JumpTek 084-0207 User manual

Version 4
Assembly, Installation and Use Manual
8’ (2.4 m) Trampoline and Enclosure Combo
084-0207
Stop
Please read and understand this manual before assembly.
Before beginning assembly of product, make sure all parts are present.
Compare parts with packaging contents list. If any part is missing, or if you
have any questions, contact the vendor’s customer service department at
1-866-567-4089.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 1 11-11-9 ��4:10

2
Dear Customer,
Thank you for choosing a JumpTek trampoline. We hope it will provide many hours of quality exercise to
make you feel better, look better and enjoy life to its fullest. It is proven that a regular exercise program
can improve physical and mental health. The JumpTek trampoline provides a convenient and simple way
to get your body in shape and achieve a happier and healthier lifestyle. Enjoy!
TABLE OF CONTENTS
Safety instructions 2 - 3
Parts list & diagram 4 - 5
Assembly 6 - 13
Information on trampoline use 13
Training with the trampoline 14 - 15
Cleaning and care 16
Technical data 16
Limited warranty 17
SAFETY INSTRUCTIONS
WARNING!
Only one person at a time is allowed on the trampoline. If more than one person uses the
trampoline at the same time, the danger of losing control, collisions or falling from the
trampoline increases. This might lead to injuries to the head, neck, back, arms or legs.
Do not land on your head or neck. This poses danger of paralysis followed by death, even
when landing in the middle of the jumping bed. To avoid the danger of a head or neck injury,
never attempt to do somersaults on the trampoline.
Only use the trampoline with a responsible adult supervising.
TO REDUCE THE RISK OF SERIOUS INJURY, READ THE FOLLOWING SAFETY
INSTRUCTIONS BEFORE ASSEMBLING AND USING THE TRAMPOLINE.
Safety instructions for trampoline
• Misuse and abuse of this trampoline is dangerous and can cause serious injuries or death. Trampolines,
being rebounding devices, propel the user to unaccustomed heights and into a variety of body
movements.
• Do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis or
death, even when landing in the middle of the trampoline.
• Do not allow more than one person on the trampoline. Use by more than one person at the same time
can result in serious injuries.
• Use the trampoline only with the supervision of a mature, knowledgeable person.
• Trampolines over 20” (51 cm) tall are not recommended for use by children under six years of age.
• Keep small children and pets away from the trampoline at all times, including during use and assembly
of the trampoline.
• Inspect the trampoline before each use. Make sure the frame padding is correctly and securely
positioned. Replace any worn, defective or missing parts.
• Climb on and o the trampoline. It is a dangerous practice to jump from the trampoline to the floor or
ground when dismounting, or to jump onto the trampoline when mounting. Do not use the trampoline
as a springboard to other objects.
• Stop bounce by flexing knees as feet come in contact with the trampoline bed. Learn this skill before
attempting others.
• Learn fundamental bounces and body positions thoroughly before trying more advanced skills. A variety
of trampoline activities can be carried out by performing the basic fundamentals in various series and
combinations, performing one fundamental move after another, with or without feet bounces between them.
• Avoid bouncing too high. Stay low until bounce control and repeated landing in the centre of the
trampoline can be accomplished. Control is more important than height.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 2 11-11-9 ��4:10

