Outdoor Lifestyles ODVILLAG-36T User manual

1OutdoorLifestyles•VillaGasOwners/InstallationManual•4072-170•RevC•04/01/14
WARNING: Foroutdooruseonly.
Outdoor Decorative Gas Appliance
Thisapplianceisonlyforusewiththetype(s)ofgasindicated
ontheratingplate.Thisapplianceisnotconvertibleforuse
withothergases,unlessacertiedkitisused.
NOTforusewithsolidwoodfuel.
Model(s):
Installation Manual
Installation and Fireplace Setup
WARNING
HOT SURFACES!
Glassandothersurfacesarehotduring
operationANDcooldown.
Hot glass will cause burns.
• DO NOTtouchglassuntilitiscooled
• NEVERallowchildrentotouchglass
• Keepchildrenaway
• CAREFULLY SUPERVISE children in same area as
replace.
• Alertchildrenandadultstohazardsofhightemperatures.
Hightemperaturesmayigniteclothingorotherflammable
materials.
• Keepclothing,furniture,draperiesandotherammable
materialsaway.
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
ODVILLAG-36T ODVILLAG-36H
ODVILLAG-42T ODVILLAG-42H
NOTICE: DO NOT discard this manual!
Pourdemanderunexemplaire
enfrançaisdeceManuel
dupropriétaire,visitezwww.
heatnglo.com/translations.
DANGER
Ifyousmellgas:
1. Shutoffgastotheappliance.
2. Extinguishanyopename.
3. If odor continues, keep away from the
applianceandimmediatelycallyourgas
supplierorredepartment.
WARNING
Donotstoreorusegasolineorotheram-
mablevaporsandliquidsinthevicinityof
thisoranyotherappliance
AnLP-cylindernotconnectedforuseshall
not be stored in the vicinity of this or any
otherappliance.
WARNING: Improper installation, ad-
justment,alteration,serviceormaintenance
cancauseinjuryorpropertydamage.Read
theinstallation,operatingandmaintenance
instructionsthoroughly before installing or
servicingthisequipment.

2Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
Safety Alert Key:
• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.
• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.
• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.
• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.
Table of Contents
1 Welcome
A.Congratulations 4
ListingLabelInformation/Location 4
B.Warranty 5
2 ProductSpecic&ImportantSafetyInformation
A.ApplianceCertication 7
B.BTUSpecications 7
C.Non-CombustibleMaterials 7
D.CombustibleMaterials 7
E.HighAltitudeInstallations 7
3 Getting Started
A.DesignandInstallationConsiderations 8
MoistureResistance 8
B.InspectApplianceandComponents 8
4 Framing and Clearances
A.ApplianceDimensionDiagram 9
B.ClearancestoCombustibles 10
C.ConstructingtheApplianceEnclosure 11
D.SecuringandLevelingtheAppliance 12
E.Non-CombustibleMaterialInstallation 12
5 Gas Information
A.FuelConversion 13
B.GasPressure 13
C.GasConnectionsProvision 13
D.HighAltitudeInstallations 14
E.AirShutterSetting 14
6 Finishing
A.FacingMaterial 15
B.MantelandWallProjections 16
Mantels 16
MantelLegsorWallProjections 17
7 Appliance Setup
A.RemovetheShippingMaterials 18
B.CleantheAppliance 18
D.InstallGasLogSet(provided) 18
E.InstallMeshDoor(optional) 18
8 Maintenance and Service
9 Reference Materials
A.ServiceParts 20
B.Accessories 24
C.ContactInformation 25
►

3
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
Customer:
Lot/Address
Model (circle one): ODVILLAG-36T
ODVILLAG-36H
ODVILLAG-42T
ODVILLAG-42H
YES IF NO, WHY?
Dealer/Distributor Phone #
Serial #:
Combustiblematerialsnotinstalledinnon-combustibleareas.
Appliance Install
Requirednon-combustibleboardisinstalled(ifapplicable).(Pg.13)
Finishing Section 6 (Pg. 16)
Appliance Setup Section 7 (Pg. 18)
Verifiedallclearancesmeetinstallationmanualrequirements.
Mantelsandwallprojectionscomplywithinstallationmanualrequirements.
WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or
explosion.
Theenclosureisinsulatedandsealed.(Pg.8)
Verifiedclearancestocombustibles.(Pg.10)
Applianceisleveledandsecured.(Pg.12)
ATTENTION INSTALLER:
Follow this Standard Work Checklist
Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthisinstallationmanual.
Date Installed:
Location of Appiance
Installer:
Allpackagingandprotectivematerialsremoved.
Refractory,logs,mediaandembersinstalledcorrectly.
Hearth&HomeTechnologiesrecommendsthefollowing:
Commentscommunicatedtopartyresponsible
4072-171•RevA•07/25/13
•Photographingtheinstallationandcopyingthischecklistforyourfile.
Startedapplianceandverifiednogasleaksexist.
Manualbagandallofitscontentsareremovedfromthefireplaceandgiventotheparty
responsibleforuseandoperation.
•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.
Optionalmeshdoorsproperlyinstalled.
yg y
__________________________by______________________on_________
(Builder/Gen.Contractor)(Installer)(Date)
Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

4Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
1 Welcome
Readthismanualbeforeinstallingoroperatingthisreplace.
Pleaseretainthisowner’smanualforfuturereferences.
A. Congratulations
Listing Label Information/Location Themodelinformationregardingyourspecicreplacecanbefoundonthe
ratingplateusuallylocatedinthecontrolareaofthereplace.
Brand: ________________________________________________ ModelName: ___________________________
SerialNumber:__________________________________________ DateInstalled: __________________________
Fireplace Information:
Local Dealer Information
DEALER: Fill in
your name, address,
phone and e-mail
information here and
replaceinformation
below.
DealerName:________________________________________________________
Address:____________________________________________________________
____________________________________________________________
Phone:_____________________________________________________________
E-mail:_____________________________________________________________
Fireplace
Model
Serial
Number
CongratulationsonselectingaOutdoorLifestylesdeco-
rativegasappliance.TheHHTgasapplianceyouhave
selectedisdesignedtoprovidetheutmostinsafetyand
reliability.
Astheownerofanewgasappliance,you'llwanttoread
andcarefullyfollowalloftheinstructionscontainedinthis
Owner'sManual.PayspecialattentiontoallCautionsand
Warnings.
ThisOwner'sManualshouldberetainedforfuturerefer-
ence.Wesuggestthatyoukeepitwithyourotherimpor-
tantdocumentsandproductmanuals.
YournewOutdoorLifestylesdecorativegasappliancewill
giveyouyearsofdurableuseandtrouble-freeenjoyment.
WelcometotheHeatilatorfamilyofreplaceproducts!
OutdoorLifestylesisaregisteredtrademarkofHearth&
HomeTechnologies.
This appliance must be installed in accordance
with local codes, if any; if not, follow ANSI
Z223.1 in the USA installation codes.
Serial (Serie):
Mfg. Date:
Outdoor decorative gas appliance - for
outdoor use only. Not for use with solid fuel.
(Foyer au gaz à évacuation - pour
installation à l'extérieur seulement. Ne doit
pas entre utilise avec un combustible solide.)
Minimum Permissible Gas Supply for Purposes
of Input Adjustment. Natural Gas Propane Gas
Approved Minimum (De Gaz) Acceptable . . 7.0 in. w.c. (Po. Col. d'eau) . . .11.0 in. w.c. (Po. Col. d'eau)
Maximum Pressure (Pression) . . . . . . . . . . 10.0 in. w.c. (Po. Col. d'eau) . .14.0 in. w.c. (Po. Col. d'eau)
Maximum Input BTUH (36 in.): . . . . . . . . . . 40,000 . . . . . . . . . . . . . . . . . . .40,000
Maximum Input BTUH (42 in.): . . . . . . . . . . 42,000 . . . . . . . . . . . . . . . . . . .42,000
This product is covered by one or more of the following patents: (Nos produits sont couverts par un ou plusieurs des brevels suivants): (United States) 4,112,913; 4,408,594; 4,422,426; 4,424,792; 4,520,791; 4,793,322; 4,852,548; 4,875,464; 5,000,162; 5,016,609; 5,076,254; 5,191,877;
5,218,953; 5,328,356; 5,429,495; 5,452,708; 5,542,407; 5,613,487; (Australia) 543790; 586383; (Canada) 1,123,296; 1,297,746; 2,195,264; (Mexico) 97-0457; (New Zealand) 200265; or other U.S. and foreign patents pending (ou autres brevets americains et etrangers en attente). 4072-166A
MADE
IN USA
ODVILLAG-36T
ODVILLAG-36H
ODVILLAG-42T
ODVILLAG-42H
Model
(Modele):
ANSI Z21.97-2012
CSA 2.41-2012
Outdoor Decorative
Gas Appliances
Outdoor Lifestyles by
Hearth & Home Technologies
7571-215th St. West, Lakeville, MN 55044
OD *
29LD
WARNING! Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage. Refer to the
owner’s information manual provided with this appliance. For
assistance or additional information, consult a qualified installer,
service agency or the gas supplier.
!
WARNING! DO NOT store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the
vicinity of this or any other appliance.
!

