IEI Technology WAFER-BT User manual

WAFER-BT
Page I
User Manual
WAFER-BT
MODEL:
3.5” SBC with Intel® 22nm Atom™/Celeron® on-board SoC,
VGA/LVDS/iDP, Dual PCIe GbE, USB 3.0, PCIe Mini,
SATA3Gb/s, mSATA, COM, Audio and RoHS
Rev. 1.01 - 4 December, 2014
WAFER-BT CPU Card

WAFER-BT
Page II
Revision
Date Version Changes
4 December, 2014 1.01 Update Section 3.2.23: USB connectors pinouts
7 July, 2014 1.00 Initial release

WAFER-BT
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

WAFER-BT
Page IV
Table ofContents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 MODEL VARIATIONS ................................................................................................... 2
1.3 FEATURES................................................................................................................... 3
1.4 CONNECTORS ............................................................................................................. 4
1.5 DIMENSIONS............................................................................................................... 5
1.6 DATA FLOW................................................................................................................ 6
1.7 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 UNPACKING............................................................................................................... 10
2.1ANTI-STATIC PRECAUTIONS.......................................................................................11
2.2 UNPACKING PRECAUTIONS........................................................................................11
2.3 PACKING LIST........................................................................................................... 12
2.4 OPTIONAL ITEMS...................................................................................................... 13
3 CONNECTORS ........................................................................................................... 14
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 15
3.1.1 WAFER-BT Layout........................................................................................... 15
3.1.2 Peripheral Interface Connectors ..................................................................... 15
3.1.3 External Interface Panel Connectors............................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 17
3.2.1 +12V DC-IN Power Connector ....................................................................... 17
3.2.2 Audio Connector.............................................................................................. 18
3.2.3 Battery Connector............................................................................................ 19
3.2.4 Buzzer Connector............................................................................................. 20
3.2.5 CPU Fan Connector ........................................................................................ 21
3.2.6 DDR3L SO-DIMM Slot.................................................................................... 21
3.2.7 Digital I/O Connector...................................................................................... 22
3.2.8 Display Port Connector................................................................................... 23
3.2.9 Front Panel Connector .................................................................................... 24
3.2.10 iRIS-1010 module slot.................................................................................... 25

WAFER-BT
Page V
3.2.11 Keyboard and Mouse Connector.................................................................... 25
3.2.12 LVDS Backlight Inverter Connector.............................................................. 26
3.2.13 LVDS LCD Connector ................................................................................... 27
3.2.14 LAN LED Connector...................................................................................... 28
3.2.15 PCIe Mini Card Slot ...................................................................................... 29
3.2.16 Power Button Connector................................................................................ 30
3.2.17 Reset Button Connector ................................................................................. 31
3.2.18 RS-232 Serial Port Connectors...................................................................... 31
3.2.19 RS-422/485 Serial Port Connector................................................................ 32
3.2.20 SATA 3Gb/s Drive Connector ........................................................................ 33
3.2.21 SATA Power Connector.................................................................................. 34
3.2.22 SMBUS Connector......................................................................................... 35
3.2.23 USB Connectors............................................................................................. 35
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 36
3.3.1 LAN Connector ................................................................................................ 37
3.3.2 USB Connectors............................................................................................... 38
3.3.3 RS-232 Serial Port Connector......................................................................... 38
3.3.4 VGA Connector................................................................................................ 39
4 INSTALLATION ......................................................................................................... 41
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 42
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 42
4.3 SO-DIMM INSTALLATION ....................................................................................... 44
4.4 SYSTEM CONFIGURATION......................................................................................... 45
4.4.1 AT/ATX Mode Select Switch............................................................................. 45
4.4.2 Clear CMOS Button......................................................................................... 46
4.4.3 LVDS Panel Resolution Selection.................................................................... 46
4.4.4 LVDS Voltage Selection.................................................................................... 48
4.4.5 Flash Descriptor Security Override Jumper.................................................... 49
4.5 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 50
4.5.1 Audio Kit Installation....................................................................................... 50
4.5.2 SATA Drive Connection ................................................................................... 51
4.5.3 Single RS-232 Cable........................................................................................ 52
4.6 EXTERNAL PERIPHERAL INTERFACE CONNECTION ................................................... 53
4.6.1 LAN Connection............................................................................................... 54

