Komatsu WA470-6 2006 Manual

Operation & Maintenance
Manual
WA470-6
WHEEL LOADER
SERIAL NUMBERS H50051 and up
VEAM946100
WARNING
Unsafe use of this machine may cause serious injury or
death. Operators and maintenance personnel must read
this manual before operating or maintaining this
machine. This manual should be kept near the machine
for reference and periodically reviewed by all personnel
who will come into contact with it.
NOTICE
Komatsu has had the operating and maintenance in-
structions translated into all the languages of the mem-
ber states in the European Union. Should you wish to
have a version of the operating instructions in another
language, please dont hesitate to ask at your local
dealers.
© 2006 Komatsu Hanomag GmbH
All Rights Reserved
Printed in Europe 10-2006

Foreword
WA470-6H – VEAM946100 1-1
1. Foreword

1.1 Foreword Foreword
1-2 WA470-6H – VEAM946100
1.1 Foreword
This manual provides rules and guidelines which will help you
use this machine safely and effectively. The precautions in this
manual must be followed at all times when performing operation
and maintenance. Most accidents are caused by the failure to
follow fundamental safety rules for the operation and mainte-
nance of machines. Accidents can be prevented by knowing
beforehand conditions that may cause a hazard when perform-
ing operation and maintenance.
WARNING
!Operators and maintenance personnel must always do as
follows before beginning operation or maintenance.
!Always be sure to read and understand this manual thor-
oughly before performing operation and maintenance.
!Read the safety messages given in this manual and the
safety labels affixed to the machine thoroughly and be sure
that you understand them fully.
!Keep this manual at the storage location for the Operation
and Maintenance Manual given below, and have all person-
nel read it periodically.
!If this manual has been lost or has become dirty and cannot
be read, request a replacement manual immediately from
KOMATSU or your KOMATSU distributor.
!If you sell the machine, be sure to give this manual to the
new owners together with the machine.
!KOMATSU delivers machines that comply with all applicable
regulations and standards of the country to which it has
been shipped. If this machine has been purchased in
another country or purchased from someone in another
country, it may lack certain safety devices and specifications
that are necessary for use in your country. If there is any
question about whether your product complies with the
applicable standards and regulations of your country, consult
KOMATSU or your KOMATSU distributor before operating
the machine.
Storage location for the Operation and Maintenance Manual:
Pocket (1) at rear of operator's seat
GK032001
1

Foreword 1.1 Foreword
WA470-6H – VEAM946100 1-3
1.1.1 EU Directives
Machines supplied by us fulfil the Directive for Machinery 89/
392/EEC and all supplements. If the machine is being used in
another country, it is possible that certain safety regulations and
specifications may not be fulfilled for use in that country. For
example, priority vehicle warning lamps may be used in some
countries, but are forbidden in others.
Please contact our dealer before using the machine if you have
any questions regarding the fulfilment of standards and regula-
tions in a specific country.
Notes on subsequent installation of electrical and elec-
tronic equipment and components
Electrical and electronic equipment and/or components which
have been installed subsequently, emit electromagnetic radia-
tion which can influence the function of the electronic compo-
nents and sections of the machine. This can have an influence
on the safety of the machine and endanger persons. For this
reason, please ensure that the following safety instructions are
observed.
If you are installing electrical or electronic equipment and/or
components in the machine and connect them to the vehicle
electrical system, you must check at own responsibility that the
installations do not cause any disturbance to the vehicle’s elec-
tronic system or other components. Above all, you must ensure
that any subsequently installed electrical and electronic compo-
nents comply with the EMV Directive 89/336/EEC in its current
edition and bear the CE mark.
The following requirements also have to be met for subsequent
installation of mobile communication systems (e.g. radio, tele-
phone):
!Only equipment approved by national legislation (e.g. BZT
approval for Germany) may be used
!The unit must be fixed in position
!Portable or mobile units may only be used inside the vehi-
cles if they are connected to a fixed outside antenna
!The transmitter unit must be spatially separated from the
vehicle’s electronic system
!Make sure when installing the antenna that this is installed
correctly with good earth connection between antenna and
vehicle mass
Also observe KOMATSU and manufacturer’s installation instruc-
tions for wiring, installation and maximum permitted power con-
sumption.

