Kid Trax Toys Ford Bronco KT1505WM User manual
tWARNING
This manual contains important safety and use informaon.
Keep this manual for future reference.
• An adult must read this enre manual
• Adult supervision is required at all mes
Age: 3–5 years
Weight: Maximum 60 lbs (27 kg)
Maximum Speed: 2.5 MPH
Baery: 6 volt
Owner's Manual
KT1505WM
Styles and colors may vary. Made in China
WARNING WARNING
WARNING
--
--
WARNING
CAUTION
FAILURE TO FOLLOW THE SAFETY INSTRUCTIONS LISTED BELOW MAY RESULT IN SERIOUS INJURY OR DEATH.
The owner’s manual contains assembly, use and maintenance instrucons.
Safe Riding Warnings
• Not be used by children under three (3) years of age or
children over ve (5) years of age
• Do not exceed the maximum weight capacity of 60 lbs. (27kg)
• Do not allow more than one (1) rider.
ADULTS AND SUPERVISORS, PLEASE NOTE:
1. Always instruct all children of common sense rules and
safe pracces.
2. Be aware that at, hard surfaces provide the safest
experience for child riders.
3. Do not allow the child rider to operate the ride-on toy
near streets, roads, sidewalks, walkways, or any other
place where they may encounter other moving vehicles.
4. Never leave children unaended with this ride-on toy.
Connuous adult supervision is required.
5. If necessary, adults and supervisors are always responsible
for seng up gates and barriers to ensure a safe riding
environment for the child rider.
6. Be aware that this ride-on toy does not have braking
capabilies. Allowing use of this ride-on toy in areas that
require braking may cause rolls, crashes, serious injury, or
death to the child rider.
7. Teach children not to allow other children to use this
ride-on toy. Communicate this message to other adults
and supervisors of fellow children with which your
child interacts.
8. Sternly alert children that hands, legs, hair, and clothing
can potenally get caught in moving parts. Ensure they
never place a body part or piece of clothing near a moving
part of the ride-on toy. Avoid loose clothing.
• Baery posts, terminals and related accessories contain lead
and lead compounds (acids) chemicals and are toxic and
corrosive. Never open the baery.
• Contact or exposure to baery leakage (lead acid) may cause
serious injury. If contact or exposure occurs with the skin or
in the eyes, or if the chemical is swallowed, immediately
call 911.
• Use of a baery or charger other than the supplied
rechargeable baery and charger may cause a re or
explosion. Only use the supplied rechargeable baery and
charger with the ride-on toy.
• Do not charge the baery near heat or ammable materials.
• Using the rechargeable baery and charger for any other
product may result in overheang, re or explosion.
Never use the rechargeable baery and charger with
another product.
Re-Charge Interval and Time
Important!
• Damage to the baery may occur if it is allowed to drain
completely. Do not allow the baery to drain completely.
• Check the baery and charger (supply cord, connector) for
wear and damage before charging. Do not charge the
baery if damage has occurred. Do not use an extension
cord when charging the ride-on toy.
• On average you will need to charge the baery for 10 hours
and no more than 24 hours. Failure to charge the baery as
directed could cause permanent damage to the baery and
void the warranty.
• Only an adult who has read and understands the safety
warnings should handle, charge and recharge the baery.
Child Safety Warnings
• Adults supervising children must read and understand this
enre manual before allowing any child to use this product.
• Adults must evaluate their own children as to maturity,
strength, judgment and ability to follow safety rules.
Published age guidelines are not a substute for careful
evaluaon of your own child.
• Adults must teach children about thinking ahead while riding
as this may be the rst me a child has ever controlled a
motorized ride-on toy. While you supervise, see through the
child’s eyes, and verbally teach them about steering and
avoiding obstacles in the approved riding area.
9. Instruct children to always wear shoes when using the
ride-on toy.
10. Conrm that children do not have access to the charging
equipment or come into contact with any part of the
ride-on toy while it is charging.
11. Do not mix old and new baeries.
12. Do not mix alkaline, standard (carbon zinc), or
rechargeable baeries.
13. Firmly instruct children to use the ride-on toy in a safe
manner. Unsafe behaviors include, but are not limited to:
• Traveling at unsafe speeds
• Not riding in the seated posion
• Riding at night or in any condions of low visibility
• Riding in any wet condions including rain, snow,
and ice
• Any kind of stunt riding: jumps, ramps, stairs, hills,
sloped surfaces, or other acons involving any
notable risk
• Any kind of o-road riding: rough terrain, dirt, mud,
gravel, or any others that involve notable risk
• Riding near any pool or open body of water
• Pushing, pulling, or shoving the driver in any way
while operang the ride-on toy
• Using the ride-on toy without the baery cover or any
other safety cover fully closed
• Pulling or hitching the ride-on toy with other similar
moving ride-on toys or products
• Riding a motorized ride-on toy can be a dangerous acvity,
even under the best of circumstances. Good choices regarding
where and when to ride, constant adult supervision of riding,
and pracce and careful riding by the child can all help to
minimize risk. However this ride-on toy is intended to move
and therefore it is possible for the rider to lose control, fall o
and/or get into dangerous situaons that no amount of care,
instrucon or experse can eliminate.
