Northern Lights M673 User manual

The California Air Resource Board is pleased to explain the
emission control system warranty on your 2006 or newer engine.
In California, new off-road C.I. engines must be designed, built,
and equipped to meet the State’s stringent anti-smog standards.
Northern Lights must warrant the emission control system on
your engine for the periods of time listed in Table 1, provided
there has been no abuse, neglect, or improper maintenance of
your engine. Your emission control system may include parts
such as the fuel injection system and the air induction system.
Also included may be hoses, belts, connectors, and other emis-
sion-related assemblies.
Where a warrantable condition exists, Northern Lights will re-
pair your off-road engine at no cost to you, including diagnosis,
parts and labor. Any warranted part, which is not scheduled for
replacement as required maintenance, shall be warranted for the
period in Table 1. If any part fails during the period of warranty
coverage, it shall be repaired or replaced by Northern Lights.
Any such part repaired or replaced under warranty shall be war-
ranted for the remaining warranty period.
As the off-road engine owner, you are responsible for the
performance of the required maintenance listed in the Owner’s
Manual. Northern Lights recommends that you retain all receipts
covering maintenance on your engine, but Northern Lights
cannot deny warranty solely for the lack of receipts or for your
failure to ensure the performance of all scheduled maintenance.
You are responsible for presenting your engine to a Northern
Lights dealer as soon as the problem exists. As the engine
owner, you should be aware that Northern Lights may deny you
warranty coverage if your engine has a part that has failed due to
abuse, neglect, improper maintenance, or unapproved modica-
tions.
Your engine is designed to operate on low sulfur (500 ppm) or
ultra-low sulfur (15 ppm) diesel fuel only. Check the owner’s
manual or the EPA sticker found on the engine for the correct
fuel type. Use of any other fuel may result in your engine no
longer operating in compliance with California’s emissions
requirements.
If you have any questions regarding your warranty rights and
responsibilities, you should contact Northern Lights at
1-800-762-0165.
CALIFORNIA EMISSIONS CONTROL
WARRANTY STATEMENT
(For off-road C.I. Diesel Engines)
NORTHERN LIGHTS ELECTRIC EMISSIONS
WARRANTY COVERAGE
Northern Lights warrants that your new off-road diesel engine,
certied for sale in California, was designed, and built to con-
form to the applicable California Air Resources Board regula-
tions for the above stated warranty period. The warranty period
begins on the date the new engine is delivered to the rst retail
purchaser. The engine model year and emissions application for
your engine are identied on the emission control label afxed
to either the rocker cover or timing case cover. This warranty
is based on the off-road engine model year stated on the label.
Your maintenance records and receipts covering the required
maintenance should be passed on to each subsequent owner of
the engine.
Any emission control system parts that are defective during
normal use will be repaired or replaced during the warranty
period. The warranty repairs and service will be performed by
any authorized dealer of Northern Lights, at the dealer’s place of
business, with no charge for parts or labor (including diagnosis).
Northern Lights will be responsible for damages to other engine
components proximately caused by a failure under warranty of
any emission warranted part.
It is recommended that replacement parts used for maintenance
or repairs are Northern Lights parts to maintain the quality origi-
nally designed into your emission certied engine. You may elect
to use other than Northern Lights parts and service for mainte-
nance, replacement, or repair without invalidating this warranty;
however, the costs of such parts and services will not be covered
under the warranty. If such parts are used the owner should
ensure that these parts are equivalent in design and durability to
Northern Lights parts. The use of non Northern Lights parts does
not invalidate the warranty on other components unless the use
of such parts cause damage to warranted parts.
Northern Lights wishes to ensure the emission control systems
warranty is being properly administered. If you believe you may
not have received the service entitled to under this warranty you
should contact Northern Lightsc for assistance. The address and
phone number is in your Operator’s Manual.