1.2 Safety information Foreword
1-4 WA470-6H – VEAM946100
1.2 Safety information
To enable you to use this machine safely, safety precautions and
labels are given in this manual and affixed to the machine to give
explanations of situations involving potential hazards and of the
methods of avoiding such situations.
1.2.1 Signal words
The following signal words are used to inform you that there is a
potential hazardous situation that may lead to personal injury or
damage.
In this manual and on machine labels, the following signal words
are used to express the potential level of hazard.
DANGER
Indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
Indicates a potentially hazardous situation which, if not avoided,
could result in death or serious injury.
CAUTION
Indicates a potentially hazardous situation which, if not avoided,
may result in minor or moderate injury. This word is used also to
alert against unsafe practices that may cause property damage.
Example of safety message using signal word
WARNING
When standing up from the operator's seat, always place the
work equipment lock lever in the LOCK position.
If you accidentally touch the control levers when they are not
locked, this may cause a serious injury or death.

Foreword 1.2 Safety information
WA470-6H – VEAM946100 1-5
Other signal words
In addition to the above, the following signal words are used to
indicate precautions that should be followed to protect the
machine or to give information that is useful to know.
NOTE
This word is used for precautions that must be taken to avoid
actions which could shorten the life of the machine.
REMARK
This word is used for information that is useful to know.

1.2 Safety information Foreword
1-6 WA470-6H – VEAM946100
1.2.2 Safety labels
Safety labels are affixed to the machine to inform the operator or
maintenance worker on the spot when carrying out operation or
maintenance of the machine that may involve hazard.
For details of safety labels, see "Safety labels (2-2)".
Safety labels using pictogram
Safety pictograms use a picture to express a level of hazardous
condition equivalent to the signal word. These safety pictograms
use pictures in order to let the operator or maintenance worker
understand the level and type of hazardous condition at all
times. Safety pictograms show the type of hazardous condition
at the top or left side, and the method of avoiding the hazardous
condition at the bottom or right side. In addition, the type of haz-
ardous condition is displayed inside a triangle and the method of
avoiding the hazardous condition is shown inside a circle.
KOMATSU cannot predict every circumstance that might involve
a potential hazard in operation and maintenance. Therefore, the
safety messages in this manual and on the machine may not
include all possible safety precautions.
If any procedures or actions not specifically recommended or
allowed in this manual are used, it is your responsibility to take
the necessary steps to ensure safety.
In no event should you engage in prohibited uses or actions
described in this manual.
The explanations, values, and illustrations in this manual were
prepared based on the latest information available at that time.
Continuing improvements in the design of this machine can lead
to changes in detail which may not be reflected in this manual.
Consult KOMATSU or your KOMATSU distributor for the latest
available information of your machine or for questions regarding
information in this manual.
GK032002
Part No

Foreword 1.3 Introduction
WA470-6H – VEAM946100 1-7
1.3 Introduction
This loader is a machine with independent transmission, moving
on chains or wheels. Driving in forward direction, the loader can
load or dig material using its attachments intended for loading
operations (i.e. bucket).
This KOMATSU machine is designed to be used mainly for the
following work:
!Digging work
!Smoothing
!Pushing work
!Loading work
For details of the operating procedure, see "Work possible using
wheel loader (3-130)".
1.3.1 Intended use
If you use the machine for any other purpose than specified
above, we will not accept any responsibility for safety. All consid-
erations concerning safety will then be up to the owner or the
operating and maintenance personnel. In any case, neither you
nor any other person are/is authorised to perform work and func-
tions explicitly prohibited in these operating instructions.
The transport of persons in the work equipment is strictly
forbidden!
For details of the operating procedure, see "Work possible using
wheel loader (3-130)".