• If this inherent risk is not acceptable, adults should not allow
children to ride this ride-on toy.
Baery and Charging Warnings
The following safety hazards may result in serious injury or death to the user of the ride-on:
• Contact between the posive and negave terminals may
result in re or explosion. Avoid direct contact between the
terminals. Liing the baery by the wires or charger can
cause damage to the baery and may result in a re.
Always li the baery by its case or handles.
• Plug wall charger directly into a wall outlet. Do not use an
extension cord when charging as the use of an extension
cord can cause a re.
• Liquids on the baery may cause re or electric shock.
Always keep all liquids away from the baery and keep the
baery dry.
• Tampering or modifying the electric circuit system may cause
a shock, re or explosion and permanently damage the
system. Exposed wiring, circuitry in the charger may cause
electric shock. Always keep the charger housing closed.
• Regularly check charger, supply cord and connector for wear
and damage. Look for frayed or kinked wires, any exposed
inner wires, any missing insulaon. If any damage is observed
do not plug in the charger and do not charge the baery.
Product Warning
WARNING
This product can expose you to chemicals including lead,
which is known to the State of California to cause cancer
and birth defects or other reproducve harm. For more
informaon go to www.P65Warnings.ca.gov.
Assembly Warnings
• The ride-on toy must be assembled by an adult who has read
and understands the instrucons in this manual.
• Choking hazard to children under the age of 3 years.
This ride-on toy contains small parts that are for adult
assembly only. Keep small children away when assembling.
• Remove and dispose of all protecve materials, plasc bags
and packaging aer assembly.
Electric Shock / Fire Warnings
2 3
Safety
If you are unsure of any informaon in this manual or have a queson regarding assembly or use please call customer service at
877-741-6154. Always keep this manual for reference and include it with resale of the ride-on toy.
• Do not mix old and new baeries.
• Do not mix alkaline, standard (carbon-zinc), or rechargeable
(nickel-cadmium baeries.
Corrosive Material Warnings
Flammable and Explosive Materials Warnings
Hardware Tools Required
To be performed by a supervising adult
Before every ride, it is important to carry out the following
safety checks. Do not ride a baery-powered ride-on toy that is
not in proper working condion! Replace any worn or broken
parts as needed.
Steering and Control
The steering wheel or handlebars are ghtened and
secured in the mount or dashboard.
The steering wheel or handlebars are posioned so that
the rider can easily operate and steer the ride-on.
There must be no diculty for the rider in turning and/or
operang the powered foot pedal or hand operated push
buon.
The steering wheel or handlebars are aligned so that the
steering column and front wheels are oriented in the
same direcon.
Wheels
The wheels are securely aached to the baery-powered
ride-on and they are in good condion. It is acceptable to
have slight lateral movement in each wheel.
The wheels have no holes or are worn down in any one
area and that the tracon strips are intact and secured to
the wheels.
The drive wheel is securely fastened to the gear box, which
houses the motor.
Ride-on
For all electrical components, make sure:
• The baery is fully charged.
• The charging cord is NOT aached to the ride-on in
any way.
• All connectors are securely snapped in place and will
not come detached while riding.
• No wiring is exposed, worn, or detached in any way;
the motor is not hot to touch.
• All electrical buons, including the power buon,
accelerator foot pedal or hand operated buon, and
any buons for lights and sounds, work properly.
• If the ride-on’s electrical components show any sign
of damage or missing parts DO NOT RIDE unl the
condion is corrected.
Make sure the ride-on is:
• Clean, dry, and in good condion.
• All plasc pieces, including fenders, seat, footrests,
steering wheel or handlebars, wheels, bumpers, and/
or hub caps are securely aached.
• There are no cracks or structural problems on the
ride-on toy.
• If the ride-on toy shows any sign of damage or missing
parts DO NOT RIDE IT unl the condion
is corrected.
Make sure all safety labels are in place and readable,
and understood by the rider.
x4
4 5
(2 included)
x8 x4
Parts
Parts Checklist
Pre-Ride Safety Checklist
Before you begin assembling, check that all parts listed are present..
