Kumio ICM1221 User manual

THANK YOU FOR CHOOSING OUR ICE MAKER
PLEASE READ THE MANUAL CAREFULLY BEFORE OPERATING
ICE MAKER
INSTRUCTION MANUAL
Model: ICM1221

IMPORTANT NOTICES
When using an electrical appliance, basic safety precautions should
always be followed to reduce the risk of fire, electric shock, and/or
injury, including the following:
1. Read all instructions before using.
2. Remove all packing material and carefully check your ice maker
to ensure it is in good condition and that there is no damage to
the ice maker or power cord and plug.
3. Before using the ice maker for the first time, please wait 2 hours
after positioning it, and keep the transparent lid open for at least 2
hours.
4. Pure water is not allowed to be used on this unit, spring water is
recommended.
5. Ensure the voltage is compliant with the voltage range stated on
the rating label, and ensure the earthing of the socket is in good
condition.
6. If the supply cord is damaged, it must be replaced by the
manufacturer or its service agent or a similarly qualified person in
order to avoid a hazard.
7. Do not upend this product or incline it over a 45℃angle.
8. To protect against risk of electric shock, do not pour water on
cord, plug and ventilation, immerse the appliance in water or any
other liquid.
9. Unplug the appliance after using or before cleaning.
10.Keep the appliance 8cm from other objects to ensure the good
heat releasing.
11.Do not use the accessories which are not recommended by
manufacturer.
1

12.This appliance can be used by children aged from 8 years and
above and persons with reduced physical, sensory or mental
capabilities or lack of experience and knowledge if they have
been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
Children shall not play with the appliance. Cleaning and user
maintenance shall not be made by children without supervision.
13.Do not use the appliance close by flames, hot plates or stoves.
14.Do not switch on the power button frequently (ensure 5min.
interval at least) to avoid the damage of compressor.
15.Metal sheet or other electric objects are not allowed to be
inserted into the appliance to avoid fire and short circuit.
16.Do not use outdoors.
17.Never clean with scouring powders or hard implements.
18.Please keep the instruction manual.
19.Warning: Do not store explosive substances such as aerosol
cans with a flammable propellant in this appliance.
20.This appliance is intended to be used in household and similar
applications such as
–staff kitchen areas in shops, offices and other working
environments.
–farm houses and by clients in hotels, motels and other
residential type environments.
–bed and breakfast type environments.
–catering and similar non-retail applications.
21.When positioning the appliance, ensure the supply cord is not
trapped or damaged.
22.Do not locate multiple portable socket-outlets or portable power
supplies at the rear of the appliance
2

23.The refrigerant and insulation blowing gas is flammable, when
disposing of the appliance, do so only at an authorized waste
disposal centre. Do not expose to flame.
This symbol indicates the refrigerant R600a and the
non-metallic materials of the appliance are flammable. It’s a warning
symbol. Warning: Risk of fire / flammable materials.
WARNING: When positioning the appliance, ensure the supply cord
is not trapped or damaged.
WARNING: Do not locate multiple portable socket-outlets or portable
power supplies at the rear of the appliance.
To avoid contamination of food, please respect the following
instructions:
–Opening the door for long periods can cause a significant increase
of the temperature in the compartments of the appliance.
–Clean regularly surfaces that can come in contact with food and
accessible drainage systems.
–Clean water tanks if they have not been used for 48 h; flush the
water system connected to a water supply if water has not been
drawn for 5 days.
–If the refrigerating appliance is left empty for long periods, switch
off, defrost, clean, dry, and leave the door open to prevent mould
developing within the appliance.)
Regarding the information pertaining to the use of the appliance,
thanks to refer to the below paragraph of the manual.
3

SPECIFICATIONS
Model number: ICM1221
Daily ice output: 26 lbs.(12kg) / 24 hours
Ice storage capacity: 1.5L/600g
Refrigerant: R600a environmental friendly refrigerant
Compression-type refrigeration: 110-120V/60Hz
Water tank capacity: 1.5 L
Voltage: 110-120V~
Frequency: 60 Hz
Power consumption: 120 W
Max overall dimensions(W×D×H): 228X320X297mm
Packing dimensions(L×W×H): 392(L)×304(W)×366(H)mm
N.W.: 16.98LBS/7.7kg
G.W.:19.18LBS/8.7kg
4

