Lenox GK228 Technical manual

WARNING

Adult supervision is required. Do not drive anywhere dangerous
slopes with more than 10 degrees, streets, next to bodies of water and
from other obstacles. The driver must sit on the seat to drive. Read the
instruction manual and acknowledge it before use.
1. Adult supervision required
2. Read the instruction manual and instruct the child user
3. The weight limit is 25kg
4. Only one rider to use at the one time
5. Please wear a bike helmet when riding
6. Sit straight on the seat when riding
7. Ride only on flat surfaces
8. Ride away from other vehicles and bodies of water
9. Wear shoes when riding

1. THE SPECIFICATIONS OF THE PEDAL GO-KART
FOR AGES FROM: 3-7 years WEIGHT : 7.6KGS
MEASUREMENTS : 93×59×56CM
TOP SPEED : 3KM/HR
LOADING CAPACITY : 25KGS
II.HOW TO OPERATE THE PEDAL GO-KART
1. Drive the go-kart as bicycle\
III. SAFETY:
Please instruct the child on the correct way to drive the pedal
go-kart. Please keep in mind the condition of the area they are
riding in and the child’s driving ability.
Designed for use by children between the ages of 3 – 7 years,
weighing less the 25kg. This is advisable to avoid damage to the
pedal go-kart.
Do not let children ride in the street, anywhere dangerous including
slopes with more than 10 degrees, streets, next to bodies of water
and away from other obstacles. Use during day light hours or in an
illuminated area is advised to avoid accidents in the dark.
When the pedal go-kart is in use, do not place anything on the
moving parts.
Do not drive on long or wet grass, mud, soft ground, gravel or
sand.

Do not drive neat anything flammable or explosive. Keep any hazardous
chemicals out of the drivers reach.
IV.MAINTENCE AND TROUBLE SHOOTING:
Factors which may influence the motor tricycles performance and
life span:
‐How flat the driving surface is
‐The weight of the driver
Cleaning: Clean the motor tricycle with a soft dry cloth. Do not use
any wax or spray liquids for cleaning. It could erode the power
switch.
Storage: Do not store the motor tricycle in an area of high
temperature, humidity or near flames. When raining or snowing,
keep the motor tricycle under cover and out of the weather.
Never push or pull the go-kart backward when it is being driven.

V. HOW TO ASSEMBLE
WARNING:
Warning: Children could be injured by sharp edges, sharp angles,
small components or electrical components. Take care when
assembling or disassembling the motor tricycle. Keep the
components and battery out of reach of children.
1. Assemble Plug board:(figure 1)
(1)

2. Front installation: (figure 2)
(2)
3. Add the gearbox:(figure 3)
(3)

4. Assemble wheel：(figure 4)
(4)
5. Assemble car floor：(figure 5)
(5)

6. Add the steering wheel rod：(figure 6)
Insert the bend end of steering wheel
rod in the front connecting board, the other end passes through front panel, as shown.
(6)
7. Assemble front board：(figure 7)
(7)

8. Steering wheel installation: (figure 8)
(8)

9.To play music: (figure 9)
1. Firstly use screwdriver to twist off battery covers screw on
the steering wheel, then remove the battery cover.
2. Install three dry batteries(AAA battery)according to positive
and negative terminals(as shown),then fit on the battery cover,
and use screwdriver to tighten the screw.
3. Once you press MUSIC SWITCH, the music will play.
(9)

10. Seat installation: (figure 10)
(10)

Executive Standard of the Product：
EN71-1；EN71-2；EN71-3 EN62115-2005；口
ASTM F963-07E1 口GB6675-2003 口