Number Part name Quanty
1Rollbar 1
2Steering wheel 1
3Steering wheel nut (aached to steering wheel) 1
4 Steering wheel bolt (aached to steering wheel) 1
5Seat back 1
6Seat boom 1
7Bronco body 1
8Spacer 1
9Wheel washer 8
10 Wheel 3
11 Wheel nut 4
12 Hubcap 4
13 Gear wheel 1
14 Rear Axle 1
15 Gear box 1
16 Mirror 2
17 Windshield 1
18 Charger 1
1
2
5
18
6
7
4
3
89
10
11
12
14
13
16
15
17
6 7
Assembly
Follow the assembly steps in the order listed below.
❶Remove the nut on the right side of the front
axle and rotate the front axle assembly
completely around unl it is facing towards the
center of the body.
❷Insert the steering column into the axle and
secure with the washer and nut. Rotate each
axle unl it is facing outwards and fasten the
nut back onto the axle assembly.
❸Insert the rear axle completely through the
rear of the rear axle opening in the wheel well.
❹ Aach the le and right rear wheel assembly to
the rear axle.
❺ Aach the le and right front wheel assembly
to the front axle.
❻ Insert the mirrors down into each mirror hole.
❼ Connect the steering wheel wires before
inserng the steering wheel over the end of the
steering column. Secure with nut and bolt.
❽Insert the tabs of the windshield down into the
holes located on the top of the Ford body.
❾ Insert the rollbar down into the rollbar holes.
❿Before aaching the seat make the one-me
baery and gearbox connecon. (See page 8.)
Place the seat boom over the seat cavity and
secure with the 2 screws.
⓫Slide the seat back down into the seat brackets
on each side, and t the boom tabs down into
the seat boom and secure with 2 screws.
⓬ Charge the baery. (See page 9.)
Be sure the gearbox and
wires are completely
inserted through the
gearbox opening.
❶❷
Insert the hubcap
tabs into the 4 slots
on the wheel inset.
❼
❻
To ghten the wheel bolts, place a
wrench on each wheel bolt and
simultaneously turn the wrenches
in the opposite direcons unl
the bolts are ght.
❽
❿
⓫
❾
❹
❹
❺
❺
❸
Steering column inserted
with nut and washer
Completely align the holes in
the steering column with the
holes in the steering wheel.
Hold the steering column ght
against the under-body while
aaching the steering wheel.
8 9
Charge Times
NOTICE
• The baery contains hazardous material that may cause
serious injury or death if handled, connected, or charged
improperly. Only an adult who has read and understands the
warnings and instrucons in this manual should handle,
connect, or charge the baery. Always contact Pacic Cycle at
1-877-741-6154 if you have any quesons or concerns
regarding handling, connecng, or charging the baery.
• Charging the baery more than 24 hours could cause the
baery to explode or ignite resulng in serious injury, death
or property damage. Do not charge the baery for more than
24 hours. Always disconnect the product from the charger
aer the baery is completely charged. Immediately
disconnect the charger from the wall aer the charger
indicator light turns green.
• A damaged supply cord, connector, or charger could cause
burns to the skin, an electrical re, serious injury, death, or
property damage. Always inspect the supply cord, connector,
and charger for damage. (e.g., frayed or kinked wires, exposed
inner wires, missing insulaon) before use. If damaged, do not
use the supply cord, connector or charger for any purpose and
properly dispose.
• Connecng the baery and baery charger to an extension
cord(s) could result in overheang, explosion, re, serious
injury, death, or property damage. Never charge the baery
using an extension cord. Always plug the charger directly into
a wall outlet.
• See addional baery and charging warnings on page 3.
• The baery may become damaged if allowed to drain
completely. Always keep the baery charged.
• The average me to charge the baery is 10 hours. Failure to
follow the instrucons regarding charging the baery may result
in permanent damage to the baery and void the warranty.
WARNING
Make the One-me Baery and Gearbox Connecons
Use
Charge the Baery
Connect the Baery Charger
18
24+
10
First charge
Regular charge
No more than
❶
❷
❸
❹
The product will not turn on
while plugged into the charger.
Remove from charger prior to
turning on.
❷
❶
10 11
Controls and Funcons
Baery Replacement and Disposal
The baery will eventually lose the ability to hold a charge.
Depending on the amount of use, and varying condions, the
baery should operate for one to three years. Follow these steps
to replace and dispose the baery.
Important! Recycle the dead baery responsibly. The baery
contains lead acid (electrolyte) and must be disposed of properly
and legally. It is illegal in most areas to incinerate lead acid
baeries or dispose of them in landlls. Take it to a federal or
state-approved lead acid baery recycler, such as an authorized
service center or your local automove baery retailer. Do not
throw the baery away with your regular household trash!
Maintenance
Service
The ride-on toy should be checked for damage, missing or badly
worn parts before each use.
• Check the ghtness of the fasteners before each use.
