Matador J210S User manual

MEAT BONE SAW
INSTRUCTION
For Your Own Safety, Read Instruction
Manual Before Operating this Equipment
i

- 2-

CONTENTS
1. BreifIntroduction&SafetyInstruciton
2. Charactor
3.Components
4. PartsExplodeDiagram
5. Operation
6. Cleanning
7. PartsNameReferencetable
8. TechnicalParameters
9. PackingList
4
5
5
6-7
8
8-9
10
11
11
- 3-

- 4-
WARNING
SAFTEY INSTRUCTIONS
Brief Instruction
• Theinstructionmanualshowsthesafetyoperationforuserreference.
• Mustreadtheinstructionscarefullyandcorrectunderstandingofitsoperation
methodsandvariousconsiderations,thenoperateorrepairandmaintenance
• Keepthismanualandplacednearthemachine,sothatcancheckatany
time ！
• Please wear prope working clothes、Security
posture and operate correctly ！
• Before use, please check again for this machine.
Pleasebesuretocheckfortheworktableofactivitiesifitwillbechangedintransit,if
there'sanylooseforfasteningscrews,ifthereisashiftofmotorbackcover!
• Please make sure to install leakage protection
devices, must be connected with the earth wire! ！
• Wore Gloves when replacing the Saw Band ！
• Never Position Fingers or thumbs in line with the cut!
Seriouspersonalinjurycouldoccur.
• DO NOT BACK MEAT AWAY fromthebladewhilethesawisrunning.
Planyourcutssoyoualwayscutthroughthemeat.Ifyouneedtobackthemeatout,
turnthebandsawoffandwaitforthebladetocometoacompletestop.Donottwistor
putexcessivestressonthebladewhilebackingmeataway
• Donot operate the emergency stop frequently In
case of damage the motor!

Charactor

1.TooTightprotectiondeviceofbandsaw!
2.Themotoroverheatingprotectiondevice.
3.Poweroffwhendooropenningsafetyprotectiondevice.
4.0.2secondsfortheemergencybrakeprotectiondevice,10timesbeyondtheEuropeanUnion's
safetystandards.(eustandards:EN60335-2-6420tharticle111)
5.Largeworkingtable,workmoresecure,moreeasily.
6.Drivenwheeldetachablewash,nohealthcorner.
7.Machinescanbedirectlysprayirrigation,clearnmoreeasilyandhealth.
Components
SawBandtensioningKnob
DrivenWheel
VerticalClampingdevice
Sawband
Meatstopper
Carryingtable
TableSlider
DrivingWheel
MeatResidue
CollectingPan
BottomDoor
Locker
TopDoorLocker
SawProtecting
Cover
MeatStopperFixer
EmergencyStop
ON/OFFSwitch
- 5-

- 6-

- 7-

Operation
A. Loosenthemeatstopper
C.Startthemachine
DEF.Putthefoodonmovable
worktingtable,thenTake
sawguardontheright
protectionlevel,promotejob
boards,tobringfoodtothe
saw(Thedrivingspeed
differsaccordingtothe
differentfood,andbaseson
thenormalrunningofsaw
bandasalimition.Repeat
theoperationfortimesuntil
thecuttingoperationis
completed,thentrunoffthe
powersupply! Never
Position Fingers or
thumbs in line with the
cut!
B. Confirmthecuttingthickness
byadjustingthedistance
betweenfrontandrearmeat
stoppersandbandsaw
- 8-
(A)
(C)
(E)
(B)
(D)
(F)
Cleaning
A. Opentheprotectiondoor B. Takeouttheresiduepan
(A) (B)

Notice:
- 9-
CDE.LossenthetensioningKnobtorelaxthebandsawthendemountthesaw(Wearinggloves
before)。Onehandpressdownthetensioningknob,onehandupwardlifttheDrivenwheel
outandclean
F. Pleaseuselowpressuresquirtgunto
spraytheinteriormincedmeat,then
reinstallmentinorder. Electrical
parts(as exterior control
knob,switch....) can't be directly
sprayed by squirt gun.
1)Duringremountingthesawband,
checkthetoothdirection,positionand
makesurethatthesawbandshall
beclosetothebackingwheelfaceof
lowerclampingdevice(Theposition
ofbackingwheelhasbeenpresetat
delivery)

2)Rotatetopwheelwithhandandmake
surethatitrunssmoothlyandthe
sawteethstandoutonthewheel(if
necessary,itcanberealizedtoadjust
theregulatingdeviceontthetopwheel)
(C) (D) (E)

- 10-
SN PartsDescription SN PartsDescription
1 BottomLockingBlock 29 MeatStopper
2 BottomDoorlockerseat 30 Motor
3 SawProtectingCover 31 CarryingPlate
4 TopLockingBlock 32 CarryingPlateSeat
5 TopDoorlockerseat 33 Movableworkingtable
6 Door 34 RightSlideRail
7 DrivenwheelCover 35 TherightwheelFrame
8 Drivenwheel 36 LockingBlock
9 DrivenwheelBearing（6004） 37 Lockinghandle
10 Sealingring 38 Lockingbolt
11 Drivenwheelaxle 39 Rollershaft
12 Drivenwheelstand 40 Rolleraxle（627）
13 Drivenslidecarriage 41 Roller
14 Adjustingnut 42 Railcarriageframe
15 Springseat 43 LeftSlideRail
16 Spring 44 LeftRollerframe
17 TensioningKnob 45 MeatScrappingPlate
18 tensioningnut 46 MeatScrappingseat
19 tensioningshaftscrew 47 MeatScrappingPlate
20 Framebolt 48 BandSawGuideSeat
21 SlideCarriagePressingPlate 49 DoorSwithseat
22 Enclosure 50 Footpad
23 BandSawGuideSeat 51 Baseseat
24 BandSawBlocker 52 DrivingWheel
25 BandSawGuidePlate 53 ResidueCollectingPan
26 MotorCover 54 DrivingWheelaxleSleeve
27 MeatStopperLockerBolt（M8） 55 BandSaw
28 MeatStopperseat
Parts Description

- 11-
Name MeatBoneSaw
Model J210S
MachineSize 550×500×920mm
PackingSize 585×585×980mm
BandSawThickness 0.5mm
BandSawLength 1650mm
BandSawwidth 19mm
PowerSupply ~110V/220V/50/60Hz
Power 750W
CuttingThickness 5 ～ 155mm
WorkingtableSize 505×415mm
MovableworkingtableRange 240mm
NetWeight ≈ 47kg
GrossWeight ≈ 52kg
BrakeTime ≤ 0.3s
Tech. Parameter

MEAT BONE SAW
INSTRUCTION
For Your Own Safety, Read Instruction
Manual Before Operating this Equipment
Packing List
InstructionManual*1,BandSaw*1,DrivingWheelDisassembleTool*1