Kenwood TK-3302 Operating manual

SERVICE MANUAL
This product uses Lead Free solder.
This product complies with the RoHS directive for the European market.
© 2008-12 PRINTED IN JAPAN
B51-8852-00 (N)358
SUPPLEMENT
TK-3302
UHF FM TRANSCEIVER
CONTENTS
GENERAL.....................................................2
SYSTEM SET-UP.........................................3
REALIGNMENT ...........................................3
DISASSEMBLY FOR REPAIR ......................6
CIRCUIT DESCRIPTION ..............................6
PARTS LIST .................................................7
EXPLODED VIEW ......................................15
PACKING....................................................16
ADJUSTMENT ..........................................18
PC BOARD
TX-RX UNIT (X57-7580-XX)..................24
SCHEMATIC DIAGRAM ............................28
BLOCK DIAGRAM .....................................32
LEVEL DIAGRAM ......................................34
SPECIFICATIONS ......................................35
Whip antenna
(T90-1040-25)
(T90-1041-25)
Button knob (PTT)
(K29-9425-03)
Button knob
(Side1/Side2)
(K29-9426-03)
Knob (Selector)
(K29-9427-03)
Knob (Volume)
(K29-9309-13)
Plastic cabinet assy
(A02-4040-03)
K2,K3,M2 Versions This TK-3302 (K2,K3,M2) service manual contains a number of
sections which differ from the service manual (B51-8840-00) for
the TK-3302/3302(U)/3306 (K,P,M,M3).
For item other than those in this TK-3302 (K2,K3,M2) service
manual, please refer to the service manual (B51-8840-00) for the
TK-3302/3302(U)/3306 (K,P,M,M3).

TK-3302
2
Document Copyrights
Copyright 2008 by Kenwood Corporation. All rights re-
served.
No part of this manual may be reproduced, translated,
distributed, or transmitted in any form or by any means,
electronic, mechanical, photocopying, recording, or other-
wise, for any purpose without the prior written permission
of Kenwood.
Disclaimer
While every precaution has been taken in the preparation
of this manual, Kenwood assumes no responsibility for er-
rors or omissions. Neither is any liability assumed for dam-
ages resulting from the use of the information contained
herein. Kenwood reserves the right to make changes to any
products herein at any time for improvement purposes.
GENERAL
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techni-
cians familiar with similar types of commercial grade com-
munications equipment. It contains all required service
information for the equipment and is current as of the pub-
lication date. Changes which may occur after publication
are covered by either Service Bulletins or Manual Revisions.
These are issued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment informa-
tion, the full part identification number should be included.
This applies to all parts : components, kits, or chassis. If the
part number is not known, include the chassis or kit number
of which it is a part, and a sufficient description of the re-
quired component for proper identification.
PERSONAL SAFETY
The following precautions are recommended for personal
safety:
• DO NOT transmit until all RF connectors are verified se-
cure and any open connectors are properly terminated.
• SHUT OFF and DO NOT operate this equipment near
electrical blasting caps or in an explosive atmosphere.
• This equipment should be serviced by a qualified techni-
cian only.
SERVICE
This transceiver is designed for easy servicing. Refer to
the schematic diagrams, printed circuit board views, and
alignment procedures contained within.
Model Type TX-RX unit Frequency range Remarks
TK-3302 K2,M2 X57-7580-22 470~512MHz IF1:
38.85MHz
LOC:
38.4MHz
TK-3302 K3 X57-7580-23 400~430MHz
Service Manual List
Title Parts number Remarks Market code
TK-3302/3302(U)/3306 B51-8840-00 K,P,M,M3
TK-3302 B51-8852-00
This service manual SUPPLEMENT K2,K3,M2

TK-3302
3
REALIGNMENT
1. Modes
User mode
Data programming mode
PC test mode PC tuning mode
PC mode
Wireless clone mode
Mode Function
User mode For normal use.
PC mode Used for communication between the trans-
ceiver and PC.
Data programming
mode
Used to read and write frequency data and
other features to and from the transceiver.
PC test mode Used to check the transceiver using the PC.
This feature is included in the FPU.
Wireless clone
mode
Used to transfer programming data from
one transceiver to another.
SYSTEM SET-UP
2. How to Enter Each Mode
Mode Operation
User mode Power ON
PC mode Received commands from PC
Wireless clone mode [PTT]+[Side2]+Power ON (Two seconds)
3. PC Mode
3-1. Preface
The transceiver is programmed by using a personal com-
puter, a programming interface (KPG-22/22A, USB adapter
(KCT-53U)) and FPU (programming software).
The programming software can be used with a PC or
compatible. Figure 1 shows the setup of a PC for program-
ming.
3-2. Connection Procedure
1. Connect the transceiver to the personal computer with
the interface cable and USB adapter (when the interface
cable is KPG-22A, the KCT-53U can be used).
Merchandise received
Choose the type of transceiver
Transceiver programming
Delivery
Are you using the speaker microphone?
A personal computer, programming interface (KPG-22/22A),
and FPU (programming software) are required for programming.
(The frequency, TX power HI/LOW, and signalling data are
programmed for the transceiver.)
YES
NO
KMC-17, KMC-21 or KMC-45
Speaker microphone
(Option)
Are you using the optional antenna? YES
NO
KRA-23 or KRA-27
Optional antenna
TX/RX 470~512
TX/RX 400~430
4.0W
4.0W
Frequency range (MHz) RF power Type
TK-3302: K2,M2
TK-3302: K3

TK-3302
4
Notes:
• You must install the KCT-53U driver in the computer to
use the USB adapter (KCT-53U).
• When using the USB adapter (KCT-53U) for the first time,
plug the KCT-53U into a USB port on the computer with
the computer power ON.
2. When the POWER is switched on, user mode can be en-
tered immediately. When the PC sends a command, the
transceiver enters PC mode.
When data is read from the transceiver, the red LED
lights.
When data is written to by the transceiver, the green LED
lights.
Notes :
• The data stored in the personal computer must match
Model Name and Model Type when it is written into EE-
PROM.
• Do not press the [PTT] key during data transmission or
reception.
3-3. KPG-22/KPG-22A Description
(PC programming interface cable : Option)
The KPG-22/22A is required to interface the transceiver
with the computer. It has a circuit in its D-sub connector
(KPG-22: 25-pin, KPG-22A: 9-pin) case that converts the RS-
232C logic level to the TTL level.
The KPG-22/22A connects the SP/MIC connector of the
transceiver to the RS-232C serial port of the computer.
3-4. KCT-53U Description (USB adapter : Option)
The KCT-53U is a cable which connects the KPG-22A to a
USB port on a computer.
When using the KCT-53U, install the supplied CD-ROM
(with driver software) in the computer. The KCT-53U driver
runs under Windows 2000 or XP.
3-5. FPU (Programming Software) Description
The FPU is the programming software for the transceiver
supplied on a CD-ROM. The software on this disk allows a
user to program the transceiver transceivers via Program-
ming interface cable (KPG-22/22A).
3-6. Programming with PC
If data is transferred to the transceiver from a PC with the
FPU, the data for each set can be modified.
Data can be programmed into the EEPROM in RS-232C
format via the SP/MIC jack.
In this mode the PTT line operate as TXD and RXD data
lines respectively.
List of FPU for transceiver
Model Type FPU
TK-3302 K2,K3,M2 KPG-118D(K)
REALIGNMENT
PC
KPG-22 or KPG-22A or
KPG-22A+KCT-53U
Illustration is KPG-22
FPU
Tuning cable
(E30-3216-05)
D-SUB
(25-pin)
Transceiver Transceiver Transceiver
KPG-22
PC
Gray
Gray/Black
1.5D-XV Lead wire
1.5D-XV Shield wire
+
–
+
–
SP
MIC
D-SUB
(9-pin)
KPG-22A
PC
USB
KPG-22A
KCT-53U
PC
Fig. 1
4. Wireless Clone Mode
4-1. Outline
“Wireless Clone Mode” copies the transceiver data to
another transceiver.
The dealer can copy the transceiver data to another trans-
ceiver even without the use of a personal computer.
4-2. Example
The transceiver can copy the programming data to one or
more transceivers via RF communication.
The clone source and clone target/s must be in wireless
clone mode.

TK-3302
5
REALIGNMENT
4-3. Operation
1. To switch the clone target/s to wireless clone mode,
press and hold the [PTT] and [side2] keys while turning
the transceiver power ON.
2. Wait for 2 seconds. The LED will light orange and the
transceiver will announce “Clone”.
3. Select a channel table number using Side1 (increment
channel table) and Side2 (decrement channnel table)
keys.
4. To switch the clone source to wireless clone mode, press
and hold the [PTT] and [side2] keys while turning the
transceiver power ON.
5. Wait for 2 seconds. The LED will light orange and the
transceiver will announce “Clone”.
6. Select the same channel table number as the clone
target/s.
7. Press [PTT] on the clone source to begin data transmis-
sion.
When the clone target starts to receive data, the LED will
light green.
When the clone source finishes sending data, a “confir-
mation” tone will sound.
If data transmission fails while cloning, an “error” tone
will sound from the target unit.
8. If the cloning fails, no data will be available in the target
unit when it is returned to User mode.
9. When the cloning is successful, the target unit’s “Scan”
and “Key lock” functions will return to their default values
(Scan = OFF, Key lock = OFF).
Notes:
• The dealer can clone data to two or more transceivers by
repeating the above procedures.
• If the transceivers wireless clone mode is configured as
“Disabled”, the transceiver cannot enter wireless clone
mode.
• The table shown below will cover the frequency tables
used for wireless cloning.
• Wireless clone mode cannot be entered in battery low
state.
• A unit cannot be a “Source Unit” if it is unprogrammed. If
[PTT] is pressed, an “error” tone will sound.
• The language used in cloning depends on the “Model
type” setting, not the FPU setting.
• Once a unit is set to be the source, it cannot be a target
after the data has been transmitted. This protects the
data in the source unit.
• Electronic interface may cause a failure in data transfer
during wireless clone, such as when waveforms or elec-
tromagnetics are being performed at the workbench.
• Wireless clone mode can be used ONLY by the autho-
rized service personnel.
• The wireless clone mode setting must be configured
as “Disable” before being delivered to the end-user.
• To clone, replace the antenna from both the source
transceiver and the target transceiver with a dummy
load.
• The transmit output power is automatically set to
Low in wireless clone mode.
• Clone frequency table
No.
Operating frequency (MHz)
TK-3302 K2,M2 TK-3302 K3
470~512 400~430
1 472.000 400.000
2 474.000 401.000
3 476.000 402.000
4 478.000 403.000
5 480.000 404.000
6 482.000 405.000
7 484.000 406.000
8 486.000 407.000
9 488.000 408.000
10 490.000 409.000
11 492.000 410.000
12 494.000 411.000
13 496.000 412.000
14 498.000 413.000
15 500.000 414.000
16 502.000 415.000
17 504.000 416.000
18 506.000 417.000
19 508.000 418.000
20 510.000 419.000

