Lenovo 3012-2KU - IdeaCentre C300 - Desktop PC Parts list manual

Version 1.0 2009.5
Hardware Replacement Guide
3000 C3 Series
3000 C3
31037187
31037187_3000 C3_HRG_FM_EN.indd 1 2009.5.11 2:04:16 PM

Hardware Replacement Guide
31037187_3000 C3_HRG_EN.indd 15 2009.5.11 1:59:31 PM

Contents
Overview ..................................................................................... 1
Chapter 1 Locations ................................................................. 4
Locating components and connectors ...........................................4
Chapter 2 Replacing hardware ............................................... 7
General information ........................................................................7
Replacing a memory module ........................................................7
Replacing the keyboard ................................................................9
Replacing the Mouse ...................................................................10
Replacing the power cord or power adapter ................................11
Appendix. ................................................................................. 13
31037187_3000 C3_HRG_EN.indd 16 2009.5.11 1:59:31 PM

1
Hardware Replacement Guide
Overview
This guide is intended to be used by customers who are replacing Customer
Replaceable Units (CRUs) as well as trained service personnel who are replacing
Field Replaceable Units (FRUs). In this guide, CRUs and FRUs will often be referred
to as parts.
Note: Trained service personnel should refer to the Hardware Maintenance
Manual (HMM) for parts ordering information.
This guide does not include procedures for all parts. It is expected that cables,
switches, and certain mechanical parts can be replaced by trained service
personnel without the need for step-by-step procedures.
Note: Use only parts provided by Lenovo®.
The description of the TV-Tuner card in this manual applies only to those computer
models that have the TV-Tuner card installed. It does not apply to those computer
models that do not have the TV-Tuner card installed.
This guide contains procedures for replacing the following parts:
• Memory modules
• Keyboard, Mouse (wired)
• Power cord, Power adapter
Safety information for replacing CRUs
Do not open your computer or attempt any repair before reading the “Important
safety information” in the Safety and Warranty Guide that was included with your
computer. If you no longer have this copy of the Safety and Warranty Guide, you
can obtain one online from the Support Web site at
http://consumersupport.lenovo.com.
Additional information resources
If you have Internet access, the most up-to-date information for your computer is
available from the World Wide Web.
You can find the following information:
• CRU removal and installation information
31037187_3000 C3_HRG_EN.indd 1 2009.5.11 1:59:12 PM

2Hardware Replacement Guide
• Publications
• Troubleshooting information
• Parts information
• Links to other useful sources of information
To access this information, go to: http://consumersupport.lenovo.com.
Tools required
To disassemble the computer, you need the following tools:
• Wrist grounding strap and conductive mat for preventing electrostatic discharge
• Flat screwdriver
• Phillips screwdriver
• Hex screwdriver
• Plastic flat screwdriver
• Plastic tweezers
Note: The screws for the different components vary in size. During the
disassembly procedure, group the screws with their corresponding
components to avoid a mismatch when replacing the components.
Handling static-sensitive devices
Static electricity, although harmless to you, can seriously damage computer
components.
When you are replacing a part, do not open the static-protective package
containing the new part until the defective part has been removed from the
computer and you are ready to install the new part.
When you handle parts and other computer components, take these precautions
to avoid static-electricity damage:
• Limit your movement. Movement can cause static-electricity to build up around
you.
• Always handle parts and other computer components carefully. Handle
adapters, memory modules, system boards, and microprocessors by the
edges. Never touch any exposed circuitry.
• Prevent others from touching the parts and other computer components.
• Before you replace a new part, touch the static-protective package containing
31037187_3000 C3_HRG_EN.indd 2 2009.5.11 1:59:12 PM

3
Hardware Replacement Guide
the part to a metal expansion-slot cover or other unpainted metal surface on the
computer for at least two seconds. This reduces static electricity in the package
and your body.
• When possible, remove the new part from the static-protective packaging, and
install it directly in the computer without setting the part down. When this is not
possible, place the static-protective package that the part came in on a smooth,
level surface and place the part on it.
• Do not place the part on the computer cover or other metal surface.
31037187_3000 C3_HRG_EN.indd 3 2009.5.11 1:59:12 PM

4Hardware Replacement Guide
Locations
Chapter
This chapter provides illustrations to help locate the various connectors, controls
and components of the computer.
Locating components and connectors
The following illustrations will help you to locate the various components and
connectors in your computer.
Font view
The following illustrations show the location of connectors on the front of the
computer.
-+
1 2 3
4
5
Brightness down button Power button
Brightness up button Camera
LCD On/Off
31037187_3000 C3_HRG_EN.indd 4 2009.5.11 1:59:14 PM

