JVC GR-DVL505UM User manual

DIGITAL VIDEO CAMERA
GR-DVL505UM/805UM
No. 86585
August 2000
This service manual is printed on 100% recycled paper.
COPYRIGHT ©2000 VICTOR COMPANY OF JAPAN, LTD.
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
Printed in Japan
S40894
SPECIFICATIONS (The specifications shown pertain specifically to the model GR-DVL505U, 805U)
Regarding service information other than these sections, refer to the GR-DVL505U, 805U service manual (No. 86550).
Also, be sure to note important safety precautions provided in the service manual.
For Connectors
S:Y:1V ( p-p ) , 75 Ω, analog output
C : 0.29 V
( p-p ) , 75 Ω, analog output
AV
Video output :1V
( p-p ) , 75 Ω, analog
Audio output : 300 mV (rms), 1 kΩ, analog, stereo
DV
Input/output : 4-pin, IEEE 1394 compliant
PC (DIGITAL PHOTO)
Digital still output : ø2.5 mm, 3-pole
JLIP/EDIT : ø3.5 mm, 4-pole
AC Power Adapter/Charger AA-V40EN
Power requirement : AC 110 V to 240 V`, 50 Hz/60 Hz
Power consumption : 23 W
Output
Charge : DC 7.2 V , 1.2 A
VTR : DC 6.3 V , 1.8 A
Dimensions (W x H x D) : 68 mm x 38 mm x 110 mm (2-11/16" x 1-1/2" x 4-3/8")
Weight : Approx. 250 g (0.56 lbs)
Specifications shown are for SP mode unless otherwise indicated. E & O.E. Design and specifications
subject to change without notice.
Camcorder
For General
Power supply : DC 6.3 V (Using AC Power Adapter/Charger)
DC 7.2 V (Using battery pack)
Power consumption
LCD monitor off, viewfinder on : Approx. 4.3 W
LCD monitor on, viewfinder off : Approx. 5.3 W
Video light : Approx. 3.5 W
Dimensions (W x H x D) : 80 mm x 96 mm x 159 mm (3-3/16" x 3-13/16" x 6-5/16")
(with the LCD monitor closed and the viewfinder pushed down)
Weight : Approx. 580 g (1.3 lbs)
Operating temperature :0°C to 40°C (32°F to 104°F)
Operating humidity : 35% to 80%
Storage temperature :–20°C to 50°C (–4°F to 122°F)
Pickup : 1/4" CCD
Lens : F 1.8, f = 3.6 mm to 36 mm, 10:1 power zoom lens
Filter diameter :ø37 mm
LCD monitor
GR-DVL805 : 3.5" diagonally measured, LCD panel/TFT active matrix system
GR-DVL505 : 3.0" diagonally measured, LCD panel/TFT active matrix system
Viewfinder
GR-DVL805 : Electronic viewfinder with 0.44" color LCD
GR-DVL505 : Electronic viewfinder with 0.24" black/white LCD
Speaker : Monaural
For Digital Video Camera
Format : DV format (SD mode)
Signal format : NTSC standard
Recording/Playback format : Video: Digital component recording
: Audio: PCM digital recording, 32 kHz 4-channel (12-bit),
48 kHz 2-channel (16-bit)
Cassette : Mini DV cassette
Tape speed : SP: 18.8 mm/s
LP: 12.5 mm/s
Maximum recording time : SP: 80 min.
(using 80 min. cassette) LP: 120 min.
For Digital Still Camera
Storage media : Built-in flash memory, 2 Mbyte
Compression system : JPEG (compatible)
File size : VGA: 640 x 480 pixels
Picture quality : 2 modes (FINE/STANDARD)
Approximate number of storable images
FINE :30
STANDARD :60
(AUDINAC KIT)