5
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
B. Warranty
Outdoor Lifestyles by Hearth & Home Technologies™
Warranty
Hearth & Home Technologies (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™
brand products (“Products”) that are purchased from an HHT authorized dealer.
WARRANTY COVERAGE:
HHT warrants to the original owner of the Product at the site of installation, and to any transferee taking
ownership of the Product at the site of installation within one year following the date of original purchase,
that the Product will be free from defects in materials and workmanship at the time of manufacture. After
installation, if covered components manufactured by HHT are found to be defective in materials or
workmanship during the applicable warranty period, HHT will, at its option, repair or replace the covered
components. This warranty is subject to conditions, exclusions and limitations as described below.
WARRANTY PERIOD:
The warranty period runs for one year, beginning on the earlier of: (i) the date of invoice for the Product;
(ii) in the case of new home construction, the date of first occupancy of the residence or six months after
the date of sale of the Product by an HHT authorized dealer, whichever occurs first; or (iii) the date 24
months following the date of Product shipment from HHT, regardless of the invoice or occupancy date.
WARRANTY CONDITIONS:
•This warranty only covers Products that are purchased through an HHT authorized dealer or
distributor. A list of HHT authorized dealers is available on the HHT branded websites.
•This warranty is only valid while the Product remains at the site of original installation.
•Contact your installing dealer for warranty service. If the installing dealer is unable to provide
necessary parts, contact the nearest HHT authorized dealer or supplier. Additional service fees
may apply if you are seeking warranty service from a dealer other than the dealer from whom
you originally purchased the Product.
•Check with your dealer in advance for any costs to you when arranging a warranty call. Travel
and shipping charges for parts are not covered by this warranty.
WARRANTY EXCLUSIONS:
This warranty does not cover the following:
•Changes in surface finishes as a result of normal use. As a heating appliance, some changes in
color of interior and exterior surface finishes may occur; this is not a flaw and not covered under
warranty.
•Damage to printed, plated, or enameled surfaces caused by fingerprints, accidents, misuse,
scratches, melted items, or other external sources and residues left on surfaces from the use of
abrasive cleaners or polishes.
•Repair or replacement of parts that are subject to normal wear and tear during the warranty
period. These parts include: paint, firebricks, grates, flame guides and the discoloration of glass.
•Minor expansion, contraction, or movement of certain parts causing noise. These conditions are
normal and complaints related to this noise are not covered by this warranty.
Outdoor Lifestyles Warranty - 2108-975B - 2/15/13 - page 1
►

6Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
 • Damagesresultingfrom:(1)failuretoinstall,operate,ormaintaintheProductinaccordancewith
theinstallationinstructions,operatinginstructions,andlistingagentidentificationlabelfurnished
withtheProduct;(2)failuretoinstalltheProductinaccordancewithlocalbuildingcodes;(3)
shippingorimproperhandling;(4)improperoperation,abuse,misuse,continuedoperationwith
damaged,corrodedorfailedcomponents,accident,orincorrectlyperformedrepairs;(5)inad-
equateventilation,negativepressureorenvironmentalconditions,including,withoutlimitation:
hail,snow,ice,fallenbranches,flooding,waterdamageandfadingofcolor;(6)useoffuelsother
thanthosespecifiedintheoperatinginstructions;(7)installationoruseofcomponentsnot
suppliedwiththeProductoranyothercomponentsnotexpresslyauthorizedandapprovedby
HHT;(8)modificationoftheProductnotexpresslyauthorizedandapprovedbyHHTinwriting;
and/or(9)interruptionsorfluctuationsofelectricalpowersupplytotheProduct.
 • Non-HHTventingcomponents,hearthcomponentsorotheraccessoriesusedinconjunctionwith
theProduct.
 • Anypartofapre-existingfireplacesysteminwhichaninsertoradecorativegasapplianceis
installed.
 • TheProduct’scapabilitytoheatthedesiredspace.Informationisprovidedtoassisttheconsumer
andthedealerinselectingtheproperappliancefortheapplication.Considerationmustbegiven
totheProduct’slocationandconfigurationandenvironmentalconditions.
This warranty is void if:
 • TheProducthasbeenover-firedoroperatedinatmospherescontaminatedbychlorine,fluorine,
orotherdamagingchemicals.Over-firingcanbeidentifiedby,butnotlimitedto,warpedplatesor
tubes,rustcoloredcastiron,bubbling,crackinganddiscolorationofsteelorenamelfinishesand
crackingorspallingofrefractoryorcementitiousmaterials.
 • TheProductissubjectedtoprolongedperiodsofdampness,condensation,iceorsnow.
 • ThereisanydamagetotheProductorothercomponentsduetowaterorweatherdamagewhich
istheresultof,butnotlimitedto,improperchimneyorventinginstallation.
LIMITATIONS OF LIABILITY:
Repairorreplacementinaccordancewiththeprovisionsofthiswarrantywillbetheowner’sexclusive
remedyforandwillconstituteHHT’ssoleobligationunderthiswarranty,underanyotherwarranty
(expressorimplied),orincontract,tortorotherwise;provided,however,thatifHHTisunabletoprovide
repairorreplacementinanexpedientandcosteffectivemanner,HHTmaydischargeallsuchobligations
byrefundingthepurchasepriceoftheProduct.Noemployee,agent,dealer,orotherpersonisauthorized
togiveanywarrantyonbehalfofHHT.TOTHEEXTENTALLOWEDBYLAW,HHTMAKESNOOTHER
WARRANTY,EXPRESSORIMPLIED,INCLUDINGANYWARRANTYOFMERCHANTABILITYOR
FITNESSFORAPARTICULARPURPOSE.HHTWILLNOTBELIABLEFORANYCONSEQUENTIAL
ORINCIDENTALDAMAGESARISINGOUTOFDEFECTSINORUSEOFTHEPRODUCTS.Some
statesdonotallowexclusionsorlimitationofincidentalorconsequentialdamages,sotheselimitations
maynotapplytoyou.Thiswarrantygivesyouspecificrights;youalsomayhaveotherrights,whichvary
fromstatetostate.Thedurationofanyimpliedwarrantyislimitedtothedurationofthewarrantyperiod
specifiedherein.
OutdoorLifestylesWarranty-2108-975B-2/15/13-page2

7
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
C. Non-Combustible Materials
• Materialswhichwill notignite andburn,composed of
anycombinationofthefollowing:
- Steel - Iron
- Brick - Tile
- Concrete - Slate
- Glass - Plasters
• MaterialsreportedaspassingASTM E 136, Standard
Test Method for Behavior of Metals, in a Vertical Tube
Furnace at 750° C
D. Combustible Materials
• Materialsmadeoforsurfacedwithanyofthefollowing
materials:
- Wood - Compressedpaper
- Plantbers - Plastic
- Plywood/OSB - Sheetrock(drywall)
• Anymaterialthatcanigniteandburn;ameproofedor
not,plasteredorun-plastered
2 ProductSpecic&ImportantSafetyInformation
A.ApplianceCertication
MODELS: ODVILLAG-36T,ODVILLAG-36H,
 ODVILLAG-42T,ODVILLAG-42H
LABORATORY:UnderwritersLaboratoriesInc.(UL)
TYPE:OutdoorDecorativeGasAppliance
STANDARD: ANSIZ21.97-2012/CSA2.41-2012
E. High Altitude Installations
NOTICE: If the heating value of the gas has been reduced,
these rules do not apply. Check with your local gas utility or
authorities having jurisdiction.
Wheninstallingabove2000feetelevation:
• IntheUSA:Reduceinputrate4%foreach1000feet
above2000feet.
• In CANADA: Input ratings are certified without a
reduction of input rate for elevations up to 4500 feet
(1370m)abovesealevel.Pleaseconsultprovincialand/
orlocalauthoritieshavingjurisdictionforinstallationsat
elevationsabove4500feet(1370m).
Checkwithyourlocalgasutilitytodetermineproper
oricesize.
B.BTUSpecications
Thisapplianceislistedforusewiththeoutdoordecora-
tivegaslogsetsupplied.
MaximumallowableBTUratings:
Unit Max BTU/HR
ODVILLAG-36 40,000
ODVILLAG-42 42,000
When an appliance is for connection to a xed piping
system, the installation must conform with local codes,
orintheabsenceoflocalcodeswiththe National Fuel
Gas Code, ANSI Z223.1/NFPA 54, or International Fuel
Gas Code.
ThisproductislistedtoANSIstandardsforoutdoordeco-
rativegasappliances.
OutdoorLifestylesisaregisteredtrademarkofHearth&
HomeTechnologies.

8Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
3 Getting Started
A. Design and Installation Considerations
Check building codes prior to installation.
• Installation MUST comply with local, regional,
stateandnationalcodesandregulations.
• Consult insurance carrier, local building, fire
ofcials or authorities having jurisdiction about
restrictions,installationinspection,andpermits.
CAUTION
Whenplanninganapplianceinstallation,it’snecessaryto
determinethefollowinginformationbeforeinstalling:
• Wheretheapplianceistobeinstalled.
• Gassupplypiping.
• Electricalwiring.
• Framingandnishingdetails.
Moisture Resistance
Thisoutdoorgasappliancewillshedmoderateamounts
ofwater,butisnotwaterproof.Waterandcondensing
watervapormayentertheenclosureundercertaincondi-
tions.
Theappliancewillnotperformasanexteriorwall.Mois-
turepenetrationmustbeconsideredforconstructionthat
placestheapplianceinstructurewallsoronmoisture
sensitivesurfaces.
When installed on exterior walls:Hearth&Home
Technologiesrecommendsthattheapplianceenclosure
beconstructedoutsidethestructure’sweatherenvelope.
Wheretheplatformmeetsthewall,useaashingdetail
similartothatrequiredforattacheddecks.Enclosure
platforms,includinghearthsshouldslopeawayfromthe
Theseappliancesmustbeinstalledoutdoors.
Thisoutdoorgasapplianceisdesignedforoutdooruse.It
mayalsobeinstalledinscreenedporchesandlanaisthat
meettheseminimumrequirements:
• Minimumporcharea:96sq.ft.
• Minimumceilingheight84in.
• Minimumoftwowallsmustbescreened.
• Minimumtopofscreenheight,sidewalls:6ft.8in.
• Minimumscreenarea:64sq.ft.
RefertoSection4.B.forclearances.
structureat1/8in.to1/4in.perfoot.Theappliancecan
beshimmedlevel.
When installed on surfaces where water may collect
or cause damage:Hearth&HomeTechnologiesrecom-
mendsthatadrainagepanbeplacedundertheunit.This
canbeconstructedofmetal,adhesivepolymermem-
brane(suchasiceandwatershield)orothersuitable
materials.Ameansofdrainageoutofthepansuchas
tubesorweepholesshouldbeprovided.Aslopeof1/8in.
to1/4in.perfoottowardsthedrainportissuggested.The
appliancecanbeshimmedlevel.
Hearthsshouldslopeawayfromthefrontoftheappliance
andenclosureat1/8in.to1/4in.perfoot.
B. Inspect Appliance and Components
• Remove the appliance and components from the
packagingandinspectfordamage.
• Reportanypartsdamagedinshipmenttoyourdealer.
• Read all the instructions before starting the
installation. Follow these instructions carefully
during the installation to ensure maximum safety
andbenet.
WARNING! Risk of Fire or Explosion! Damaged parts
could impair safe operation. DO NOT install damaged, in-
complete or substitute components. Keep alliance dry.
Hearth&HomeTechnologiesdisclaimsanyresponsibil-
ityfor,andthewarrantywillbevoidedby,thefollowing
actions:
• Installationanduseofanydamagedappliance.
• Modicationoftheappliance.
• InstallationotherthanasinstructedbyHearth&Home
Technologies.
• Improperpositioningofthegaslogs.
• Installation and/or use of any component part not
approvedbyHearth&HomeTechnologies.
Anysuchactionmaycausearehazard.
WARNING! Risk of Fire or Explosion! DO NOT use this
applianceifanyparthasbeenunderwater.Callaqualied
service technician to inspect the appliance and to replace
any part of the gas control system which has been under
water.

