Intex Auto Cleaner User manual

100
IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
OOWWNNEERR’’SSMMAANNUUAALL
Auto Cleaner
IMPORTANT
SAFETY RULES
Read, Understand, and Follow all
Instructions Carefully before
Installing and using this Product.
Don’t forget to try these other fine Intex products: Pools, Pool Accessories,
Inflatable Pools and In-Home Toys, Airbeds and Boats available at fine
retailers or visit our website.
For illustrative purposes only.
©2008 Intex Marketing Ltd. - Intex Development Co. Ltd. - Intex Trading Ltd.
- Intex Recreation Corp.
All rights reserved/Tous droits réservés/Todos los derechos reservados/Alle
Rechte vorbehalten. Printed in China/Imprimé en Chine/Impreso en China/Gedruckt in China.
®™ Trademarks used in some countries of the world under license from/®™ Marques utilisées dans certains pays sous
licence de/Marcas registradas utilizadas en algunos países del mundo bajo licencia de/Warenzeichen verwendet in einigen
Ländern der Welt in Lizenz von/Intex Marketing Ltd. to/à/a/an Intex Trading Ltd., Intex Development Co. Ltd., G.P.O
Box 28829, Hong Kong & Intex Recreation Corp., P.O. Box 1440, Long Beach, CA 90801 • Distributed in the European
Union by/Distribué dans l’Union Européenne par/Distribuido en la unión Europea por/Vertrieb in der Europäischen Union
durch/Intex Trading B.V., P.O. Box nr. 1075 – 4700 BB Roosendaal – The Netherlands
100IO-A0-0908

100
IO
SAVE THESE INSTRUCTIONS Page 2
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
TTAABBLLEEOOFFCCOONNTTEENNTTSS
Warnings.......................................................................... 3
Parts List & Reference.................................................... 4-5
Set Up Instructions ........................................................ 6-8
Operating Instructions .................................................. 9
Debris Net Cleaning........................................................ 10
Long Term Storage.......................................................... 10
Troubleshooting Guide................................................... 11
General Aquatic Safety................................................... 12
Intex Service Center Locations..................................... 13

100
IO
SAVE THESE INSTRUCTIONS Page 3
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
SSAAFFEETTYYRRUULLEESS
WARNING
•TO REDUCE THE RISK OF INJURY, DO NOT PERMIT CHILDREN TO
USE THIS PRODUCT.
•DO NOT OPERATE THE FILTER PUMP WHILE THE POOL IS
OCCUPIED OR IN USE.
• REMOVE THE PRODUCT FROM THE POOL WHILE THE POOL IS
OCCUPIED OR IN USE.
• TURN OFF OR UNPLUG THE FILTER PUMP BEFORE ADJUSTING,
CLEANING OR SERVICING.
• REMOVE THE PRODUCT FROM THE POOL BEFORE PLACING A
POOL COVER OVER THE POOL.
• STORE THE PRODUCT AND ACCESSORIES IN A DRY AND SAFE
PLACE INDOORS.
• FOR POOL AND FILTER PUMP PROBLEMS REFER TO THEIR
RESPECTIVE OWNER'S MANUAL FOR ADVICE.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN PROPERTY
DAMAGE, SERIOUS INJURY OR DEATH.
This Filter-Pump system is intended to be used only for the purposes described in
the manual! Failure to follow all product, package and package insert safety and
installation instructions could result in electric shock, entanglement, other serious
injury or death.
Filter Pump Flow Rate Requirement:
2000 - 4000 gallons/hour (7570 - 15140 liters/hour)
IMPORTANT SAFETY RULES
Read, Understand and Follow All Instructions Carefully Before Installing and Using this Product.
READ AND FOLLOW ALL INSTRUCTIONS

100
IO
SAVE THESE INSTRUCTIONS Page 4
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
PPAARRTTSSLLIISSTT
NOTE: Drawings for illustration purpose only. May not reflect actual product. Not to scale.
7
1
4 5
8
11
2
9
10
6
3
12
13
* Optional
* Optional
PARTS LIST

100
IO
SAVE THESE INSTRUCTIONS Page 5
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
PPAARRTTSSRREEFFEERREENNCCEE
PARTS REFERENCE
Before assembling your product, please take a few minutes to check the contents
and become familiar with all the parts.
NOTE: Drawings for illustration purpose only. May not reflect actual product. Not to
scale.
REF. NO. DESCRIPTION QTY. SPARE PART NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
CLEANER TOP
SCREW
BUMPER
DEBRIS NET
CLEANER BASE
HOSE CLAMP
HOSE ADAPTOR (OPTIONAL)
HOSE A
HOSE B
HOSE C
HOSE D
HOSE ADAPTOR FOR SMALL AGP POOL (OPTIONAL)
DEAD WEIGHT BLOCK
10960
10858
10857
10855
10965
10272
10859
10850
10851
10852
10957
10910
11138
1
2
2
1
1
1
1
1
3
2
1
1
2
1
2
7
89
10 11
36
4
13
5
12