TK-3302
6
1. Frequency Configuration
The receiver utilizes double conversion. The first IF is
38.85MHz and the second IF is 450kHz. The first local oscil-
lator signal is supplied from the PLL circuit.
The PLL circuit in the transmitter generates the neces-
sary frequencies. Fig. 1 shows the frequencies.
ANT
TX/RX : :
ANT
SW
RF
AMP
TX
AMP
RF
AMP
1st MIX MCF
38.85MHz
CF
450kHz
IF
SYSTEM
AF
AMP
SP
RX: .
PLL
VCO
MIC
AMP
MIC
TX: @
38.4MHz
X3
multiply TCXO 12.8MHz
Model Type qw e
TK-3302 K2,M2 470~512MHz 470~512MHz 431.15~473.15MHz
TK-3302 K3 400~430MHz 400~430MHz 361.15~391.15MHz
Fig. 1 Frequency configuration
CIRCUIT DESCRIPTION
DISASSEMBLY FOR REPAIR
Screw sequence for mounting the TX-RX
unit to the chassis
Attach the TX-RX unit to the chassis using the screws in
the order shown in the drawing below.
TX-RX UNIT
Component side view
@;
=
B
>2
:

8
.

TK-3302
7
PARTS LIST
Chip capacitor
Code L W T
Empty 5.6±0.5 5.0±0.5 Less than 2.0
A 4.5±0.5 3.2±0.4 Less than 2.0
B 4.5±0.5 2.0±0.3 Less than 2.0
C 4.5±0.5 1.25±0.2 Less than 1.25
D 3.2±0.4 2.5±0.3 Less than 1.5
E 3.2±0.2 1.6±0.2 Less than 1.25
F 2.0±0.3 1.25±0.2 Less than 1.25
G 1.6±0.2 0.8±0.2 Less than 1.0
H 1.0±0.05 0.5±0.05 0.5±0.05
Chip resistor
Code L W T
E 3.2±0.2 1.6±0.2 1.0
F 2.0±0.3 1.25±0.2 1.0
G 1.6±0.2 0.8±0.2 0.5±0.1
H 1.0±0.05 0.5±0.05 0.35±0.05
• Rating wattage
Code Wattage Code Wattage Code Wattage
1J 1/16W 2C 1/6W 3A 1W
2A 1/10W 2E 1/4W 3D 2W
2B 1/8W 2H 1/2W
(Less than 10pF)
Code B C D F G
(pF) ±0.1 ±0.25 ±0.5 ±1 ±2
CAPACITORS
C C 4 5 T H 1 H 2 2 0 J
1 2 3 4 5 6
1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating
2 = Shape ... round, square, etc. 5 = Value
3 = Temp. coefficient 6 = Tolerance
• Temperature coefficient
1st Word C L P R S T U
Color* Black Red Orange Yellow Green Blue Violet
ppm/°C 0 –80 –150 –220 –330 –470 –750
• Tolerance (More than 10pF)
Code C D G J K M X Z P No code
(%) ±0.25 ±0.5 ±2 ±5 ±10 ±20 +40 +80 +100 More than 10μF : –10~+50
–20 –20 –0 Less than 4.7μF : –10~+75
• Voltage rating
2nd word A B C D E F G H J K V
1st word
0 1.0 1.25 1.6 2.0 2.5 3.15 4.0 5.0 6.3 8.0 –
1 10 12.5 16 20 25 31.5 40 50 63 80 35
2 100 125 160 200 250 315 400 500 630 800 –
3 1000 1250 1600 2000 2500 2150 4000 5000 6300 8000 –
• Chip capacitors
(EX) C C 7 3 F S L 1 H 0 0 0 J Refer to the table above.
1 2 3 4 5 6 7 1 = Type
(Chip) (CH, RH, UJ, SL) 2 = Shape
3 = Dimension
(EX) C K 7 3 F F 1 H 0 0 0 Z 4 = Temp. coefficient
1 2 3 4 5 6 7 5 = Voltage rating
(Chip) (B, F) 6 = Value
7 = Tolerance
RESISTORS
• Chip resistor (Carbon)
(EX) R D 7 3 E B 2 B 0 0 0 J
1 2 3 4 5 6 7
(Chip) (B, F)
• Carbon resistor (Normal type)
(EX) R D 1 4 B B 2 C 0 0 0 J
1 2 3 4 5 6 7
1 = Type 5 = Rating wattage
2 = Shape 6 = Value
3 = Dimension 7 = Tolerance
4 = Temp. coefficient
CC45 Color*
2nd Word G H J K L
ppm/°C ±30 ±60 ±120 ±250 ±500
Example : CC45TH = –470±60ppm/°C
• Capacitor value
010 = 1pF 2 2 0 = 22pF
100 = 10pF
101 = 100pF Multiplier
102 = 1000pF = 0.001μF 2nd number
103 = 0.01μF 1st number
L
W
T
• Dimension

TK-3302
8
✽New Parts. indicates safety critical components.
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
L: Scandinavia K: USA P: Canada
Y: PX (Far East, Hawaii) T: England E: Europe
Y: AAFES (Europe) X: Australia M: Other Areas
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
PARTS LIST
1 1A A02-4040-03 PLASTIC CABINET ASSY
2 3A A10-4124-01 CHASSIS
4 2C,2E B09-0725-03 CAP ACCESSORY
7 1C B62-2109-00 INSTRUCTION MANUAL K,M,K2
7 1C B62-2109-00 INSTRUCTION MANUAL K3,M2
8 1E B62-2139-00 INSTRUCTION MANUAL P
9 1A D10-0649-03 LEVER
10 1A D21-0863-04 SHAFT
11 1A D32-0441-13 STOPPER
13 3B E04-0477-05 RF COAXIAL RECEPTACLE (SMA)
14 3A E23-1253-04 TERMINAL (BATT-)
15 2A E23-1254-04 TERMINAL (BATT+)
16 2B E37-1175-15 SP WIRE LEAD (BROWN)
17 2B E37-1176-15 SP WIRE LEAD (GREEN)
19 3A F20-3353-14 INSULATING SHEET (CHASSIS-BATT+)
21 1A G01-4542-04 COIL SPRING (LEVER)
22 1A G01-4543-14 COIL SPRING (STOPPER)
23 2A G10-1330-04 FIBROUS SHEET (AUDIO IC)
24 2A G11-4465-04 RUBBER SHEET (FINAL FET)
25 3B G13-2009-04 CUSHION (CHASSIS)
26 3A G13-2033-04 CUSHION (BATT-)
27 3A G13-2034-14 CUSHION (CHASSIS-)
28 3A G13-2038-24 CUSHION (CHASSIS-CERAMIC FILTER)
29 2A G13-2039-14 CUSHION (PCB-CERAMIC FILTER)
30 3A G53-1604-03 PACKING (CHASSIS)
31 2A G53-1605-03 PACKING (BATT+)
32 2A G53-1609-14 PACKING (ECM)
33 2B G53-1799-03 PACKING (VOLUME/SELECTOR)
34 1B G53-1800-03 PACKING (SP/MIC)
35 1B G53-1801-03 PACKING (SPEAKER)
36 2B G53-1802-04 PACKING (SMA)
38 2E
✽H12-4250-05 PACKING FIXTURE P
39 2D H12-4251-05 PACKING FIXTURE K,M,K2
39 2D H12-4251-05 PACKING FIXTURE K3,M2
40 1F H13-2109-03 CARTON BOARD P
42 3D H52-2300-13 ITEM CARTON CASE K,M,K2
42 3D H52-2300-13 ITEM CARTON CASE K3,M2
43 3F H52-2301-13 ITEM CARTON CASE P
46 2A J19-5463-03 HOLDER (BATT+)
47 2A J19-5473-03 HOLDER ASSY (BATT+)
48 2C,2E J19-5521-03 HOLDER (SP/MIC) ACCSSORY
49 2B J19-5522-03 SPEAKER CLASP
50 2C,1E J29-0734-05 BELT HOOK ACCESSORY
51 2A J82-0121-05 FPC
52 1A J99-0737-04 ADHESIVE SHEET (PTT)
54 1B K29-9309-13 KNOB (VOLUME)
55 1A K29-9425-03 BUTTON KNOB (PTT)
56 1A K29-9426-03 BUTTON KNOB (MON/PF)
57 1B K29-9427-03 KNOB (SELECTOR)
A 3B N14-0848-05 CIRCULAR NUT (SELECTOR)
B 3B N14-0849-05 CIRCULAR NUT (VOLUME)
C 2B N30-2604-48 PAN HEAD MACHINE SCREW
D 3A N30-2606-48 PAN HEAD MACHINE SCREW
E
2A,3A,2B N83-2005-48 PAN HEAD TAPTITE SCREW
61 2C,2E N99-2046-05 SCREW SET ACCESSORY
63 2A
✽R31-0670-15 VARIABLE RESISTOR
65 2A S60-0440-05 ROTARY SWITCH
67 1B T07-0369-15 SPEAKER
68 2D,2E T90-1039-25 WHIP ANTENNA K,P,M
68 2D T90-1040-25 WHIP ANTENNA K2,M2
68 2D T90-1041-25 WHIP ANTENNA K3
70 1F W08-0970-35 AC ADAPTER (TRANSFORMER) P
71 1C W08-0988-05 CHARGER (KSC-35) K,M,K2
71 1C W08-0988-05 CHARGER (KSC-35) K3,M2
72 1D W08-0989-15 AC ADAPTER (SWITCHING) K,K2,K3
73 1D W08-0992-05 AC ADAPTER (SWITCHING) M,M2
74 2F W08-1067-05 CHARGER (KSC-31) P
D303 B30-2315-05 LED (RED)
D304 B30-2314-05 LED (GREEN)
C1 CK73HB1H332K CHIP C 3300PF K
C2 CK73HB1C682K CHIP C 6800PF K
C3 CK73GB1A105K CHIP C 1.0UF K
C4 CK73HB1A104K CHIP C 0.10UF K
C5 CK73HB1H471K CHIP C 470PF K K,P,M
C5 CK73HB1H471K CHIP C 470PF K K2,M2
C5,6 CK73HB1H471K CHIP C 470PF K K3
C6 CK73HB1E103K CHIP C 0.010UF K K,P,M
C6 CK73HB1E103K CHIP C 0.010UF K K2,M2
C7 CC73HCH1H100D CHIP C 10PF D
C8-10 CC73HCH1H101J CHIP C 100PF J
C11 CK73FB0J106K CHIP C 10UF K K,P,M
C11 CK73FB0J106K CHIP C 10UF K K2,M2
C11 CK73FB1H471K CHIP C 470PF K K3
C12 CK73HB1H471K CHIP C 470PF K
C13 CC73HCH1H100D CHIP C 10PF D
C14 CK73HB1E103K CHIP C 0.010UF K K3
C14,15 CK73HB1E103K CHIP C 0.010UF K K,P,M
C14,15 CK73HB1E103K CHIP C 0.010UF K K2,M2
C15 CK73HB1H471K CHIP C 470PF K K3
C16 CC73HCH1H470J CHIP C 47PF J
C17 CK73HB1E103K CHIP C 0.010UF K
C18 CC73HCH1H180J CHIP C 18PF J
C21 CK73HB1E103K CHIP C 0.010UF K
C22 CK73FB0J106K CHIP C 10UF K
C23 CK73HB1E103K CHIP C 0.010UF K
C25 CC73HCH1H300J CHIP C 30PF J
C26 CC73HCH1H020B CHIP C 2.0PF B
C27 CS77AA1VR33M CHIP TNTL 0.33UF 35WV
C29 CC73HCH1H270J CHIP C 27PF J
TK-3302 (Y50-6350-XX)
TX-RX UNIT (X57-7580-XX)
TK-3302
TX-RX UNIT (X57-7580-XX) -20: K,P,M -22: K2,M2 -23: K3