• Check the ghtness of the wheels before each use.
• Ensure the baery is securely in place before each use.
• Store the ride-on toy indoors or cover it with a tarp to protect it
from the wet weather. Keep it away from sources of heat, such as
stoves and heaters.
• Do not leave the vehicle in the sun for long periods of me or
fading may occur. Store in shade or cover with tarp.
• Do not wash the vehicle with a hose.
• Do not wash the vehicle with soap and water.
• Clean the vehicle with a so, dry cloth. To restore shine to plasc
parts, use a non-wax furniture polish. Do not use car wax,
abrasive cleaners or wash the vehicle with soap and water. Water
will damage the motor, electrical system and baery.
Do not return this product to the place of purchase. If your ride-on
toy needs service, repairs or replacement parts, call:
Pacic Cycle Consumer Relaons
Hours: 8:00 am – 5:00 pm (CST) Monday - Friday
Phone: 877-741-6154
Email: [email protected]
For a complete list of replacement parts, please contact
Pacic Cycle Consumer Relaons. To order parts, please have
the model and serial number available, which can be found
underneath the seat on the baery cover.
FCC Statement
Any changes or modicaons to this unit not expressly approved by
the party responsible for compliance could void the user's authority
to operate the equipment.
NOTE: This equipment has been tested and found to comply with
the limits for a Class B digital device, pursuant to part 15 of the FCC
Rules. These limits are designed to provide reasonable protecon
against harmful interference in a residenal installaon. This
equipment generates, uses and can radiate radio frequency energy
and, if not installed and used in accordance with the instrucons,
may cause harmful interference to radio communicaons.
However, there is no guarantee that interference will not occur in
a parcular installaon. If this equipment does cause harmful
interference to radio or television recepon, which can be
determined by turning the equipment o and on, the user is
encouraged to try to correct the interference by one or more of
the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separaon between the equipment and receiver.
• Connect the equipment into an outlet on a circuit dierent from
that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.
This ride-on toy contains a sealed
lead acid NON SPILLABLE BATTERY.
This baery must be recycled.
On/O Switch
Forward/Reverse
switch
Horn
Lights
Press the pedal
to accelerate
Maximum
Speed: 2.5 MPH
Li foot o
pedal to stop
12
© 2019 Pacic Cycle Inc.
4902 Hammersley Rd.
Madison, WI 53711
One Year Limited Warranty | Six-Month Limited Warranty on Baery
Pacic Cycle, Inc. (PC) warrants this product to the original retail purchaser as follows: The ride-on toy (except for the baery) is
warranted against defecve materials or workmanship for one year from the date of original purchase. The baery is warranted
against defecve materials or workmanship for six months from the date of original purchase. An original receipt is required to
validate your warranty. PC will, at its opon, provide replacement parts or replace this product. PC reserves the right to substute if
the part or model has been disconnued. To make a claim under this warranty you must contact us at www.kidtraxtoys.com; fax us at
1-800-858-2800, 24 hours a day; write to Kid Trax Consumer Relaons Department, Kid Trax Toys,P.O. Box 344 Olney, IL 62450 or call
1-877-741-6154 from 8 a.m. to 5 p.m., Monday through Friday, CST. Proof of purchase is required, and shipping charges are the
responsibility of the consumer.
Warranty Limitaons
This warranty does not include damages which arise from accident, misuse, abuse, neglect or other causes not arising out of defects
in materials or workmanship, nor does it cover damages arising out of service by other than an authorized PC service center. For
personal use only. Not for commercial use. The original owner shall pay all labor charges connected with the repair or replacement of
all parts. Under no circumstances does this limited warranty include the cost of shipment or transportaon to or from an authorized
repair center or Kid Trax retailer.
Limitaon of Damages
The warranty and remedies as set forth are exclusive and in lieu of all others, oral or wrien, expressed or implied. In no event will PC
or the dealer selling this product be liable to you for any damages, including incidental or consequenal damages, arising out of the
use or inability to use this product. Some states do not allow limitaons as the exclusion or limitaon of incidental or consequenal
damages, so the above limitaons may not apply to you.
Limitaons of Warranes and Warranty Terms
Any warranes, including implied warranes of the merchantability and tness for a parcular purpose, shall be limited to the
duraon and terms of the express wrien warranty. This warranty gives you specic legal rights, and you may have other rights,
which vary from state to state.
Neither PC nor the dealer selling this product authorized any person to create for it any other warranty, obligaon or liability in
connecon with this product.
Pacic Cycle Consumer Relaons
Hours: 8:00 am – 5:00 pm (CST) Monday - Friday
Phone: 877-741-6154
Email: customerservice@kidtraxtoys.com
Warranty
Table of contents
Other Kid Trax Toys Stroller manuals
