ORA XL MIRROR User manual

Tools
• Flatscrewdriver
• Phillipsheadscrewdriver
• 10mmRingspanneror10mmSocket
• PlasticRulerorsomethingsimilartoprotectthetrim
• Containertoholdscrewsandlooseitems
Installation
Therstprocedureistoremovetheinternaldoorcover.
Instructionsbelowmayrefertothe“latchend”orthe“hingeend”.
Thismeansthatifyoulookatthedriver’sdoorfromtheinside,theRightsideisthe“latch
end”,andtheLeftsideisthe“hingeend”.
1. Lowerdoorwindowalltheway.
2. Remove4screwsatbaseofthedoor.
INSTRUCTIONSTOINSTALLTHE
ORAXLMIRROR
TOTHETOYOTALANDCRUISER100SERIES
LATCH
END
HINGE
END
IMPORTANT: DO NOT ALTER THE PRE-SET ANGLE OF THE MIRROR
UNTIL YOU HAVE INSTALLED IT. SHIFTING IT OUT OF ITS DEFAULT
POSITION COULD DAMAGE PARTS.
1
More information https://www.caravansplus.com.au

3. Remove2plasticcapsat“hingeend”.Theywillpopouteasilywithaatscrewdriver.
4. Removescrewsundercap.
5. Removetriangularplasticcoveratthe“hingeend”coveringthemirrorbolts.Itwill
detachwithsomermmanualpressure.
6. Doorhandle:Popoutthescrewcoverbywedginginaatscrewdriver.Remove
screwbehindthecover.
2
More information https://www.caravansplus.com.au

7. Removedoorlatchoutercoverwithatscrewdriver.Loosentoprst,thenthebottom.
8. Removeelectricalwindowcontrolpanelusingatscrewdriverandaplasticruleror
similartoprotectthetrim.
9. Removethewireplugbehindtheelectricalwindowcontrolpanelbypressingsmall
tag.
10. Removethescrewbehindthewindowcontrolpanel.
3
More information https://www.caravansplus.com.au

11. Remove2plasticpinsat“latchend”and1atthe“hingeend”.UsePhillipsscrew
drivertopopinsidebuttonthenremoveusingyourngernailstoliftthemout.
12. Allthescrewsandpinsconnectingthedoorcovershouldnowberemoved.Tap
underneaththedoorcoverwiththepalmofyourhanduntilthetopseparatesfromthe
windowcavity.Thenremovethedoorpanel.
13. Unplugtheelectricalwiringconnectingtothemirrorelectricsbypressingthesmall
tag.
4
More information https://www.caravansplus.com.au

ThenextprocedureistoremovetheexistingmirrorandtoinstalltheORAXL.It may be
helpful to have another person assist with holding the mirrors whilst they are being
detached and installed.
14. Use10mmsocketorringspannertoloosenthebolts,beginningwiththebottombolts.
15. Donottouchthescrewinthecentre.Thisscrewhelpssupportthemirrorwhilstyou
areremovingbolts.Oncetheboltshavebeenremovedliftthemirrorandcarefully
removeandfeedelectricalcablethrough.
16. SeattheORAXLmirrorinplace,ensuringthattherubbersealisushandinposition.
17. Screwinthetopboltrst(initiallynottootight)thentheothers.Thentightenallbolts.
5
More information https://www.caravansplus.com.au

18. Connectthemirror’selectricalplugends.Thencheckthattheelectricalmirrorbuttons
work.Thelargertopsectionofthemirrorshouldmoveleft/right/up/downasyour
standardmirrordid.Thebottommirrorismanuallyadjusted.
19. Replacethedoorpanel.Makesurethatyoufeedthroughthecablefortheelectric
windowrst.Then,startingwiththewindowcavityatthetop,usingsomemanual
pressuretopopitintoplace.

20. Replacethe2plasticpinsatthe“latchend”thenthesinglepinatthe“hingeend”.
Hint:preparethepinbypushingtheshaftthroughpastthehead.Thenpopitback
intothehole,andpressthecentrepinuntilush.
21. Replacethetwoscrewsandplasticcapsatthe“hingeend”onthedoor.
6
More information https://www.caravansplus.com.au

22. Replacethe4basescrews.
23. Replacethedoorhandlecover.Thenreplacethescrewbehindthedoorhandle.
24. Replacethetriangularplasticcover.
YournewORAXLtowingmirrorisnowreadytouse.
TheMirrorsarepresettotheoptimumangleforviewingfromthedriver’sposition.However
theywillfoldinifyouaccidentallystrikeanobject.
ORAXLmirrorswillextendoutanextra100mmifrequired.Firmlypullonthemirrorhead
untilitslidesallthewayout.
Ifyouhaveanyquestionscalluson02)62393858
Disclaimer;
Theseinstructionsareforaninstallerwithbasiccompetencyinhandlingtools.Theaveragehandy-personshould
beabletoinstallthesemirrorswithoutdamaginganycarcomponents.Ifyoudonotfeelthatyouhavetheseskills,
pleasehavetheminstalledbyasuitablyqualiedtradeperson(eg.amechanic).ORAProductsdoesnottakeany
responsibilityfordamagetothecarthatmayoccurasaresultoftheinstallationorremovaloftheORAXLMirrors.
7
More information https://www.caravansplus.com.au