Murata LBAE0ZZ2AG User manual

CONFIDENTIAL
1/ 24
[Gateway]
User Manual for NF
Model name: LBAE0ZZ2AG

CONFIDENTIAL
2/ 24
Revision History
Date Revision Change point
1.0 Original

CONFIDENTIAL
3/ 24
Table of contents
1 Description........................................................................................................................................ 4
2 Product specification ........................................................................................................................ 5
2.1 Hardware specification.............................................................................................................. 5
2.2 Body shape and dimensions...................................................................................................... 6
2.3 Block diagram............................................................................................................................ 8
2.4 Operation Mode ....................................................................................................................... 10
2.5 Label..........................................................................................................................................11
2.6 Package .................................................................................................................................... 12
2.7 Safety-related security ............................................................................................................ 13
3 Appendix ......................................................................................................................................... 14
3.1 Antenna Specification ............................................................................................................. 14
3.2 Antenna Setup......................................................................................................................... 16
3.3 Antenna directivity.................................................................................................................. 16
3.4 Tx timing chart for IEEE802.15.4.. ........................................................................................ 16
4 Information of importer, manufacturer and factory...................................................................... 17
5 Applicable standards and certification .......................................................................................... 18
6 NOTICE .......................................................................................................................................... 20
6.1 Storage and operation conditions ........................................................................................... 20
6.2 Caution for use ........................................................................................................................ 20
6.3 Limitation of applications ....................................................................................................... 21
7 Note on safety ................................................................................................................................. 22
8 Warranty for product...................................................................................................................... 23
8.1 Warranty period and its scope ................................................................................................ 23
8.2 Warranty exception ................................................................................................................. 24

CONFIDENTIAL
4/ 24
1Description
-LBAE0ZZ2AG is the multiple RF protocol gateway for wireless sensor network. This product
can receive the sensor data from wireless sensor tag (LBAE0ZZ2AM) through IEEE802.15.4
and can measure own sensor data and upload the data to the cloud through 4G.
-IEEE802.15.4 frequency band is 2405MHz~2480MHz.
-Waterproof performance equivalent to IP54.
-Operates on internal lithium ion battery or external lithium ion battery.
-It is mainly used in the transportation of pharmaceutical products and medical equipment and is
not intended to be used in environments that require high reliability such as automobiles, and
power plants.
-No accessories.

CONFIDENTIAL
5/ 24
2Product specification
2.1 Hardware specification
Model Name LBAE0ZZ2AG
Wireless
communication
IEEE802.15.4
Interface IEEE802.15.4
Frequency 2405MHz - 2480MHz+/-9ppm
(+/-30ppm@-30℃~+85℃)
Channel BW 5MHz
Modulation OQPSK
Antenna Monopole pattern antenna (less than +1.2dBi)
RF output power Less than 9dBm (e.i.r.p.)
Duty cycle Less than 0.5%.
4G module LE910C1-NF
(LTE FDD Cat.1. 3GPP release 9 compliant)
bands B2, B4, B5, B12, B13, B14, B66, B71
RF output power Class 3 (0.2 W, 23 dBm) @ LTE
GNSS GPS / GLONASS Use GNSS module (MAX-M8C)
Rx only
Power supply Battery Lithium ion battery*1pc
(min 3.0V / typ. 3.85V / max 4.36V)
External CHEERO CHE-104 (Connect with USB cable)
Hardware Human interface Push switch*3pcs
Reset switch*1pc
OLED*1pc
3 color 1pcBlue & 3ColorLED(Red & Green &
Blue)*1
Buzzer*1pc
SIM Slot (Micro SIM Card)*1
Accessory -
Operating environment IP grade IP54
Temperature -10degC ~ +60degC
Humidity 0%RH ~ 90%RH (non-condensing)
Material Polycarbonate
Case Flame retardancy UL94 V-2
Minimum Thickness 0.6mm

CONFIDENTIAL
6/ 24
2.2 Body shape and dimensions
External
Label

CONFIDENTIAL
7/ 24
Internal
IC901
IC1001
Main
module
4G
module
IC701
IC604
IEEE802.15.4 module
GNSS module
IEEE802.15.4 antenna
4G antenna
GNSS antenna

