Intermatic AG4803C3 User manual

277/480 VAC Four wire plus Ground
Found in Main Disconnect Switches,
Main Distribution panels, Load Centers
Sub panels and equipment locations.
Line
Line
Line
Neutral
Ground
WHITE
BLACK
BLACK
BLACK
277 v
277 v
480 v
480 v
480 v
277 v
Model AG4803C3
Type 1 or Type 2 Surge Protection Device
INSTALLATION INSTRUCTIONS
480 VAC Three wire plus Ground
Found at Service Entrances and
Meter Cabinets.
Line
Line
Line
Grounded Neutral
WHITE
BLACK
BLACK
BLACK
480 v
480 v
480 v 277 v
277 v
277 v
Risk of Electric Shock
WARNING
• Thoroughlyreadinstructionsbeforeinstallingunit.
 • InstallationandServicetobeperformedbya 
  qualiedlicensedelectrician.
 • Intendedforindoororoutdooruse.
• Allwiringmustcomplywithallstateandlocal
 electricalcodesincludingtheNationalElectrical
 Codeand/orCanadianElectricalCode.
• Suitableforuseonacircuitcapableofdelivering
 notmorethan50,000rmssymmetricalamperes.
• Thisunitcontainsnoserviceableparts.
• Thisproductdoesnotprotectagainstdirect
 lightningstrikes.
Type 1 installation:
Atypicalinstallationofatype1SPDwillbeconnectedbetweenthesecondaryoftheservicetransformerandthe
linesideoftheservicepanel.ThisinstallationisintendedtobeinstalledwithoutovercurrentprotectiontotheSPD.
Type 2 installation:
Atypicalinstallationofatype2SPDwillbeconnectedtotheloadsideoftheservicepanelandisintendedtobe
installedwithovercurrentprotectiontotheSPD.
 1. Determininglocation:
  • Ensureconductorlengthsareasshortandstraightaspossibleforbestperformance.Donotcoilexcess
   wire.TheSPDfunctionsbestifallbendsinwiresarerounded,ideallytoa4”radius.Hard90degreebend
   willreduceefciency.Cutallleadstothecorrectlength.Donotcoilexcessleads.
  • Installappropriateweatherproofttingsiftheunitistobemountedoutside.
  • BracketpartnumberAG1BRKTisalsoavailableifneeded.
 2. Connectwiresasshownwithindiagrams.Ifyourapplicationdoesnotmatchoneofthediagramsbelow
  consultyoursupplier.
 3. Ensureallmountingandelectricalconnectionsarecorrectandsecurelyfastened.Onceenergizedthegreen
  indicatorLEDwillbeON.
Maintenance:
¡ACVoltageSPD:
 • PeriodicallycheckSPDtoensuregreenindicatorLEDisON.IfgreenLEDisOFFprotectionhasdiminished
  andtheSPDshouldbereplacedimmediately.
277/480VAC WYE 3 PHASE
IMPORTANT SAFETY INSTRUCTIONS • SAVE THESE INSTRUCTIONS

158--01000
ONE YEAR LIMITED PRODUCT WARRANTY
For
INTERMATIC SURGE PROTECTIVE DEVICES
(1) What is Covered By This Limited Warranty
ReplacementofProduct
IntermaticIncorporated(“Intermatic”)warrantstotheoriginalpurchaseronly,IntermaticAGSeriesSurgeProtectiveDevices(eacha“Prod-
uct”)shallbefreefromdefectsinmaterialorworkmanshipforaperiodofoneyear(12months)fromdateofpurchaseor18monthsfrom
dateofmanufacture.Ifthepurchaserdiscoversadefectinmaterialorworkmanship,thepurchasermustpromptlysubmitawarrantyclaim.
UponadeterminationbyIntermaticthattheProductisdefective,Intermatic,atitssoleoptionshallcorrectanydefectinmaterialorwork-
manshipbyreplacingtheDefectiveProductatIntermatic’sexpense.Theforegoingremedyisthepurchaser’sexclusiveremedyforabreach
ofwarranty.