1
TABLE OF CONTENTS
DIFFERENT TABLE ................................................................................................................................................................ 1 to 3
4. CHARTS AND DIAGRAMS
4.1 MAIN CIRCUIT BOARD.............................................................................................................................................4-1
4.2 JACK, REAR AND JUNCTION CIRCUIT BOARDS .................................................................................................. 4-7
5. PARTS LIST
5.1 PACKING AND ACCESSORY ASSEMBLY <M1> ..................................................................................................... 5-1
5.2 FINAL ASSEMBLY <M2> ...........................................................................................................................................5-3
5.3 ELECTRICAL PARTS LIST
MONITOR BOARD ASSEMBLY <02> .......................................................................................................................5-6
6. AC POWER ADAPTER CHARGER (AA-V40EN)
6.1 CABINET ASSEMBLY <MA> .....................................................................................................................................6-1
6.2 SCHEMATIC DIAGRAM ............................................................................................................................................6-2
6.3 CIRCUIT BOARD.......................................................................................................................................................6-4
6.4 ELECTRICAL PARTS LIST........................................................................................................................................6-5
The following table indicate main different points between models GR-DVL805U,DVL505U,DVL805UM and GR-DVL505UM.
Note: Mark
is same as left.
AC POWER ADAPTER CHARGER AA-V40U AA-V40EN
LCD MONITOR 3.5" 3" 3.5" 3"
S CABLE,S-VIDEO CABLE Optional Provided
VIEW FINDER Color Black/White Color Black/White
GR-DVL805U GR-DVL505U GR-DVL805UM GR-DVL505UM
MODEL
ITEM
1 PACKING CASE LY31631-008B LY31631-007B –
3 POLY BAG * LY30023-015A LY30023-008A
9 Q.CARD(JCA) YU10350 –
10 WARRANTY INF. BT-51005-4 –
11 REGIST.CARD BT-51020-2 –
! 29 AC POWER ADAPTER CHARGER LY20591-001B LY20591-011A
30 S CABLE,S-VIDEO CABLE – – QAM0004-003
31 CORE FILTER – – QQR0491-002
32 MINI DV TAPE Not used Used
The following table indicate different parts number between models GR-DVL805U,DVL505U,DVL805UM and GR-DVL505UM.
PACKING AND ACCESSORY ASSEMBLY <M1> Note: As for IB (INSTRUCTION), refer to sec. 5.
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL505U GR-DVL805UM/505UM
Note: Mark – is not used. Mark
is same as left. Mark * reference model was also changed.

2
FINAL ASSEMBLY <M2>
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
! 101 LOWER CASE ASSY * LY20560-001B LY20560-001D * LY20560-001B LY20560-001D
104 CASS.COVER ASSY * LY31609-001A LY31609-001C * LY31609-001A LY31609-001C
104C BKT(E.KNOB) * LY42173-001A LY42173-001B * LY42173-001A LY42173-001B
111 UPPER CASE(3)ASSY * LY20550-002A LY20550-002C * LY20550-002A LY20550-002C
111A SHEET(EARTH) * LY31599-001A –* LY31599-001A –
127 TOP COVER (3) LY20552-010A LY20552-006A
131 SPECIAL SCREW * LY30018-084A LY30018-079A * LY30018-084A LY30018-079A
139 SCREW * LY30018-096A QYSPSPT1725R * LY30018-096A QYSPSPT1725R
141 SCREW * LY30018-084A QYSPSGT1760R * LY30018-084A QYSPSGT1760R
143 SPECIAL SCREW * LY30018-059A LY30018-084A * LY30018-059A LY30018-084A
150 HOLDER(MECHA)ASSY * LY31618-001B LY31618-001C * LY31618-001B LY31618-001C
150B SPECIAL SCREW, X4 * LY30018-056A LY30018-0B4A * LY30018-056A LY30018-0B4A
214 SHEET * –LY42583-001A * –LY42583-001A
ELECTRONIC VIEWFINDER ASSEMBLY <M4>
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
300 COLOR VF UNIT * LY20596-001A LY20596-001C ––
350 E.VF ASSY ––LYH20136-001A
301/351 VF CASE(UPPER)ASSY * LY31600-001A LY31600-001C * LY31600-001A LY31600-001C
306/356 HINGE(VF)ASSY * LY31602-001A LY31602-001C * LY31602-001B LY31602-001C
362 HOLDER(B/W LCD) ––* LY20481-001A LY20481-002A
MONITOR ASSEMBLY <M5>
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
! 500 MONITOR ASSY LYH20135-006B LYH20135-005B
! 501 MONITOR COVER ASSY * LY20565-006A LY20565-006B * LY20565-005A LY20565-005B
502 MONITOR CASE ASSY LY20598-002A LY20598-001A
503 HOLDER(3LCD) ––* LY20566-001A LY20566-001B
504 HOLDER(3.5/3PWB) LY20568-001A LY20567-001A
509 BACK LIGHT QLL0081-001 QLL0080-001
510 LCD MODULE QLD0096-002 QLD0118-001
MAIN BOARD ASSEMBLY <01>
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW MAIN BOARD ASSY * YB10277F-02 YB10277F-04 * YB10277F-02 YB10277F-04
R4301 MG RESISTOR * –NRSA6AJ-560W * –NRSA6AJ-560W
WR3 THIN WIRE * –YU40017-060-1 * –YU40017-060-1
OT2 SPACER(A) * LY30029-055A LY30029-055B * LY30029-055A LY30029-055B
OT3 SPACER(A) * –LY30029-051A * –LY30029-051A
Note: Mark –is not used. Mark
is same as left. Mark * reference model was also changed.