9
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
4 Framing and Clearances
A. Appliance Dimension Diagram
Dimensionsareactualappliancedimensions.Useforreferenceonly.ForframingdimensionsandclearancesrefertoSection5.
Figure 4.1 Appliance Dimensions
23 3/4 in.
603 mm
21 3/8 in.
543 mm
68°
9 1/4 in.
235 mm
7 1/2 in.
191 mm
GAS
KNOCKOUT
48 1/4 in.
1226 mm
36 in.
914 mm
41 1/8 in.
1045 mm
GAS
KNOCKOUT
19 3/4 in.
502 mm
20 7/8 in.
530 mm
7 5/8 in.
194 mm
9 1/4 in.
235 mm
7 1/2 in.
191 mm
39 1/2 in.
1003 mm
7 5/8 in.
194 mm
29 3/4 in.
756 mm
21 3/8 in.
543 mm
68°
9 1/4 in.
235 mm
7 1/2 in.
191 mm
GAS
KNOCKOUT
48 1/4 in.
1226 mm
42 in.
1067 mm
47 1/8 in.
1197 mm
GAS
KNOCKOUT
19 3/4 in.
502 mm
20 7/8 in.
530 mm
7 5/8 in.
194 mm 9 1/4 in.
235 mm
7 1/2 in.
191 mm
39 1/2 in.
1003 mm
7 5/8 in.
194 mm
ODVILLAG-36
ODVILLAG-42

10 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
B. Clearances to Combustibles
Whenselectingalocationfortheapplianceitisimpor-
tanttoconsidertherequiredclearancestowalls(see
Figure4.2).
WARNING! Risk of Fire or Burns! Provide adequate
clearance around air openings and for service access.
Due to high temperatures, the appliance should be lo-
catedoutoftrafcandawayfromfurnitureanddraperies.
NOTICE: Illustrationsreecttypicalinstallationsandare
FOR DESIGN PURPOSES ONLY. Illustrations/diagrams
are not drawn to scale. Actual installation may vary due to
individual design preference.
B
Note: If this surface is
inside the building’s
warm air envelope...
D
D
57-3/4 in.
(1467 mm)
D
...then this surface
must be an exterior
wall system.
D
DC
C
D
A
D
Figure 4.2 Appliance Locations
A B C D
ODVILLAG-36 in. 67 7/8 21 1/2 42 1/2
mm 1724 546 1067 13
ODVILLAG-42 in. 73 7/8 21 1/2 48 1/2
mm 1876 546 1219 13

11
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
Use only noncombustible
material below the top of
the top standoffs.
1/2 in. (13 mm)
1/2 in. (13 mm)
1/2 in.
(13 mm)
Combustible
facing
0 in.
Combustible flooring may be installed next
to the front of the appliance.
84 in.
(2134 mm)
to ceiling
0 in.
Combustible Object
36 in.
(914 mm)
Upper front can be
covered with
non-combustible
material or removed
and replaced with
non-combustible
material.
0 in. to level
of standoffs
C
B
A
Framing Dimensions A B C
ODVILLAG-36 in. 21 1/2 39 3/4 42
mm 546 1010 1067
ODVILLAG-42 in. 21 1/2 39 3/4 48
mm 546 1010 1219
Figure 4.3 Framing Dimensions
C. Constructing the Appliance Enclosure
NOTICE: Install appliance on hard metal or wood surfaces
extending full width and depth. DO NOT install directly on
carpeting, vinyl, tile or any combustible material other than
wood.
WARNING! Risk of Fire! Maintainspeciedairspace
clearances to appliance.
• Insulation and other materials must be secured to
prevent accidental contact.
• The enclosure must be properly blocked to prevent
blown insulation or other combustibles from entering
andmakingcontactwithreplaceorchimney.
• Failuretomaintainairspacemaycauseoverheatingand
are.