DESCRIPTION
1. Micro switch support
2. Evaporator
3. Water Tray
4. Ice shovel board
5. Ice collecting tray
6. Water box
7. Control panel
8. Buttons
9. Front housing
10. Ice shovel
11. Top cover
12. Transparent lid
13. Motor Mount
14. Back housing
15.Air vent
10
9
8
7
6
5
4
1
15
14
11
12
13
3
2
5

FEATURE
Quick ice making
Prompt when the ice is full and water is insufficient
Bullet ice
9 pcs ice can be made in nine minutes
1. During transportation, do not tilt the machine more than 45
degrees, do not reverse the machine. This may damage the
compressor and the sealing system.
2. Remove all packing materials, check the machine carefully and
make sure that the machine, power cord and plug are normal.
3. The machine should be on a level surface. To ensure sufficient
ventilation, the distance of the back of ice maker to the wall
should be at least 150 mm, it should be away from the oven,
radiator or other heat source.
4. Before using the machine for the first time, place the machine
and leave the transparent cover open for at least two hours.
5. Make sure that the home voltage is consistent with the voltage
indicated by the machine.
6. Distilled water is not allowed. Mineral water is recommended.
6

CONTROL PANEL OPERATION
ICE FULL: Ice full alarm
ADD WATER: Water shortage alarm
ICE MAKING: Ice making
1) Plug in the power, the ICE MAKING indicator light flashes, and the
machine will start the deicing function. Press the POWER button, the
ICE MAKING indicator light is always on and then the ice block will
be made automatically. After the ice making is completed, the
deicing will be carried out, and then the ice shoveling function will be
entered, and so on.
2) ADD WATER: water shortage alarm
When the ADD WATER light turns red, it means that there is water
shortage in the water tank. You need to add water and press the
POWER button to restart the machine.
Power button
7

3) ICE FULL: Ice full alarm
When the ice reaches the maximum capacity of the ice storage
container, the ICE FULL light flashes, and the machine stops. At this
time, the ice needs to be poured out. When the ice position is lower
than the full sensor position, the machine will restart automatically.
4) ICE MAKING: Ice making
When this light is always on, it means that the ice maker is making
ice.
OPERATING INSTRUCTIONS
Step 1
Open the lid and take out the basket and add water to the reservoir.
Note: There is a maximum scale MAX in the reservoir. The water
should not exceed the MAX position. If the water exceeds the
maximum scale MAX, you need to open the bottom drain plug,
release the excess water, and cover with a transparent cover.
Step 2
Plug in the power and press the power button to start the machine.
1. The three cycles used for the first time, the ice produced is small
and irregular.
2. When the ice basket is full, please take out the ice immediately, do
not let the ice overflow the ice basket
8

CLEANING & USE GUIDANCE
1. Clean the inner liner,ice collecting tray,water box, ice shovel
and evaporator frequently.When cleaning, unplug the unit and
remove the ice cubes. Use a diluted solution of water and
vinegar to clean the inside and the outside surface of the ice
maker.Do not spray Ice maker with chemicals or diluted agents
such as acids, gasoline or oil. Rinse thoroughly before starting.
2. Keep ventilation openings inthe appliance enclosure, or inthe
built-instructure, clear ofobstruction. Donot use mechanical
devices or other means to accelerate the defrosting process,
other than those recommended by the manufacturer.
3. Reuse the machine after being idled for a period of time, itmay
not have enough water to pump forairretard, inthis case, the
water shortage indicator “ADD WATER”will light up, just
repress POWER button to restart the ice maker.
4. To ensure the cleanness of ice, please change water for water
reservoir at least once one day.Ifdo notuse for a long time,
please drain the water out and clean itup.
5. If the compressor takes a strike action for shortage water,fully
water or interruption of power supply,itwill delay for 3minutes to
start up after restarted.
6. Always use fresh water before starting ice production either at
initial installation or after a long shut-off period.
7. According to the actual use of the machine, the filter screen in
the water tank shall be regularly cleaned after disassembly to
prevent the water inlet from being blocked by scale. As shown in
the figure below. Take out the ice basket and filter cover from
the water tank in turn, clean the filter cover with clean water with
a brush, and then put them back in place.
9