100
IO
SAVE THESE INSTRUCTIONS Page 6
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
SSEETT--UUPPIINNSSTTRRUUCCTTIIOONNSS
SET-UP INSTRUCTIONS
1. If you use filter pump which is 3000 gal ~ 4000 gal, add the dead weight
block (13) at the base. See Fig. 1. But no need it when your filter pump
is 2000 gal ~ 2900 gal.
2. With screws (2), connect the bumpers (3) to the cleaner at both ends.
See Fig. 2.
2
1
13

100
IO
SAVE THESE INSTRUCTIONS Page 7
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
SSEETT--UUPPIINNSSTTRRUUCCTTIIOONNSS
3. From inside of the pool, unscrew the nozzle from the water return
connector (upper hose connection). See Fig. 3.
4. Screw the hose adaptor (7) to hose
A (8). See Fig. 4.
NOTE: Please use hose adaptor for
small AGP pool (12) instead of hose
adaptor (7) If your pool comes
with 1-1/4" outlet.
5. Screw the end of hose A (8) with
adaptor to the threaded strainer
connector, from inside of the pool.
See Fig. 5.
SET-UP INSTRUCTIONS (continued)
3
4
7
8
5
Threaded Strainer
Connector
8
Lower Hose
Connection
Upper Hose
Connection Threaded Strainer
Connector
nozzle
Inside of
the Pool
Wall

100
IO
SAVE THESE INSTRUCTIONS Page 8
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
SSEETT--UUPPIINNSSTTRRUUCCTTIIOONNSS
SET-UP INSTRUCTIONS (continued)
6. Connect the rest of the hoses together outside the pool, in the order of
hose description (Fig. 6), B-C-B-C-B-D or B-C-B-D.
7. With hose clamp (6), fasten the end
of hose D (11) to the top connection
of cleaner. A small coin can be used
to tighten the hose clamp. See Fig. 7.
8. Place auto cleaner into the water. Fill up the hose assembly with water
by submerging the hose into the water to remove all of the entrapped air
from the hose.
9. Connect hose B (9) from the hose assembly to the hose A (8) which
was already installed in step 4. See Fig. 8.
10. Set up the Filter Pump following the Filter Pump owner's manual. The
auto cleaner is now ready to use.
7
6
98
11
8
6
(B) (C) (B) (C) (B) (D)
(D)(B) (C) (B)
For pool size above 18':
For pool size 18' and below:

100
IO
SAVE THESE INSTRUCTIONS Page 9
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
OOPPEERRAATTIINNGGIINNSSTTRRUUCCTTIIOONNSS
1. The filter pump is an airtight system. In a counter-clockwise motion turn
the top air release valve 1 – 2 turns to open it.
2. When water starts flowing out of the air release valve hole, screw in the
air release valve back into the filter housing cover. Do not over tighten
the valve.
3. Connect the filter pump to the power outlet and turn ON the pump.
4. Hold the auto cleaner upside down below the water surface to jet out
the water. See Fig. 9. This will evacuate all the air in the hose and
auto cleaner, so the cleaner will sink to the bottom and keep the pool
clean.
5. The auto cleaner will change direction each time one of the bumpers
touches the pool sidewall.
OPERATING INSTRUCTIONS
9

100
IO
SAVE THESE INSTRUCTIONS Page 10
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
1. Make sure the filter pump is turned off, and disconnect the power cord
from the electrical outlet.
2. Using the Set Up instructions in reverse, disassemble the auto cleaner.
3. Clean and air dry all the accessories and parts thoroughly.
4. Keep the hoses straight during storage.
5. The original packaging can be used for storage. Store in a dry, cool
storage location.
MMAAIINNTTEENNAANNCCEE
DEBRIS NET CLEANING
1. Make sure the filter pump is turned off, and disconnect the power cord
from the electrical outlet. Remove the auto cleaner from the pool.
2. Unlock four buckles located on the four sides. See Fig. 10.
3. Remove the debris net (4) from the cleaner base (5). If debris is on the
debris net and cleaner base, use garden hose to flush the debris off.
Use the brush if necessary. See Fig. 11.
4. Reassemble auto cleaner reversing steps 1, 2 and 3.
LONG TERM STORAGE
10
11
4
5