3
SAFETY INSTRUCTIONS
• With the head erect, focus eyes toward the perimeter of the trampoline. This will help control bouncing.
• Avoid bouncing when tired. Keep turns short.
• Properly secure the trampoline when not in use. Protect it against unauthorized use. If a trampoline
ladder is used, the supervisor should remove it from the trampoline when leaving the area to prevent
unsupervised access by children under six years of age.
• Keep objects away that could interfere with the user. Maintain a clear area around the trampoline.
• Do not use the trampoline while under the influence of alcohol or drugs.
• For additional information concerning the trampoline equipment, contact the manufacturer.
• For information concerning skill training, contact a certified trampoline instructor.
• Bounce only when the surface of the bed is dry. Wind or air movement should be calm to gentle. The
trampoline should not be used in gusty or severe winds.
• Read all instructions before using the trampoline. Warnings and instructions for the care, maintenance
and the use of this trampoline are included to promote safe, enjoyable use of this equipment.
• This trampoline is for home use only. Do not use for institutional or commercial purposes. Failure to
follow this warning could result in minor or moderate injury.
• The weight limit on the trampoline is 113 kg (250 lb).
Safety instructions for enclosure net
• Do not bounce against the trampoline net.
• This enclosure net is only to be used with a trampoline of a size for which the enclosure is designed.
• Make sure that no fire is lit close to the enclosure. In windy conditions, sparks and embers can travel
significant distances and burn holes in the enclosure net.
• Any large trampoline with an enclosure net installed can be blown around in high winds and cause
personal injury or property damage. We recommend removing the trampoline enclosure and
disassembling the trampoline in strong winds.
WARNING: Before starting any exercise or conditioning program consult a personal physician
to see if you require a complete physical exam. This is especially important if you are over the
age of 35, have never exercised before, are pregnant or suer from any illness.
>7,5 m
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 3 11-11-9 ��4:10

4
PARTS LIST
No. Description Qty No. Description Qty
1Enclosure Net x1 15 Spacer x24
2Ball Cap x6 16 Bolt Clamp x12
3Ball Cap
Screw x6 17 Locking Nut x24
4T-shaped Joint x2 18 U-shaped Bolt x12
5Vertical Leg
Tube (right) x3 19 Top Rail Tube (a) x4
6V-shaped
Tube x3 20 Top Rail Tube (b) x2
7Long Nut x6 21 Top Rail Tube (c) x2
8Washer x6 22 Lower Pole Foam
(pre-installed) x6
9Bolt x6 23 Upper
Supporting Pole x6
10 Vertical Leg
Tube (left) x3 24 Upper Pole Foam
(pre-installed) x6
11
Trampoline
Mat
(with sewn-in
V-rings)
x1 25 Foam Sleeve x6
12 Spring x48 26 Allen Key x2
13 Frame Pad x2 27 Spring Hook Tool x1
14
Lower
Supporting
Pole
x6
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 4 11-11-9 ��4:10

5
DIAGRAM
21
4
27
26
5
12 6101114
25
24
23
22
21
20
19
13
3
18
15
16
17
9
8
7
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 5 11-11-9 ��4:11

6
ASSEMBLY
Place all parts from the box in a cleared area and position them on the floor in front of
you. Remove all packing materials and place them back in the box. Do not dispose of the
packing materials until assembly is completed. Read each step carefully before beginning
assembly and make sure you understand each step. If you are missing a part please call
our toll-free number for assistance: 1-866-567-4089.
WARNINGS:
• Always use two or more strong people to assemble the trampoline. Failure to use two or
more strong people may allow the springs to strike back and hit someone, which could
cause serious injury or death.
• Keep children and pets away from the trampoline during assembly.
• Keep fingers away from the places where they can be pinched or trapped.
• The frame pad must be installed before using the trampoline.
• Do not attempt to assemble the trampoline if any parts are missing.
• Adequate overhead clearance is essential. A minimum of 24’ (8 m) from ground level is recommended.
Provide clearance for wires, tree limbs, and other possible hazards.
• Lateral clearance is essential. Place the trampoline away from walls, structures, fences and other play
areas. Maintain a clear space on all sides of the trampoline.
• Place the trampoline on a level surface before use.
• Use the trampoline in a well-lit area. Artificial illumination may be required for indoor or shady areas.
• Secure the trampoline against unauthorized and unsupervised use.
• Remove any obstructions from beneath the trampoline.
• The owner and supervisors of the trampoline are responsible for making all users aware of practices
specified in the user instructions.
Step 1: Preparation
• Place the Top Rail Tubes (19, 20, 21), T-shaped Joints (4), Vertical Leg Tubes (5, 10) and V-shaped Tubes
(6) on a level surface, as shown in the picture below. This provides an overview of the parts and the way
they should be assembled.
21 20
19
10 5
4
6
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 6 11-11-9 ��4:11

