Jacuzzi Proclear User manual

Custom Designed
For Your Jacuzzi® Ho t Tub!
Please refer to the operating manual for complete installation
instructions.
PRECAUTIONARY STATEMENT
Hazards to Humans and Domestic Animals.
CAUTION
In the unlikely event that a cartridge breaks, mineral media should
not be ingested by humans or animals as it may cause gastric
distress.
FIRST AID
IF INGESTED: Call Poison Control Center or doctor immediately for
treatment advice.
STORAGE / DISPOSAL
Storage – store in areas inaccessible to small children.
Disposal – After 4 months of use, discard cartridge in household
trash. Do not save the cartridge for re-use. The cartridge is
manufactured with mineral sealed media inside. In the unlikely
event a cartridge breaks, remove it and vacuum out any media
introduced into the spa water.
DIRECTIONS FOR USE
It is a violation of Federal Law to use this product in a manner
inconsistent with its labeling.
See Owner’s Manual inside box for directions for use.
CHANGE THIS CARTRIDGE EVERY 4 MONTHS
Use of this cartridge for longer than 4 continuous months will void
the warranty. Discard this cartridge at the end of 4 months.
W12211 Rev B 2890-185
proclearTM
proclearTM
proclearTM proclearTM
Proclear™ water is brilliantly
clear and soft.
An alternative to chlorine
when used in combination
with MPS*
Ends chlorine hassle when
used in combination with
MPS*, and improves water
quality.
Reduces potential for
unpleasant odor and
scum lines.
Enhanced bather comfort.
It’s compatible - proclear™
can even be used with
your ozonator.
EXCLUSIVELY DESIGNED
TO WORK IN
YOUR JACUZZI®
*Potassium peroxymonosulfate
KEEP OUT OF REACH OF CHILDREN
CAUTION
See back panel for additional precautionary statements.
ACTIVE INGREDIENTS:
Metallic Silver** 0.92%
OTHER INGREDIENTS 99.08%
TOTAL 100.00%
**From Silver Nitrate
EPA Reg. No. 67712-15-79651
EPA Est. No. 67712-CA-001
NET CONTENTS: 98 grams (0.22 lbs.)
SPA CAPACITY: Up to 500 Gallons
LASTS UP TO A FULL 4 MONTHS
Mineral Spa Sanitizer
INSTALLS IN SECONDS!
CUSTOM DESIGNED FOR
YOUR JACUZZI®FILTER
1. Twist and remove lter cap.
2. Match up tabs on proclear™
sanitizer with tabs on
Jacuzzi® lter lid. Twist
sanitizer gently until it
locks securely on the lid.
3. Slide the entire device into
the core of your Jacuzzi lter
cartridge.
4. Lock cap into place.
Distributed by:
Jacuzzi Hot Tubs
14525 Monte Vista Ave.
Chino, CA 91710
Manufactured by:
Zodiac Pool Systems, Inc.
2620 Commerce Way
Vista, CA 92081-8438
Nature2is a registered trademark of
Zodiac Pool Care, Inc, an aliate of
Zodiac Pool Systems, Inc. ©2010

Owner’s Manual
ProclearTM treated water is brilliantly clear
and soft.
An alternative to chlorine when used in
combination with MPS*
Ends chlorine hassle when used in
combination with MPS*, and improves
water quality.
Reduces potential for unpleasant odor
and scum lines.
Enhanced bather comfort.
It’s compatible - proclear can even be
used with your ozonator.
The proclear mineral spa sanitizer is
designed only for residential portable spas.
For Customer assistance:
Contact your Jacuzzi® Dealer.
Locate a Jacuzzi® Dealer near you
at www.jacuzzi.com, or
Contact Zodiac Pool Systems, Inc:
(phone) 1-800-822-7933
(e-mail) cust[email protected]
NATURE2®** SPA TEST STRIPS:
Just dip and swirl the test strip. See accurate
and reliable results on the levels of MPS*,
Alkalinity and pH in your spa water. For more
information about Nature2® Spa Test Strips,
contact your Jacuzzi®Dealer. For a Jacuzzi®
Dealer near you, go to www.jacuzzi.com.
Custom Designed
For Your Jacuzzi®Hot Tub!
Mineral Spa Sanitizer
proclearTM
proclearTM
EPA Reg. No. 67712-15-79651
EPA Est. No. 67712-CA-001
IMPORTANT: Spa Owner, save this manual!
Installer, leave this manual with the spa owner!
ACTIVE INGREDIENTS:
Metallic Silver* 0.92%
OTHER INGREDIENTS 99.08%
TOTAL 100.00%
*From Silver Nitrate
KEEP OUT OF REACH OF CHILDREN
CAUTION
See back for additional
precautionary statements
Net Contents: 0.22 lbs. (98 grams)
Capacity: Up to 500 gallons (1,893 liters)
Twist and remove filter cap.
STEP 1
Before opening your lter, please refer
to the spa owner’s manual for complete
installation instructions.
Installation:
ProclearTM features
Nature2® technology.
Match up tabs on proclearTM with tabs
on Jacuzzi®filter lid.
Twist proclearTM gently until it locks
securely on the lid.
Slide the entire device into the core
of your Jacuzzi®filter cartridge.
Lock cap into place.
proclearTM
STEP 2
STEP 3 STEP 4
*potassium peroxymonosulfate
**Nature2is a register trademark of Zodiac Pool Care, Inc.,
an aliate of Zodiac Pool Systems, Inc.
TL-2716 Rev. A 01/10

