Kumio ICM1234 User manual

THANK YOU FOR CHOOSING OUR ICE MAKER
PLEASE READ THE MANUAL CAREFULLY BEFORE OPERATING
IC E MAKER
INSTRUCTION MANUAL
Model: ICM1234

1
IMPORTANT NOTICES
When using an electrical appliance, basic safety precautions should
always be followed to reduce the risk of fire, electric shock, and/or
injury, including the following:
1. Read all instructions before using.
2. Remove all packing material and carefully check your ice maker
to ensure it is in good condition and that there is no damage to
the ice maker or power cord and plug.
3. If the supply cord is damaged, it must be replaced by the
manufacturer or its service agent or a similarly qualified person in
order to avoid a hazard.
4. This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities, or
lack of experience and knowledge, unless they have been given
supervision or instruction concerning use of the appliance by a
person responsible for their safety. Children should be
supervised to ensure that they do not play with the appliance.
This appliance can be used by children aged from 8 years and
above and persons with reduced physical, sensory or mental
capabilities or lack of experience and knowledge if they have
been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
Children shall not play with the appliance. Cleaning and user
maintenance shall not be made by children without supervision.
5. This appliance is intended to be used in household and similar
applications such as
–staff kitchen areas in shops, offices and other working
environments;
–farm houses and by clients in hotels, motels and other
residential type environments;

2
–bed and breakfast type environments;
6. –Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are of the
type recommended by the manufacturer.
–WARNING: When positioning the appliance, ensure the supply
cord is not trapped or damaged.
–WARNING: Do not locate multiple portable socket-outlets or
portable power supplies at the rear of the appliance.
–WARNING: fill with potable water only.
7. Before using the Ice maker for the first time, please wait 2 hours
after positioning it, and keep the transparent lid open for at least
2hours
8. Pure water is not allowed to be used on this unit, spring water is
recommended.
9. Ensure the voltage is compliant with the voltage range stated on
the rating label, and ensure the earthing of the socket is in good
condition.
10.Do not upend this product or incline it over a 45℃angle.
11.To protect against risk of electric shock, do not pour water on
cord, plug and ventilation, immerse the appliance in water or any
other liquid.
12.Unplug the appliance after using or before cleaning.
13.Keep the appliance 8cm from other objects to ensure the good
heat releasing.
14.Do not use the accessories which are not recommended by
Manufacturer.
15.Do not use the appliance close by flames, hot plates or stoves.
16.Do not switch on the power button frequently (ensure 5min.
interval at least) to avoid the damage of compressor.
17.Do not use outdoors.

3
18.Never clean with scouring powders or hard implements.
19.Please keep the instruction manual.
20.To avoid contamination of food, please respect the following
instructions:
–Opening the door for long periods can cause a significant
increase of the temperature in the compartments of the
appliance.
–Clean regularly surfaces that can come in contact with food
and accessible drainage systems.
–Clean water tanks if they have not been used for 48 h; flush the
water system connected to a water supply if water has not been
drawn for 5 days.
–If the refrigerating appliance is left empty for long periods,
switch off, defrost, clean, dry, and leave the door open to prevent
mould developing within the appliance.)
21.Regarding the information pertaining to the use of the appliance,
please refer to the paragraphs below.

SPECIFICATIONS
Model number：ICM1234
Daily ice output：26 lbs.（12kg） / 24 hours
Ice storage capacity：1.6L/850g
Refrigerant：R600a
Compression-type refrigeration: 110-120V/60Hz
Water tank capacity：1.5 L
Voltage：AC 110-120V
Frequency：60 Hz
Power consumption：120 W
Max overall dimensions(W×D×H)：228x320x297 mm
Packing dimensions(L×W×H)：392×304×361 mm
N.W.：15.87lbs/7.2kg
G.W.：18.08lbs/8.2kg
4

DESCRIPTION
Upper cover
Transparent lid
Micro switch support
Ice shovel board
Ice collecting tray
Front housing
Silica gel stopple at
water outlet
Ice shovel
Buttons
Control panel
Water box
Bullet evaporator
Motor support
Rear housing
Water tank
Vents
5