7
ASSEMBLY
Step 2: Assembling the Vertical Leg Tubes
• Connect all six Vertical Leg Tubes (5, 10) to the V-shaped Tubes (6) and secure with Long Nuts (7),
Washers (8) and Bolts (9).
• Fasten the Long Nuts (7) with Allen Key (26) and make sure all connections are tight.
7
10 65
8
9
26
7
Step 3: Assembling the Top Rail Frame
• Connect Top Rail Tubes (a) (19) to the T-shaped Joints (4). First slide the bigger end of the Top Rail
Tube (a) (19) into the T-shaped Joint (4). Then slide the smaller end of another Top Rail Tube (a) into
the joint. Make sure the smaller end is tightly connected to the bigger end and T-shaped Joint.
• Repeat this step to connect the other set of the Top Rail Tubes (a) (19) and T-shaped Joint (4).
• Slide the smaller end of the Top Rail Tube (b) (20) into the bigger end of the Top Rail Tube (c) (21) to
connect Top Rail Tubes (b) and (c).
• Connect all the assembled sections by sliding the smaller ends of each section into the bigger ends of
each next section to complete the Top Rail Frame.
Note: When connecting the Top Rail Tubes (a) (19) to the T-shaped Joints (4), be sure that
the opening on each T-shaped Joint is facing the inner side of the Top Rail Frame.
19
20 421
Step 4: Assembling the Leg Tubes to the Top Rail Tubes
• Connect the assembled Leg Tubes to the assembled Top Rail Frame.
• Make sure that the locking tabs on the Vertical Leg Tubes (5, 10) go through the openings on the
T-shaped Joints (4) and connection tabs of the Top Rail Tubes (b) and (c).
5 10
Locking
tab
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 7 11-11-9 ��4:11

8
ASSEMBLY
• After completing the assembly, the trampoline frame should look like the illustration below.
Step 5: Preparing the Trampoline Mat
• Unfold the Trampoline Mat (11).
• Have the Springs (12) and Spring Hook Tool (27) ready for assembly.
Step 6: Connecting the Trampoline Mat to the Top Rail Frame
• Hang the Trampoline Mat (11) on the Top Rail Frame using the provided Springs (12).
• Use the Spring Hook Tool (27) to pull and insert the Springs (12) into the openings on the Top Rail
Tubes (19, 20, 21).
Sewn-in
V-ring
x1
x48
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 8 11-11-9 ��4:11

9
ASSEMBLY
• When connecting the Springs (12) always connect the Springs opposite to each other to get an even
result in tensioning the Trampoline Mat (11).
Notes:
• The even distribution of tension is a critical factor in the proper assembly of the Trampoline Mat.
• If the Springs (12) can only be inserted with the use of extensive force, they are not
inserted in the correct order and manner.
• Make sure that the Springs (12) are always inserted at an angle of approximately 90° to
the openings on the Top Rail Frame.
• After completing the assembly, the Trampoline Frame and Mat should look like the illustration below.
Step 7: Assembling the Supporting Poles
• Connect all six Upper Supporting Poles (23) to the six Lower Supporting Poles (14). Make sure that the
locking tabs “click” into the openings of the Upper Supporting Poles (23).
Note: All of the Supporting Poles come with pre-installed Pole Foams (22, 24).
Opening
Locking tab
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 9 11-11-9 ��4:11