WHEN: WHAT TO DO:
Run spa according to recommendations supplied to you by the manufacturer of your spa.
Test the water with the Nature2® Spa Test Strip (or equivalent). If the MPS*level is low, add
1 tablespoon of MPS*to spa per 250 gallons (approx. 1000 liters).
(Note: 1 tablespoon is approximately ½ ounce or 16 grams)
Use the Nature2Spa Test Strip (or equivalent) to test the spa water after each addition of MPS.*
If the test strip indicates levels below the OK range, add 1 tablespoon MPS*to spa per 250 gallons and re-test. Enter
spa only after test strip indicates a sufficient level of MPS.*
Add 1 tablespoon of MPS*to spa per 250 gallons (approx. 1000 liters)
Adjust the pH, total alkalinity and hardness as needed. A convenient way to test pH and total alkalinity is the use of
the Nature2® Spa Test Strip.
Drain and refill your spa. Replace proclear, repeat sanitizer start-up.
Shock treat with 1.5 tablespoons of an EPA registered source of dichlor** per 250 gallons (approx. 1000 liters) to
remedy problems which may occur when bathing loads are high, when successive MPS** test strip reading indicate
high demand, when water appears hazy or dull, when unpleasant odors or eye irritation occur, after heavy wind and
rainstorms or if foam develops.
EVERY DAY:
AFTER EACH USE:
ONCE PER WEEK:
EVERY 4 MONTHS:
AS NEEDED:
BEFORE EACH USE:
NOTE: As an alternative to MPS*, an EPA registered source of dichlor** may be substituted: 1 tablespoon dichlor**= approximately 3 tablespoons MPS.*
IMPORTANT: Perform start-up procedures for spas which have been unused or unattended. The proclear™ is not to be used with products
containing biguanides. If biguanide or bromine products are being used, BE SURE TO DRAIN AND REFILL SPA WITH FRESH WATER WHEN USING
THE LOW CHLORINE RECIPE.
REPLACEMENT INTERVALS  FOR PROCLEAR
A cartridge lasts four (4) months. The cartridge should not be used longer than four (4) months.
STORAGE/DISPOSAL:
Storage – store in areas inaccessible to small children. Disposal – After four (4) months of use, discard proclear™ in household trash. Do not save
the cartridge for re-use. The cartridge is manufactured with the mineral media sealed inside. In the unlikely event a cartridge breaks, remove it
and vacuum out any media introduced into the spa.
MINERAL SPA SANITIZER
PRECAUTIONARY STATEMENT
Hazards to Humans and Domestic Animals.
CAUTION
In the unlikely event that a cartridge breaks, mineral media should not be ingested by humans or animals as it may cause gastric distress.
FIRST AID
If Ingested: Call Poison Control Center or doctor immediately for treatment advice.
Proclear™ has been designed to sanitize spas up to 500 gallons.
DIRECTIONS FOR USE:
It is a violation of Federal law to use this product in a manner inconsistent with its labeling.
LOWCHLORINE RECIPE
• Proclear™
• Non-chlorine oxidizer (potassium peroxymonosulfate)
• Nature2® Spa Test Strips or equivalent (*MPS, pH, total alkalinity)
• pH, hardness, and total alkalinity adjusting chemicals
• Dichlor**, EPA registered source
PROCLEAR™COMPATIBILITY
ATTENTION
Not to be used with product containing biguanides. If biguanide or bromine products are being used, be sure to drain and rell with fresh water.
STARTUP
Before starting up a new proclear, clean debris and algae out of the spa and spa equipment.
IMPORTANT: Do not install the new proclear until the spa water is clean and chemically balanced.
Balance spa water before installing proclear.
pH 7.2-7.6
Calcium Hardness 200-400 ppm
Total Alkalinity (TA) 80-120 ppm
INSTALL PROCLEAR™
Add 1 ½ tablespoons of dichlor** to spa per 250 gallons (approx. 1000 liters). Note: 1 ½ tablespoons is approximately ¾ oz or 24 grams.
Do not enter the spa if the free available chlorine residual is over 5ppm.
* potassium peroxymonosulfate
** sodium dichloroisocyanurate dihydrate
proclearTM