3
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW1 MONITOR BOARD ASSY YB10280G1-01 * YB10280F1-01 YB10280F1-02
Note: Mark –is not used. Mark
is same as left. Mark * reference model was also changed.
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW2 LCD BL BOARD ASSY YB10280B2-01 YB10280A2-01
C7501 CAPACITOR NCZ1016-180X NCZ1016-150X
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW2 JUNCTION BOARD ASSY * YB10278A2-01 YB10278A2-02 * YB10278A2-01 YB10278A2-02
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW1 JACK BOARD ASSY * YB10278A1-01 YB10278A1-02 * YB10278A1-01 YB10278A1-02
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW3 REAR BOARD ASSY * YB10278A3-01 YB10278C3-02 * YB10278A3-01 YB10278C3-02
MODEL
ITEM
REF. NO. GR-DVL805U GR-DVL805UM GR-DVL505U GR-DVL505UM
PW3 B/W VF BOARD ASSY ––YB10280A3-01
MONITOR BOARD ASSEMBLY <02>
LCD BL BOARD ASSEMBLY <03>
JUNCTION BOARD ASSEMBLY <05>
JACK BOARD ASSEMBLY <06>
REAR BOARD ASSEMBLY <07>
B/W VF BOARD ASSEMBLY <08>

6-1
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
1
6
2
RATING LABEL
MAIN &
TERMINALASSY <91>
4
4
3
5
5
SECTION 6
AC POWER ADAPTER CHARGER (AA-V40EN)
SAFETY PRECAUTION
Parts identified by the !symbol are critical for safety. Replace only with specified part numbers.
6.1 CABINET ASSEMBLY <MA>
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
CABINET ASSEMBLY <MA>
!1 PTY20591-013 UPPER CASE ASSY
!2 PTY20483-023 LOWER CASE
!3 PTY20483-035 POWER CORD
4 YQ10531-011 SCREW,x2
5 PTY20545-055 SCREW,x3
6 PTY20591-053 SWITCH COVER

6.2 SCHEMATIC DIAGRAM
NOTE: When ordering parts, be sure to order according to
the Part Number indicated in the Parts List.
6-2
5
4
1
2
3
ABCD
PC123YS
CN1 1221304
MIAN & TERMINAL
AC110
2200P
2200P
PC123YS

Safety precautions
The components identified by the symbol !are
critical for safety. For continued safety, replace safety
critical components only with manufacturer’s recom-
mended parts.
6-3
EFG
H
SV
SG
CN2
SW1
TERMINAL
C35
0.22
TP15
TP16
0.22
Q27
UN2211
R60
10K
SV
SG

