Outdoor Lifestyles Dakota42-B User manual

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 1
Owner’s Manual
Installation and Operation
Models:
Dakota 42-B
Dakota 42H-B
DO NOT DISCARD THIS MANUAL
CAUTION
• Important operating
and maintenance
instructions included.
• Leave this
manual with party
responsible for use
and operation.
• Read, understand
and follow these
instructions for safe
installation and
operation.
DO NOT
DISCARD
Installationandserviceofthisapplianceshould
beperformedbyqualiedpersonnel.Hearth&
Home Technologies suggests NFI certied or
factory-trained professionals, or
technicianssupervisedbyanNFI
certiedprofessional.
This appliance must be installed outside.
Note: An arrow () found in the text signies change in
content.
If the information in these instruc-
tions is not followed exactly, a
 re may result causing property
damage, personal injury, or death.
• Donotstoreorusegasolineorotheram-
mablevaporsandliquidsinthevicinityof
this or any other appliance.
• What to do if you smell gas:
- Do not try to light any appliance.
- Donottouchanyelectricalswitch.Donot
use any phone in your building.
- Immediatelycallyourgassupplierfrom
a neighbor’s phone. Follow the gas
supplier’s instructions.
- Ifyoucannotreachyourgassupplier,call
theredepartment.
• Installationandservicemustbeperformed
byaqualiedinstaller,serviceagency,or
the gas supplier.
WARNING
HOT SURFACES!
Glass and other surfaces are hot during
operation and cool down.
WARNING
• CAREFULLY SUPERVISE children in same room as
appliance.
• Alert children and adults to hazards of high
temperatures.
High temperatures may ignite clothing or other
fl ammable materials.
• Keepclothing,furniture,draperiesandothercombustibles
away.
Hot glass will cause burns.
• Donottouchglassuntilitiscooled
• NEVERallowchildrentotouchglass
• Keepchildrenaway

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 2
Read this manual before installing or operating this appliance.
Please retain this owner’s manual for future reference.
CongratulationsonselectingaHeat&GloLifeStyleCollection
gas appliance—an elegant and clean alternative to wood
burningappliances.TheHeat&GloLifeStyleCollectiongas
applianceyouhaveselectedisdesignedtoprovidetheutmost
insafety,reliability,andefciency.
As the owner of a new appliance, you’ll want to read and
carefully follow all of the instructions contained in this owner’s
manual.Payspecialattentiontoallcautionsandwarnings.
This owner’s manual should be retained for future reference.
Wesuggestyoukeepitwithyourotherimportantdocuments
and product manuals.
The information contained in this owner’s manual, unless
noted otherwise, applies to all models and gas control
systems.
YournewHeat&GloLifeStyleCollectiongasappliancewill
giveyou yearsofdurableuseandtrouble-freeenjoyment.
Welcome to the Heat & Glo LifeStyle Collection family of
appliance products!
Homeowner Reference Information
Model Name:  Datepurchased/installed:
SerialNumber: Location on appliance:
Dealershippurchasedfrom:  Dealerphone:
Notes:
We recommend that you record the following pertinent
information about your appliance:
Listing Label Information/Location
Themodelinformationregardingyourspecicappliancecanbefoundontheratingplateusuallylocatedinthecontrolarea
of the appliance.
Congratulations
Model Number
Serial Number
Type of Gas
Gas and Electric Information
This appliance must be installed in accordance with local codes, if any; if not, follow ANSI Z223.1 in
the USA installation codes.
ANSI Z21.50-2003 - CSA 2.22-M2003
Serial (Serie):
Mfg. Date:
Vented gas fireplace - for outdoor installation
only. Not for use with solid fuel. (Foyer au
gaz à évacuation - pour installation à
l'extérieur seulement. Ne doit pas entre
utilise avec un combustible solide.)
Minimum Permissible Gas Supply for Purposes
of Input Adjustment. Natural Gas Propane Gas
Approved Minimum (De Gaz) Acceptable . . 7.0 in. w.c. (Po. Col. d'eau) . . .11.0 in. w.c. (Po. Col. d'eau)
Maximum Pressure (Pression) . . . . . . . . . . 10.0 in. w.c. (Po. Col. d'eau) . .14.0 in. w.c. (Po. Col. d'eau)
Maximum Input BTUH: . . . . . . . . . . . . . . . . 60,000 . . . . . . . . . . . . . . . . . . .53,000
Orifice Size: . . . . . . . . . . . . . . . . . . . . . . . . #25DMS . . . . . . . . . . . . . . . . . .#44DMS
This product is covered by one or more of the following patents: (Nos produits sont couverts par un ou plusieurs des brevels suivants): (United States) 4,112,913; 4,408,594; 4,422,426; 4,424,792; 4,520,791; 4,793,322; 4,852,548; 4,875,464; 5,000,162; 5,016,609; 5,076,254; 5,191,877;
5,218,953; 5,328,356; 5,429,495; 5,452,708; 5,542,407; 5,613,487; (Australia) 543790; 586383; (Canada) 1,123,296; 1,297,746; 2,195,264; (Mexico) 97-0457; (New Zealand) 200265; or other U.S. and foreign patents pending (ou autres brevets americains et etrangers en attente).
DAKOTA42-B
DAKOTA42L-B
4036-994A
MADE
IN USA
Model
(Modele):
VENTED GAS
FIREPLACE
8R54
Outdoor Lifestyles by
Hearth & Home Technologies
7571 - 215th St. West., Lakeville, MN 55044
OD