10
ASSEMBLY
Step 8: Attaching the Foam Sleeve
• Insert the assembled Upper and Lower Supporting Poles (14, 23) into the wider opening of the Foam Sleeve
(25).
• Slide the assembled poles in until the top end of the Upper Supporting Pole (23) comes out on the
opposite side.
• Make sure that the Sleeve (25) covers the entire preinstalled foam of the Supporting Poles.
Smaller opening
Top end of the Upper Supporting Pole
Step 9: Fixing the Ball Cap
• Place a Ball Cap (2) onto the top end of each Upper Supporting Pole (23). Make sure that the screw
hole on the Ball Cap (2) is aligned with the screw hole on the top end of the Pole.
• Fasten the Ball Caps (2) using the Ball Cap Screws (3).
Phillips screwdriver
2
3
Step 10: Fixing the Supporting Poles to the Trampoline Legs
• Place a U-shaped Bolt (18) around one of the Lower Supporting Poles (14).
• Attach the Spacer (15) to the U-shaped Bolt (18) and then, in an upright position, hold it against one of
the vertical legs of the trampoline.
• Secure the U-shaped Bolt (18) with a Bolt Clamp (16) and two Locking Nuts (17).
• Adjust the height level of the Supporting Pole to reach an appropriate position and tighten the
connection with a Spanner (not provided). The bottom end of the Foam Sleeve (25) should be at the
same height level as the Top Rail Frame.
U-shaped Bolt
Lower Supporting Pole Vertical Leg
Spacer
Bolt Clamp
Locking Nut
Wrench
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 10 11-11-9 ��4:11

11
ASSEMBLY
• Repeat the steps above to attach all six Supporting Poles onto the vertical legs of the trampoline.
• After completing the assembly, the Supporting Poles should look like the illustration below.
Step 11: Assembling the Enclosure Net
Note: The edge with pre-sewn loops is the upper part of the Enclosure Net.
• Locate a position for the entrance of the trampoline and hang the pre-sewn loop closest to the opening
onto the Ball Cap (2).
• Hang the rest of the pre-sewn loops around the remaining five Ball Caps (2).
• Attach the bottom end of the Enclosure Net (1) to the trampoline bed using the existing bed springs.
• Align the eyelets of the Enclosure Net (1) with the V-rings of the bed and untie one of the springs using
the hook tool.
Note: It is essential to select the closest eyelet to its respective V-ring. Even small
misalignments may cause problems with proper assembly.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 11 11-11-9 ��4:12

12
ASSEMBLY
• Guide the Spring through the Enclosure Net’s eyelet and the trampoline bed’s V-ring and reattach the
Spring to the trampoline frame. Repeat the same steps for each Spring in a clockwise direction.
Eyelet
Trampoline
Mat
Enclosure
Net
• Secure all of the six hook-and-loop straps around the six Supporting Poles, making sure that they are
securely fastened.
Step 12: Attaching the Frame Pad
• Place both Frame Pads (13) on the trampoline and tie them using the sewn-in straps.
• Align the outer straps with each T-shaped Joint (4).
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 12 11-11-9 ��4:12

13
ASSEMBLY
• Secure the straps around the T-shaped Joint (4) from the inner side with a knot.
• Thread the straps through the sewn-in strap hook under the Frame Pad (13) and the closest V-ring. Tie
knots to secure the Frame Pads (13).
Sewn-in V-ring
• Now the trampoline and enclosure are assembled.
INFORMATION ON TRAMPOLINE USE
Jumpers, please pay attention:
• Do not use the trampoline if you are tired or under the influence of alcohol or drugs.
• Do not jump too high. To avoid fatigue, do not jump too long. Control your jumps. When
using the trampoline, a supervisor has to be present. Do not jump alone.
• Do not wear clothes with hooks or parts that might become entangled in the jumping
bed.
• Climb onto the trampoline. Do not jump from the trampoline. Do not use the trampoline
as a springboard to other objects.
Supervisors, please pay attention:
• It is the responsibility of the owner or the supervisor to ensure that all users of the
trampoline are suciently informed about all warnings and safety instructions and to
enforce them.
• All trampoline users need a supervisor, regardless of their age or capabilities.
• Remove all objects that might interfere with the jumper from the surroundings of the
trampoline. Pay attention to what is above, below and around the trampoline.
• When it is not in use, keep the trampoline secured to prevent it from being used without
supervision.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 13 11-11-9 ��4:12