6.3 CIRCUIT BOARD
6-4

6-5
6.4 ELECTRICAL PARTS LIST
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
MAIN & TERMINAL BOARD ASSY <91>
!PW1 PTY20591-503 MAIN & TERMINAL BOARD ASSY
!HS1 PTY20483-071 HEAT SINK A
!HS2 PTY20591-072 HEAT SINK B
OT1 PTY10067-551 SCREW
IC21 M61030AFP CHARGE COTROL IC 24pin SOP
Q1 FS2KM18A MOS FET
Q2 2SD2227 TRANSISTER
Q3 2SD2227 TRANSISTER
Q21 UN2211TX DIG.TRANSISTER
Q22 2SA1037AK/QR/-X CHIP TRANSISTER
Q23 2SB1592 TRANSISTER
Q24 2SA1037AK/QR/-X TRANSISTER
Q25 2SA1037AK/QR/-X TRANSISTER
Q26 2SA1037AK/QR/-X TRANSISTER
Q27 UN2211TX DIG TRANSISTOR
D1 S1WBA60 B.DIODE 600V 1A
D5 1SS244T77 DIODE 200V 6A
D6 1SS244T77 DIODE 200V 6A
D21 MA7D56 DIODE 60V 10A
ZD1 MTZJ12C-T2 ZENER DIODE 12V
ZD2 MTZJ6.2B-T2 ZENER DIODE 6.2V 500mW
ZD21 MTZJ12C-T2 ZENER DIODE 12V
ZD22 MTZJ12C-T2 ZENER DIODE 12V
ZD23 MTZJ12C-T2 ZENER DIODE 12V
ZD24 MTZJ12C-T2 ZENER DIODE 12V
ZD25 MA4047NM ZENER DIODE 4.7V 500mW
LED1 YQ10531-540 LED RED POWER
LED2 YQ10531-542 LED GREEN CHARGE
R1 QRN141J-105 RESISTOR 1MΩ1/4W
R3 PTY10067-601 MF RESISTOR 0.62Ω1W
R4 QRE141J-334Y RESISTOR 330kΩ1/4W
R5 QRE141J-334Y RESISTOR 330kΩ1/4W
R7 QRE141J-751Y RESISTOR 750Ω1/4W
R8 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R9 NRSA02J-272X MG RESISTOR 2.7kΩ1/10W
R10 NRSA02J-104X MG RESISTOR 100kΩ1/10W
R11 NRSA02J-682X MG RESISTOR 6.8kΩ1/10W
R12 QRE141J-181Y RESISTOR 180Ω1/4W
R13 QRE141J-334Y RESISTOR 330kΩ1/4W
R14 QRE141J-334Y RESISTOR 330kΩ1/4W
R15 NRSA02J-182X MG RESISTOR 1.8kΩ1/10W
R16 NRSA02J-753X MG RESISTOR 75kΩ1/10W
R22 NRSA02J-621X MG RESISTOR 620Ω1/10W
R23 PTY20539-605 MF RESISTOR 0.20Ω2W
R24 NRSA02J-102X MG RESISTOR 1kΩ1/10W
R25 NRSA02J-101X MG RESISTOR 100Ω1/10W
R26 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R27 NRSA02J-102X MG RESISTOR 1kΩ1/10W
R28 NRSA02J-151X MG RESISTOR 150Ω1/10W
R29 PTY20539-601 MG RESISTOR 47.0kΩ1/10W
R30 PTY20539-601 MG RESISTOR 47.0kΩ1/10W
R31 NRSA02F-103X MG RESISTOR 10.0kΩ1/10W
R32 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R33 NRSA02J-333X MG RESISTOR 33kΩ1/10W
R34 PTY20539-601 MG RESISTOR 47.0kΩ1/10W
R35 PTY20539-602 MG RESISTOR 11.0kΩ1/10W
R36 NRSA02F-6192X MG RESISTOR 61.9kΩ1/10W
R37 PTY20539-603 MG RESISTOR 1.0kΩ1/10W
