Kohler K-16027X-4 Assembly instructions








• 
• 
• 
 
108 mm
(มม.)
97.5 mm
(มม.)
114 mm
(มม.)
48 mm
(มม.)
17°
105 mm (มม.)
390 mm
(มม.)
Max
40 mm
(มม.)
ไม่เกิน
G1/2"
Ø54
Ø37
Ø32
177 mm (มม.)
Ø30~37
K-16027X-4
JULY SINGLE-HOLE LAVATORY FAUCET

INSTALLATION AND CARE GUIDE

©2015 Kohler Co. 1 1106828-X2-C
This document contains the lastest product information
available at time of publication. Kohler reserves the right
to make changes in product characteristics, packaging or
availability at anytime without notice.
The product pictured in the installation steps may differ
from the model being installed.
IMPORTANT NOTICE TO INSTALLERS!: Please
leave these instructions for the consumer. They contain
important information.
•Shut off the main water supplies.
•Flush the water supply pipes thoroughly to remove
debris.
•For new installations, install the faucet and drain to
lavatory before installing the lavatory.
 BEFORE YOU BEGIN
 HANDLE OPERATION
 ROUGH-IN DIMENSION

 Lift the handle gently. Turn left for hot water, right for
cold water.

• 

• 

• 


• 

• 



• 



1106828-X2-C 2 ©2015 Kohler Co.
 INSTALL THE DRAIN
•Thread the mounting stud
into the hole in the bottom of
the faucet body.
•Insert lift rod to the hole of
the body.
•Slide the washer over the
exible hoses and mounting
stud, and into the groove
at the bottom of the faucet
body.
• Insert the exible hoses into
the lavatory hole. Position
the faucet.
•From underside of the
lavatory, place the brackets
(Rubber washer is on the
top) onto the mounting stud,
and secure the faucet with
the nut.
•
Attach the hoses to water
supplies. When facing front
of faucet, the left hose
connects to hot water, the
right hose with “COLD” label
connects to cold water.
•Remove the protective cover
from the ange.
•Apply a ring of plumbers
putty or other sealant to the
underside of the ange
according to the putty
manufacturer’s instructions.
• Assemble the nut, at
washer, and tapered gasket
(tapered side up) fully onto
the body.
•From the underside of the
xture, insert the drain body
up into the drain hole.
• From the top of the xture,
securely hand tighten the
ange onto the drain body.
•Make sure the drain body
seal hole is facing the back
of the xture, and securely
tighten the nut.
• Remove any excess sealant.
•Press the seal into the seal
hole on the body.
•Insert the stopper into the
ange.
•Fit the rod through the hole
in the stopper. Hand tighten
the body nut.
Lift Rod
Washer
Flexible Hose
Faucet Body
Stud
Rubber Bracket
Bracket
Nut
แหวนรองยางรูปเกือกมา
แหวนรอง
รูปเกือกมา
ตัวกอก
สายน้ำดี
แหวนรอง
สลักเกลียว
นอต
กานยกสะดืออาง
• 
• 
 
 
• 
 
 
• 
 
 
• 
 
• 
 
 
• 
• 
• 
• 
 
Body Nut
Link
Link
Clip
Clip
Screw
Screw
Stopper
Flange
Apply
the sealant
Gasket
Washer
Nut
Body
Tailpiece
Seal Hole
Rod
Faucet
แหวนรอง
หนาแปลน
ทากาว
ตัวอุด
สะดืออาง
ประเก็น
นอต
นอต
ทอตอสะดืออาง
รูทอสะดือ
กานโยก
สกรู
สกรู
คลิป
คลิป
กานตอ
กานตอ
ทอ
กอกนํ้า
 INSTALL THE FAUCET

Lever
Bonnet
Plug Button
Screw
Nut
O-ring
Cartridge Seat
Aerator
Mounting Hardware
1110391
834791
3008523
833438
3008435
871472
O-ring
880085
O-ring
1080817
Stopper
880008
O-ring
880084
Valve
834460
Lift Rod
834799
Hose
834754
3008414
837261
836664
Pop Up Drain
834753
Link Kit
880037
Washer
880406
กานโยก
ฝาครอบ
ปลั๊ก
สกรู
นอต
แหวนยางโอ-ริง
แหวนยางโอ-ริง
แหวนยางโอ-ริง
ฝาปด
แหวนยางโอ-ริง
วาลว
กานยกสะดืออาง
สายน้ำดี
ฐานรองวาลว
ปากกอก
อุปกรณยึดกอกน้ำ
สะดืออางแบบปอปอัพ
ชุดแกนยก
สะดืออาง
แหวนรอง
K-16027X-4
**Color code must be specied when ordering.

NOTE: For all Asia pacic regions (excluding China) add SP (SPxxxxxxx**) in front of the part number when ordering.