TK-3302
9
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
C30 CC73HCH1H101J CHIP C 100PF J K2,M2
C30 CK73HB1H471K CHIP C 470PF K K,P,M
C30 CK73HB1H471K CHIP C 470PF K K3
C31 CK73HB1E103K CHIP C 0.010UF K
C32 CS77CA1C3R3M CHIP TNTL 3.3UF 16WV
C33 CK73HB1H471K CHIP C 470PF K
C35 CS77CA1V0R1M CHIP TNTL 0.1UF 35WV K,P,M
C35 C92-0863-05 CHIP TNTL 0.047UF 35WV K2,K3,M2
C36 CK73HB1H332K CHIP C 3300PF K
C38 CK73HB1H471K CHIP C 470PF K K3
C39 CK73HB1C682K CHIP C 6800PF K
C40 CC73HCH1H050B CHIP C 5.0PF B
C41 CC73HCH1H030B CHIP C 3.0PF B
C42 CC73HCH1H050B CHIP C 5.0PF B
C43 CC73HCH1H101J CHIP C 100PF J K3
C44,45 CK73GB1A105K CHIP C 1.0UF K
C47 CC73HCH1H100C CHIP C 10PF C
C50 CK73HB1H471K CHIP C 470PF K
C51 CC73HCH1H030B CHIP C 3.0PF B K3
C51 CC73HCH1H100D CHIP C 10PF D K,P,M
C51 CC73HCH1H100D CHIP C 10PF D K2,M2
C52 CC73HCH1H090B CHIP C 9.0PF B K,P,M
C52 CC73HCH1H110J CHIP C 11PF J K2,M2
C52 CC73HCH1H150J CHIP C 15PF J K3
C53 CC73HCH1H080B CHIP C 8.0PF B K2,M2
C53 CC73HCH1H090B CHIP C 9.0PF B K3
C53 CC73HCH1H110J CHIP C 11PF J K,P,M
C55 CC73HCH1H0R5B CHIP C 0.5PF B K,P,M
C55 CC73HCH1H020B CHIP C 2.0PF B K3
C56 CC73HCH1H060B CHIP C 6.0PF B K2,M2
C56 CC73HCH1H080B CHIP C 8.0PF B K3
C56 CC73HCH1H120J CHIP C 12PF J K,P,M
C57 CC73HCH1H040B CHIP C 4.0PF B K,P,M
C57 CC73HCH1H090B CHIP C 9.0PF B K2,M2
C57 CC73HCH1H100B CHIP C 10PF B K3
C58,59 CC73HCH1H010B CHIP C 1.0PF B K,P,M
C58,59 CC73HCH1H010B CHIP C 1.0PF B K2,M2
C58,59 CC73HCH1H1R5B CHIP C 1.5PF B K3
C60 CC73HCH1H020B CHIP C 2.0PF B K,P,M
C60 CC73HCH1H040B CHIP C 4.0PF B K3
C60,61 CC73HCH1H030B CHIP C 3.0PF B K2,M2
C61 CC73HCH1H030B CHIP C 3.0PF B K,P,M
C61 CC73HCH1H070B CHIP C 7.0PF B K3
C62 CK73HB1H471K CHIP C 470PF K
C63 CC73HCH1H050B CHIP C 5.0PF B K2,M2
C63 CC73HCH1H060B CHIP C 6.0PF B K,P,M
C63 CC73HCH1H060B CHIP C 6.0PF B K3
C64 CC73HCH1H040B CHIP C 4.0PF B K2,M2
C64 CC73HCH1H050B CHIP C 5.0PF B K,P,M
C64 CC73HCH1H3R5B CHIP C 3.5PF B K3
C65 CC73HCH1H040B CHIP C 4.0PF B K3
C65 CC73HCH1H060B CHIP C 6.0PF B K,P,M
C65 CC73HCH1H060B CHIP C 6.0PF B K2,M2
C66 CK73HB1H471K CHIP C 470PF K
C67 CC73HCH1H040B CHIP C 4.0PF B K2,K3,M2
C67 CC73HCH1H050B CHIP C 5.0PF B K,P,M
C68 CK73HB1H471K CHIP C 470PF K K2,K3,M2
C68,69 CK73HB1H471K CHIP C 470PF K K,P,M
C70 CC73HCH1H0R5B CHIP C 0.5PF B K2,K3,M2
C70,71 CC73HCH1H0R5B CHIP C 0.5PF B K,P,M
C71 CC73HCH1H0R3B CHIP C 0.3PF B K2,K3,M2
C72,73 CK73HB1A104K CHIP C 0.10UF K
C74,75 CK73HB1H471K CHIP C 470PF K
C76 CS77CP0J100M CHIP TNTL 10UF 6.3WV
C77 CK73HB1H471K CHIP C 470PF K
C78 CC73HCH1H300J CHIP C 30PF J K3
C78 CC73HCH1H330J CHIP C 33PF J K,P,M
C78 CC73HCH1H330J CHIP C 33PF J K2,M2
C79,80 CK73HB1H471K CHIP C 470PF K
C81 CC73HCH1H150J CHIP C 15PF J
C83-85 CK73HB1H471K CHIP C 470PF K
C86 CC73HCH1H100B CHIP C 10PF B
C101,102 CK73HB1H471K CHIP C 470PF K
C103 CC73HCH1H120J CHIP C 12PF J K2,K3,M2
C103 CC73HCH1H300J CHIP C 30PF J K,P,M
C104 CC73HCH1H040B CHIP C 4.0PF B K,P,M
C104 CC73HCH1H160J CHIP C 16PF J K3
C106 CK73GB1A105K CHIP C 1.0UF K
C107 CK73HB1H471K CHIP C 470PF K
C108 CK73GB1A105K CHIP C 1.0UF K
C109 CC73HCH1H060B CHIP C 6.0PF B K,P,M
C109 CC73HCH1H060B CHIP C 6.0PF B K2,M2
C109 CC73HCH1H180J CHIP C 18PF J K3
C111 CK73GB1A105K CHIP C 1.0UF K
C112,113 CK73HB1H471K CHIP C 470PF K
C114 CK73HB1A104K CHIP C 0.10UF K
C115 CC73HCH1H050B CHIP C 5.0PF B K2,K3,M2
C115 CC73HCH1H110J CHIP C 11PF J K,P,M
C117 CC73HCH1H020B CHIP C 2.0PF B K2,M2
C117 CC73HCH1H110J CHIP C 11PF J K,P,M
C118 CC73HCH1H090B CHIP C 9.0PF B K3
C120 CK73HB1H471K CHIP C 470PF K
C122 CK73HB0J105K CHIP C 1.0UF K K2,K3,M2
C123 CC73HCH1H0R5B CHIP C 0.5PF B K3
C124 CK73HB1H471K CHIP C 470PF K
C125 CC73HCH1H100B CHIP C 10PF B K,P,M
C125 CC73HCH1H100B CHIP C 10PF B K2,M2
C125 CC73HCH1H150J CHIP C 15PF J K3
C126 CC73HCH1H060B CHIP C 6.0PF B K2,M2
C126 CC73HCH1H110J CHIP C 11PF J K,P,M
C127 CC73HCH1H160J CHIP C 16PF J K,P,M
C127 CC73HCH1H180J CHIP C 18PF J K2,M2
C127 CC73HCH1H470J CHIP C 47PF J K3
C128,129 CK73HB1H471K CHIP C 470PF K
C130 CK73GB1A105K CHIP C 1.0UF K
C131 CK73HB1E103K CHIP C 0.010UF K
C132 CC73HCH1H560J CHIP C 56PF J K2,M2
C133 CK73GB1A105K CHIP C 1.0UF K
C135,136 CK73HB1H471K CHIP C 470PF K
C137 CC73HCH1H101J CHIP C 100PF J
C140 CK73HB1H471K CHIP C 470PF K
C141 CK73HB1A104K CHIP C 0.10UF K
C142 CC73GCH1H430J CHIP C 43PF J K,P,M
C142 CC73GCH1H470J CHIP C 47PF J K3
C143 CC73GCH1H300J CHIP C 30PF J K2,M2
C144 CK73HB1H471K CHIP C 470PF K
C145 CC73GCH1H010B CHIP C 1.0PF B K2,M2
C145 CC73GCH1H360J CHIP C 36PF J K3
C146 CC73GCH1H120J CHIP C 12PF J K,P,M
C154 CK73HB1H471K CHIP C 470PF K