5
Hardware Replacement Guide
Left and right view
The following illustrations show the location of connectors on the left and right side
of the computer.
Attention: Be sure not to block any air vents on the computer. Blocked air
vents may cause thermal problems.
1 2 3
Memory card reader Optical drive slot
USB ports (2)
31037187_3000 C3_HRG_EN.indd 5 2009.5.11 1:59:17 PM

6Hardware Replacement Guide
Rear view
The following illustration shows the location of connectors on the rear of the
computer.
1
2
3
4
5
6
7
8
Power connector USB ports (4)
TV tuner (Select models only) IEEE 1394 connector
PS2 Keyboard connector Headphone connector
Ethernet connector Microphone connector
Note: Before you buy an antitheft device, be sure it is compatible with the
security cable slot on your computer.
31037187_3000 C3_HRG_EN.indd 6 2009.5.11 1:59:18 PM

7
Hardware Replacement Guide
Attention:
Do not remove the computer cover or attempt any repair before reading the
“Important safety information” in the Safety and Warranty Guide that was
included with your computer or in the Hardware Maintenance Manual (HMM)
for the computer. To obtain copies of the Safety and Warranty Guide or
HMM, go to the Support Web site at http://consumersupport.lenovo.com.
Note: Use only parts provided by Lenovo.
General information
Pre-disassembly instructions
Before proceeding with the disassembly procedure, make sure that you do the
following:
1. Turn off the power to the system and all peripherals.
2. Unplug all power and signal cables from the computer.
3. Place the system on a flat, stable surface.
Replacing a memory module
Attention:
Turn off the computer and wait 3 to 5 minutes to let the computer cool before
removing the computer cover.
To remove the computer cover:
Note: For this procedure, it helps to place the computer face-down on a soft
flat surface. Lenovo recommends that you use a blanket, towel, or other soft
cloth to protect the touch screen surface from scratches or other damage.
Replacing hardware
Chapter
31037187_3000 C3_HRG_EN.indd 7 2009.5.11 1:59:19 PM

8Hardware Replacement Guide
1. Remove any media (diskettes, CDs, or memory cards) from the drives, shut
down your operating system, turn off all attached devices, and the computer.
2. Unplug all power cords from electrical outlets.
3. Disconnect all cables attached to the computer. This includes power cords,
input/output (I/O) cables, and any other cables that are connected to the
computer. Refer to “Locating connectors on the rear of the computer”.
4. Remove the screw that secures the memory cover to the back of the computer.
5. Gently slide the cover toward the side of the computer, and then remove it.
31037187_3000 C3_HRG_EN.indd 8 2009.5.11 1:59:22 PM

9
Hardware Replacement Guide
6. Push out the latches on both sides of the memory socket to release the
memory module and gently pull the memory module upward to remove it
from its socket . Both memory modules can be removed by using the same
procedure.
1
1
2
7. Align then insert the new memory module into the socket and push down
on the top edge of the memory module . Make sure the latches lock the
memory module in place.
21
2
8. Slide the memory cover backward until it snaps into position.
9. Screw back the screw on the memory cover.
Replacing the keyboard
Attention:
Do not remove the computer cover or attempt any repair before reading the
“Important safety information” in the Safety and Warranty Guide that was
included with your computer or in the Hardware Maintenance Manual (HMM)
for the computer. To obtain copies of the Safety and Warranty Guide or
31037187_3000 C3_HRG_EN.indd 9 2009.5.11 1:59:27 PM

10 Hardware Replacement Guide
HMM, go to the Support Web site at http://consumersupport.lenovo.com.
To replace the keyboard:
1. Remove any media (diskettes, CDs, or memory cards) from the drives,
shut down your operating system, and turn off all attached devices and the
computer.
2. Unplug all power cords from electrical outlets.
3. Locate the connector for the keyboard. Refer to “Left and right view” and “Rear
view”.
Note: Your keyboard might be connected to the standard keyboard
connector at the rear of the computer or to a USB connector either side
or rear of the computer.
1 2
4. Disconnect the failing keyboard cable from the computer and connect the new
keyboard cable to the same connector.
Replacing the Mouse
Attention:
Do not remove the computer cover or attempt any repair before reading the
“Important safety information” in the Safety and Warranty Guide that was
included with your computer or in the Hardware Maintenance Manual (HMM)
for the computer. To obtain copies of the Safety and Warranty Guide or
HMM, go to the Support Web site at http://consumersupport.lenovo.com.
To replace the Mouse:
1. Remove any media (diskettes, CDs, or memory cards) from the drives,
shut down your operating system, and turn off all attached devices and the
computer.
31037187_3000 C3_HRG_EN.indd 10 2009.5.11 1:59:30 PM