CONFIDENTIAL
8/ 24
2.3 Block diagram
Block Diagram of product
Block Diagram of RF device(IEEE802.15.4)
MicroUSB
(ForCommunication)
MicroUSB
(For Charging)
Battery
(Lithiumion)
(TypicalVoltage 3.8V)
Battery
Management
3.8V
Battery
Check
Switch IC
X601
X602
4GANT
ZigbeeANT
OLED
DCDC
converter(12V)
MicroSim
Reset
Botton
Power/OK
Botton
Forward
Botton
Back
Botton
Buzzer
UART
UART
LED
3color
Crypto
Authentication
Device
Temperature
&Humidity Pressure 3‐Axis Accelerometer Illuminance
EEPROM
(64kbit)
IC71
GNSS IC
IC604
Telink Zigbeemodule
(TLSR8269F512ET48)
IC1001
Telit4Gmodule
(LE910C1‐NA)
Moduleapproved
FCCID:RI7LE910CXNF
IC:5131A‐LE910CXNF
DCDC
3.0V
IC901
TelitMainmodule
(HE922)
GNSS ANT
LDO
1.8V
LDO
1.8V
Yellowline:3.8Vdc
Redline:3.0Vdc
Pattern
Antenna
Pattern
Antenna
ExternalAntenna
SincetheWLAN,BT, 2G and 3Gfunctionsof
theHE922aredisabled,theyareoutsidethe
scopeofthisapplication.

CONFIDENTIAL
9/ 24
Block Diagram of RF device(4G)

CONFIDENTIAL
10 / 24
Block Diagram of RF device(GNSS)
2.4 Operation Mode
Mode Sensor IEEE802.15.4 GNSS 4G
Sleep OFF OFF OFF OFF
Measuring ON OFF Rx OFF
802.15.4 Tx OFF Tx OFF OFF
802.15.4 Rx OFF Rx OFF OFF
GNSS Rx OFF OFF Rx OFF
4G Tx ON OFF OFF Tx
4G Rx ON OFF OFF Rx
802.15 and 4G never transmit at the same time

CONFIDENTIAL
11 / 24
2.5 Label
Top Label
Bottom Label

CONFIDENTIAL
12 / 24
2.6 Package
The product is wrapped with an ESD compatible sheet.
×5pcs/box

CONFIDENTIAL
13 / 24
2.7 Safety-related security
Requirement Specification/conditions Compliance verified by
a) Protection against casual or
coincidental violation;
The transmitted data is
encrypted and exchanged.
b) Protection against intentional
violation using simple means
with low resources, generic skills
and low motivation;
Uses proprietary
communication protocols.
c) Protection against intentional
violation using sophisticated
means with moderate resources,
specific skills related to the
considered equipment and
moderate motivation;
N/A
d) Protection against intentional
violation using sophisticated
means with extended resources,
specific skills related to the
considered equipment and high
motivation.
N/A

CONFIDENTIAL
14 / 24
3Appendix
3.1 Antenna Specification
Model name IEEE802.15.4 antenna
Frequency 2405MHz…2480MHz
Antenna Type Monopole pattern antenna
Connector type -
Peak gain +1.2dBi
Photo

CONFIDENTIAL
15 / 24
Model name GNSS antenna
Frequency 1559MHz…1610MHz
Antenna Type Active patch antenna module
Connector type U.FL
Peak gain 3.0dBi (Rx only)
Photo
Model name 4G antenna
Frequency 617MHz…2170MHz
Antenna Type Monopole pattern antenna
Connector type -
Peak gain 1.6dBi
Photo

CONFIDENTIAL
16 / 24
3.2 Antenna Setup
The antennas of this product are built-in pattern antennas for IEEE802.15.4 and 4G, and an
antenna module for GNSS.
3.3 Antenna directivity
pattern antennas for IEEE802.15.4 and 4G
Omnidirectional antenna
GNSS
The null point of the antenna is the direction of the bottom side. The main lobe is in the top
side.
3.4 Tx timing chart for IEEE802.15.4..
*The Conducted power test was modified to allow measurements under 100% continuous
radiation conditions as a conservative condition. The maximum duty ratio in actual use is less
than 8.361msec/1.79sec = 0.5%.