©2015 Kohler Co. 3 1106828-X2-C
 SERVICE PARTS
•Remove and adjust the stopper as
needed so it lifts about 3/8” (1 cm)
when opened. To adjust, rotate the
threaded stopper rod in or out as
needed. Retighten the stopper nut.
•Slide one end of the clip onto the
rod. Slide the link onto the rod with
the thumbscrew facing the back of
the xture.
•Squeeze the other end of the clip,
aligning the hole with the rod.
•Move the link to the proper position
by squeezing the clip and sliding it
along the rod.
•Insert the lift rod into the hole in the
faucet and then into the hole in the
link.
•Tighten the thumbscrew onto the
link so the top of lift rod high from
mounting surface can not exceed
2-3/8” (6 cm) when the drain is
closed.
• 

 
 
• 


• 
 
• 

• 
 
• 



Body Nut
Link
Link
Clip
Clip
Screw
Screw
Stopper
Flange
Apply
the sealant
Gasket
Washer
Nut
Body
Tailpiece
Seal Hole
Rod
Faucet
แหวนรอง
หนาแปลน
ทากาว
ตัวอุด
สะดืออาง
ประเก็น
นอต
นอต
ทอตอสะดืออาง
รูทอสะดือ
กานโยก
สกรู
สกรู
คลิป
คลิป
กานตอ
กานตอ
ทอ
กอกนํ้า

การรับประกันสินค้า LIMITED WARRANTY
Kohler (Thailand) Public Company Limited warrants to the original
products, which are purchased from authorized distributors and dealers
within Kingdom of Thailand only, to be free of defects in material and
workmanship.
Within the below mentioned periods from the date of purchase,
Kohler(Thailand) Public Company Limited will at its election, repair,
replace or make appropriate adjustment where company’s inspection
disclose any such defect occurring in normal usage and maintenance
but is not responsible for labor charges, removal charges, installation,
or other incidental or consequential costs. In no event shall the liability of
Kohler(Thailand) Public Company Limited exceed the purchase price
of the product. This warranty applies only to Kohler Faucets installed in
Thailand.
• Ceramic Valve(leak/drip)
- Lifetime Limited Warranty* for residential use
- and Five (5) Years for commercial use
• Finish Five(5) Years
• Fitting Five(5) Years
• Automatic faucet One(1) Year
• Hygiene spray(leak/drip Five(5) Years for selected models
from hygiene spray body) only
• Shower Five(5) Years
• Bathroom accessories Five(5) Years
This limited warranty DOES NOT COVER the defect or damage caused
by accident, natural disasters such as fire, flood, or earthquake, misuse
or abuse of products. Improper care and cleaning will avoid the warranty.
Consumers are responsible for the cost of service parts and service
fee for such cases.
To ensure continuous product quality and performance, as well as
product durability and lifetime, without any damage to the product,
consumers should purchase and use only genuine service parts and
after-sales services from Kohler (Thailand) Public Company Limited or
company’s authorized service centers, distributors, or dealers only.
*KOHLER® Faucet Lifetime Limited Warranty
Kohler (Thailand) warrants its faucets manufactured after January 1,
1997, to be leak and drip free during normal residential use for as long as
the original consumer purchaser owns his or her home. If the faucet
should leak or drip during normal use, Kohler (Thailand) will, free of
charge; replace
the new cartridge necessary to put the faucet in good
working condition.
Kohler (Thailand) also warrants all other aspects of the faucet or
accessories (“Faucet”)**to be free of defects in material and workmanship
during normal residential use for as long as the original consumer
purchaser owns his or her home. If a defect is found in normal residential
use, Kohler (Thailand) will, at its election, repair, provide a replacement
part or product, or make appropriate adjustment. Damage to a product
caused by accident, misuse, or abuse is not covered by this warranty.
Improper care and cleaning will also void the warranty.
Proof of purchase (original sales receipt) must be provided to
Kohler (Thailand) with all warranty claims. Kohler (Thailand) is not responsible
for labor charges, installation, or other incidental or consequential costs.
In no event shall the liability of Kohler (Thailand) exceed the purchase
price of the Faucet.
Important: Never use cleaners containing abrasive cleansers, ammonia,
bleach, acids, waxes, alcohol, solvents or other products not recommended
for chrome. This will void the warranty.
To obtain warranty service, please contact your dealers or contact the
KOHLER (Thailand) Call Center, together with proof of purchase at;
Call Center
KOHLER (Thailand) Public Company Limited
16th Floor, Jasmine City Building
2 Soi Sukhumvit 23, Sukhumvit Road,
Wattana, Bangkok 10110
Tel: [phone] Fax: [phone]
Email: [email protected]
COPYRIGHT ©2015 BY KOHLER (THAILAND) PUBLIC COMPANY
LIMITED
1106828-X2-C 4 ©2015 Kohler Co.
Call Center Tel. +(66) 2204 6222
E-mail: [email protected]