12 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
D. Securing and Leveling the Appliance
WARNING! Risk of Fire! Prevent contact with:
• Saggingorlooseinsulation
• Insulationbackingorplastic
• Framingandothercombustiblematerials
Block openings into the enclosure to prevent entry of
blown-in insulation. Make sure insulation and other ma-
terials are secured.
DO NOT notch the framing around the appliance
standoffs.
Failure to maintain air space clearance may cause over-
heatingandre.
The diagram shows how to properly position and secure
theappliance(seeFigure4.4).Nailingtabsareprovidedto
securetheappliancetotheframingmembers.
• Bendoutnailingtabsoneachside.
• Placetheapplianceintoposition.
• Keepnailingtabsushwiththeframing.
• Leveltheappliancefromsidetosideandfronttoback.
• Shimtheapplianceasnecessary.Itisacceptabletouse
woodshimsunderneaththeappliance.
• Securetheappliancetotheframingbyusingnailsor
screwsthroughthenailingtabs.
• Securetheappliancetotheoorbyinsertingtwoscrews
throughthepilotholesatthebottomoftheappliance.
Figure 4.4 Proper Positioning and Securing of an Appliance
NAILING TABS
(BOTH SIDES)
E. Non-Combustible Material Installation
Combustible
Framing
12 in.
Noncombustible
Facing
Combustible
Facing
Figure 4.5 Noncombustible Material Installation
• A 12 in. noncombustible facing material (supplied) is
required off the top of the appliance.Above 12 in., a
combustiblefacingmaterialisacceptable.
• Combustibleframingcanbeinstalledaboveappliance
topstandoffs,behindthe12in.noncombustiblefacing.

13
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
A. Fuel Conversion
• Make sure the appliance is compatible with available
gastypes.
• Conversions must be made by a qualified service
technicianusingHearth&HomeTechnologiesspecied
andapprovedparts.
WARNING! Risk of Fire or Explosion! High pressure
will damage valve. Low pressure may cause explosion.
• Verifyinletpressures.Verifyminimumpressureswhen
otherhouseholdgasappliancesareoperating.
• Install regulator upstream of valve if line pressure is
greaterthan1/2psig(14in.w.c.).
5 Gas Information
FireRisk.
ExplosionHazard.
Highpressurewilldamagevalve.
• Disconnect gas supply piping BEFORE
pressuretestinggasline attestpressures
above1/2psig.
• Close the manual shutoff valve BEFORE
pressuretestinggasline attestpressures
equaltoorlessthan1/2psig.
WARNING
When an appliance is for connection to a xed piping
system, the installation must conform with local codes,
orintheabsenceoflocalcodeswiththe National Fuel
Gas Code, ANSI Z223.1/NFPA 54, or International Fuel
Gas Code.
B. Gas Pressure
Refertoinstructionsprovidedwithlogset.
Firebox
Repack
insulation
knockout
Combustible
materials
Maintain air clearance
to combustibles.
Gas line Gas line
Refractory
Seal with
fireplace mortar
or non-combust-
ible sealant
Outer shell
of fireplace
Figure 5.1 Gas Line Installation
C. Gas Connections Provision
WARNING! Fire and/or Asphyxiation Risk! Use with
outdoor decorative appliance only. Not for use with solid
fuel.
Thecertiedoutdoordecorativegaslogset(supplied)
mustbeinstalledinthisreplace.
• Knockoutsareprovidedonbothsidesofthereplace
andinrefractoriesfor1/2in.(13mm)ironpipe.
• Sealrefractoryaroundpipe with replace mortar or a
non-combustiblesealant.

14 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
D. High Altitude Installations
NOTICE: If the heating value of the gas has been reduced,
these rules do not apply. Check with your local gas utility or
authorities having jurisdiction.
Wheninstallingabove2000feetelevation:
• IntheUSA:Reduceinputrate4%foreach1000feet
above2000feet.
• InCANADA:Inputratingsarecertiedwithoutareduction
of input rate for elevations up to 4500 feet (1370 m)
above sea level. Please consult provincial and/or
local authorities having jurisdiction for installations at
elevationsabove4500feet(1370m).
Checkwithyourlocalgasutilitytodetermineproperorice
size.
E. Air Shutter Setting
Refertoinstructionsprovidedwithlogset.

15
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
6 Finishing
A. Facing Material
• Metalfrontfacesmaybecoveredwithnon-combustible
materialsonly.
• Facingand/ornishingmaterialsmustnotinterferewith
airowthroughlouvers,operationoflouversordoors,
oraccessforservice.
• Facingand/ornishingmaterialsmustneveroverhang
intotheapplianceopening.
• Observe all clearances when applying combustible
materials.
• Sealjointsbetweenthenishedwallandappliancetop
and sides using a 300º F minimum sealant. Refer to
Figure10.1.
WARNING! Risk of Fire! DO NOT apply combustible ma-
terials beyond the minimum clearances. Comply with all
minimumclearances to combustibles as speciedinthis
manual. Overlapping materials could ignite and will inter-
fere with proper operation of doors and louvers.
0 in. 0 in.
0 in.
Finish wall material may be
combustible - Top and Sides
High Temperature Sealant (300° F/149° C min.)
Top and Side Seal Joint
12 in. noncombustible
material (required)
Figure 6.1 Non-combustible Facing Diagram