New engines certied for sale and registered in California have
the following items covered by the emission warranty when the
items were rst installed on the new engine as original equip-
ment by Northern Lights:
 Fuel Injection Pump
 Fuel Injection Nozzle
 Air Cleaner Element
 Exhaust Manifold
 Inlet Manifold
 Oil Filler Cap
 PVC Hose
 Intake Air Resonator
 Intake & Exhaust Gaskets
L581 12/12
Warranty
Model  hours/years
M/NL673 1500/2
M/NL773 1500/2
M/NL843 1500/2
M/NL844 3000/5
M864 3000/5
M944 3000/5
Table1

YOUR WARRANTY RIGHTS AND OBLIGATIONS
Northern Lights warrants to the initial purchaser and each sub-
sequent owner, that this off-road engine is designed, built and
equipped to conform at the time of sale to all applicable regula-
tions of the U.S. Environmental Protection Agency. Also that the
engine is free of defects in material and workmanship that would
cause this engine fail to conform with the EPA regulations dur-
ing the emission warranty period as indicated in Table 1.
Your emission control system may include parts such as the fuel
injection system and the air induction system. Also included
may be hoses, belts, connectors and other emission-related as-
semblies.
When a warrantable condition exists, Northern Lights will repair
your off-road engine at no cost to you, including diagnosis, parts
and labor.
MANUFACTURER’S WARRANTY COVERAGE
The off-road engines are warranted for the period indicated in
Table 1, depending on engine model. If any emission-related
part on your engine is defective, the part will be repaired or
replaced by Northern Lights. The warranty period begins on the
date of sale to the ultimate purchaser.
FEDERAL EMISSION DESIGN AND
DEFECT LIMITED WARRANTY
OWNER’S WARRANTY RESPONSIBILITIES
As the engine owner, you are responsible for the performance
of the required maintenance listed in your Owner’s Manual.
Northern Lights recommends that you retain all receipts cover-
ing maintenance on your off-road engine, but Northern Lights
cannot deny warranty solely for the lack of receipts or for your
failure to ensure the performance of all scheduled maintenance.
As the engine owner, you should be aware that Northern Lights
may deny you warranty coverage if your off-road engine or part
has failed due to abuse, neglect, improper maintenance or unap-
proved modications.
You are responsible for initiating the warranty process. You
must present your engine to an Northern Lights dealer as soon
as the problem exists. If you have any questions regarding your
warranty rights and responsibilities, contact Northern Lights by
calling 1-800-762-0165.
EMISSION CONTROL SYSTEM WARRANTY
PARTS LIST
 Fuel Injection Pump
 Fuel Injection Nozzle
 Air Cleaner Element
 Exhaust Manifold
 Inlet Manifold
 Oil Filler Cap
 PVC Hose
 Intake Air Resonator
 Intake & Exhaust Gaskets
 Turbocharger (if equipped)
 Aftercooler element (if equipped)
 Crankshaft position sensor (if equipped)
LIMITATIONS
This warranty will not cover the following:
1) diagnosis or inspection expenses that do not result in
eligible,
2) consequential damages such as loss of time, inconve-
nience, loss of use of the engine or equipment,
3) replacement parts used for required maintenance,
4) conditions resulting from tampering, misuse, abuse,
improper adjustment, engine alteration, use of add-on
or modied parts, use of replacement parts that are not
the same in performance and durability as the approved
parts, accident, failure to use recommended fuel or oil,
use of unapproved fuel or oil additives, or not perform-
ing required maintenance,
5) damages or repair costs caused by the Owner’s unrea-
sonable delay in making the engine available for inspec-
tion and repair,
6) replacement parts used for required or scheduled mainte-
nance.
L581 12/12
Table1
Warranty
Model  hours/years
M/NL673 1500/2
M/NL773 1500/2
M/NL843 1500/2
M/NL844 3000/5
M864 3000/5
M944 3000/5
Northern Lights, Lugger and Technicold brands are manufactured by Northern Lights, Inc.