Marineland SMALL ANIMAL User manual

OPERATING MANUALOPERATING MANUAL
OPERATING MANUALOPERATING MANUAL
SMALLANIMALVERTICAL
DISPLAY SYSTEMS
DISPLAY

SYSTEMS


TABLE OF CONTENTS
TABLE

OF

CONTENTS
►ImportantSafeguards Page 1
►Introduction Page 2
►System Specifications Page 3
►InstallationInstructions Pages 4‐6
►O
p
eration
(
Slide outDrawers
)
Pa
g
es 7‐9
p (
)
g
►Odor ControlCartridgeReplacement Page 10
►FluorescentLamp Replacement Page 11
►
Wt Bttl Rl t d
P
12
►
W
a
t
er
B
o
ttl
e
R
ep
l
acemen
t
an
d

RemovableDividerProcedures
P
age
12
►TroubleshootingGuidelines Page 13
►
Warranty
Page
14
►
Warranty
Page
14

IMPORTANTSAFEGUARDS
WARNING
Toguardagainstinjury,basicsafetyprecautionsshouldbeobserved,includingthefollowing:
READANDFOLLOWALL
SAFETY INSTRUCTIONS
SAFETY

INSTRUCTIONS
DANGER
Toavoidpossibleelectricshock,specialcareshouldbetakenintheuseofthis equipment.
Foreachofthefollowingsituations,donotattemptrepairsyourself;
contactanauthorizedservicefacilityforservice.
1. A. Ifanappliancefallsintothewater,DON’Treachforit!Firstturnoffpoweratmaindisconnectandthen
retrieveit.Ifelectricalcomponentsoftheappliancegetwet,turnofftheapplianceimmediately.
B. Carefullyexaminetheapplianceafterinstallation.Itshouldnotbepluggedinifthereiswateronpartsnot
intendedtobewet.
C. Donotoperateanyapplianceifithasadamagedcordorplug,orifitismalfunctioningorifitisdroppedor
damagedinanymanner.
2. Closesu
p
ervisionisnecessar
y
whenan
y
a
pp
lianceisusedb
y
ornearchildren.
p y y pp y
3. Toavoidinjury,donotcontactmovingpartsorhotpartssuchasheaters,reflectors,lampbulbs,etc.
4. Alwaysturnoffpoweratmaindisconnectwhennotinuse,beforeputtingonortakingoffpartsandbefore
cleaning.Neveryankacordtopullaplug.Grasptheplugandpulltodisconnect.
5Donotuseanapplianceforotherthanintendeduse.Theuseofattachmentsnotrecommendedorsoldby
theappliancemanufacturermaycauseanunsafecondition.
6. Donotinstallorstoretheappliancewhereitwillbeexposedtotheweatherortotemperaturesbelow
freezing.
7. Makesureapplianceissecurelyinstalledbeforeoperatingit.
8. Readandobservealltheimportantnoticesontheappliance.
9. Thisapplianceshouldbeconnectedtoagrounded,metallic,permanentwiringsystem,oranequipment‐
ro ndin cond ctor sho ld be rn ith the circ it cond ctors and connected to the eq ipment
ro ndin
g
ro
u
ndin
g
cond
u
ctor

sho
u
ld

be

r
u
n
w
ith

the

circ
u
it

cond
u
ctors

and

connected

to

the

eq
u
ipment
‐g
ro
u
ndin
g
terminalorleadontheappliance.
10. Thisapplianceistobeinstalledbyaqualifiedelectricianinaccordancewithallappropriatecodesand
ordinances.
SAVE THESE INSTRUCTIONS
SAVE

THESE

INSTRUCTIONS
Page1

TheHighCapacityVerticalDisplaySystemfor
HealthierSmallAnimals
,
EasierMaintenance
,

,
,
IncreasedSales!
Thismanualwillprovideyouwiththeinformationyouneedtosuccessfullyoperateand
maintainyourSmallAnimal Vertical DisplaySystem.Pleasereaditcarefullyandkeepit
forfuturereference.
YourfullyintegratedMarinelandSmallAnimal Systemprovideseasy‐to‐maintain enclosures
withminimalcornersforeasiercleaningandbetterhygiene.Enclosuresslideoutlikeno
other systemforcleaningpurposes,betterviewingofspeciesandalternatecapture.Also
includedareremovabledividersthatallowyoutouseanentiretankforlargerspeciesor
justtomakeamorespaciousenclosure.Theseenclosuresareventilatedwithperforated,
closinglidsandventsforoptimaluseofVentilationSystemthatincludesOdorControl
Cartridges.
TheMarinelandSmallAnimal Systemenhancesviewing,improvessalesand
useslessenergy.
Congratulationsonyournew,“PlugandPlay”MarinelandSmallAnimal
Merchandiserpurchase!
Page2

SYSTEMSpecifications
MECHANICAL(approximate): MATERIALSOFCONSTRUCTION:
Integrated3Drawer/HabitatRackSystem
SmallAnimalVerticalDisplayModularSystem
Size:52“Lx25“Wx76"H
ShippingWeight:640 lbs(approx.)
LockingSystem:MechanicalKey
(KeyFobOption)
Frame:PowderCoatedSteel
DrawerGlides:150lbs
Glass:3/16”Tempered
Doors:ExtrudedAluminum
d l
ELECTRICAL:
Voltage:120VAC/60Hz,5AMP
LIGHTING:
Lights:T8‐32wattFlorescent
Si
d
ePane
l
s:ImpactResistantABS
AIRCIRCULATION:
Blower:150CFM
Filter:60SquareInches
BUYERSUPPLIEDCONNECTIONS:
CordConnection:120VAC,60Hz,15AMP
APPROVALS:
ElectricalSafety:ETLListed
Seismic:CaliforniaSeismicCode
Page3

InstallationInstructions
Forsystemtechnicalsupportcall the
MaRSTechnicalSupportDivision: (800)576‐6277
YourSmallAnimalsystemcomescompletewiththeseinstallation
items:
“RedHead”cementanchorswithrequirednutsandwashers
Seismicbracesandbolts
Grade5“through”Bolts
Extralevelinglegs
Rollof1‐inch,2‐sidedmountingtape
Inadditiontothoseprovided,youwillneedtheseitems:
Heavy‐dutyhammerdrillwitha3/8‐inchbitanddrillgauge
Tapemeasure

½
‐
inch and a9/16
‐
inch open
‐
end wrench
A
½
inch

and

a

9/16
inch

open
end

wrench
Ratchetwitha9/16‐inchsocket
Hammer
Channellockpliers
Twolevels:Onelarge,onesmall
Note:AspeciallydesigneddollyisavailableforrentfromMarinelandforeasier
movementoftheMaRSunits.
Step1:PositionSmallAnimalSystem
Assistanceofatleastoneotherpersonisrecommendedtorollthe
SmallAnimalunitintotheinstallationarea.
B
CarefullyplacetheSmallAnimalunitinanuprightposition.Make
suretheunitisstraightandinthecorrectplace.Placetheseismic
braceanddeterminetheproperdrillingsitesfortheseismicbrace
anchorboltholes.Makesuretheholeontheunitisinthemiddle
(seepictureA)Useablackpermanentmarkertodottheareawhere
youwilldrillintothefloor(seepictureB).
xC
Page4
TheSmallAnimalSystemwillbeanchoredin2‐Corners(see
drawingC).
x
FRONTOFREPTILEUNIT

InstallationInstructionscont.
Step2:ScoreandDrill
RemovetheSmallAnimalsystemawayfromthemarked
areaandusethedrilltoscorethenecessaryholes.Drillthe
holes3‐inchesdeepatbothcorners.
NOTE:Takeextracaretomakesuretheholesaredrilled
vertically.
Step3:InstallAnchorBolts
Positioneachboltinadrilledholeandhammersecurely
into place Each anchor bolt should extend about 1 ½
‐
into

place
.
Each

anchor

bolt

should

extend

about

1

½

inchesupfromfloorlevel.
Step4:PositionSmallAnimalSystem
Withtheassistanceofatleastoneotherperson,rollthesmallanimalunitbackintothe
installationarea.CarefullytilttheSmallAnimalSystemtocleartheanchorboltsandplacethe
i i
ih
ii
un
i
t
i
nanupr
i
g
h
tpos
i
t
i
on.
NOTE:Toensureeasierinstallation,removefrontbottom(Kick)Panel.Donotinstallprovided
endpanelsuntiltheunithasbeeninstalled.
Step5:LevelAssembledRack
Check horizontal and vertical levels Adjust Leveling Legs as necessary
Check

horizontal

and

vertical

levels
.
Adjust

Leveling

Legs

as

necessary
.
Step6:InstallSeismicBraces
FitSeismicBracestothecementAnchorBolts.AttachBraces
Page5
usingwashersandnutsprovided.