FEATURE
Quick ice making
Prompt when the ice is full and water is insufficient
Bullet ice
9 pcs ice can be made in nine minutes
Large and small ice can be made
Self -cleaning function
1. During transportation, do not tilt the machine more than 45
degrees, do not reverse the machine. This may damage the
compressor and the sealing system.
2. Remove all packing materials, check the machine carefully and
make sure that the machine, power cord and plug are normal.
3. The machine should be on a level surface. To ensure sufficient
ventilation, the distance of the back of ice maker to the wall should
be at least 150mm, it should be away from the oven, radiator or other
heat source.
4. Before using the machine for the first time, place the machine and
leave the transparent cover open for at least two hours.
5. Make sure that the home voltage is consistent with the voltage
indicated by the machine.
6. Distilled water is not allowed. Mineral water is recommended.
7. When the indoor temperature is lower than 15 degrees, please
choose small ice. When the indoor temperature is higher than 30
degrees, it is recommended to choose large ice.
6

CONTROL PANEL OPERATION
POWER: ON-OFF switch button
SELECT: Mode selection button
ICE FULL: Ice full alarm indicator light
ADD WATER: Water shortage alarm indicator light
L: Large ice indicator light
S: Small ice indicator light
1). Plug in the power, the "L" indicator light flashes, and the machine
will start the deicing function. Press the POWER button, the "L"
indicator light is always on and then the ice block will be made
automatically. After the ice making is completed, the deicing will be
carried out, and then the ice shoveling function will be entered, and
so on. Press the SELECT button to select large ice and small ice
7

modes, press the POWER button once to enter the selected mode.
When the indoor temperature is lower than 15 degrees, please
choose small ice. When the indoor temperature is higher than 30
degrees, it is recommended to choose large ice.
2). ADD WATER: water shortage alarm
When the “ADD WATER” light turns red, it means that there is water
shortage in the water tank. You need to add water and press the
POWER button to restart the machine.
3) ICE FULL: Ice full alarm
When the ice reaches the maximum capacity of the ice storage
container, the "ICE FULL"indicator light flashes, and the machine
stops. At this time, the ice needs to be poured out. When the ice
position is lower than the full sensor position, the machine will restart
automatically.
4) CLEAN: Cleaning function
Plug in the power, hold the POWER button for 3 seconds to start up
the self-cleaning function. The machine first deicing once, and then
starts cleaning. Each cleaning has 5 cycles (pumping
water—pouring water). The “L” large ice indicator light and “S”
small ice indicator light flash alternately. Do not disconnect the power
supply during the cleaning. After the cleaning, the product
automatically enters the standby mode.
8

OPERATING INSTRUCTIONS
Step 1
Open the lid and take out the ice collecting tray and add water to the
reservoir.
Note: There is a maximum scale MAX in the reservoir. The water
should not exceed the MAX position. If the water exceeds the
maximum scale MAX, you need to open the bottom drain plug,
release the excess water, and cover with a transparent cover.
Step 2
Plug in the power and press the POWER button to start the machine.
1. The three cycles used for the first time, the ice produced is small
and irregular.
2. When the ice collecting tray is full, please take out the ice
immediately, do not let the ice overflow the ice collecting tray.
CLEANING & USE GUIDANCE
1. Clean the inner liner, ice collecting tray, water box, ice shovel,
ect frequently. When cleaning, unplug the unit and remove the
ice cubes. Use a diluted solution of water and vinegar to clean
the inside and the outside surface of the Ice maker. Do not spray
ice maker with chemicals or diluted agents such as acids,
gasoline or oil. Rinse thoroughly before starting.
2. Keep ventilation openings in the appliance enclosure, or in the
built-in structure, clear of obstruction. Do not use mechanical
devices or other means to accelerate the defrosting process,
9