14
TRAINING WITH THE TRAMPOLINE
Fundamental trampoline skills
Bouncing
The most important thing about bouncing is that it should be done with control in the centre of the mat.
The basic bounce should always be low. High, reckless bouncing should never be allowed.
Stop Bouncing
This technique allows the jumper to gain control by stopping quickly. It is achieved by keeping the feet
in contact with the mat, and absorbing the rebound of the trampoline with the knees and waist. This skill
should be the first skill learned and should be employed whenever you feel out of balance or land away
from the centre area.
• Stand in the centre of the mat with your feet about hip-width apart.
• Attempt about three easy bounces, keeping them low and controlled.
• To keep your balance, focus your eyes towards the perimeter of the trampoline while bouncing.
• Stop bounce by bending your knees and bringing your hips in contact with the mat.
Arm Action
Arms are very important for proper control and lift. Whenever
you go up, your arms go up. They go up to a set position,
about shoulder height and shoulder width. They should remain
in this balanced position until you start coming down. Then
they circle down and go slightly behind the hips, ready to be
lifted as you bounce up.
Bounce Variations
The illustration on the right shows three variations, the tuck,
the pike, and the straddle pike, respectively. These should be
assumed at the top of the bounce, before resuming the normal
landing position on your feet. Practice these simple variations
and concentrate on perfect form. Make sure that your toes are
pointed and your fingers straight. These are simple variations
to the basic bounce and are very important for gaining
experience in coordinated movement.
Training
1. Basic jump
• Stand straight on the trampoline.
• Gather a little momentum with your arms and jump at the
same time from the mat.
• Hold your feet together in the air and point your toes
downward.
• To keep your balance, focus your eyes toward the perimeter
of the trampoline while bouncing.
• Hold your feet shoulder - width apart when landing.
• When you want to stop, bend your knees and hips when your
feet come into contact with the trampoline.
2. Knee bounce
• Start with the basic jump, holding a low height.
• Land on your knees, with your back straight.
• Keep balance with your arms.
• Gather a little momentum with your arms to go back to a
standing position.
3. Hands and knees bounce
• Start with the basic jump, holding a low height.
• Land on your hands and knees. Make sure you put the weight
on both of your hands and knees. Do not sit on your heels.
• Remain this position and try to bounce. Do not rock back
and forth between your hands and knees. Develop an even
landing on all of the four points.
• Look slightly in front of your hands when landing. Push to
rebound to your feet.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 14 11-11-9 ��4:12

15
TRAINING WITH THE TRAMPOLINE
4. Seat bounce
• Start with the basic jump, holding a low height.
• Land on your bottom, with your back straight.
• Keep your hands beside your hips. Do not lock your elbows.
• Push yourself up to standing position again with your hands.
5. Front bounce
• Do a basic jump first.
• After landing, push yourself forward with your feet and hold
your arms in front of you.
• Let yourself drop forward and land like shown, with your
arms crossed beneath your head.
• Use your arms and the momentum to get back to a standing
position.
• Note: Only do this jump if the trampoline has sucient space
for it.
6. 180° bounce
• This is a dicult jump that requires a lot of body control.
• Do a complete front bounce first.
• After landing, use your left or right arm and hand to make a
180° roll.
• Keep your back straight.
• After landing, jump back to a standing position.
• Note: Only do this jump if the trampoline has sucient space
for it.
7. Full twist bounce
• Start with the seat bounce.
• When you bounce up, keep moving your shoulder in the
direction of the twist.
• During the twist, place your hands by your sides and hold
your body straight.
• After the twist, finish in the seat drop position.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 15 11-11-9 ��4:12