Theproductmustbeinstalledintheappropriateapplicationincompleteaccordancewiththeinstallationinstructions.Allbuildingwiringand
otherconnectionstotheProductmustconformtoallapplicablenational,state,andlocalelectricalcodes;theProductmustnotbeopened,
modied,exposedtoextremeheatorcold,submergedorsubjectedtoabnormaluseorservice.Allproductsmustbeusedinaccordance
withtheinstructionsprovidedwiththeProductandthepurchasershallbesolelyresponsibleforselectingaProductmodelwithspecications
appropriatefortheequipmenttobeprotected.Intermaticshalldetermine,initssolediscretion,whetheranyProductreturnedbyapurchaser
hasbeenusedinaccordancewithitsinstructions,isanappropriatemodelforthepurchaser’susethereof,andwhethertheProductisdefective.
(2) What is Not Covered By This Warranty
Intermaticdoesnotwarrant(a)defectsintheProductordamagetoanyequipmentcausedbythefailuretoproperlyinstalltheProduct,(b)
damagecausedbyuseoftheProductforpurposesotherthanthoseforwhichitwasdesigned,(c)damagecausedbydisastersuchasre,
oodandwind,(d)damagecausedbyunauthorizedattachmentsormodicationoftheProduct,(e)damagetotheProductoccurringduring
theshipment,(f)electricaldisturbancesexceedingpublishedproductspecications,(g)damagetotheProductcausedbyanyotherabuse
ormisusebythepurchaser,or(h)damageduetodirectorvicinitylightningstrikes.Thiswarrantyappliestoresidentialandcommercialap-
plications.ThisdeviceisnotintendedtoprovideprotectionduringUtilityvoltageswellsorlossofneutralconditionswhicharebydenition
nottransienteventsandarenotcoveredbythiswarranty.
(3) Disclaimer of Warranty
THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER EXPRESSED WARRANTIES. TO THE EXTENT ALLOWED BY LAW,
ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION OF
THIS LIMITED WARRANTY.
(4) Limitation of Remedies
INNOCASESHALLINTERMATICBELIABLEFORANYSPECIAL,INCIDENTAL,ORCONSEQUENTIALDAMAGESBASEDUPON
BREACHOFWARRANTY,BREACHOFCONTRACT,NEGLIGENCE,STRICTTORT,ORANYOTHERLEGALTHEORY.SUCHEXCLUDED
DAMAGESINCLUDE,BUTARENOTLIMITEDTO,DAMAGETOSOFTWARE,LOSSOFDATA,LOSSOFPROFITS,LOSSOFSAVINGS
ORREVENUE,LOSSOFUSEOFTHEPRODUCTORANYASSOCIATEDEQUIPMENT,COSTOFCAPITAL,COSTOFANYSUB-
STITUTEEQUIPMENT,FACILITIESORSERVICES,DOWNTIME,THECLAIMSOFTHIRDPARTIESINCLUDINGCUSTOMERS,DAM-
AGETOPROPERTYANDPERSONALINJURY.SOMESTATESDONOTALLOWLIMITSONWARRANTIESORONREMEDIESFOR
BREACHINCERTAINTRANSACTIONS,INSUCHSTATES,THELIMITSINTHISPARAGRAPHANDINPARAGRAPH(3)MAYNOTAPPLY.
(5) Time Limit for Bringing Suit
Noactionarisingoutofanyclaimedbreachofwarrantymaybebroughtmorethanoneyearafterthecauseofactionhasoccurred.
(6) No Other Warranties
Unlessmodiedinwritingsignedbybothparties,thisagreementisunderstoodtobethecompleteandexclusiveagreementbetweenthe
parties,supersedingallprioragreements,oralorwritten,andallothercommunicationsbetweenthepartiesrelatingtothesubjectmatterof
thisagreement.NoemployeeofIntermaticoranyotherpartyisauthorizedtomakeanywarrantyinadditiontothosemadeinthisagree-
ment.Thiswarrantyismadeby:IntermaticIncorporated/AfterSalesService,7777WinnRd.,SpringGrove,IL.60081-9698/815-675-7000
http://www.intermatic.com
INTERMATIC INCORPORATED
SPRING GROVE, ILLINOIS 60081-9698
http://www.intermatic.com