TK-3302
10
Ref. No. Address Parts No. Description Desti-
nation
New
parts
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
C155 CC73GCH1H0R3B CHIP C 0.3PF B K3
C161 CC73GCH1H010B CHIP C 1.0PF B K,P,M
C161 CC73GCH1H1R5B CHIP C 1.5PF B K3
C162 CC73GCH1H010B CHIP C 1.0PF B K2,M2
C162 CC73GCH1H020B CHIP C 2.0PF B K,P,M
C164 CC73GCH1H030B CHIP C 3.0PF B K3
C166 CC73GCH1H050B CHIP C 5.0PF B K2,M2
C166 CC73GCH1H060B CHIP C 6.0PF B K,P,M
C166 CC73GCH1H070B CHIP C 7.0PF B K3
C167 CK73HB1H471K CHIP C 470PF K
C168 CC73GCH1H040B CHIP C 4.0PF B K,P,M
C168 CC73GCH1H040B CHIP C 4.0PF B K3
C168 CC73GCH1H2R5B CHIP C 2.5PF B K2,M2
C169 CC73GCH1H040B CHIP C 4.0PF B K2,M2
C169 CC73GCH1H2R5B CHIP C 2.5PF B K,P,M
C169 CC73GCH1H2R5B CHIP C 2.5PF B K3
C170 CC73GCH1H101J CHIP C 100PF J
C172 CC73GCH1H010B CHIP C 1.0PF B K3
C172 CC73GCH1H030B CHIP C 3.0PF B K,P,M
C172 CC73GCH1H060B CHIP C 6.0PF B K2,M2
C173 CC73GCH1H0R5B CHIP C 0.5PF B K,P,M
C173 CC73GCH1H0R5B CHIP C 0.5PF B K3
C174 CC73GCH1H050B CHIP C 5.0PF B K,P,M
C174 CC73GCH1H100C CHIP C 10PF C K3
C174 CC73GCH1H110J CHIP C 11PF J K2,M2
C175 CC73GCH1H020B CHIP C 2.0PF B K,P,M
C176 CC73GCH1H050B CHIP C 5.0PF B K,P,M
C176 CC73GCH1H070B CHIP C 7.0PF B K2,M2
C176 CC73GCH1H100C CHIP C 10PF C K3
C177 CC73GCH1H0R3B CHIP C 0.3PF B K3
C177 CC73GCH1H0R5B CHIP C 0.5PF B K2,M2
C177 CC73GCH1H020B CHIP C 2.0PF B K,P,M
C178 CC73GCH1H020B CHIP C 2.0PF B K2,M2
C178 CC73GCH1H030B CHIP C 3.0PF B K,P,M
C178 CC73GCH1H060B CHIP C 6.0PF B K3
C201 CK73GB1C224K CHIP C 0.22UF K
C202 CK73FB0J106K CHIP C 10UF K
C203 CK73HB1E103K CHIP C 0.010UF K
C204 CK73HB1H102K CHIP C 1000PF K
C205 CK73HB1H182K CHIP C 1800PF K
C206,207 CK73HB1H561K CHIP C 560PF K
C208 CK73HB1A104K CHIP C 0.10UF K
C209 CC73HCH1H680J CHIP C 68PF J
C210-213 CK73HB1A104K CHIP C 0.10UF K
C214 CC73HCH1H020B CHIP C 2.0PF B
C215,216 CK73HB1E103K CHIP C 0.010UF K
C219 CC73HCH1H010B CHIP C 1.0PF B K,P,M
C219 CC73HCH1H010B CHIP C 1.0PF B K3
C220 CC73HCH1H180J CHIP C 18PF J
C222 CK73HB1H471K CHIP C 470PF K
C223 CK73HB1E103K CHIP C 0.010UF K
C224 CK73HB1A104K CHIP C 0.10UF K
C225 CK73HB1E103K CHIP C 0.010UF K
C226 CK73HB1H471K CHIP C 470PF K
C227 CC73HCH1H180J CHIP C 18PF J
C228 CK73HB1H471K CHIP C 470PF K
C230 CK73HB1E103K CHIP C 0.010UF K
C231 CK73HB1H102K CHIP C 1000PF K K3
C231 CK73HB1H471K CHIP C 470PF K K,P,M
C231 CK73HB1H471K CHIP C 470PF K K2,M2
C232 CC73HCH1H040B CHIP C 4.0PF B K2,M2
C232 CC73HCH1H3R5B CHIP C 3.5PF B K,P,M
C232 CC73HCH1H3R5B CHIP C 3.5PF B K3
C233 CC73HCH1H060B CHIP C 6.0PF B
C234 CK73HB1H471K CHIP C 470PF K
C235 CC73HCH1HR75B CHIP C 0.75PF B K3
C236 CC73GCH1H040B CHIP C 4.0PF B K,P,M
C236 CC73GCH1H070B CHIP C 7.0PF B K3
C236 CC73GCH1H2R5B CHIP C 2.5PF B K2,M2
C237 CC73HCH1H220J CHIP C 22PF J K,P,M
C237 CC73HCH1H270J CHIP C 27PF J K3
C237 CC73HCH1H300J CHIP C 30PF J K2,M2
C238 CC73HCH1H010B CHIP C 1.0PF B
C239 CK73HB1H471K CHIP C 470PF K
C240 CC73HCH1H020B CHIP C 2.0PF B K,P,M
C240 CC73HCH1H040B CHIP C 4.0PF B K3
C240 CC73HCH1H1R5B CHIP C 1.5PF B K2,M2
C241 CK73FB0J106K CHIP C 10UF K
C242 CC73HCH1H040B CHIP C 4.0PF B K2,M2
C242 CC73HCH1H060B CHIP C 6.0PF B K,P,M
C242 CC73HCH1H080B CHIP C 8.0PF B K3
C243 CK73HB1H471K CHIP C 470PF K
C244 CC73HCH1H220J CHIP C 22PF J K,P,M
C244 CC73HCH1H270J CHIP C 27PF J K3
C244 CC73HCH1H300J CHIP C 30PF J K2,M2
C245 CC73HCH1HR75B CHIP C 0.75PF B K2,M2
C245 CC73HCH1H010B CHIP C 1.0PF B K,P,M
C245 CC73HCH1H010B CHIP C 1.0PF B K3
C246 CK73HB1H471K CHIP C 470PF K
C247 CC73HCH1H020B CHIP C 2.0PF B K,P,M
C247 CC73HCH1H020B CHIP C 2.0PF B K2,M2
C247 CC73HCH1H040B CHIP C 4.0PF B K3
C248 CC73HCH1H220J CHIP C 22PF J K,P,M
C248 CC73HCH1H270J CHIP C 27PF J K3
C248 CC73HCH1H300J CHIP C 30PF J K2,M2
C249 CC73GCH1H030B CHIP C 3.0PF B K2,M2
C249 CC73GCH1H040B CHIP C 4.0PF B K,P,M
C249 CC73GCH1H080B CHIP C 8.0PF B K3
C250 CK73HB1H471K CHIP C 470PF K
C252-254 CK73HB1H471K CHIP C 470PF K
C256 CK73HB1H471K CHIP C 470PF K
C257 CC73HCH1H080B CHIP C 8.0PF B K3
C257 CC73HCH1H2R5B CHIP C 2.5PF B K2,M2
C257 CC73HCH1H3R5B CHIP C 3.5PF B K,P,M
C258 CC73HCH1H220J CHIP C 22PF J K,P,M
C258 CC73HCH1H220J CHIP C 22PF J K3
C258 CC73HCH1H300J CHIP C 30PF J K2,M2
C259 CC73HCH1H020B CHIP C 2.0PF B K,P,M
C259 CC73HCH1H1R5B CHIP C 1.5PF B K2,K3,M2
C260 CK73HB1H471K CHIP C 470PF K
C261 CC73HCH1H020B CHIP C 2.0PF B K3
C261 CC73HCH1H030B CHIP C 3.0PF B K,P,M
C261 CC73HCH1H1R5B CHIP C 1.5PF B K2,M2
C262 CC73HCH1H220J CHIP C 22PF J K,P,M
C262 CC73HCH1H220J CHIP C 22PF J K3
C262 CC73HCH1H300J CHIP C 30PF J K2,M2
C263 CC73HCH1H010B CHIP C 1.0PF B K,P,M
C263 CC73HCH1H020B CHIP C 2.0PF B K2,M2
C263 CC73HCH1H060B CHIP C 6.0PF B K3
C264 CC73HCH1H020B CHIP C 2.0PF B K3