WAFER-BT
Page VI
4.6.2 Serial Device Connection ................................................................................ 55
4.6.3 USB Connection............................................................................................... 55
4.6.4 VGA Monitor Connection ................................................................................ 56
5 BIOS.............................................................................................................................. 58
5.1 INTRODUCTION......................................................................................................... 59
5.1.1 Starting Setup................................................................................................... 59
5.1.2 Using Setup...................................................................................................... 59
5.1.3 Getting Help..................................................................................................... 60
5.1.4 Unable to Reboot after Configuration Changes.............................................. 60
5.1.5 BIOS Menu Bar................................................................................................ 60
5.2 MAIN........................................................................................................................ 61
5.3ADVANCED............................................................................................................... 62
5.3.1 ACPI Settings................................................................................................... 63
5.3.2 Super IO Configuration ................................................................................... 64
5.3.2.1 Serial Port n Configuration....................................................................... 64
5.3.3 Hardware Monitor ........................................................................................... 68
5.3.3.1 Smart Fan Mode Configuration................................................................ 69
5.3.4 RTC Wake Settings........................................................................................... 72
5.3.5 Serial Port Console Redirection...................................................................... 73
5.3.5.1 Console Redirection Settings.................................................................... 74
5.3.6 CPU Configuration.......................................................................................... 77
5.3.7 IDE Configuration ........................................................................................... 78
5.3.8 USB Configuration........................................................................................... 79
5.4 CHIPSET ................................................................................................................... 80
5.4.1 North Bridge Configuration............................................................................. 81
5.4.1.1 Intel IGD Configuration............................................................................ 82
5.4.2 Southbridge Configuration .............................................................................. 83
5.4.2.1 PCI Express Configuration ....................................................................... 85
5.5 SECURITY................................................................................................................. 86
5.6 BOOT........................................................................................................................ 87
5.7 EXIT......................................................................................................................... 89
ABIOS MENU OPTIONS............................................................................................. 91
B TERMINOLOGY........................................................................................................ 94

WAFER-BT
Page VII
C HAZARDOUS MATERIALS DISCLOSURE......................................................... 99
C.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY..................................... 100

WAFER-BT
Page VIII
List of Figures
Figure 1-1: WAFER-BT...................................................................................................................2
Figure 1-2: Connectors ..................................................................................................................4
Figure 1-3: Dimensions (mm)........................................................................................................5
Figure 1-4: Data Flow Diagram......................................................................................................6
Figure 3-1: Connector and Jumper Locations (Front)..............................................................15
Figure 3-2: +12V DC-IN Power Connector Location..................................................................18
Figure 3-3: Audio Connector Location.......................................................................................19
Figure 3-4: Battery Connector Location.....................................................................................20
Figure 3-5: Buzzer Connector Location .....................................................................................20
Figure 3-6: CPU Fan Connector Locations................................................................................21
Figure 3-7: DDR3L SO-DIMM Slot Location ...............................................................................22
Figure 3-8: Digital I/O Connector Location ................................................................................22
Figure 3-9: Display Port Connector Location............................................................................23
Figure 3-10: Front Panel Connector Location ...........................................................................24
Figure 3-11: iRIS-1010 Module Slot Location ............................................................................25
Figure 3-12: Keyboard and Mouse Location..............................................................................26
Figure 3-13: Backlight Inverter Connector Location.................................................................27
Figure 3-14: LVDS Connector Location......................................................................................28
Figure 3-15: LAN LED Connector Location ...............................................................................29
Figure 3-16: PCIe Mini Card Slot Location.................................................................................30
Figure 3-17: Power Button Connector Location........................................................................30
Figure 3-18: Reset Button Connector Location.........................................................................31
Figure 3-19: RS-232 Serial Port Connectors Locations............................................................32
Figure 3-20: RS-422/485 Connector Location............................................................................33
Figure 3-21: SATA 3Gb/s Drive Connectors Locations............................................................34
Figure 3-22: SATA Power Connector Location .........................................................................34
Figure 3-23: SMBUS Connectors Location................................................................................35
Figure 3-24: USB Connectors Locations....................................................................................36
Figure 3-25: External Peripheral Interface Connector..............................................................37
Figure 3-26: LAN Connector........................................................................................................37
Figure 3-27: RS-232 Serial Port Connector................................................................................39