TROUBLESHOOTING
1. Please note, if a power failure occurs due to disconnection of the
power cord, or the power button has been pushed off during an ice
making cycle, small ice chips may formed and lodge in the
automatic shovel causing it to jam. If this occurs, the ice chips may
be removed by disconnecting the power cord and gently pushing
the shovel to the rear of the cabinet and removing the ice chips,
then restarting.
2. Please check if the water reservoir is flat when the ice shovel can
not remove the ice to ice basket. If not, please push the ice shovel
gently by finger, then press POWER button to restart.
10
ice basket
filter cover

All indicators twinkle
simultaneously
1. Water tray is blocked by
ice cube
2. The motor is stuck, or
the motor falls off, or the
motor is damaged
3. Micro switch damaged
1. Unplug the power to take out the ice
which blocking the tray, then plug the
power and press the POWER button,
the machine will restart 3minutes later.
2. Call the service hotline
The machine has been
working, but the water
has been warming
Solenoid broke down 1. Replace the solenoid valve
2. Call the service hotline
When the ice is full, the
machine does not display
the ICE FULL Icon
1. Ice full sensor damaged
2. Solar light interference
1. Replace the ice full sensor
2. Making ice indoor
3. Call the service hotline
11
PROBLEM POSSIBLE CAUSE SUGGESTED SOLUTIONS
The compressor works
abnormally with a
buzzing noise
The voltage is lower than
recommended
Stop the ice maker and do not restart
until the voltage is normal.
Water shortage indicator
light is on
1.There is no water
2.The pump is full of air
1.Add to some water until it reaches
MAX position
2.Press POWER button to restart
Indicator lights on display
are not on Blown fuse/ No power Replace fuse/Turn power on
The ice made is too large
and with pieces sticking
together.
Ice of previous cycles left in
the water tray
Take out the ice under the standby
state
The ice making process
was correct, but no ice
came out?
1. The compressor has no
refrigerant
2. Compressor damaged
Fan motor damaged
Call the service hotline

Correct Disposal of this product
This marking indicates that this product should not
be disposed with other household wastes throughout
the EU. To prevent possible harm to the environment
or human health from uncontrolled waste disposal,
recycle it responsibly to promote the sustainable
reuse of material resources. To return your used
device, please use the return and collection systems
or contact the retailer where the product was
purchased. They can take this product for
environmental safe recycling.
12
1. If the power cord is damaged; it must be replaced by the
manufacturer, its service agent or a similarly qualified person in
order to avoid a hazard.
2. Fill with potable water only.
3. It is normal for the compressor and condenser surface to reach
temperatures between 70°C and 90°C during operation and
surrounding areas may be very hot.
4. Due to fast freezing, ice cubes may opaque. This is air trapped in
the water and will not affect quality or taste of ice.
5. This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities or
lack of experience and knowledge unless they have been given
supervision or instruction concerning use of the appliance by a
person responsible for their safety.
6. Children should be supervised to ensure that they do not play
with the appliance.
7. Do not immerse in water.

:$55$17<:$55$17<
LimitedLimited two-yeartwo-year warrantywarranty
ThisThis warrantywarranty isis availableavailable toto consumersconsumers only.only. YouYou areare aa
ccoonnssuummeerr iiff yyoou ou owwn a kn a kuummiio io icce me maakkeerr tthhaatt wwaass ppuurrcchhaasseedd aatt
retailretail forfor personal,personal, familyfamily oror householdhousehold use.use. ExceptExcept asas
otherwisotherwisee requiredrequired underunder applicableapplicable law,law, thisthis warrantywarranty isis notnot
availableavailable toto retretailersailers oror otherother commercialcommercial purchaserspurchasers oror owners.owners.
WeWe warrantwarrant thatthat youryour kumiokumio iceice mmaakerker willwill bebe freefree ofof defecdefecttss inin
materialsmaterials andand workmanshipworkmanship underunder normalnormal homehome useuse forfor 22 yyeearsars
fromfrom thethe datedate ofof originaloriginal purchase.purchase. IfIf youryour kumiokumio iceice makermaker isis
proveprove toto bebe defectivedefective ((NonNon Man-damaged)withinMan-damaged)within thethe warrantywarranty
period,period, wewe willwill offeroffer freefree replacementreplacement oror reimburse.reimburse.
ThThaannk you fork you for usiusinng ourg our proprodducts. Plucts. Pleeaasese contaccontactt
VXSSRUW#NXPLRQHWVXSSRUW#NXPLRQHW oorr CCuussttoommeerr SSeerrvviiccee OOnnlineline iiff yyoouu hhaavvee aannyy
quequessttionionss..
13