TK-3302
11
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
C383-385 CK73HB1A104K CHIP C 0.10UF K
C386 CK73HB1E103K CHIP C 0.010UF K
C388,389 CK73HB1H471K CHIP C 470PF K
C390,391 CK73GB1A105K CHIP C 1.0UF K
C392 CK73HB1A473K CHIP C 0.047UF K
C393 CK73FB0J106K CHIP C 10UF K
C395 CC73HCH1H221J CHIP C 220PF J
C396 CK73HB1A104K CHIP C 0.10UF K
C397 CK73GB1C474K CHIP C 0.47UF K
C399 CC73HCH1H101J CHIP C 100PF J
C400 CK73FB0J106K CHIP C 10UF K
C402 CK73HB1A104K CHIP C 0.10UF K
C403 CK73HB1A473J CHIP C 0.047UF J
C404 CS77CC0J101M CHIP TNTL 100UF 6.3WV
C405 CC73HCH1H221J CHIP C 220PF J
C408 CK73HB1H471K CHIP C 470PF K K2,M2
C408,409 CK73HB1H471K CHIP C 470PF K K,P,M
C408,409 CK73HB1H471K CHIP C 470PF K K3
C411 CK73HB1H471K CHIP C 470PF K K,P,M
C413-415 CK73HB1H471K CHIP C 470PF K
TC1,2 C05-0384-05 CERAMIC TRIMMER CAP (10PF)
CN301 E40-6573-05 FLAT CABLE CONNECTOR
J301 E11-0703-05 PHONE JACK (2.5/3.5)
F301 F53-0324-05 FUSE(2.5A)
101 2A J30-1282-14 SPACER
CD201 L79-1866-05 TUNING COIL
CF201 2A L72-0973-05 CERAMIC FILTER
L1 L92-0138-05 CHIP FERRITE
L2 L40-4791-86 SMALL FIXED INDUCTOR (4.7UH)
L4 L40-5681-86 SMALL FIXED INDUCTOR (0.56UH)
L6 L40-5681-86 SMALL FIXED INDUCTOR (0.56UH)
L7 L92-0138-05 CHIP FERRITE
L8 L40-1875-71 SMALL FIXED INDUCTOR (18NH)
L9 L92-0470-05 CHIP FERRITE
L10,11 L40-1885-92 SMALL FIXED INDUCTOR (180NH)
L12 L40-1875-71 SMALL FIXED INDUCTOR (18NH)
L13,14 L40-1885-92 SMALL FIXED INDUCTOR (180NH)
L15 L40-2278-67 SMALL FIXED INDUCTOR (22NH) K2,M2
L15 L40-2778-67 SMALL FIXED INDUCTOR (27NH) K,P,M
L15 L40-2778-67 SMALL FIXED INDUCTOR (27NH) K3
L16 L40-1878-67 SMALL FIXED INDUCTOR (18NH) K,P,M
L16 L40-1878-67 SMALL FIXED INDUCTOR (18NH) K2,M2
L16 L40-2278-67 SMALL FIXED INDUCTOR (22NH) K3
L17,18 L41-2785-45 SMALL FIXED INDUCTOR (270NH)
L19,20 L40-1885-92 SMALL FIXED INDUCTOR (180NH)
L21 L92-0138-05 CHIP FERRITE
L22,23 L40-2275-71 SMALL FIXED INDUCTOR (22NH)
L101 L40-1875-71 SMALL FIXED INDUCTOR (18NH)
L102 L40-2775-71 SMALL FIXED INDUCTOR (27NH) K3
L102 L40-3975-71 SMALL FIXED INDUCTOR (39NH) K,P,M
L102 L40-3975-71 SMALL FIXED INDUCTOR (39NH) K2,M2
L103 L40-1575-71 SMALL FIXED INDUCTOR (15NH) K,P,M
L103 L40-1875-71 SMALL FIXED INDUCTOR (18NH) K3
L103 L40-2275-71 SMALL FIXED INDUCTOR (22NH) K2,M2
L104 L40-3368-71 SMALL FIXED INDUCTOR (3.3NH) K2,M2
L104 L40-8265-71 SMALL FIXED INDUCTOR (8.2NH) K,P,M
L104 L40-8265-71 SMALL FIXED INDUCTOR (8.2NH) K3
C264 CC73HCH1H220J CHIP C 22PF J K2,M2
C264 CC73HCH1H3R5B CHIP C 3.5PF B K,P,M
C265 CC73HCH1H030B CHIP C 3.0PF B K,P,M
C265 CC73HCH1H050B CHIP C 5.0PF B K3
C265 CC73HCH1H080B CHIP C 8.0PF B K2,M2
C266 CC73HCH1H050B CHIP C 5.0PF B K,P,M
C266 CC73HCH1H060B CHIP C 6.0PF B K2,M2
C266 CC73HCH1H070B CHIP C 7.0PF B K3
C290 CC73HCH1H020B CHIP C 2.0PF B
C291 CC73HCH1H060B CHIP C 6.0PF B
C303 CC73HCH1H101J CHIP C 100PF J
C304 CK73HB1A104K CHIP C 0.10UF K
C305 CC73HCH1H101J CHIP C 100PF J
C306 CK73GB1A105K CHIP C 1.0UF K
C307 CC73HCH1H101J CHIP C 100PF J
C310 CK73GB1A105K CHIP C 1.0UF K
C311 CC73HCH1H101J CHIP C 100PF J
C312 CK73HB1H471K CHIP C 470PF K
C313 CC73HCH1H101J CHIP C 100PF J
C315 CC73HCH1H101J CHIP C 100PF J
C316 CK73HB1H471K CHIP C 470PF K
C318 CK73HB1E103K CHIP C 0.010UF K
C319 CK73HB1H102K CHIP C 1000PF K
C320 CC73HCH1H101J CHIP C 100PF J
C321 CK73GB1A105K CHIP C 1.0UF K
C322 CC73HCH1H101J CHIP C 100PF J
C323 CK73GB1A105K CHIP C 1.0UF K
C325 CC73HCH1H101J CHIP C 100PF J
C327 CK73HB1H471K CHIP C 470PF K
C331 CK73HB1A104K CHIP C 0.10UF K
C332 CC73HCH1H050B CHIP C 5.0PF B
C334 CK73HB1E103K CHIP C 0.010UF K
C335 CK73FB0J106K CHIP C 10UF K
C337 CC73HCH1H050B CHIP C 5.0PF B
C339 CK73GB1A105K CHIP C 1.0UF K
C341 CK73HB1H471K CHIP C 470PF K
C353-355 CK73HB1E103K CHIP C 0.010UF K
C356 CK73HB1H102K CHIP C 1000PF K
C358 CK73GB1C224K CHIP C 0.22UF K
C359 CK73FB0J106K CHIP C 10UF K
C360 CK73HB1A104K CHIP C 0.10UF K
C361 CK73GB1A105K CHIP C 1.0UF K
C362 CK73HB1H471K CHIP C 470PF K
C363 CC73HCH1H820J CHIP C 82PF J
C364 CC73HCH1H120J CHIP C 12PF J
C365 CC73HCH1H820J CHIP C 82PF J
C366 CK73HB1A104K CHIP C 0.10UF K
C367 CK73GB1A105K CHIP C 1.0UF K
C368 CK73HB1H271K CHIP C 270PF K
C369,370 CK73HB1A104K CHIP C 0.10UF K
C371 CK73FB0J106K CHIP C 10UF K
C372 CK73HB1H471K CHIP C 470PF K
C373 CC73HCH1H121J CHIP C 120PF J
C374 CK73HB1H102K CHIP C 1000PF K
C375,376 CK73HB1H471K CHIP C 470PF K
C377 CK73HB1A683K CHIP C 0.068UF K
C378 CC73HCH1H820J CHIP C 82PF J
C379,380 CK73GB1A105K CHIP C 1.0UF K
C381 CK73HB1H391K CHIP C 390PF K
C382 CK73HB1C153K CHIP C 0.015UF K
If a part reference number is listed in a shaded
box, that part does not come with the PCB.