other than those recommended by the manufacturer.
3. Reuse the machine after being idled for a period of time, it may
not have enough water to pump for air blockage, in this case, the
water shortage indicator “ADD WATER”will light up, just
repress POWER button to restart the ice maker.
4. To ensure the cleanness of ice, please change water for water
reservoir at least once one day. If do not use for a long time,
please drain the water out and clean it up.
5. If the compressor takes a strike action for shortage water, fully
water or interruption of power supply, it will delay for 3 minutes to
start up after restarted.
6. Always use fresh water before starting ice production either at
initial installation or after a long shut-off period.
TROUBLESHOOTING
1. Please note, if a power failure occurs due to disconnection of the
power cord, or the power button has been pushed off during an ice
making cycle, small ice chips may formed and lodge in the
automatic shovel causing it to jam. If this occurs, the ice chips may
be removed by disconnecting the power cord and gently pushing
the shovel to the rear of the cabinet and removing the ice chips,
then restarting.
2. Please check if the water reservoir is flat when the ice shovel can
not remove the ice to ice basket. If not, please push the ice shovel
gently by finger, then press POWER button to restart.
PROBLEM POSSIBLE CAUSE SUGGESTED SOLUTIONS
The compressor works
abnormally with a
buzzing noise
The voltage is lower than
recommended
Stop the ice maker and do not restart
until the voltage is normal.
10

Water shortage indicator
light is on
1.There is no water
2.The pump is full of air
1.Add to some water until it reaches
MAX position
2.Press POWER button to restart the
machine
Indicator lights on display
are not on Blown fuse/ No power Replace fuse / Turn power on
The ice made is too large
and with pieces sticking
together
Ice of previous cycles left in
the water tray
Take out the ice under the standby
state
The ice making process
was correct, but no ice
came out?
1.
The compressor has
no refrigerant
2. Compressor damaged
3. Fan motor damaged
Call the service hotline
All indicators twinkle
simultaneously
1.
Water tray is blocked
by ice cube
2. The motor is stuck, or
the motor falls off, or
the motor is damaged
3. The micro s
witch was
destroyed
1. Unplug the power to take out the
ice which blocking the tray, then
plug the power and press the
POWER button, the machine will
restart 3minutes later.
2. Call the service hotline
The machine has been
working, but the water
has been warming
Solenoid broke down Replace the solenoid valve
When the ice is full, the
machine does not display
the ICE FULL icon
1.
Ice full sensor
damaged
2. Sunlight interference
1. Replace the ice full sensor
2. Making ice indoor
3. Call the service hotline
11

1. If the power cord is damaged, it must be replaced by the
manufacturer, its service agent or a similarly qualified person in
order to avoid a hazard.
2. Fill with potable water only.
3. It is normal for the compressor and condenser surface to reach
temperatures between 70°C and 90°C during operation and
surrounding areas may be very hot.
4. Due to fast freezing, ice cubes may opaque. This is air trapped in
the water and will not affect quality or taste of ice.
5. This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities or
lack of experience and knowledge unless they have been given
supervision or instruction concerning use of the appliance by a
person responsible for their safety.
6. Children should be supervised to ensure that they do not play
with the appliance.
7. Do not immerse in water.
Correct Disposal of this product
This marking indicates that this product should not be
disposed with other household wastes throughout the
EU. To prevent possible harm to the
environment or
human health from uncontrolled waste disposal, recycle
it responsibly to promote the sustainable reuse of
material resources. To return your used device, please
use the return and collection systems or contact the
retailer where the product
was purchased. They can
take this product for environmental safe recycling.
12

WARRANTY
Limited two-year warranty
This warranty is available to consumers only. You are a
consumer if you own a kumio ice maker that was purchased at
retail for personal, family or household use. Except as
otherwise required under applicable law, this warranty is not
available to retailers or other commercial purchasers or owners.
We warrant that your kumio ice maker will be free of defects in
materials and workmanship under normal home use for 2 years
from the date of original purchase. If your kumio ice maker is
prove to be defective (Non Man-damaged)within the warranty
period, we will offer free replacement or reimburse.
Thank you for using our products. Please contact
[e-mail] or Customer Service Online if you have any
questions.
13