WAFER-BT
Page IX
Figure 3-28: VGA Connector .......................................................................................................39
Figure 4-1: SO-DIMM Installation ................................................................................................44
Figure 4-2: AT/ATX Mode Select Switch Location ....................................................................46
Figure 4-3: Clear CMOS Button Location...................................................................................46
Figure 4-4: LVDS Panel Resolution Selection Switch Location ..............................................48
Figure 4-5: LVDS Voltage Selection Jumper Location .............................................................49
Figure 4-6: Flash Descriptor Security Override Jumper Location ..........................................50
Figure 4-7: Audio Kit Cable Connection.....................................................................................51
Figure 4-8: SATA Drive Cable Connection.................................................................................52
Figure 4-9: Single RS-232 Cable Installation .............................................................................53
Figure 4-10: LAN Connection......................................................................................................54
Figure 4-11: Serial Device Connector.........................................................................................55
Figure 4-12: USB Connector........................................................................................................56
Figure 4-13: VGA Connector .......................................................................................................57

WAFER-BT
Page X
List of Tables
Table 1-1: WAFER-BT Model Variations.......................................................................................2
Table 1-2: Technical Specifications..............................................................................................9
Table 3-1: Peripheral Interface Connectors...............................................................................16
Table 3-2: Rear Panel Connectors ..............................................................................................17
Table 3-3: +12V DC-IN Power Connector Pinouts.....................................................................18
Table 3-4: Audio Connector Pinouts ..........................................................................................19
Table 3-5: Battery Connector Pinouts........................................................................................20
Table 3-6: Buzzer Connector Pinouts.........................................................................................21
Table 3-7: CPU Fan Connector Pinouts .....................................................................................21
Table 3-8: Digital I/O Connector Pinouts....................................................................................23
Table 3-9: Display Port Connector Pinouts ...............................................................................24
Table 3-10: Front Panel Connector Pinouts...............................................................................25
Table 3-11: Keyboard and Mouse Connector Pinouts..............................................................26
Table 3-12: Backlight Inverter Connector Pinouts....................................................................27
Table 3-13: LVDS Connector Pinouts.........................................................................................28
Table 3-14: LAN LED Connector Pinouts...................................................................................29
Table 3-15: Power Button Connector Pinouts...........................................................................31
Table 3-16: Reset Button Connector Pinouts............................................................................31
Table 3-17: RS-232 Serial Port Connector Pinouts ...................................................................32
Table 3-18: RS-422/485 Connector Pinouts ...............................................................................33
Table 3-19: DB-9 RS-422/485 Pinouts.........................................................................................33
Table 3-20: SATA Power Connector Pinouts.............................................................................35
Table 3-21: SMBUS Connectors Pinouts ...................................................................................35
Table 3-22: USB Connector Pinouts...........................................................................................36
Table 3-23: LAN Pinouts ..............................................................................................................37
Table 3-24: Connector LEDs........................................................................................................38
Table 3-25: USB 2.0 Port Pinouts................................................................................................38
Table 3-26: USB 3.0 Port Pinouts................................................................................................38
Table 3-27: RS-232 Serial Port Connector Pinouts ...................................................................39
Table 3-28: VGA Connector Pinouts...........................................................................................40
Table 4-1: AT/ATX Mode Select Switch Settings.......................................................................45