16 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
Measured from top of hood (in inches)
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
84 in. minimum
floor to ceiling
Floor
2
1
A B C D E F G H I J K L M N O P Q R
A B C D E F G H I J K L M N O P Q R
Com bus tible
in. 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33
mm 406 432 457 483 508 533 559 584 610 635 660 686 711 737 762 787 813 838
Noncom bus tible
in. 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29
mm 305 330 356 381 406 432 457 483 508 533 559 584 610 635 660 686 711 737
B. Mantel and Wall Projections
WARNING! Risk of Fire! Comply with all minimum clear-
ancesasspecied.Framingcloserthantheminimumslisted
must be constructed entirely of non-combustible materials
(i.e., steel studs, concrete board, etc.).
Mantels
Figure6.2 MinimumVerticalandMaximumHorizontalDimensionsofCombustibles

17
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
12 IN. (305 MM) MIN.
TO PERPENDICULAR WALL
A
14-1/2 IN. (368 MM) MIN.
FROM FIREPLACE OPENING
TO PERPENDICULAR WALL
B
Mantel leg or
perpendicular wall
Combustible
Facing Material
A
B
6 IN. (152 MM) MIN.
TO PERPENDICULAR WALL
A
8-1/2 IN. (216 MM) MIN.
FROM FIREPLACE OPENING
TO PERPENDICULAR WALL
B
Combustible
Noncombustible
Figure 6.3 Mantel Leg or Wall Projections (Acceptable on both sides of opening)
Mantel Legs or Wall Projections

18 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
7 Appliance Setup
D. Install Gas Log Set (provided)
Refertoinstallationinstructionsprovidedwithlogset.
A. Remove the Shipping Materials
Removegaslogset(2boxes)frominsidetherebox.
B. Clean the Appliance
Clean/vacuumanysawdustthatmayhaveaccumulated
insidetherebox.
E. Install Mesh Door (optional)
Refertoinstructionsprovidedwithmeshdoors.
WARNING! Risk of Fire! Install ONLY doors or fronts
approved by Hearth & Home Technologies. Unapproved
doorsorfrontsmaycausereplacetooverheat.
C. Install Hood
• Loosensixscrewslocatedonbottomedgeofupperface.
• Slidehoodintoposition.
• Tightensixscrewspreviouslyloosened.
Figure 7.1 Install Hood

19
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
8 Maintenance and Service
• Refer to installation instructions provided with the log
set.
• Any guard or other protective device removed for
servicing the appliance must be replaced prior to
operatingtheappliance.
• Installation and repair should be done by a qualied
service person. The appliance should be inspected
beforeuseandatleastannuallybyaqualiedservice
person. More frequent cleaning may be required as
necessary. It is imperative that control compartment,
burners, and circulating air passageways of the
appliancebekeptclean.

20 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-170 • Rev C • 04/01/14
9 Reference Materials
Service Parts ODVILLAG-36T, ODVILLAG-36H
Beginning Manufacturing Date: Jan 2011
Ending Manufacturing Date: Active
IMPORTANT:THISISDATEDINFORMATION.Partsmustbeorderedfromadealerordistributor.
Hearth and Home Technologies does not sell directly to consumers.Providemodel
numberandserialnumberwhenrequestingservicepartsfromyourdealerordistributor.
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
HearthKitw/Logs,24”NG 4072-180 Y
For valve and log service parts see the instructions included in the above kits.
1 TopStandoff Qty4req 4044-111
2 Non-combustibleLip,36” 4072-254
3 Non-combustibleFront 4072-174
4 Hood 4072-244
5 UpperTrim 4072-121
6 LeftSideTrim 4072-125
7 FirescreenRod 1piece 4072-133
8 FirescreenAssembly 4072-019 Y
9 LowerTrim 4072-120
10 RightSideTrim 4072-124
11 NailingFlange Qty4req 4044-161
ConversionKit,LP LPK-ODVILLAG Y
InstallationInstructionsandOwner’sManual 4072-170
Additionalservicepartsfollowingpage. 11/13
36” Outdoor Gas Fireplace
1
2
3
4
5
6
7
8
9
10
11
A. Service Parts