1.3 Introduction Foreword
1-8 WA470-6H – VEAM946100
1.3.2 Directions of machine
In this manual, the directions of the machine (front, rear, left,
right) are determined according to the view from the operator's
seat in the direction of travel (front) of the machine.
1.3.3 Visibility from operator's seat
The visibility standards (ISO 5006) for this machine require a
view shown in the diagram on the right side.
Visibility in immediate area
The visibility of this machine in the area 1 m from the outside
surface of the machine at a height of 1.5 m is shown in the dia-
gram on the right side. The hatched area (A) shows the area
where the view is blocked by part of the machine when mirrors
or other aids to visibility are installed as standard. Please be fully
aware that there are places that cannot be seen when operating
the machine.
GK032003
Front
Rear
RightLeft
Bucket
GK038001
1 m
1 m

Foreword 1.3 Introduction
WA470-6H – VEAM946100 1-9
12-M Radius visibility
The visibility at a radius of 12 m from the machine is as shown in
the diagram below. The hatched areas (B) show the areas
where the view is blocked when mirrors or other aids to visibility
are installed as standard. Please be fully aware that there are
places that cannot be seen when operating the machine.
GK038002
12m

1.4 Necessary information Foreword
1-10 WA470-6H – VEAM946100
1.4 Necessary information
When requesting service or ordering replacement parts, please
inform your KOMATSU distributor of the following items.
1.4.1 Product Identification Number (PIN)/Machine serial no. plate and
position
On the center right of the front frame.
1.4.2 Engine serial no. plate and position
It is at the top at the rear of the engine on the right side of the
machine.
EPA: Environmental Protection Agency, U.S.A.
GK038003GB
GK047001

Foreword 1.4 Necessary information
WA470-6H – VEAM946100 1-11
1.4.3 ROPS/FOPS-Cab serial no. plate
This plate is located on the right inside cab on the rear beam.
1.4.4 Axle serial no. plate
This plate is located on the right of front axle and on the left of
rear axle.
1.4.5 Transmission serial no. plate
This plate is located in travel direction front, above the transmis-
sion output.
GK032006
WARNING
GK032007
GK032008

1.4 Necessary information Foreword
1-12 WA470-6H – VEAM946100
1.4.6 Seat operator serial no. plate
This plate is located in front of seat, covered by the bellows.
1.4.7 Position of service meter
The service meter is displayed on the character display at the
bottom center of the machine monitor.
1.4.8 Table to enter serial no. and distributor
GK032009
GK038005
Machine serial No.
Engine serial No.
Product identification
number (PIN)
Distributor name
Address
Service Personnel
Phone/Fax

Foreword 1.5 Contents
WA470-6H – VEAM946100 1-13
1.5 Contents
1. Foreword . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
1.1 Foreword . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
1.1.1 EU Directives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
1.2 Safety information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
1.2.1 Signal words . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
1.2.2 Safety labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
1.3 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7
1.3.1 Intended use. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7
1.3.2 Directions of machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-8
1.3.3 Visibility from operator's seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-8
1.4 Necessary information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10
1.4.1 Product Identification Number (PIN)/Machine serial no. plate and position . . . . . . . . . 1-10
1.4.2 Engine serial no. plate and position . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10
1.4.3 ROPS/FOPS-Cab serial no. plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11
1.4.4 Axle serial no. plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11
1.4.5 Transmission serial no. plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11
1.4.6 Seat operator serial no. plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12
1.4.7 Position of service meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12
1.4.8 Table to enter serial no. and distributor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12
1.5 Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-13
1.6 Dimensions, weights and operating data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-20
1.6.1 WA470-6H: Dimensions, weights and operating data . . . . . . . . . . . . . . . . . . . . . . . . . 1-20
1.7 CE-Conforming equipment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-21
1.7.1 CE-Conforming equipment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-21
1.7.2 Manufacturer-supplied CE-Conforming equipment, according to
document 419-93-H1250 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-22
2. Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
2.1 Safety labels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
2.1.1 Location of safety labels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
2.1.2 Presentation of safety labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
2.2 General precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-7
2.3 Precautions for operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-20
2.3.1 Starting engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-20
2.3.2 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-22
2.3.3 Transportation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-29
2.3.4 Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-31
2.3.5 Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-33
2.4 Precautions for maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-34
2.5 Precautions with tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-43