100
IO
SAVE THESE INSTRUCTIONS Page 11
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
TROUBLESHOOTING GUIDE
TTRROOUUBBLLEESSHHOOOOTTIINNGGGGUUIIDDEE
IMPORTANT
If you continue to experience difficulty, please contact our
Consumer Service Department for assistance. See back cover for
contact information.
Q. What should I do if Auto Cleaner doesn’t move or movement is very
slow?
A. 1. Pull the cleaner’s hose and lift auto cleaner off from the wrinkles.
2. Check the circulation line:
i. Ensure the filter pump is turned on.
ii. Ensure the plunger valves are opened.
iii. Clean or replace cartridge.
Q. What should I do if Auto Cleaner lifts off from the pool floor?
A. Release air from the auto cleaner by following the “Owner’s Manual”.
Q. What is the easiest way to carry the Auto Cleaner out from the pool
after used?
A. Release the water inside the auto cleaner by following the steps below:
1. Make sure the filter pump is turned off, and disconnect the power
cord from the electrical outlet.
2. Pull the cleaner’s hose slowly and lift the auto cleaner up just right
below the water surface.
3. Hold the hose with one hand, and lift the auto cleaner up slowly
with an angle (either head or tail up) by carrying the cleaner bottom
with another hand.
4. After the water has been fully released from the auto cleaner, carry
the auto cleaner out with both hands. DO NOT lift the hose or
bumper which could be damaged.
English

100
IO
SAVE THESE INSTRUCTIONS Page 12
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
SSAAFFEETTYYGGUUIIDDEELLIINNEESS
GENERAL AQUATIC SAFETY
Water recreation is both fun and therapeutic. However, it involves
inherent risks of injury and death. To reduce your risk of injury, read
and follow all product, package and package insert warnings and
instructions. Remember, however, that product warnings, instructions
and safety guidelines cover some common risks of water recreation,
but do not cover all instances or risk and or danger.
For additional safeguards, also familiarize yourself with the following
general guidelines as well as guidelines provided by nationally
recognized Safety Organizations:
• Demand constant supervision.
• Learn to swim.
• Take the time to learn CPR and first aid.
• Instruct anyone who is watching your children about potential pool
hazards and about the use of protective devices such as locked doors,
barriers, etc.
• Teach children what to do in case of an emergency.
• Always use common sense and good judgement when enjoying any
water activity.
• Supervise, Supervise, Supervise.
English