CONFIDENTIAL
17 / 24
4Information of importer, manufacturer and factory
-Information of the importer
Company name:
Address:
-Information of the manufacturer
Company name: Murata manufacturing Co., Ltd.
Address: 1-10-1 Higashikotari, Nagaokakyo-shi, Kyoto 617-8555 Japan
-Information of the factory
Company name: Komatsu Murata manufacturing Co., Ltd.
Address: Hikari-machi, Komatsu-shi, Ishikawa 923-8626 Japan

CONFIDENTIAL
18 / 24
5Applicable standards and certification
This product complies with the radio regulations described in the specification. Be sure to comply
with following points upon usage.
-When using this product, use an application that is compatible with the country / region of use.
-DO NOT use applications from different regions.
-DO NOT disassemble or modify the product.
-DO NOT peel off the product label.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two
conditions: (1) This device may not cause harmful interference, and (2) this device must accept any
interference received, including interference that may cause undesired operation.
U.S. manufacturing contact information
Company name: Murata Electronics North America, Inc.
Address: 2200 Lake Park Drive, Smyrna, GA 30080-7604, USA.
Phone: [phone]
FCC CAUTION
Changes or modifications not expressly approved by the party responsible for compliance could void
the user’s authority to operate the equipment.
Note: This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection
against harmful interference in a residential installation. This equipment generates, uses and can
radiate radio frequency energy and, if not installed and used in accordance with the instructions, may
cause harmful interference to radio communications. However, there is no guarantee that interference
will not occur in a particular installation. If this equipment does cause harmful interference to radio
or television reception, which can be determined by turning the equipment off and on, the user is
encouraged to try to correct the interference by one or more of the following measures:
-Reorient or relocate the receiving antenna.
-Increase the separation between the equipment and receiver.
-Connect the equipment into an outlet on a circuit different from that to which the receiver is
connected.
-Consult the dealer or an experienced radio/TV technician for help.
This transmitter must not be co-located or operated in conjunction with any other antenna or

CONFIDENTIAL
19 / 24
transmitter.
This equipment complies with FCC radiation exposure limits set forth for an uncontrolled
environment and meets the FCC radio frequency (RF) Exposure Guidelines. This equipment should
be installed and operated keeping the radiator at least 20cm or more away from person’s body.
IC CAUTION
This device contains licence-exempt transmitter(s)/receiver(s) that comply with Innovation, Science
and Economic Development Canada’s licence-exempt RSS(s). Operation is subject to the following
two conditions:
1. This device may not cause interference.
2. This device must accept any interference, including interference that may cause undesired
operation of the device.
L’émetteur/récepteur exempt de licence contenu dans le présent appareil est conforme aux CNR
d’Innovation, Sciences et Développement économique Canada applicables aux appareils radio
exempts de licence. L’exploitation est autorisée aux deux conditions suivantes :
1. L’appareil ne doit pas produire de brouillage;
2. L’appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est
susceptible d’en compromettre le fonctionnement.
This equipment complies with ISED radiation exposure limits set forth for an uncontrolled
environment and meets RSS-102 of the ISED radio frequency (RF) Exposure rules. This equipment
should be installed and operated keeping the radiator at least 20cm or more away from person’s
body.
Cet équipement est conforme aux limites d’exposition aux rayonnements énoncées pour un
environnement non contrôlé et respecte les règles d’exposition aux fréquences
radioélectriques (RF) CNR-102 de l’ISDE. Cet équipement doit être installé et utilisé en
gardant une distance de 20 cm ou plus entre le radiateur et le corps humain.

CONFIDENTIAL
20 / 24
6NOTICE
6.1 Storage and operation conditions
The product shall not be stored in an atmosphere with high temperature and high humidity.
Any excess mechanical shock shall not be applied to the product.
Do not store or use in the following circumstances.
-In an atmosphere containing corrosive gas (Cl2, NH3, SOx, NOx etc.)
-In an atmosphere containing combustible and volatile gases
-In an atmosphere containing organic solvents
-In an atmosphere with strong electromagnetic field and static electricity
-In an atmosphere containing hot air or close to fire
-Humid place where water condenses
-Freezing place
-Dusty environment
This equipment should be installed and operated keeping the radiator at least 20cm or more
away from person’s body.
6.2 Caution for use
Do not disassemble, modify or repair this product.
If water or a foreign object gets inside the case, unplug the DC power supply or battery and
stop using it.
If there is smoke, a strange smell or noise, unplug the DC power supply or battery and stop
using it.
If the product is dropped or gets a strong physical impact, power it off and stop using it.
Do not touch the product during and after being used in a low or high temperature
environment.
Corrosive gas may generate harmful substances. Do not use the product in an atmosphere
containing corrosive gas.