TK-3302
12
Ref. No. Address Parts No. Description Desti-
nation
New
parts
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
L105 L41-2278-45 SMALL FIXED INDUCTOR (22NH) K,P,M
L105 L41-2278-45 SMALL FIXED INDUCTOR (22NH) K2,M2
L105 L41-4765-45 SMALL FIXED INDUCTOR (4.7NH) K3
L106 L92-0472-05 CHIP FERRITE
L107 L40-2263-92 SMALL FIXED INDUCTOR (2.2NH) K3
L107 L40-2763-92 SMALL FIXED INDUCTOR (2.7NH) K,P,M
L107 L40-8265-92 SMALL FIXED INDUCTOR (8.2NH) K2,M2
L108 L34-4603-15 AIR-CORE COIL K,P,M
L108 L34-4603-15 AIR-CORE COIL K3
L108 L34-4604-15 AIR-CORE COIL K2,M2
L109 L92-0472-05 CHIP FERRITE
L111 L41-2785-45 SMALL FIXED INDUCTOR (270NH)
L112 L34-4572-05 AIR-CORE COIL
L113-115 L34-4564-05 AIR-CORE COIL
L116 L41-1092-44 SMALL FIXED INDUCTOR (1UH)
L201 L40-1091-86 SMALL FIXED INDUCTOR (1.0UH)
L202 L92-0138-05 CHIP FERRITE
L203 L41-5685-39 SMALL FIXED INDUCTOR (0.56UH)
L204 L40-1885-92 SMALL FIXED INDUCTOR (180NH)
L205 L40-2775-71 SMALL FIXED INDUCTOR (27NH) K,P,M
L205 L40-2775-71 SMALL FIXED INDUCTOR (27NH) K2,M2
L205 L40-3375-71 SMALL FIXED INDUCTOR (33NH) K3
L206,207 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH)
L208 L92-0138-05 CHIP FERRITE
L209 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH)
L210 L41-2785-45 SMALL FIXED INDUCTOR (270NH)
L212 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH) K2,M2
L212,213 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH) K,P,M
L212,213 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH) K3
L213 L41-3963-14 SMALL FIXED INDUCTOR (3.9NH) K2,M2
L214 L41-4775-45 SMALL FIXED INDUCTOR (47NH) K,P,M
L214 L41-4775-45 SMALL FIXED INDUCTOR (47NH) K3
L215 L41-3963-14 SMALL FIXED INDUCTOR (3.9NH) K2,M2
L250 L40-1875-71 SMALL FIXED INDUCTOR (18NH)
L301 L92-0472-05 CHIP FERRITE
L302-304 L92-0138-05 CHIP FERRITE
L305 L92-0140-05 CHIP FERRITE
X1 L77-3042-05 TCXO (12.8MHZ)
X301 L78-1433-05 RESONATOR (14.746MHZ)
XF201 L71-0619-05 MCF (38.85MHZ/6.5KH)
CP1 RK75HA1J101J CHIP-COM 100 J 1/16W
CP201 RK75HA1J104J CHIP-COM 100K J 1/16W
CP202 RK75HA1J474J CHIP-COM 470K J 1/16W
CP203 RK75HA1J104J CHIP-COM 100K J 1/16W
CP204 RK75HA1J474J CHIP-COM 470K J 1/16W
CP301,302 RK75HA1J473J CHIP-COM 47K J 1/16W
CP303,304 RK75HA1J102J CHIP-COM 1.0K J 1/16W
R1 RK73HB1J223J CHIP R 22K J 1/16W
R2 RK73HB1J103J CHIP R 10K J 1/16W
R3 RK73HB1J154J CHIP R 150K J 1/16W K3
R3 RK73HB1J184J CHIP R 180K J 1/16W K,P,M
R3 RK73HB1J184J CHIP R 180K J 1/16W K2,M2
R4 RK73HB1J563J CHIP R 56K J 1/16W
R5 RK73HB1J104J CHIP R 100K J 1/16W
R7 RK73HB1J000J CHIP R 0.0 J 1/16W
R8 RK73HB1J101J CHIP R 100 J 1/16W
R9 RK73HB1J222J CHIP R 2.2K J 1/16W K2,M2
R9 RK73HB1J821J CHIP R 820 J 1/16W K,P,M
R9 RK73HB1J821J CHIP R 820 J 1/16W K3
R10 RK73HB1J000J CHIP R 0.0 J 1/16W
R11 RK73HB1J274J CHIP R 270K J 1/16W K,P,M
R11 RK73HB1J274J CHIP R 270K J 1/16W K3
R11 RK73HB1J334J CHIP R 330K J 1/16W K2,M2
R12 RK73HB1J221J CHIP R 220 J 1/16W
R13 RK73HB1J101J CHIP R 100 J 1/16W
R14 RK73HB1J100J CHIP R 10 J 1/16W
R15 RK73HB1J561J CHIP R 560 J 1/16W
R16 RK73HB1J000J CHIP R 0.0 J 1/16W K,P,M
R16 RK73HB1J181J CHIP R 180 J 1/16W K2,K3,M2
R17 RK73HB1J122J CHIP R 1.2K J 1/16W K2,K3,M2
R17 RK73HB1J182J CHIP R 1.8K J 1/16W K,P,M
R18 RK73HB1J681J CHIP R 680 J 1/16W
R19 RK73HB1J223J CHIP R 22K J 1/16W
R20 RK73HB1J000J CHIP R 0.0 J 1/16W
R21,22 RK73HB1J103J CHIP R 10K J 1/16W
R23 RK73HB1J470J CHIP R 47 J 1/16W K3
R26 RK73HB1J333J CHIP R 33K J 1/16W
R27 RK73HB1J684J CHIP R 680K J 1/16W
R28 RK73HB1J102J CHIP R 1.0K J 1/16W
R29 RK73HB1J154J CHIP R 150K J 1/16W
R30 RK73HB1J273J CHIP R 27K J 1/16W
R31 RK73HB1J274J CHIP R 270K J 1/16W
R32 RK73HB1J394J CHIP R 390K J 1/16W K3
R32 RK73HB1J474J CHIP R 470K J 1/16W K,P,M
R32 RK73HB1J474J CHIP R 470K J 1/16W K2,M2
R33 RK73HB1J100J CHIP R 10 J 1/16W K3
R33 RK73HB1J101J CHIP R 100 J 1/16W K2,M2
R33-36 RK73HB1J101J CHIP R 100 J 1/16W K,P,M
R34 RK73HB1J181J CHIP R 180 J 1/16W K2,M2
R34-36 RK73HB1J101J CHIP R 100 J 1/16W K3
R35 RK73HB1J820J CHIP R 82 J 1/16W K2,M2
R36 RK73HB1J101J CHIP R 100 J 1/16W K2,M2
R37 RK73HB1J472J CHIP R 4.7K J 1/16W
R38 RK73HB1J154J CHIP R 150K J 1/16W
R39 RK73HB1J101J CHIP R 100 J 1/16W
R40 RK73HB1J472J CHIP R 4.7K J 1/16W K,P,M
R40 RK73HB1J472J CHIP R 4.7K J 1/16W K2,M2
R41 RK73HB1J562J CHIP R 5.6K J 1/16W
R42 RK73HB1J220J CHIP R 22 J 1/16W
R43 RK73HB1J471J CHIP R 470 J 1/16W
R45 RK73HB1J562J CHIP R 5.6K J 1/16W
R101 RK73HB1J332J CHIP R 3.3K J 1/16W
R102 RK73HB1J273J CHIP R 27K J 1/16W
R103 RK73HB1J331J CHIP R 330 J 1/16W
R104 RK73HB1J390J CHIP R 39 J 1/16W K3
R104 RK73HB1J470J CHIP R 47 J 1/16W K,P,M
R104 RK73HB1J470J CHIP R 47 J 1/16W K2,M2
R105 RK73HB1J183J CHIP R 18K J 1/16W K3
R105 RK73HB1J273J CHIP R 27K J 1/16W K,P,M
R105 RK73HB1J273J CHIP R 27K J 1/16W K2,M2
R106 RK73HB1J331J CHIP R 330 J 1/16W
R107 RK73HB1J390J CHIP R 39 J 1/16W K3
R107 RK73HB1J560J CHIP R 56 J 1/16W K,P,M
R107 RK73HB1J560J CHIP R 56 J 1/16W K2,M2
R109 RK73HB1J000J CHIP R 0.0 J 1/16W
R111 RK73HB1J393J CHIP R 39K J 1/16W K,P,M
R111 RK73HB1J393J CHIP R 39K J 1/16W K2,M2
R111 RK73HB1J473J CHIP R 47K J 1/16W K3
R112 RK73HB1J220J CHIP R 22 J 1/16W
R113 RK73HB1J104J CHIP R 100K J 1/16W