100
IO
SAVE THESE INSTRUCTIONS Page 13
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.3” PANTONE 295U 08/05/2008
English
AREAS LOCATION AREAS LOCATION
For service questions or to order replacement parts, please contact the appropriate office
listed below or visit www.intexdevelopment.com for answers to most frequently asked
questions.
• ARGENTINA JARSE INDUSTRIAL Y COMERCIAL S.A
MANUEL GARCIA 122/124
CIUDAD AUTÓNOMA DE BUENOS AIRES
(CP 1284)
TEL: [phone]
E-mail: [email protected]
Website: www.serviciointex.com.ar
• PERU COMEXA S.A.
AV. COMANDANTE ESPINAR 142
MIRAFLORES, LIMA PERÚ
TEL: [phone]
E-mail: [email protected]
Website: www.serviciointex.com.pe
• URUGUAY ALLERTON S.A.
ALBERTO ZUM FELDE #2393
11400 MONTEVIDEO URUGUAY
TEL: [phone]
E-mail: [email protected]
Website: www.serviciointex.com.uy
• SAUDI ARABIA SAUDI ARABIAN MARKETING &
AGENCIES CO. LTD.
PRINCE AMIR MAJED STREET,
AL-SAFA DISTRICT. JEDDAH,
KINGDOM OF SAUDI ARABIA
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.samaco.com.sa
• AUSTRIA STEINBACH VERTRIEBSGMBH
AISTINGERSTRAßE 2
4311 SCHWERTBERG
TEL: [phone]
FAX: + 43 (7262) 61439
E-mail: [email protected]
Website: www.intexcorp.at
• CZECH REPUBLIC / INTEX TRADING S.R.O.
EASTERN EUROPE BENESOVSKA 23,
101 00 PRAHA 10,
CZECH REPUBLIC
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• BELGIUM N.V. SIMBA-DICKIE BELGIUM S.A.
MOESKROENSESTEENWEG 383C,
8511 AALBEKE, BELGIUM
TEL: [phone]
FAX: [phone]
E-mail: [e-mail]
• DENMARK K.E. MATHIASEN A/S
SINTRUPVEJ 12, DK-8220
BRABRAND, DENMARK
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexnordic.com
• SWEDEN LEKSAM AB
BRANDSVIGSGATAN 6,
S-262 73 ÄNGELHOLM,
SWEDEN
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexnordic.com
• NORWAY NORSTAR AS
PINDSLEVEIEN 1,
N-3221 SANDEFJORD,
NORWAY
TEL: [phone]
FAX: [phone]
E-mail: [e-mail]
Website: www.intexnordic.com
• FINLAND NORSTAR OY
SUOMALAISTENTIE 7,
FIN-02270 ESPOO,
FINLAND
TEL: [phone]
FAX: [phone]
E-mail: [e-mail]
Website: www.intexnordic.com
• RUSSIA LLC BAUER
KIEVSKAYA STR., 20,
121165 MOSCOW, RUSSIA
TEL: [phone]/9802
FAX: [phone]
E-mail: [email protected]
Website: www.intex.su
• POLAND KATHAY HASTER
UL. LUTYCKA 3, 60-415 POZNAN
TEL: [phone]
FAX: [phone]
E-mail: [e-mail]
• HUNGARY RECONTRA LTD./RICKI LTD.
H-1113 BUDAPEST, DARÓCZI ÚT 1-3,
HUNGARY
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• BRASIL KONESUL MARKETING & SALES LTDA
RUA ANTONIO DAS CHAGAS,
1.528 - CEP. 04714-002,
CHÁCARA SANTO ANTONIO - SÃO
PAULO - SP - BRASIL
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• ISRAEL ALFIT TOYS LTD
MOSHAV NEHALIM,
MESHEK 32, 49950, ISRAEL
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• ASIA INTEX DEVELOPMENT CO. LTD.
8TH FLOOR,
DAH SING FINANCIAL CENTRE,
108 GLOUCESTER ROAD,
WANCHAI, HONG KONG
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexdevelopment.com
• EUROPE INTEX TRADING B.V.
POSTBUS 1075, 4700 BB ROOSENDAAL,
THE NETHERLANDS
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexcorp.nl
• FRANCE REFLEX SERVICES
(SAV INTEX FRANCE)
52, ROUTE NATIONALE,
39190 BEAUFORT, FRANCE
TEL: [phone] (0.15 TTC/min)
FAX: [phone]
E-mail: [email protected]
Website: www.intex.fr
• GERMANY STEINBACH VERTRIEBSGMBH
AN DER WELLE 4
60322 FRANKFURT
TEL: [phone]
FAX: + 43 (7262) 61439
E-mail: [email protected]
Website: www.intexcorp.de
• ITALY A & A MARKETING SERVICE
OFFICE: VIA DEI MESTIERI 8, 20049
CONCOREZZO, MILANO - ITALY
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexitalia.com
• UK TOY BROKERS LTD
MARKETING HOUSE,
BLACKSTONE ROAD,
HUNTINGDON, CAMBS.
PE29 6EF. UK
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.intexspares.com
• SWITZERLAND GWM AGENCY
GARTEN-U. WOHNMÖBEL,
RÄFFELSTRASSE 25,
POSTFACH,
CH-8045 ZURICH/SWITZERLAND
TEL: [phone] or [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.gwm.ch
• SPAIN KOKIDO BVI LIMITED
AV. MORERAS, 1 - NAVES 7-10 POL.LND
CAMPORROSSO 28350 CIEMPOZUELOS,
MADRID - APDO.DE CORREOS 134
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
E-mail: [email protected]
• PORTUGAL KOKIDO BVI LIMITED
AVENIDA ANTÓNIO AUGUSTO AGUIAR
Nº 163, SALA 3 - 5º DIREITO
1050 LISBOA
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• AUSTRALIA HUNTER OVERSEAS PTY LTD
LEVEL 1, 225 BAY STREET,
BRIGHTON, VICTORIA,
AUSTRALIA
TEL: [phone] or 1800-224-094
FAX: [phone]
E-mail: [email protected]
Website: www.hunteroverseas.com.au
• NEW ZEALAND HAKA NEW ZEALAND LIMITED
UNIT 4, 11 ORBIT DIVE, ALBANY,
AUCKLAND 0757, NEW ZEALAND
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• MIDDLE EAST FIRST GROUP INTERNATIONAL
REGION AL MOOSA GROUP BUILDING, 1ST
FLOOR, OFFICE 102 & 103, UMM HURAIR
ROAD, KARAMA, DUBAI, UAE
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
Website: www.firstgroupinternational.com
• SOUTH AFRICA WOOD & HYDE
15-17 PACKER AVENUE, INDUSTRIA 2,
CAPE TOWN, SOUTH AFRICA 7460
TEL: [phone]
FAX: [phone]
E-mail: [email protected]
• CHILE SILFA LTDA
CERRO SAN LUIS # 9987, BODEGA 22
QUILICURA, SANTIAGO DE CHILE
TEL: [phone]
E-mail: [email protected]
Website: www.serviciointex.cl