1.5 Contents Foreword
1-14 WA470-6H – VEAM946100
3. Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
3.1 General view . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
3.1.1 General view of machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
3.1.2 General view of controls and gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
3.2 Explanation of components. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
3.2.1 Machine monitor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Types of warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Central warning lamp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9
Character display portion. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10
Emergency stop item. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Caution items. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19
Inspection and maintenance item . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-22
Pilot display portion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-26
Meter display portion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-32
Other functions of machine monitor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-35
3.2.2 Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-40
3.2.3 Control levers, pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-56
3.2.4 Steering tilt lock lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-63
3.2.5 Cap with lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-64
3.2.6 Safety bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-65
3.2.7 Towing pin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-66
3.2.8 Grease pump. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-66
3.2.9 Cab door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-67
3.2.10 Cab door open lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-67
3.2.11 Cab window open lock. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-68
Cab left window open lock reset knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-68
Cab right window open lock reset knob. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-68
Reset right window open lock for escape . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-68
3.2.12 Backup alarm. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-69
3.2.13 Fuse. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-70
Fuse capacity and name of circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-70
3.2.14 Slow blow fuse. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-71
3.2.15 Power outlet. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-72
3.2.16 Air conditioner (standard) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-73
General locations and function of control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-73
Method of operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-76
Precautions when using . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-78
Precautions for inspection and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-78
Cool box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-79
3.2.17 Air conditioner (automatic). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-80
General locations and function of control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-80
Method of operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-84
Precautions when using . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-86
Precautions for inspection and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-86
3.2.18 Handling cab wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-87
Preventing damage to wiper arm bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-87

Foreword 1.5 Contents
WA470-6H – VEAM946100 1-15
3.3 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-88
3.3.1 Check before starting engine, adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-88
Walk-around check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-88
Check before starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-91
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-99
Safety belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-100
Adjust lever stand. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-101
Adjusting mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-102
Operations and checks before starting engine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-103
3.3.2 Starting engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-105
Normal starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-105
Starting in cold weather . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-107
Automatic warming-up operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-109
3.3.3 Operations and checks after starting engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-110
Breaking-in the machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-110
Normal operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-111
3.3.4 Stopping engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-113
3.3.5 Check after stopping engine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-113
3.3.6 Moving the machine (directional, speed), stopping the machine . . . . . . . . . . . . . . . . 3-114
Preparations for moving the machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-114
Changing gear speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-117
Changing direction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-118
Using switch to change between forward and reverse. . . . . . . . . . . . . . . . . . . . . . . . 3-120
Stopping the machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-122
Transmission cut-off function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-123
3.3.7 Turning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-125
Emergency steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-126
3.3.8 Operation of work equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-128
Lift arm operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-129
Bucket operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-129
3.3.9 Work possible using wheel loader . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-130
Digging operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-130
Leveling operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-134
Pushing operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-134
Load and carry operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-134
Loading operations. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-135
3.3.10 Precautions for operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-137
Permissible water depth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-137
If wheel brake does not work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-137
Precautions when driving up or down slopes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-137
3.3.11 Adjusting work equipment posture . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-140
Adjusting boom kickout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-140
Adjusting bucket positioner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-141
Bucket level indicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-141
3.3.12 Parking machine. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-142
3.3.13 Checks after completion of operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-144
Before stopping engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-144
After stopping engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-144
3.3.14 Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-145

1.5 Contents Foreword
1-16 WA470-6H – VEAM946100
3.3.15 Handling the tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-146
Precautions when handling tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-146
Tire pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-146
Precautions for using load and carry method . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-148
3.4 Transportation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-149
3.4.1 Transportation procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-149
3.4.2 Loading, unloading work with trailers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-149
Loading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-150
Securing machine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-150
Unloading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-152
3.4.3 Lifting machine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-153
Location of lifting position mark . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-154
Weight table. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-154
Lifting procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-155
3.5 Cold weather operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-156
3.5.1 Precautions for low temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-156
Fuel and lubricants . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-156
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-156
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-157
3.5.2 Precautions after completion of work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-158
3.5.3 After cold weather . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-158
3.5.4 Warming-up operation for steering hydraulic circuit in cold weather . . . . . . . . . . . . . . 3-159
3.6 Long-term storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-160
3.6.1 Before storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-160
3.6.2 During storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-160
3.6.3 After storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-161
3.7 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-162
3.7.1 When machine runs out of fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-162
3.7.2 Towing the machine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-162
When engine can be used. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-165
When engine cannot be used . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-165
Releasing parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-166
Emergency travel operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-168
3.7.3 If battery is discharged . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-169
Removal and installation of battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-170
Precautions for charging battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-170
Starting engine with booster cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-171
3.7.4 Other trouble . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-173
Electrical system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-173
Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-174
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-176