WAFER-BT
Page XI
Table 4-2: Clear CMOS Button Settings.....................................................................................46
Table 4-3: LVDS Panel Resolution Selection.............................................................................47
Table 4-4: LVDS Voltage Selection Jumper Settings................................................................48
Table 4-5: Flash Descriptor Security Override Jumper Settings.............................................49
Table 5-1: BIOS Navigation Keys................................................................................................60

WAFER-BT
Page XII
List ofBIOS Menus
BIOS Menu 1: Main.......................................................................................................................61
BIOS Menu 2: Advanced..............................................................................................................62
BIOS Menu 3: ACPI Configuration..............................................................................................63
BIOS Menu 4: Super IO Configuration........................................................................................64
BIOS Menu 5: Serial Port n Configuration Menu.......................................................................64
BIOS Menu 6: Hardware Monitor.................................................................................................69
BIOS Menu 7: Smart Fan Mode Configuration ..........................................................................70
BIOS Menu 8: RTC Wake Settings ..............................................................................................72
BIOS Menu 9: Serial Port Console Redirection.........................................................................74
BIOS Menu 10: Console Redirection Settings...........................................................................75
BIOS Menu 11: CPU Configuration.............................................................................................77
BIOS Menu 12: IDE Configuration...............................................................................................78
BIOS Menu 13: USB Configuration.............................................................................................79
BIOS Menu 14: Chipset ................................................................................................................81
BIOS Menu 15: Northbridge Chipset Configuration..................................................................81
BIOS Menu 16: Integrated Graphics...........................................................................................82
BIOS Menu 17: Southbridge Chipset Configuration.................................................................84
BIOS Menu 18: Console Redirection Settings...........................................................................85
BIOS Menu 19: Security...............................................................................................................86
BIOS Menu 20: Boot.....................................................................................................................87
BIOS Menu 21:Exit........................................................................................................................89

WAFER-BT
Page 1
1Introduction
Chapter
1

WAFER-BT
Page 2
1.1 Introduction
Figure 1-1: WAFER-BT
The WAFER-BT SBC motherboard is an Intel® Atom™/Celeron® processor platform. It
supports one 204-pin 1066/1333 MHz single-channel DDR3L SO-DIMM supports up to
8GB (J1900, N2930, E3845, E3827, E3826) or 4GB (N2807, E3825, E3815).
The WAFER-BT includes a VGA connector, a LVDS connector and an iDP connector.
Expansion and I/O include one USB 2.0 connector and one USB 3.0 connector on the rear
panel, four USB 2.0 connectors by pin header and two SATA 3Gb/s connectors. Serial
device connectivity is provided by two internal RS-232 connectors, one external RS-232
connector and one internal RS-422/485 connector. Two RJ-45 Ethernet connectors
provide the system with smooth connections to an external LAN.
1.2 Model Variations
The model variations of the WAFER-BT Series are listed below.
ModelNo. SoC
WAFER-BT-i1-J19001-R10 Intel® Celeron® quad-core J1900 (10W)
WAFER-BT-i1-N29301-R10 Intel® Celeron® quad-core N2930 (7.5W)
WAFER-BT-i1-N28071-R10 Intel® Celeron® dual-core N2807 (4.3W)
WAFER-BT-i1-E38XX1-R10 Intel® Atom™ E38XX
Table 1-1: WAFER-BT Model Variations

WAFER-BT
Page 3
1.3 Features
Some of the WAFER-BT motherboard features are listed below:
3.5" SBC supports Intel® 22nm Atom™/Celeron® on-board SoC
Dual independent display support
One 204-pin 1066/1333 MHz single-channel DDR3L SO-DIMM supports up to
8GB (J1900, N2930, E3845, E3827, E3826) or 4GB (N2807, E3825, E3815)
COM, USB 3.0, SATA 3Gb/s, PCIE mini, mSATA and Audio support
IEI one key recovery solution allows you to create rapid OS backup and
recovery