R38 PTY20539-601 MG RESISTOR 47.0kΩ1/10W
R39 PTY20539-604 MG RESISTOR 1.3kΩ1/10W
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
R40 PTY20450-200 MG RESISTOR 20.0kΩ1/4W
R41 NRSA02F-1152X MG RESISTOR 11.5kΩ1/10W
R42 NRSA02F-1152X MG RESISTOR 11.5kΩ1/10W
R43 QRE141J-103Y MF RESISTOR 10kΩ1/4W
R45 NRSA02J-222X MG RESISTOR 2.2kΩ1/10W
R46 NRSA02J-472X MG RESISTOR 4.7kΩ1/10W
R47 NRSA02J-221X MG RESISTOR 220Ω1/10W
R48 NRSA02J-102X MG RESISTOR 1kΩ1/10W
R49 NRSA02J-473X MG RESISTOR 47kΩ1/10W
R50 NRSA02F-5622X MG RESISTOR 56.2kΩ1/10W
R51 NRSA02F-5112X MG RESISTOR 51.1kΩ1/10W
R52 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R53 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R54 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R55 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R56 NRSA02J-103X MG RESISTOR 10kΩ1/10W
R60 NRSA02J-103X MG RESISTOR 10kΩ1/10W
!C1 PTY20292-303 CAPACITOR 0.068µF 275V
C2 YQ10626-402 E CAPACITOR 47µF 400V
C3 PTY10067-651 CAPACITOR 1500pF 250V
C4 NCB21CK-224X CAPACITOR 0.22µF 16V
C5 PTY10067-653 CAPACITOR 0.01µF 50V
C6 NCB21HK-391X CAPACITOR 390pF 50V
!C7 PTY20538-611 CAPACITOR 2200pF 250V
!C8 PTY20538-611 CAPACITOR 2200pF 250V
C9 NDC21HJ-680X CAPACITOR 68pF 50V
C10 NDC21HJ-151X CAPACITOR 150pF 50V
C11 NDC21HJ-151X CAPACITOR 150pF 50V
C21 PTY10067-657 CAPACITOR 0.01µF 250V
C22 PTY20292-321 E CAPACITOR 680µF 16V
C23 QETL1CM-227 E CAPACITOR 220µF 16V
C24 NCB21CK-224X CAPACITOR 0.22µF 16V
C25 NCF21EZ-104X CAPACITOR 0.1µF 25V
C26 NCB21CK-224X CAPACITOR 0.22µF 16V
C27 NCB21EK-473X CAPACITOR 0.047µF 25V
C28 NCB21HK-473X CAPACITOR 0.047µF 50V
C29 NCB21EK-104X CAPACITOR 0.1µF 25V
C30 NCF21EZ-104X CAPACITOR 0.1µF 25V
C31 NCB21HK-222X CAPACITOR 0.0022µF 50V
C32 QEHA1HM-475 E CAPACITOR 4.7µF 50V
C33 NCF21EZ-104X CAPACITOR 0.1µF 25V
C34 NCF21EZ-104X CAPACITOR 0.1µF 25V
C35 QFLA1HJ-224 F CAPACITOR 0.22µF 50V
!T1 PTY20538-801 SW TRANS
VR1 PTY20483-101 VOLUME 2kΩ
!F1 PTY20450-041 FUSE 1A 250V
JK1 YQ21032-301 DC JACK
!L1 PTY20450-401 LINE FILTER
L12 PTY10067-702 BEAD INDUCTOR
L21 PTY10067-703 COIL
!PHC1 PC123YS PHOTO COUPLER
SW1 PTY20545-662 SWITCH
WR1 PTY20591-052 FLAT CABLE (5P)
TB1 PTY20545-051 TERMINAL,x5
CN1 PTY20483-001 CONNECTOR
Ozaki-M14D23/D2L