11
Hardware Replacement Guide
2. Unplug all power cords from electrical outlets.
3. Locate the connector for the mouse. Refer to “Left and right view” and “Rear
view”.
Note: Your mouse connected to the USB connector at either side or the rear
of the computer.
4. Disconnect the failing mouse cable from the computer and connect the new
mouse cable to the same connector.
Replacing the power cord or power adapter
Attention:
Do not remove the computer cover or attempt any repair before reading the
“Important safety information” in the Safety and Warranty Guide that was
included with your computer or in the Hardware Maintenance Manual (HMM)
for the computer. To obtain copies of the Safety and Warranty Guide or
HMM, go to the Support Web site at http://consumersupport.lenovo.com.
To replace the power cord and power adapter:
1. Remove any media (diskettes, CDs, or memory cards) from the drives,
shut down your operating system, and turn off all attached devices and the
computer.
2. Locate the connector for the power cord. Refer to “Rear view”.
31037187_3000 C3_HRG_EN.indd 11 2009.5.11 1:59:30 PM

12 Hardware Replacement Guide
3. Disconnect the failing power cord and adapter from the computer and connect
the new power cord and adapter to the same connector.
31037187_3000 C3_HRG_EN.indd 12 2009.5.11 1:59:31 PM

13
Hardware Replacement Guide
Appendix.
Statement
Thanks for using Lenovo products.
Carefully read all of the documents shipped with your computer before you install
and use the product for the first time. Lenovo will not assume responsibility for
damage that results from failure to operate the product according to instructions
and requirements described in the manuals included with your computer. Lenovo
will not assume responsibility for any loss caused except that caused by the
installation or operations carried out by Lenovo professional service staff.
Lenovo has made every attempt to ensure that the manuals included with your
computer, are correct and accurate, but makes no guarantee that the publications
are error free.
To provide better service, Lenovo reserves the right to improve and/or modify the
products and software programs described in the manuals included with your
computer and the content of the manual at any time without additional notice.
All of the manuals included with your computer are provided to help you use
Lenovo products appropriately, but do not provide any description of the software/
hardware configuration for the product. For the configuration of the product, refer
to related contract (if any), product packing list for the product or retailer.
The content of the manuals included with your computer is protected by
copyright laws and rules. None of the manuals included with your computer may
be reproduced or transcribed by any means, or transmitted through wired or
wireless network in any form, or translated into any language without prior written
permission of Lenovo. All Lenovo publications included with your system are
protected by Copyright © 2009 Lenovo. All rights reserved.
The software and hardware configuration included with your computer depends on
the actual configuration of the computer and may differ from other similar models.
Customers are welcome to contact us for any inconsistency between the product
and the manuals included with your computer. For the latest information or any
questions or comments, please visit consumer support website at:
http://consumersupport.lenovo.com
31037187_3000 C3_HRG_EN.indd 13 2009.5.11 1:59:31 PM

14 Hardware Replacement Guide
Lenovo is a registered trademark of Lenovo.
Microsoft, Windows, and Windows Vista are trademarks of the Microsoft group of
companies.
Intel Inside is the registered trademark of Intel.
AMD, the AMD Arrow logo, ATI, the ATI logo, AMD Athlon, AMD LIVE, AMD
Opteron, AMD Phenom, AMD Sempron, Avivo, Catalyst, Cool'n'Quiet, CrossFireX,
Overdrive, Powerplay, Radeon, The Ultimate Visual Experience, and combinations
thereof are trademarks of Advanced Micro Devices, Inc. in the United States and/
or other jurisdictions.
The table above includes the logo and registered trademarks of Lenovo and its
partners.
Other registered trademarks mentioned in all the manuals included with your
computer belong to the specific company respectively.
All rights reserved.
The manual included with your computer is protected by copyright laws and
rules. None of the manuals included with your computer may be reproduced or
transcribed by any means, or transmitted through wired or wireless network in any
form, or translated into any language without prior written permission of Lenovo.
Names or marks of certain companies mentioned in the manuals included with
your computer or this document are only used to state trademark rights, and they
will not necessarily indicate that related software or hardware is included. The
concrete configuration of the product depends on the description of the specific
model.
31037187_3000 C3_HRG_EN.indd 14 2009.5.11 1:59:31 PM