Foreword 1.5 Contents
WA470-6H – VEAM946100 1-17
4. Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4.1 Guides to maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
4.2 Outlines of service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
4.2.1 Handling oil, fuel, coolant, grease and carrying out KOWA
(KOMATSU Oil Wear Analysis) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Coolant and water for dilution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9
Grease . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Carrying out KOWA (KOMATSU Oil Wear Analysis) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Storing oil and fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
4.2.2 Outline of electric system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
4.3 Wear parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
4.3.1 Wear parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
4.4 Fuel, coolant and lubricants. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
4.4.1 Lubrication chart. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
4.4.2 Use of fuel, coolant and lubricants according to ambient temperature . . . . . . . . . . . . 4-19
4.4.3 Recommended brands, recommended quality for products other than
KOMATSU genuine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
4.5 Standard tightening torques for bolts and nuts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
4.5.1 Torque list. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
4.6 Periodic replacement of safety critical parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
4.7 Maintenance schedule chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
4.7.1 Maintenance schedule chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
4.8 Replace injector assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-30
4.9 Service procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
4.9.1 Initial 50 hours service (only after the first 50 hours) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
Check for loose wheel hub bolts, tighten . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
4.9.2 Initial 250 hours service (only after the first 250 hours) . . . . . . . . . . . . . . . . . . . . . . . . 4-31
Replace transmission oil filter cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
Replace hydraulic tank filter element . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
4.9.3 Initial 1000 hours service (only after the first 1000 hours) . . . . . . . . . . . . . . . . . . . . . . 4-31
Check engine valve clearance, adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
4.9.4 When required . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
Clean, replace air cleaner element. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
Clean inside of cooling system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
Check transmission oil level, add oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
Check axle oil level, add oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
Clean axle case breather . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
Clean air conditioner condenser. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Check window washing fluid level, add fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
Clean radiator fins and cooler fins . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
Turn, replace bolt on cutting edge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
Replace bucket teeth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-48

1.5 Contents Foreword
1-18 WA470-6H – VEAM946100
Check air conditioner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-49
Replace slow blow fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
Checking function of accumulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Selection and inspection of tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-53
4.9.5 Check before starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
Check before starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
4.9.6 Every 50 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
Drain water, sediment from fuel tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
4.9.7 Every 100 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Lubricate rear axle pivot pin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Check oil level in hydraulic tank, add oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Clean element in air conditioner fresh air filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-57
4.9.8 Every 250 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-58
Check battery electrolyte level. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-58
Check parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-61
Check alternator belt tension, adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-61
Check air conditioner compressor belt tension, adjust . . . . . . . . . . . . . . . . . . . . . . . . . 4-63
Check for loose wheel hub bolts, tighten. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
Clean element in air conditioner recirculation filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
Checking function of accumulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-66
Lubricating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-67
4.9.9 Every 500 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
Change oil in engine oil pan, replace engine oil filter cartridge . . . . . . . . . . . . . . . . . . . 4-68
Replace fuel pre-filter cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-70
4.9.10 Every 1000 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-72
Replace fuel main filter cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-72
Change oil in transmission case and transmission oil filter cartridge,
clean strainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-74
Clean transmission case breather . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-75
Lubricating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-76
Check of engine air intake piping clamps for looseness . . . . . . . . . . . . . . . . . . . . . . . . 4-76
Replace corrosion resistor cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-76
4.9.11 Every 2000 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-77
Change oil in hydraulic tank, replace hydraulic filter element . . . . . . . . . . . . . . . . . . . . 4-77
Replace hydraulic tank breather element . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-80
Change axle oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-81
Replace element in air conditioner recirculation air filter, fresh air filter . . . . . . . . . . . . 4-82
Check brake disc wear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-82
Checking function of accumulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-84
Check alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
Check engine valve clearance, adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
Check vibration damper. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
4.9.12 Every 4000 hours service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
Lubricating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-86
Check water pump. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Check air conditioner compressor, adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Check for loose engine high-pressure piping clamps, hardening of rubber . . . . . . . . . 4-88
Checking for missing fuel spray prevention cap, hardening of rubber. . . . . . . . . . . . . . 4-88
Check starting motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89