/8
(1153)
46 1/2
(1182)
Dimensions shown as in. and (mm).

3 of 6
P/N 0407200A HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
C
O
I
L
D5ELE
D5EE
FAN
46 1/2(1181)
47 1/2
(1207)
61/8
(201)
37 3/4(959)
Refrigeration
Outlet
29 1/2(749)
31 5/8(803)
26 1/2(672)
75/8
(194)
33 1/2(851)
19
(483)
7 1/2(191)
81 1/8
(2062)
56 1/4
(1429) 61
(1549)
51/2
(139)
30 3/8
(772)
22
(559)
Lighted Shelf
(Optional)
84 3/8
(2142)
Impact
D5ELE / D5EE
Dairy & Delicatessen
Dimensions shown as in. and (mm).
NOTE: The bumpers are 4 in. (102 mm) wide. The center of the top bumper is
14 1/4in. (368 mm) from the floor and the center of the lower bumper
is 6 1/8in. (155 mm) from the floor.
Multi-deck, 5 Display Levels
NSF Certification
These merchandisers are manufactured to meet ANSI /National
Sanitation Foundation (NSF®) Standard #7 requirements.
REFRIGERATION DATA
Note: This data is based on store temperature
and humidity that does not exceed 75°F and
55% R.H.
D5ELE D5EE
Discharge Air (°F) 32 32
Evaporator (°F) 24 24
Unit Sizing (°F) 22 22
Btu/hr/case* D5ELE D5EE
Parallel 10,700 10,170
Conventional 11,400 10,830
*For all refrigeration equipment other than
Hussmann, use conventional Btu values.
DEFROST DATA
D5ELE D5EE
Frequency (hr) 66
Defrost Water (lb/ft/day) 10.5 10.5
(± 15% based on case configuration and
product loading).
OFFTIME D5ELE D5EE
Temp Term (°F) 48°48°
Failsafe (minutes) 35 35
GAS OR ELECTRIC Not Recommended
Standard Defrost Thermostat
Close on rise: close 48°F — open 33°F
CONVENTIONAL CONTROLS
Low Pressure Backup Control
D5ELE D5EE
CI/CO (Temp °F)** 17°/ 7° 17°/ 7°
Indoor Unit Only, Pressure Defrost
Termination (Temp °F)**
Not Recommended
**Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICAL DATA
Drip Pipe (in.) 1 1/2
Liquid Line (in.) 3/8
Suction Line (in.) 7/8
Estimated Charge (lb)***
D5ELE 2.4
D5EE 2.4
***This is an average for all refrigerant
types. Actual refrigerant charge may vary
by approximately half a pound.
Length Added to Lineup by:
Each End/Partition (in.) 1 1/2

4 of 6 D5ELE / D5EE Data Sheet Set
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Electrical Data
Number of Fans D5ELE D5EE
Refrigeration – 9W 2 2
Ambient Air Wipe – 15W 1 1
Export – 9W 2 2
Amperes Watts
Merchandiser D5ELE D5EE D5ELE D5EE
Fans (Refrigeration)
Standard (120V 60Hz) 1.40 1.40 110 110
Energy Efficient (120V 60Hz) 0.76 0.76 50 50
Export (230V 50Hz) 0.76 0.76 114 114
Fans (Ambient Air Wipe)
Standard (120V 60Hz) 0.25 0.25 22 22
Energy Efficient (120V 60Hz) NA NA NA NA
Export (230V 50Hz) 0.15 0.15 25 25
Constant On Anti-sweat Heaters NA NA NA NA
Cycling Anti-sweat Heaters NA NA NA NA
Minimum Circuit Ampacity
With Standard Fans (120V 60Hz) 1.60 1.60
With Energy Efficient Fans (120V 60Hz) 0.96 0.96
With Export Fans (230V 50Hz) 0.47 0.47
Maximum Over Circuit Protection
Standard 120V 20 20
Export (230V 50Hz) 15 15
Electric Defrost Heaters (208V 1ΦΦ)NA NA NA NA
Standard Lighting
1 Row Canopy 0.51 0.51 59 59
Optional Lighting
1 Row Canopy and 1 Row Rail 1.02 1.02 118 118
2 Rows Canopy 1.02 1.02 118 118
2 Rows Canopy and 1 Row Rail 1.53 1.53 177 177
Optional Shelf Lighting
1 Row of Shelves 0.51 0.51 59 59
2 Rows of Shelves 1.02 1.02 118 118
3 Rows of Shelves 1.53 1.53 177 177
4 Rows of Shelves 2.04 2.04 236 236
Impact
D5ELE / D5EE
Dairy & Delicatessen

5 of 6P/N 0407200A HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
3
Defrost
Termination
Thermostat
Refrigeration
Thermostat
Dark Blue To
Condensing
Unit
}
Light Blue
4
Fan Wiring
Offtime Defrost
2 Fans 120V NEUTRAL
BROWN BAND
120V POWER
Fans 1
BROWN BAND
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS
2
Connector
Connector
G
Connector
Connector Connector
Connector Connector
Optional Shelf Harness and Light Circuits for
One Row of Shelves
120 V
Power
B
WGB
BL
G
G
RR
BL BL G
W
Shelf Harness
Shelf Light Circuits
BL
G
R
6
5
W
BL R
6
G
R
Shelf Lighting
G
R
BL
BL
B

6 of 6 D5ELE / D5EE Data Sheet Set
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
BWBL
RR BL
BL
RR
BL
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
BL
RR
BL
5
Standard Lighting 1 Row Canopy or Optio nal 1 Row Rail
Light Circuits
Optional Lig hting 2 Ro ws Cano py
6
66
6
6
6
5
5
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS