Mastercare MB-80 User manual

!
Integrity!Bath!
!"#$%&!'()*&
Installation!Manual!
+,-$./0/.12/"34&5&6"789(:3&:3.%7#$#;&
:<-"=2132&,10$2>&:342=7.2/"34&
6$1#&5&?"%%"@&A%%&:342=7.2/"34&B9"="789%>&
SN:_____________________________________!
&
&
! !
Part#!805015!

Integrity)Bath)Model&MB-80&Installation&Manual&
&&
*C(DE(CF&
G18$&D&"0&H&
D*IC&CJ29&AK$&L&M"%7<N74O&PQ&R)R*C&
)**(IF)(H)RI&&?AST&J*D(HRE(FC*D&
@@@U<142$=.1=$N129U."<&
IMPORTANT! SAFETY! INSTRUCTIONS!READ! AND!
FOLLOW!ALL!INSTRUCTIONS!THROUGHLY!
!"#$%&'() The$ caution$ heading$ identifies$ important$
maintenance$and$operation$information.$$Failure$to$ obey$a$
caution$ warning$ may$ result$ in$ damage$ to$ the$ Entree$ Bath$
and$may$void$the$warranty$
CU Plan!Bathing!System!Layout!
DU Mark!Tub!Center!Line!On!Wall!&!Floor!!!!!
EU Install!Electrical!Service!
CD*V& AMO& R*& WXO& D*& A<-& MYA,,& A& Z?M:& =$.$-21.%$& 0%749&
<"732$#&/3&@1%%&
WARNING:$Electrical$current$can$cause$severe$injury$or$
death$if$the$following$precautions$are$not$headed.$
WARNING:$Turn$off$power$source.$
WARNING:$Lock$ circuit$ open$ to$ prevent$ accidental$
activation.$
WARNING:$Electrical$ service$ must$ be$ located$ higher$
than$plumbing$service.$
WARNING:$Electrical$ switches$ and$ outlets$ must$ not$ be$
in$reach$by$bathers$in$the$tubs.$
WARNING:$Electrical$ wiring$ must$ comply$ with$ all$
applicable$codes.$A$licensed$electrician$may$be$required$
to$install$the$service.$
WARNING:$Connect$ the$ bathing$ system$ ONLY$ to$ a$
circuit$protected$by$a$CLASS$A$GFCI.$
WARNING:$Connect$ only$ to$ branch$ circuit$ protected$ by$
an$ over$ current$ protection$ device$ rated$ not$ more$ than$
20$amps.$
JU Install!Plumbing!Service!
:2&/4&42="38%>&=$."<<$3#$#&2912&1&0%""=&#=1/3&N$&/3421%%$#&
/3& 29$& K$./3/2>& "0&29$& 0="32& "0& 29$& 27N&J*[& $/29$=& 4/#$&"0&
29$&.$32$=%/3$&"0&29$&27NU&*+,--.)/012)34),454,)67)284)9.49)
:84.4)$.971;-.24.)4724.1)284)203<&
G%7<N/38& 4$=K/.$& <742& ."<-%>& @/29& 1%%& 1--%/.1N%$&
N7/%#/38&13#&-%7<N/38&."#$4U&A&%/.$34$#&-%7<N$=&<1>&N$&
=$\7/=$#&2"&/3421%%&29/4&4$=K/.$U&
Y".1%& -%7<N/38& ."#$4& <1>& =$\7/=$& N1.]& 0%"@& -="2$.2/"3&
2"&N$&/3421%%$#&/3&N"29&29$&9"2&13#&."%#&@12$=&&%/3$4U&*=>=)
$.9;)18-0,?)34)10;;,64?)3@)A012-/4.B)7-2)/970C9A20.4.<)
CAUTION:$The$ tubs$ use$ flexible$ hoses.$ It$ is$ an$ industry$
standard$ and$ it$ is$ recommended$ by$ MasterCare$ to$
replace$the$hoses$every$5$years$and$to$inspect$the$hoses$
yearly$for$any$obvious$ signs$of$damage$ or$wear.$If$any$
sign$of$damage$or$wear$is$noticed,$replace$de$hoses.$
CAUTION:$Wall$and$floor$openings$for$the$electrical$and$
plumbing$ service$ installation$ should$ be$ closed$ and$
sealed$to$help$mantain$sanitary$conditions.$
MB-80!FOOT!PRINT!
B^G&V:Q_&
MB-80!?6^PB&V:Q_&
R)&C`D[&
EE[&
?^6&
a^^6&
,_:PZ&
℄&
EE&C`D[&
?Yb,W&!^bPBQa&
D*A`D*V&AM&
abGYQS&
6QMQGBA'YQ&
H*[&!:P&B^&
AYY^_&?^6&
a^^6&,_:PZ&
C*[&
D*[(DH[&
C)[&
H[&
E[&
D&C`D[&
D[&GVM&_A,BQ&&G:GQ&
E`J[&
W^B`M^Ya&
Y:PQ,&
'-241()$84)846D82)-C)284)>E!):9124);6;4)18-0,?)
34)F=G)",,)?6/4716-71)9.4)9;;.-H6/924,@)IJK)LJM=))
Drain!Connection:&D[&GVM&4.9$#7%$&J*&-/-$4U&
Water! Connection:&E`J[& 0$<1%$& -/-$& 4@/K$%&
."33$.2/"34&47--%/$#&N>&29$&<13701.27=$=U&
Water! Supply:&E`J[& M"--$=& 9"2& 13#& ."%#U&
!/3/<7<& J*& G,:& 0"=& 9"2& 13#& ."%#& =$\7/=$#U&
!1c/<7<& 2$<-$=127=$&"0& 9"2& @12$=& 47--%>T&
CCH&?&"=&%".1%&."#$O&@9/.9$K$=&/4&%$44U&,972&"00&
K1%K$4& 12& 73/2& 47--%/$#& N>& %".1%& -%7<N/38&
."32=1.2"=U&

Integrity)Bath)Model&MB-80&Installation&Manual&
&&
*C(DE(CF&
G18$&E&"0&H&
D*IC&CJ29&AK$&L&M"%7<N74O&PQ&R)R*C&
)**(IF)(H)RI&&?AST&J*D(HRE(FC*D&
@@@U<142$=.1=$N129U."<&
BATHING!SYSTEM!INSTALLATION!
ZQPQ6AY&_A6P:PZ,T&
WARNING:$Risk$of$electrical$shock.$
A%%&$\7/-<$32&."<$4&4213#1=#&@/29&1&CD*V&L&E&-="38&
$%$.2=/.1%& -%78U& G%78& 29$& N129/38& 4>42$<& /32"& 1& CD*V&
AMO&R*&WXO&D*&A<-&MYA,,&A&Z?M:&=$.$-21.%$U&A%%&91=#&
@/=/38& <742& N$& -$=0"=<$#& N>& 1& %/.$34$#&$%$.2=/./13&
0"%%"@/38&%".1%&."#$4U&B9$&<1/3&-"@$=&47--%>&<742&N$&
#/4."33$.2$#&N$0"=$&91=#&@/=/38U&
WARNING:$Failure$to$disconnect$main$power$before$hard$
wiring$ unit$ can$ result$ in$ Electrical$ Shock,$ Death$ or$
Damage$to$Equipment$not$covered$with$the$warranty.$
A3& $\7/-<$32& 8="73#/38&2$=</31%& /4& -="K/#$#& /3& 29$&
0/$%#&@/=/38&."<-1=2<$32&+$%$.2=/.1%&N"c&"3&29$&73/2;U&
B"& =$#7.$& 29$& =/4]& "0& $%$.2=/.1%& 49".]O& 29/4& 2$=</31%&
<742&N$&."33$.2$#&2"&29$&8="73#/38&<$134&-="K/#$#&
/3& 29$& $%$.2=/.1%& 47--%>& -13$%& @/29& 1& ."3#7.2"=&
$\7/K1%$32&/3&4/X$&2"&./=.7/2&."3#7.2"=4&47--%>/38&29/4&
$\7/-<$32U&
:3421%%& 29/4& 73/2& /3& 1.."=#13.$& @/29& 29$& M131#/13&
$%$.2=/.1%& ."#$O& -1=2& :O& /3& M131#1& 13#& /3& 1.."=#13.$&
@/29&29$&bU,U&312/"31%&$%$.2=/.1%&."#$&/3&29$&bU,UAU&"=&
%".1%&."#$4&@9/.9$K$=&1--%/$4U&
WARNING:$Risk$of$Scalding.$
W"2& @12$=& .13& 4.1%#& -$"-%$U& B$<-$=127=$& ."32="%&
K1%K$& <742& N$& 1#d742$#& N$0"=$& 74/38& N129U& a"& 3"2&
1%%"@&2$<-$=127=$&2"&$c.$$#&C*FUJ&?&+JE&M;&
Other$Precautions:$
B7N&13#&.1N/3$2&."<-"3$324&1=$&9$1K>&13#&N7%]>U&a"&
3"2&122$<-2&2"&%/02&"=&<"K$&29/4&27N&"=&.1N/3$2&1%"3$U&
a1<-&"=&@$2&0%""=4&.13& N$& 4%/--$=>&.174/38&01%%4&13#&
4$=/"74& /3d7=>U& a=>& 29$& 0%""=& N$0"=$& 421=2/38& 2"& /3421%%&
N129/38&4>42$<U&
,213#/38&/3&27NO&"=&"3&2"-&$#8$&"0&27N&.13&#1<18$&29$&
27N&"=&%$1#&2"&01%%4&13#&4$=/"74&/3d7=>U&a"&3"2&4213#&/3&
27N&#7=/38&/3421%%12/"3&"=&74$U&a"&3"2&1%%"@&=$4/#$324&
2"&4213#&/3&29$&27NU&
CAUTIONT& $84) 203) 0141) C,4H63,4) 8-141KK62) 61) 97) 67?012.@)
1297?9.?) 97?) 61) .4A-//47?4?) 3@) N9124.!9.4) 2-) .4;,9A4)
284) 8-141) 454.@) C654) *O<) @49.1) 97?) 2-) 671;4A2) 284) 8-141)
@49.,@)C-.)97@)-356-01)16D71)-C)?9/9D4B):49.B)42AG))%C)97@)
16D71) -C) ?9/9D4) -.) :49.) 9.4) 7-24?) .4;,9A4) 284) 8-141G
CU Check!Electrical!and!Plumbing!and!Service!!Rough-Ins!
•'129/38&4>42$<&%".12/"3&/#$32/0/$#&13#&<1=]$#&-$=&
/342=7.2/"34&/3&="789(/34&
•G%7<N/38& /3421%%$#& 1.."=#/38& 2"& /342=7.2/"34& /3&
="789(/3&<1371%U&
•_1%%& 13#& 0%""=& "-$3/384& 1="73#& -/-$4& .%"4$#& 13#&
sealed.
DU Clear!Waste!Water!Drain!
•!1]$&47=$&@142$&@12$=&#=1/3&/4&0=$$&"0&#$N=/4&
EU Flush!debris!from!hot!and!cold!water!service!lines.!
•?%749&#$N=/4&0="<&29$&/3."</38&9"2&13#&."%#&@12$=&
%/3$4& N$0"=$& ."33$.2/38& 27N& 9"4$4U& 673& 1N"72& C*&
81%%"34& 29="789& $1.9& %/3$& /32"& 1& N7.]$2U& B9/4& @/%%&
-="2$.2&29$&-%7<N/38&K1%K$4&/3&29$&N129/38&4>42$<&
0="<&-"2$32/1%&#1<18$&N>&</8=12/"3&"0&#$N=/4&/32"&
K/21%&."<-"3$324U&
•e"7& 1=$&3"@& =$1#>& 2"& /3421%%& >"7=& !142$=M1=$&
:32$8=/2>&'129/38&,>42$<U&
JU Position!Tub!
•6$<"K$& 4/#$& 4$=K/.$& 1..$44& -13$%O& =$<"K$&
#/4/30$.2132&N"c&N>&=$<"K/38&29$&D&N"%24&12&29$&2"-&
"0&29$&N"c&29$3&%/02&13#&=$<"K$&N"c$4U&,$2&2"&29$&
4/#$&"0&29$&#""=&"-$3/38U&
•,%/#$&29$&N1.]&"0&29$&27N&2"&29$&@1%%O&.$32$=/38&2"&
29$&Df&#=1/3&="789(/3U&
•!1]$&47=$&Df&#=1/3&"3&27N&/4&1%/83$#&@/29&Df&#=1/3&
="789(/3U& M"33$.2& @/29& Df& 0%$c/N%$& ."33$.2"=&
+?$=3."&."7-%/38;U&a"3g2&2/892$3&>$2U&&
G:MBb6Q& ^6& ,MWQ!Q& ^?& Df& a6A:P& ^P& Bb'& hDf&
a6A:P&^P&6^bZW(:P&h&Df&?YQS:'Q&M^PPQMB^6&
?:Z& C& h& G:MBb6Q& ^?& BWQ& AMBbAY& APMW^6& '^YB&
W^YQ&Y^MAB:^P&
HU Set!Anchors!
•?/3#& 29$& 2@"& C`Jf& 9"%$4& %".12$#& /3& 29$& 0/N$=8%144&
=$1=&0%""=&1=$1&"0&29$&27NU&!1=]&29$&9"%$&%".12/"34&
"3&29$&0%""=O&#/4."33$.2&29$&Df&#=1/3&13#&4%/#$&29$&
27N&0"=@1=#&1N"72&4/c&0$$2U&a=/%%&2@"&C`Df&9"%$4&0"=&
29$& C`Jf& ,,& 13.9"=& N"%2& 13.9"=4U& M%$13`N%"@& "72&
29$& 9"%$4& 2912& @$=$& -=$K/"74%>& #=/%%$#U& ,%/#$& 29$&
27N& N1.]O& ."33$.2& 29$& #=1/3& 13#& 4$2& 29$& 13.9"=4&
1.."=#/38%>U&
RU Reposition!Tub!Against!Wall!
•:3421%%&29$&13.9"=&N"%24&%""4$%>U&&
•,%/#$&29$&27N&N1.]&2"&29$&@1%%U&
•M"33$.2&29$&#=1/3O&N72&#"&3"2&2/892$3U&
IU Level!Tub!
•A#d742&%$8&%$K$%/38&4.=$@4&2"&%$K$%&29$&27N&
•M9$.]&2"&N$&47=$&@12$=&#=1/34&."<-%$2$%>U&

Integrity)Bath)Model&MB-80&Installation&Manual&
&&
*C(DE(CF&
G18$&J&"0&H&
D*IC&CJ29&AK$&L&M"%7<N74O&PQ&R)R*C&
)**(IF)(H)RI&&?AST&J*D(HRE(FC*D&
@@@U<142$=.1=$N129U."<&
a6A_:PZ&^6&G:MBb6Q&^?&YQVQY:PZ&,M6Q_,&APa&BWQ:6&
Y^MAB:^P&:P&BWQ&Bb'U&
&
)U Tighten!Anchor!Bolts!
FU Make!Final!Connections!
•M"33$.2&9"2&`&."%#&@12$=&9/89&-=$447=$&9"4$4&0="<&
/34/#$& /0& 29$& 47--"=2& .1N/3$24& 2"&29$& 9"2& 13#&."%#&
@12$=&47--%>&K1%K$4&@/29&if&<1%$&?BB&0/22/384U&
•M"33$.2&29$&Df&27N&#=1/3&2"&29$&Df&#=1/3&="789(/3&
13#&2/892$3U&
•G%78&29$&N129/38&4>42$<&/32"&1&CD*V&AMO&R*&WXO&D*&
A<-&MYA,,&A&Z?M:&=$.$-21.%$U&
C*U Connect!Disinfectant!Shower!Wand!Hose!
•M"33$.2&jf&0$<1%$&$3#&"0&29$&#/4/30$.2132&9"4$&2"&
29$&jf&%"@$=&<1%$&0/22/38&"3&29$&/34/#$&2"-&"0&29$&
#/4/30$.2132&N"cU&
a6A_:PZ&^6&G:MBb6Q&^?&YQVQY:PZ&,M6Q_,&APa&BWQ:6&
Y^MAB:^P&:P&BWQ&Bb'&
VERIFY!SYSTEM!OPERATION!
CCU Close!and!Lock!Door!
•6"212$&13#&-"4/2/"3&#""=&/34/#$&29$&27N&14&01=&14&/2&
@/%%&8"U&_/29&N"29&913#4&-749&#""=&#"@3&.1=$07%%>&
732/%& /2& %12.9$4& /3& 29$& #"@3& -"4/2/"3U& 6"212$& #""=&
.1<&1=<&7-&/32"&07%%&%".]$#&-"4/2/"3U&
&
!
!
CDU Turn!On!BathAire!
•B7=3& "3& '129A/=$& N>& -749/38& 29$& k'129A/=$&
^3`^00f&N722"3U&
CEU Turn!on!Supply!Water!
•B7=3&"3&29$&9"2&13#&."%#&@12$=&47--%>&K1%K$4U&
•_/29&29$&49"@$=&@13#&-"/32$#&/34/#$&29$&27NO&27=3&
29$& .9="<$& 49"@$=& 4-=1>& "3`"0& 913#%$& ."732$=&
.%".]@/4$& +"3;& 2"& -7=8$& 29$& -%7<N/38& 4>42$<& "0&
13>& 2=1--$#& 1/=U& B7=3& "00& 102$=& 2=1--$#& 1/=& /4&
-7=8$#U&
CJU Check!for!Connector!Leaks!
•M9$.]& 1%%& 9"4$& ."33$.2/"34& 0"=& %$1]4U& _9/%$&
9"%#/38& 29$& 49"@$=& @13#& "K$=& /34/#$& "0& 29$& 27NO&
27=3& .9="<$& 49"@$=& 4-=1>& 913#%$& ."732$=&
.%".]@/4$& +"3;& 13#& .9$.]& 0"=& %$1]4U& B7=3& 49"@$=&
4-=1>& "00U& _9/%$& 9"%#/38& #/4/30$.2132& @13#& "K$=&
/34/#$& 27NO& 27=3& .9="<$& #/4/30$.2132& ."732$=&
.%".]@/4$& +"3;& 13#& .9$.]& 0"=& %$1]4U& B7=3&
#/4/30$.2132& 913#%$& .%".]@/4$& +"00;U& B/892$3& 13>&
%""4$&."33$.2/"34&2912&1=$&%$1]/38U&
CHU Check!Fill!Temp!Gauge!
•A#d742& 2$<-$=127=$& "0& 29$& /3."</38& @12$=& 2"&
1--="c/<12$%>& C*D& ?& +EFM;& N>& 27=3/38& 29$& </c/38&
K1%K$&913#%$&2"&1&-"4/2/"3&2912&-="K/#$4&1&."342132&
=$1#"72& "0& #$4/=$#& 2$<-$=127=$& "3& 29$&
B9$=<"<$2$=& %".12$#& "3&29$& =/892& 4/#$& "0& 29$&
=$4$=K"/=U&B9$3&27=3&29$&</c/38&K1%K$&913#%$&2"&07%%&
9"2U&
CRU Check!BahAire!Hydromassage!Function!
•A/=&N7NN%$4&49"7%#&0%"@&$K$3%>&"72&"0&1%%&1$=12"=4U&
M9$.]&1%%&073.2/"34&"3&29$&'129A/=$&."32="%&-13$%U&
CIU Drain!Tub!
•6"212$& a=1/3& ^-$3`M%"4$& 913#%$& 2"& "-$3&
-"4/2/"3U& A%%"@& 27N& 2"& #=1/3& ."<-%$2$%>U& M9$.]&
1%%& #=1/3& ."33$.2/"34& 0"=& %$1]4U& !1]$& 47=$& 1%%&
@12$=& #=1/34& 0="<& 27NU& :0& 3"2O& 27N& /4& 3"2& %1K$%U&
Y$K$%&27N&-$=&/342=7.2/"34&"3&-18$&EU&
C)U Check!and!Adjust!Disinfectant!Dispensing!System!