TK-3302
13
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
R114 RK73HB1J822J CHIP R 8.2K J 1/16W
R116 RK73HB1J331J CHIP R 330 J 1/16W K,P,M
R116 RK73HB1J331J CHIP R 330 J 1/16W K2,M2
R118 RK73HB1J000J CHIP R 0.0 J 1/16W K2,M2
R118 RK73HB1J331J CHIP R 330 J 1/16W K3
R119 RK73GB2A000J CHIP R 0.0 J 1/10W
R120 RK73EB2ER39K CHIP R 0.39 K 1/4W
R121 RK73HB1J103J CHIP R 10K J 1/16W K,P,M
R121 RK73HB1J153J CHIP R 15K J 1/16W K3
R121 RK73HB1J472J CHIP R 4.7K J 1/16W K2,M2
R122 RK73HB1J273J CHIP R 27K J 1/16W K,P,M
R122 RK73HB1J273J CHIP R 27K J 1/16W K2,M2
R122 RK73HB1J683J CHIP R 68K J 1/16W K3
R123 RK73EB2ER39K CHIP R 0.39 K 1/4W
R124 RK73HB1J101J CHIP R 100 J 1/16W K3
R124 RK73HB1J220J CHIP R 22 J 1/16W K,P,M
R124 RK73HB1J220J CHIP R 22 J 1/16W K2,M2
R125 RK73HB1J683J CHIP R 68K J 1/16W
R126 RK73EB2ER39K CHIP R 0.39 K 1/4W
R127,128 RK73GH2A154D CHIP R 150K D 1/10W
R129,130 RK73GH2A334D CHIP R 330K D 1/10W
R131 RK73HB1J105J CHIP R 1.0M J 1/16W
R132 RK73HB1J473J CHIP R 47K J 1/16W
R133 RK73HB1J000J CHIP R 0.0 J 1/16W
R134 RK73HB1J563J CHIP R 56K J 1/16W
R135 RK73HB1J104J CHIP R 100K J 1/16W K2,K3,M2
R135 RK73HB1J184J CHIP R 180K J 1/16W K,P,M
R136 RK73HB1J474J CHIP R 470K J 1/16W
R137 RK73FB2B000J CHIP R 0.0 J 1/8W
R138 RK73GB2A151J CHIP R 150 J 1/10W
R140 RK73GB2A000J CHIP R 0.0 J 1/10W
R141 RK73HB1J000J CHIP R 0.0 J 1/16W
R201 RK73HB1J184J CHIP R 180K J 1/16W K3
R201 RK73HB1J823J CHIP R 82K J 1/16W K,P,M
R201 RK73HB1J823J CHIP R 82K J 1/16W K2,M2
R203 RK73HB1J472J CHIP R 4.7K J 1/16W
R204 RK73HB1J100J CHIP R 10 J 1/16W
R205 RK73HB1J823J CHIP R 82K J 1/16W
R206 RK73HB1J272J CHIP R 2.7K J 1/16W
R207 RK73HB1J332J CHIP R 3.3K J 1/16W
R208 RK73HB1J823J CHIP R 82K J 1/16W
R209 RK73HB1J332J CHIP R 3.3K J 1/16W
R210 RK73HB1J392J CHIP R 3.9K J 1/16W K,P,M
R210 RK73HB1J392J CHIP R 3.9K J 1/16W K2,M2
R210 RK73HB1J472J CHIP R 4.7K J 1/16W K3
R211 RK73HB1J101J CHIP R 100 J 1/16W
R212 RK73HB1J184J CHIP R 180K J 1/16W K2,M2
R212 RK73HB1J224J CHIP R 220K J 1/16W K,P,M
R212 RK73HB1J224J CHIP R 220K J 1/16W K3
R213 RK73HB1J391J CHIP R 390 J 1/16W
R214 RK73HB1J331J CHIP R 330 J 1/16W
R215 RK73HB1J222J CHIP R 2.2K J 1/16W
R216 RK73HB1J151J CHIP R 150 J 1/16W
R217 RK73HB1J332J CHIP R 3.3K J 1/16W
R218 RK73HB1J823J CHIP R 82K J 1/16W K3
R218,219 RK73HB1J563J CHIP R 56K J 1/16W K,P,M
R218,219 RK73HB1J563J CHIP R 56K J 1/16W K2,M2
R219 RK73HB1J563J CHIP R 56K J 1/16W K3
R220 RK73HB1J000J CHIP R 0.0 J 1/16W
R221 RK73HB1J105J CHIP R 1.0M J 1/16W
R222 RK73HB1J150J CHIP R 15 J 1/16W K3
R222 RK73HB1J220J CHIP R 22 J 1/16W K,P,M
R222 RK73HB1J220J CHIP R 22 J 1/16W K2,M2
R223 RK73HB1J121J CHIP R 120 J 1/16W K3
R223 RK73HB1J221J CHIP R 220 J 1/16W K,P,M
R223 RK73HB1J221J CHIP R 220 J 1/16W K2,M2
R225 RK73HB1J683J CHIP R 68K J 1/16W
R226 RK73HB1J000J CHIP R 0.0 J 1/16W
R227 RK73FB2B000J CHIP R 0.0 J 1/8W K,P,M
R227 RK73FB2B000J CHIP R 0.0 J 1/8W K3
R228 RK73HB1J102J CHIP R 1.0K J 1/16W
R229 RK73GB2A000J CHIP R 0.0 J 1/10W K2,M2
R301 RK73HH1J474D CHIP R 470K D 1/16W
R302 RK73GB2A000J CHIP R 0.0 J 1/10W
R303 RK73HB1J101J CHIP R 100 J 1/16W
R304 RK73HB1J334J CHIP R 330K J 1/16W
R305 RK73HH1J474D CHIP R 470K D 1/16W
R306 RK73HB1J184J CHIP R 180K J 1/16W
R307 RK73GB2A271J CHIP R 270 J 1/10W
R308 RK73GB2A221J CHIP R 220 J 1/10W
R309,310 RK73GB2A000J CHIP R 0.0 J 1/10W
R313 RK73HB1J102J CHIP R 1.0K J 1/16W
R314,315 RK73HB1J103J CHIP R 10K J 1/16W
R316 RK73HB1J222J CHIP R 2.2K J 1/16W
R317 RK73HB1J472J CHIP R 4.7K J 1/16W
R318 RK73HB1J182J CHIP R 1.8K J 1/16W
R319 RK73HB1J000J CHIP R 0.0 J 1/16W
R320 RK73HB1J123J CHIP R 12K J 1/16W
R321 RK73HB1J103J CHIP R 10K J 1/16W
R322,323 RK73HB1J102J CHIP R 1.0K J 1/16W
R324,325 RK73HB1J472J CHIP R 4.7K J 1/16W
R340-342 RK73HB1J103J CHIP R 10K J 1/16W
R344 RK73HB1J474J CHIP R 470K J 1/16W
R345 RK73HB1J273J CHIP R 27K J 1/16W
R347 RK73GB2A000J CHIP R 0.0 J 1/10W
R348 RK73HB1J102J CHIP R 1.0K J 1/16W
R349 RK73HB1J105J CHIP R 1.0M J 1/16W
R350 RK73HB1J124J CHIP R 120K J 1/16W
R351 RK73HB1J334J CHIP R 330K J 1/16W
R352 RK73HB1J154J CHIP R 150K J 1/16W
R353 RK73HB1J123J CHIP R 12K J 1/16W
R354 RK73HB1J334J CHIP R 330K J 1/16W
R355 RK73HB1J124J CHIP R 120K J 1/16W
R356 RK73HB1J472J CHIP R 4.7K J 1/16W
R357 RK73HB1J563J CHIP R 56K J 1/16W
R358 RK73HB1J474J CHIP R 470K J 1/16W
R359 RK73HB1J473J CHIP R 47K J 1/16W
R360 RK73HB1J562J CHIP R 5.6K J 1/16W
R361 RK73GB2A000J CHIP R 0.0 J 1/10W
R362 RK73HB1J184J CHIP R 180K J 1/16W
R363,364 RK73HB1J104J CHIP R 100K J 1/16W
R365 RK73HB1J332J CHIP R 3.3K J 1/16W
R366 RK73HB1J154J CHIP R 150K J 1/16W
R367 RK73HB1J393J CHIP R 39K J 1/16W
R368 RK73GB2A000J CHIP R 0.0 J 1/10W
R369 RK73HB1J823J CHIP R 82K J 1/16W
R370 RK73HB1J102J CHIP R 1.0K J 1/16W
R371 RK73HB1J272J CHIP R 2.7K J 1/16W
R372 RK73HB1J000J CHIP R 0.0 J 1/16W
R373 RK73HB1J224J CHIP R 220K J 1/16W

TK-3302
14
Ref. No. Address Parts No. Description Desti-
nation
New
parts
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-7580-XX)
R374 RK73HB1J153J CHIP R 15K J 1/16W
R375 RK73HB1J182J CHIP R 1.8K J 1/16W
R376 RK73HB1J471J CHIP R 470 J 1/16W
R377 RK73HB1J473J CHIP R 47K J 1/16W
R378 RK73HB1J561J CHIP R 560 J 1/16W
R379 RK73HB1J102J CHIP R 1.0K J 1/16W
R380 RK73HB1J474J CHIP R 470K J 1/16W
R381 RK73HB1J151J CHIP R 150 J 1/16W
R383 RK73HB1J563J CHIP R 56K J 1/16W
R384 RK73HB1J333J CHIP R 33K J 1/16W
R385 RK73GB2A101J CHIP R 100 J 1/10W
R387 RK73HB1J104J CHIP R 100K J 1/16W
R388 RK73HB1J101J CHIP R 100 J 1/16W
R389 RK73HB1J000J CHIP R 0.0 J 1/16W
R390 RK73GB2A000J CHIP R 0.0 J 1/10W
R391 RK73HB1J102J CHIP R 1.0K J 1/16W
R393 RK73GB2A000J CHIP R 0.0 J 1/10W
R394 RK73HB1J473J CHIP R 47K J 1/16W
R398 RK73HB1J000J CHIP R 0.0 J 1/16W
VR1 R32-0736-05 SEMI FIXED VARIABLE RESISTOR
S1-3 S70-0414-05 TACT SWITCH
MIC301 2A T91-0651-15 MIC ELEMENT
D3,4 1SV325F VARIABLE CAPACITANCE DIODE
D6 1SV325F VARIABLE CAPACITANCE DIODE
D8 1SV325F VARIABLE CAPACITANCE DIODE
D9 KDV214E-P DIODE
D10 MC2858 DIODE
D101 UDZW5.1(B) ZENER DIODE
D103 HSC277 DIODE
D104 HVC131 DIODE K2,K3,M2
D104,105 HVC131 DIODE K,P,M
D106 HVC131 DIODE K2,K3,M2
D201-205 HVC355B VARIABLE CAPACITANCE DIODE
D301 GN1G DIODE
D302 HRC0203C DIODE
D306 KDR731 DIODE
D307 MC2850 DIODE
D308,309 KDR731 DIODE
IC1 MB15A02PFV2E1 MOS-IC
IC101 BA2904FVM MOS-IC
IC201 TA31136FNG MOS-IC
IC301 BD4840FVE MOS-IC
IC303 XC6209B502PR MOS-IC
IC304 XC6209B502MR MOS-IC
IC305 BR24L16F-W ROM IC
IC306 ✽R5F212CCKCMB MICRO CONTROL UNIT
IC308 AQUA-L MOS-IC
IC309 TA7368FG MOS-IC
Q1 KTC4075E(Y,GR) TRANSISTOR
Q2 2SC4774 TRANSISTOR
Q3 2SC5636 TRANSISTOR
Q4,5 2SK1875-F(V) FET
Q6 KTC4075E(Y,GR) TRANSISTOR
Q7,8 RT1P430U TRANSISTOR
Q9 2SC5636 TRANSISTOR
Q10 KTC4075E(Y,GR) TRANSISTOR
Q11 2SC5636 TRANSISTOR
Q101 2SC5636 TRANSISTOR
Q102 2SC4926YD TRANSISTOR K,P,M
Q102 2SC5455-A TRANSISTOR K2,K3,M2
Q103 RQA0004PXDQS FET
Q104 RT1N441U TRANSISTOR K2,K3,M2
Q106 RD07MVS1BT122 FET
Q107 RT1N441U TRANSISTOR
Q108 2SK1824-A FET
Q109 RT1P441U TRANSISTOR
Q201 RT1P441U TRANSISTOR
Q202 2SC4774 TRANSISTOR
Q203,204 3SK318 FET
Q301,302 RT1N441U TRANSISTOR
Q303 RT1P141U TRANSISTOR
Q304 DTB723YE DIGITAL TRANSISTOR
Q305,306 2SC4919 TRANSISTOR
Q307 RT1N441U TRANSISTOR
Q308 KTC4075E(Y,GR) TRANSISTOR
Q310 2SC4116(GR)F TRANSISTOR
Q311 2SA1586(Y,GR)F TRANSISTOR
Q312 RT1N441U TRANSISTOR
Q313 2SB1694 TRANSISTOR
Q314 RT1N441U TRANSISTOR
Q315,316 2SK3577-A FET
TH101 B57331V2104J THERMISTOR
TH201 B57331V2104J THERMISTOR