WAFER-BT
Page 4
1.4 Connectors
The connectors on the WAFER-BT are shown in the figure below.
Figure 1-2: Connectors

WAFER-BT
Page 5
1.5 Dimensions
The dimensions of the board are listed below:
Figure 1-3: Dimensions (mm)

WAFER-BT
Page 6
1.6 Data Flow
Figure 1-4 shows the data flow between the system chipset, the CPU and other
components installed on the motherboard.
Figure 1-4: Data Flow Diagram

WAFER-BT
Page 7
1.7 Technical Specifications
WAFER-BT technical specifications are listed below.
Specification WAFER-BT
SoC Intel® Atom™ E3845 on-board SoC (1.91GHz, quad-core,
2MB cache, TDP=10W)
Intel® Atom™ E3827 on-board SoC (1.75GHz, dual-core,
1MB cache, TDP=8W)
Intel® Atom™ E3826 on-board SoC (1.46GHz, dual-core,
1MB cache, TDP=7W)
Intel® Atom™ E3825 on-board SoC (1.33GHz, dual-core,
1MB cache, TDP=6W)
Intel® Atom™ E3815 on-board SoC (1.46GHz, single-core,
512KB cache, TDP=5W)
Intel® Celeron® J1900 on-board SoC (2GHz, quad-core,
2MB cache, TDP=10W)
Intel® Celeron® N2930 on-board SoC (1.83GHz, quad-core,
2MB cache, TDP=7.5W)
Intel® Celeron® N2807 on-board SoC (1.58GHz, dual-core,
2MB cache, TDP=4.3W)
BIOS AMI UEFI BIOS
Memory One 204-pin 1066/1333 MHz single-channel DDR3L
SO-DIMM supports up to 8GB (J1900, N2930, E3845, E3827,
E3826) or 4GB (N2807, E3825, E3815)
Graphics Intel® HD Graphics Gen 7 Engines with 4 execution unit,
supports DX11.1, OpenGL 4.2 and OpenCL1.2
Display Output Dual Independent Display
1 x VGA (Resolution: 2560x1600@60Hz)
1 x 24-bit dual-channel LVDS connector (1920x1200@60Hz)
1 x iDP interface for HDMI, LVDS, VGA, DVI, DP (up to
3840x2160@60 Hz)

WAFER-BT
Page 8
Specification WAFER-BT
Ethernet 1 x PCIe GbE by Intel I210 controller (LAN1)
1 x PCIe GbE by Intel I211 controller (LAN2)
Super IO Fintek F81866
Embedded Controller ITE IT8528E
Audio Realtek ALC662 HD codec
Watchdog Timer Software programmable support 1~255 sec. system reset
I/O Interface
Audio Connector 1 x Analog audio by 10-pin (2x5) header
Ethernet Two RJ-45 ports
KB/MS 1 x PS/2 KB/MS
Serial Ports 1 x RS-422/485 (by pin header)
3 x RS-232 (1 on rear I/O, 2 by pin header)
USB Ports 1 x USB 3.0 (on rear I/O)
5 x USB 2.0 (1 on rear I/O, 4 by pin header)
Front Panel 1 x 6-pin (1x6) wafer for power LED & HDD LED
1 x 2-pin (1x2) wafer for power button
1 x 2-pin (1x2) wafer for power reset button
LAN LED 2 x 2-pin header for LAN1 Link LED, LAN2 Link LED
FAN 1 x 4-pin CPU fan connector
1 x 4-pin system fan connector
SMBus 1 x 4-pin (1x4) wafer
Expansion 1 x Full-size PCIe Mini card slot with mSATA support (SATA2
and mSATA share SATA signal)
iRIS Remote Management
Module
1 x iRIS-1010 slot
Digital I/O 8-bit digital I/O (4-bit input, 4-bit output)
Storage