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 3
Table of Contents
1 Listing and Code Approvals
A. ApplianceCertication.........................4
B. GlassSpecications ..........................4
C. BTUSpecications ...........................4
D. HighAltitudeInstallations ......................4
2 Getting Started
A. DesignandInstallationConsiderations ............5
MoistureResistance: .............................5
B. ToolsandSuppliesNeeded.....................6
C. InspectApplianceandComponents ..............6
3 Framing and Clearances
A. SelectApplianceLocation ......................7
B. Clearances .................................8
C. MantelProjections............................8
4 Termination Locations
A. VentTerminationMinimumClearances ............9
5 Appliance Preparation
A. RemoveLogsandShippingCover ..............10
B. SecuringandLevelingAppliance ...............10
6 Gas Information
A. FuelConversion ............................11
B. GasPressure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
C. GasConnection.............................11
D. HighAltitudeInstallations .....................12
E. ValveAccess ...............................13
7 Electrical Information
A. IntellireIgnitionSystemWiring ................14
8 Finishing
A. MantelProjections...........................15
B. FacingMaterial .............................16
9 Appliance Setup
A. CleantheAppliance. . . . . . . . . . . . . . . . . . . . . . . . . . 17
B. GrateAssemblyPlacement ....................17
C. PositioningtheLogs .........................17
D. GlassAssembly .............................19
E. PlacingLavaRock...........................19
F. ReinstallDoorLock ..........................19
10 Operating Instructions
A. BeforeLightingAppliance .....................20
B. LightingtheAppliance ........................21
C. AftertheApplianceisLit ......................22
D. FrequentlyAskedQuestions ...................22
11 Troubleshooting
A. IntellireIgnitionSystem ......................23
12 Maintaining and Servicing the Appliance
A. ValveServiceandReplacement ................25
B. BatteryReplacement.........................26
B. MaintenanceandServiceTasks:................27
13 Reference Materials
A. ApplianceDimensionDiagram .................28
B. ServicePartsList. . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
C. Warranty ..................................34
D. ContactInformation ..........................36


 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 4
1 Listing and Code Approvals
A. Appliance Certication
This product is listed to ANSI standards for “Vented Gas
Fireplaces”andapplicablesectionsof“GasBurningHeating
AppliancesforManufacturedHomesandRecreationalVehi-
cles”,and“GasFiredAppliancesforUseatHighAltitudes”.
DoNOTusethisapplianceifanyparthasbeenunder
water.Immediatelycallaqualiedservicetechnician
to inspect the appliance and to replace any part of the
control system and any gas control which has been
under water.
WARNING
MODELS: Dakota42-B,Dakota42H-B
LABORATORY: UnderwritersLaboratories,Inc.(UL)
TYPE: VentedGasAppliance
STANDARD: ANSI Z21.50-2003—CSA2.22-M2003
Note: This installation must conform with local codes. In the
absence of local codes you must comply with the National
Fuel Gas Code, ANSI Z223.1-latest edition intheU.S.A.
and the CAN/CGA B149 Installation CodesinCanada.
B. Glass Specications
Hearth & Home Technologies appliances manufactured with
temperedglassmaybeinstalledinhazardouslocationssuch
asbathtubenclosuresasdenedbytheConsumerProduct
SafetyCommission(CPSC).Thetemperedglasshasbeen
testedandcertiedtotherequirementsofANSIZ97.1and
CPSC 16 CFR 1202 (Safety Glazing Certication Council
SGCC#1595and1597.ArchitecturalTesting,Inc.Reports
02-31919.01and02-31917.01).
ThisstatementisincompliancewithCPSC16CFRSection
1201.5“Certicationandlabelingrequirements”whichrefers
to15U.S.Code(USC)2063stating“…Suchcerticateshall
accompany the product or shall otherwise be furnished to
anydistributororretailertowhomtheproductisdelivered.”
Somelocalbuildingcodesrequiretheuseoftemperedglass
with permanent marking in such locations. Glass meeting
thisrequirementisavailablefromthefactory.Pleasecontact
your dealer or distributor to order.
Models
Maximum
Input BTUH
Orice Size
(DMS)
Dakota42-B(NG) 60,000 25
Dakota42-B(LP) 53,000 44
D. High Altitude Installations
U.L.Listedgasappliancesaretestedandapprovedwithout
requiringchangesforelevationsfrom0to2000feetinthe
U.S.A.andCanada.
Wheninstallingthisapplianceatanelevationabove2000ft,
it may be necessary to decrease the input rating by chang-
ing the existing burner orice to a smaller size. Input rate
shouldbereducedby4%foreach1000ftabovea2000ft
elevationintheU.S.A.,or10%forelevationsbetween2000
and4500ftinCanada.Iftheheatingvalueofthegashas
beenreduced,theserulesdonotapply.Toidentifytheprop-
eroricesize,checkwiththelocalgasutility.
Ifinstallingthisapplianceatanelevationabove4500ft(in
Canada),checkwithlocalauthorities.
C. BTU Specications