16
CLEANING AND CARE
Inspection
• Check the trampoline and enclosure before each use for wear and damage. In case of damage have it
repaired by your specialist retailer immediately.
The following conditions could pose potential hazards:
• Missing, improperly positioned or insecurely attached frame pad.
• Punctures, frays, tears, or holes worn in the mat or frame pad.
• Deterioration in the stitching or fabric of the mat or frame pad.
• Ruptured springs.
• A bent or broken frame.
• A sagging mat.
• Unstable or improper assembling of the Supporting Poles and the trampoline vertical legs.
• Unfixed enclosure net.
• Sharp protrusions on the frame or enclosure.
• Unstable parts and connections.
Cleaning
• Clean the frame pad with a soft cleanser to remove oil or dirt stains. Use cleansers suitable for padding
only.
• Clean the enclosure net with a brush or a slightly damp cloth to remove dirt or dust.
• Remove dirt and dust with a soft and slightly damp cloth.
• When rust appears on the surface, remove it with either wire brush or coarse sandpaper. Then treat the
spot with non-toxic paint.
• For cleaning the frame pad do not use aggressive cleansers or cleansers containing chemicals.
Storing
• For extended periods of disuse, disassemble the enclosure net and trampoline and store them in a
clean and dry place.
TECHNICAL DATA
7 x 8' (221 x 244 cm)
249 lb
(113 kg)
90 lb (41.1
kg)
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 16 11-11-9 ��4:12

17
LIMITED WARRANTY
This JumpTek product is guaranteed for one year from the date of original retail purchase against defects
in materials and workmanship.
Subject to the conditions and limitations described below, this product, if returned to us with proof of
purchase within the stated warranty period and if covered under this warranty, will be repaired or replaced
(with the same model, or one of equal value or discretion), at our option. We will bear the cost of any
repair or replacement and any costs of labour relating thereto.
These warranties are subject to the following conditions and limitations:
a) a bill of sale verifying the purchase and purchase date must be provided;
b) this warranty will not apply to any product or part thereof that is worn or broken or that
has become inoperative due to abuse, misuse, accidental damage, neglect or lack of proper
installation, operation or maintenance (as outlined in the applicable owner’s manual or operating
instructions) or that is being used for industrial, professional, commercial or rental purposes;
c) this warranty will not apply to normal wear and tear or to expendable parts or accessories that
may be supplied with the product and that are expected to become inoperative or unusable after
a reasonable period of use;
d) this warranty will not apply to routine maintenance and consumable items such as, but not limited
to, fuel, lubricants, vacuum bags, blades, belts, sandpaper, bits, fluids, tune-ups or adjustments;
e) this warranty will not apply where damage is caused by repairs made or attempted by others (i.e.,
persons not authorized by the manufacturer);
f) this warranty will not apply to any product that was sold to the original purchaser as a
reconditioned or refurbished product (unless otherwise specified in writing);
g) this warranty will not apply to any product or part thereof if any part from another manufacturer
is installed therein or any repairs or alterations have been made or attempted by unauthorized
persons;
h) this warranty will not apply to normal deterioration of the exterior finish, such as, but not limited
to, scratches, dents, paint chips, or to any corrosion or discolouring by heat, abrasive and
chemical cleaners; and
i) this warranty will not apply to component parts sold by and identified as the product of another
company, which shall be covered under the product manufacturer’s warranty, if any.
Additional Limitations
This warranty applies only to the original purchaser and may not be transferred. Neither the retailer nor
the manufacturer shall be liable for any other expense, loss or damage, including, without limitation,
any indirect, incidental, consequential or exemplary damages arising in connection with the sale, use or
inability to use this product.
Notice to Consumer
This warranty gives you specific legal rights, and you may have other rights, which may vary from
province to province. The provisions contained in this warranty are not intended to limit, modify, take
away from, disclaim or exclude any statutory warranties set forth in any applicable provincial or federal
legislation.
084-0207-Cantire-8ft Trampoline Combo-GB-02.indd 17 11-11-9 ��4:12