InstallationInstructionscont.
Step7:SecureAssembled
Rack
InsertfrontThroughBoltsinto
theframeandSeismicBrackets
(
A
). Secure all connections (
B
).
A B
(
A
).

Secure

all

connections

(
B
).
Step8:InstallSystemSidePanels
D
C
BeforeyoubeginStep8&9,makesureyoulineuptheEndPanelsandVerticalExtrusions
correctly.
Stripsofdouble‐sidedtapeareincludedon
thenarrowsurfacesoftheendframework.
Peelthetape(C)andpresspanelsfirmly
intoplace(D).Note: Donotpeelthefront
tapewheretheVerticalextrusiongoes.
D
C
Step9:InstallSystemVerticalExtrusions
Peeltheremainingdouble‐sidedtapeincludedon
thenarrowsurfacesoftheend,frontframework
(E).PressAluminumVerticalExtrusionfirmlyinto
p
lace
(
F
)
.
E F
Step10:PluginSmallAnimalSystem
HavetheVentilation,LightingandDoor
Lockin
g
S
y
stemconnections
p
lu
gg
edinto
p
(
)
g y pgg
theappropriatereceptacle.
Makesurethatthereare3electricaloutlets
availabletoplugtheVentilation,Lighting
andDoorLockingSystem.
(LefttoRight)Ventilation,LightingandDoorLockingSystem
connections
Page6
Forsystemtechnicalsupportcall the
MaRSTechnicalSupportDivision: (800)576‐6277

OPERATION(SLIDEOUTDRAWERS)
SlideOutDrawer.
TheDrawersontheMarinelandSmallAnimal Vertical
DisplayconvenientlySlideOutforpurposessuchas
cleaning and capture of small animals The Drawers
cleaning

and

capture

of

small

animals
.
The

Drawers

stabilizingfeatureincludesuperiorglidesthat
improvestrengthandresultsinasmootherslideout
ofdrawers.
Tounlockadrawer,simplyusethe key(seepicture
1),thenpullopendesiredlevel.Orusethe*KeyFob
(
see
picture 2
)then pull open desired level
(
see
picture

2
)
,
then

pull

open

desired

level
.
Theseactionsallowyoutoopenonetieratatimeby
holdingthedrawerinthemiddle(seepicture3)and
gentlypullingforwardtowardsyou.
Note:Openthedrawersgentlyandsmoothsoyoudo
not disturb the small animals within the enclosures
21
not

disturb

the

small

animals

within

the

enclosures
.
*IfyourpurchaseincludedaKeyFob(soldasan
option),pressingtheKeyFobforasecondortwowill
allowyouaround8secondstoopenonedrawer.
Whenreadytoclosethedrawer,gentlypushthe
drawerawa
y
from
y
ou
,
smoothl
y
anduntil
y
ouhearit
yy, y y
lock.
Caution: Makesurethatpeoplearenotnearthe
drawerwhenclosingtopreventinjury.Toguard
againstinjury,basicsafetyprecautionsshouldbe
observed.Misuseofdrawersmayalsocausedamage
to the Small Animal Vertical Display
3
to

the

Small

Animal

Vertical

Display
.
Ifneededandincaseofanelectricalissuewherethe
KeyFoborKeywillnotopenthedrawers.Amanual
overrideisavailableonthesystem.Thedrawer
manualoverrideislocatedabovetheunit.Usean
appropriatelattertoreachthetop(see picture4).
Each drawer is labeled you must close the drawer in
Each

drawer

is

labeled
,
you

must

close

the

drawer

in

ordertoopenanother.
Page7
4
MiddleTop Bottom