•_/29& #/4/30$.2132& @13#& -/32$#& /34/#$& 29$& 27NO&
27=3&.9="<$&#/4/30$.2132&^3`^00&913#%$&."732$=&
.%".]@/4$&1%%&29$&@1>&"3U&
•B9$& .%$1=& 27N/38& %/3$& 0="<& 29$& D& %/2$=& N"22%$& "0&
."3.$32=12$#&.%$13$=&#/4/30$.2132&49"7%#&N$&07%%U&
A02$=& 1& 0$@& 4$."3#4& 1& 4"1->& #/4/30$.2132&
4"%72/"3&@/%%&$</2&0="<&29$&@13#U&&
CAUTION:$$84) A,4974.JP167C4A2972) 1@124/) 61)
;.4142) 92) 284) C9A2-.@) 2-) ?61;4714) Q) -R) -C)
A-7A472.924?) ?6167C4A2972) ;4.) D9,,-7) -C) :924.G)

Integrity)Bath)Model&MB-80&Installation&Manual&
&&
*C(DE(CF&
G18$&H&"0&H&
D*IC&CJ29&AK$&L&M"%7<N74O&PQ&R)R*C&
)**(IF)(H)RI&&?AST&J*D(HRE(FC*D&
@@@U<142$=.1=$N129U."<&
#167D)-284.)3.97?)?6167C4A2972)A,4974.1)-.) 1@124/)
.4;,9A4/472) ;9.21) A-0,?) A9014) 2861) .4A-//47?4?)
.926-)2-)A897D4)97?).410,2)67)97)67A-..4A2)1-,026-7G$
•B9$&0%"@&=12$&"0&."3.$32=12$&.13&N$&1#d742$#&N>&
27=3/38& 29$& 1#d742<$32& 4.=$@& +,$$& 29$& -/.27=$;&
"3& 29$& /3d$.2"=& 9"74/38& ."732$=& .%".]@/4$& 0"=&
<"=$O&.%".]@/4$&0"=&%$44U&
•B9$&&1#d742<$32&4.=$@&.13&N$&1..$44$#&29="789&
29$& 4<1%%& -%788$#& 9"%$& 2"& 29$& %$02& "0& 29$&
#/4/30$.2132&^3`^00&913#%$U&
CFU Check! and! Program! Bath! Oil! and! Shampoo!
Dispensing!System!
•6$<"K$& 29$& 4$=K/.$& 1..$44& #""=& "3& 29$& =/892&
4/#$& "0& 29$& 27NU& M"33$.2& 29$& D& %/2$=& d784& "0& 29$&
N129&"/%&13#&491<-""&49/--$#&4$-1=12$%>&/3&29$&
,21=2$=&l/2&2"&29$&1--="-=/12$&#/4-$34/38&9"4$4U&
'129& "/%& %$02& 9"4$& 13#& ,91<-""& =/892& 9"4$U& B"&
-=/<$O& -749& 29$& 1--="-=/12$& N722"3& 0"=& 29$&
4"%72/"3&>"7&@132&2"&-=/<$U&
•6$0$=&2"&29$&^-$=12/"3&!1371%&0"=&29$&'129&^/%&
13#& ,91<-""& #/4-$34/38& 4>42$<& 2"& 4$2& 7-& 13#&
.9$.]& 29$& 4>42$<& 2"& <1]$& 47=$& /2& "-$=12$4& 14&
/32$3#$#U&,$2&2"&#/4-$34$&j&"X&N129&"/%&13#&m&"X&
491<-""U&
:0& 13>& -="N%$<4& 1=$& $3."732$=$#& #7=/38& .9$.]/38&
13#& 1#d742/38& #/4-$34/38& 4>42$<4O& .9$.]& 29$&
!1/32$313.$& !1371%& /3.%7#$#& @/29& >"7=& 27N& "=&
.1%%& >"7=& %".1%& !142$=M1=$& =$-=$4$3212/K$& "=&
!142$=M1=$&#/=$.2&0"=&2$.93/.1%&47--"=2U&
D*U Clean!and!Rinse!the!Bathing!System!before!Using!
•'$0"=$&74/38&29/4&$\7/-<$32T&
o6$<"K$& 1%%& ="789& #$N=/4& 0="<& /34/#$&
29$&27NU&
oM%$13& 13#& =/34$& 29$& 4>42$<& 0"%%"@/38&
29$&87/#$%/3$4&/3&29$&^-$=12/"3&!1371%U&