TK-3302
15
EXPLODED VIEW
3
2
1
BA
57
54
55
52
56
1
11
10
9
22
21
34
67
35
49
16
17
E
TX-RX unit
Ex10
A
C
C
B
E
Dx2
701
Model name plate
32
MIC301
51
29
CF201
63
65 36
13
33
25
24
28
47
31
46 15
2
19 30
27
26 14
A : N14-0848-05
B : N14-0849-05
C M2.6 x 4 : N30-2604-48
D M2.6 x 6 : N30-2606-48
E M2 x 5 : N83-2005-48
23
101
X57
X57
Parts with the exploded numbers larger than 700 are not supplied.
If a part reference number is listed in a box on the exploded view of the PCB, that part does not come with the PCB.
These parts must be ordered separately.

TK-3302
16
PACKING (K2,K3,M2 TYPE)
Parts with the exploded numbers larger than 700 are not supplied.
3
2
1
DC
7 Instruction manual
(B62-2109-00)
704 Protection bag
71 Charger (KSC-35)
(W08-0988-05)
72 AC adapter
(W08-0989-15): K,K2,K3
73 AC adapter
(W08-0992-05): M,M2
50 Belt hook
(J29-0734-05)
48 Holder (SP/MIC)
(J29-5521-03)
4 Cap
(B09-0725-03)
61 Screw set
(N99-2046-05)
39 Packing fixture
(H12-4251-05)
42 Item carton case
(H52-2300-13)
68 Whip antenna
(T90-1039-25): K,M
(T90-1040-25): K2,M2
(T90-1041-25): K3
706 Battery assy (Li-ion)
*1
*2
*2
*1
703

TK-3302
17
PACKING (P TYPE)
Parts with the exploded numbers larger than 700 are not supplied.
3
2
1
FE
7 Instruction manual
(B62-2139-00)
703
704 Protection bag
50 Belt hook
(J29-0734-05)
4 Cap
(B09-0725-03)
61 Screw set
(N99-2046-05)
48 Holder (SP/MIC)
(J29-5521-03)
38 Packing fixture
(H12-4250-05)
43 Item carton case
(H52-2301-03)
40 Carton board
(H13-2109-03)
70 AC adapter
(W08-0970-35)
74 Charger (KSC-31)
(W08-1067-05)
707 Battery assy (Ni-MH)
68 Whip antenna
(T90-1039-25)
*1
*1

TK-3302
18
Test Equipment Required for Alignment
Test Equipment Major Specifications
1. Standard Signal Generator (SSG)
Frequency Range Operational frequency range of the transceiver
Modulation Frequency modulation and external modulation
Output –127dBm/0.1µV to greater than –47dBm/1mV
2. RF Power Meter
Input Impedance 50Ω
Operation Frequency Operational frequency range of the transceiver
Measurement Range Vicinity of 10W
3. Deviation Meter Frequency Range Operational frequency range of the transceiver
4. Digital Volt Meter (DVM) Measuring Range 10mV to 10V DC
Input Impedance High input impedance for minimum circuit loading
5. Oscilloscope DC through 30MHz
6. High Sensitivity
Frequency Counter
Frequency Range 10Hz to 1000MHz
Frequency Stability 0.2ppm or less
7. DC Ammeter 5A
8. AF Volt Meter (AF VTVM) Frequency Range 50Hz to 10kHz
Voltage Range 1mV to 10V
9. Audio Generator (AG) Frequency Range 50Hz to 5kHz or more
Output 0 to 1V
10. Distortion Meter Capability 3% or less at 1kHz
Input Level 50mV to 10Vrms
11. Spectrum Analyzer Measuring Range DC to 1GHz or more
12. Tracking Generator Center frequency 50kHz to 600MHz
Output Voltage 100mV or more
13. 4ΩDummy Load Approx. 4Ω, 3W
14. Regulated Power Supply 5V to 10V, approx. 3A
Useful if ammeter equipped
■Antenna connector adapter
The antenna connector of this transceiver uses an SMA
terminal.
Use an antenna connector adapter [SMA(f) – BNC(f) or
SMA(f) – N(f)] for adjustment. (The adapter is not provided
as an option, so buy a commercially-available one.)
■Repair Jig (Chassis)
Use jig (part No.: A10-4215-03) for repairing the transceiv-
er. Place the TX-RX unit on the jig and fit it with screws.
The jig facilitates the voltage check and protects the final
amplifier FET when the voltage on the flow side of the TX-
RX unit is checked during repairs.
■Battery Jig (W05-1011-00)
Connect the power cable properly between the battery
jig installed in the transceiver and the power supply, and
be sure output voltage and the power supply polarity prior
to switching the power supply ON, otherwise over voltage
and reverse connection may damage the transceiver, or the
power supply or both.
Note: When using the battery jig, you must measure the
voltage at the terminals of the battery jig. Otherwise, a
slight voltage drop may occur within the power cable, be-
tween the power supply and the battery jig, especially while
the transceiver transmits.
+ Terminal (Red)
– Terminal (Black)
S
–
+
C1
100P/25V
C2
470P/25V
C3
100/25V
R1
1.8M
+
+Terminal
(Red)
–Terminal
(Black)
Power
supply
Power
cable
Schematic diagram
ADJUSTMENT

TK-3302
19
Frequency and Signaling
The transceiver has been adjusted for the frequencies
shown in the following table. When required, re-adjust them
following the adjustment procedure to obtain the frequen-
cies you want in actual operation.
■Frequency (MHz)
• TK-3302 K2,M2
Channel No. RX Frequency TX Frequency
1 495.050 495.100
2 470.050 470.100
3 519.950 519.900
4 495.000 495.000
5 495.200 495.200
6 495.400 495.400
7~16 - -
• TK-3302 K3
Channel No. RX Frequency TX Frequency
1 415.050 415.100
2 400.050 400.100
3 429.950 429.900
4 415.000 415.000
5 415.200 415.200
6 415.400 415.400
7~16 - -
■Signaling
Signaling No. RX TX
1 None None
2 None 100Hz Square Wave
3 QT 67.0Hz QT 67.0Hz
4 QT 151.4Hz QT 151.4Hz
5 QT 250.3Hz QT 250.3Hz
6 DQT D023N DQT D023N
7 DQT D754I DQT D754I
8 DTMF Decode [159D] DTMF Encode [159D]
9 None DTMF Tone 9
ADJUSTMENT
Preparations for Tuning the Transceiver
Before attempting to tune the transceiver, connect the
unit to a suitable power supply.
Whenever the transmitter is tuned, the unit must be con-
nected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a
8Ωdummy load and connected to an AC voltmeter and an
audio distortion meter or a SINAD measurement meter at all
times during tuning.
■Adjustment frequency
TEST CH TK-3302 K2,M2
RX TX
Center 495.050MHz 495.100MHz
Low 470.050MHz 470.100MHz
High 519.950MHz 519.900MHz
Low’ 482.550MHz 482.600MHz
High’ 507.550MHz 507.600MHz
TEST CH TK-3302 K3
RX TX
Center 415.050MHz 415.100MHz
Low 400.050MHz 400.100MHz
High 429.950MHz 429.900MHz
Low’ 407.550MHz 407.600MHz
High’ 422.550MHz 422.600MHz
■List of FPU for transceiver
Model Type FPU
TK-3302 K2,K3,M2 KPG-118D(K)

TK-3302
20
ADJUSTMENT
Fig. 1 Center frequency: K2,M2
Fig. 2 High-edge frequency: K2,M2
Fig. 3 Low-edge frequency: K2,M2
Fig. 4 Center frequency: K3
Fig. 5 High-edge frequency: K3
Fig. 6 Low-edge frequency: K3