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 5
A. Design and Installation Considerations
Checkbuildingcodespriortoinstallation.
• Installation MUST comply with local, regional,
state and national codes and regulations.
• Consult insurance carrier, local building, fire
ofcials or authorities having jurisdiction about
restrictions,installationinspection,andpermits.
CAUTION
When planning an appliance installation, it’s necessary to
determine the following information before installing:
• Wheretheapplianceistobeinstalled.
• Gassupplypiping.
• Electricalwiring.
• Framingandnishingdetails.
2 Getting Started
Moisture Resistance:
Thisoutdoorreplacewillshedmoderateamountsofwater,
but is not waterproof. Water and condensing water vapor
may enter the chase under certain conditions.
Thereplacewillnotperformasanexteriorwall.Moisture
penetration must be considered for construction that places
thereplaceinstructurewallsoronmoisturesensitivesur-
faces.
When installed on exterior walls: Hearth & Home Tech-
nologies recommends that the replace chase be con-
structed outside the structure’s weather envelope. Where
theplatformmeetsthewall,useaashingdetailsimilarto
thatrequiredforattacheddecks.Chaseplatforms,including
hearths should slope away from the structure at 1/8 in. to
1/4in.perfoot.Thereplacecanbeshimmedlevel.
When installed on surfaces where water may collect or
cause damage: Hearth & Home Technologies recommends
that a drainage pan be placed under the unit. This can be
constructedofmetal,adhesivepolymermembrane(suchas
ice and water shield) or other suitable materials. A means of
drainage out of the pan such as tubes or weep holes should
be provided.A slope of 1/8 in. to 1/4 in. per foot towards
thedrainportissuggested.Thereplacecanbeshimmed
level.
Hearths should slope away from the front of the replace
andchaseat1/8in.to1/4in.perfoot.Sparkstripsmustbe
on top of any combustible hearth materials used for moisture
management.
These appliances must be installed outdoors.
TheDakota42-BSeriesoutdoorgasreplaceisdesigned
for outdoor use. It may also be installed in screened porches
and lanais that meet these minimum requirements:
• Minimumporcharea-96squarefeet
• Minimumceilingheight-84in.
A minimum of two walls can be screened but must be open
tooutsideventilation.
• Minimumscreenarea-64squarefeet
• Minimumscreentopheight-80in.
RefertoSection3.B.forclearances.

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 6
B. Tools and Supplies Needed
Beforebeginningtheinstallationbesurethatthefollowing
toolsandbuildingsuppliesareavailable.
Reciprocatingsaw Framingmaterial
Pliers Hitempcaulkingmaterial
Hammer Gloves
Phillipsscrewdriver Framingsquare
Flatbladescrewdriver Electricdrillandbits(1/4in.)
Plumbline Safetyglasses
Manometer Voltmeter
Tapemeasure Level
Non-corrosiveleakchecksolution
1/2-3/4inchlength,#6or#8Self-drillingscrews
C. Inspect Appliance and Components
• Carefullyremovetheapplianceandcomponentsfromthe
packaging.
• Thegaslogsmaybepackagedseparatelyandmustbe
eldinstalled.
• Reporttoyourdealerany parts damaged in shipment,
particularly the condition of the glass.
• Read all of the instructions before starting the
installation. Follow these instructions carefully
during the installation to ensure maximum safety and
benet.
Inspect appliance and components for
damage. Damaged parts may impair safe
operation.
• DoNOTinstalldamagedcomponents.
• DoNOTinstallincompletecomponents.
• DoNOTinstallsubstitutecomponents.
Reportdamagedpartstodealer.
WARNING
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be
voidedby,thefollowingactions:
• Installation and use of any damaged appliance or
ventsystemcomponent.
• Modicationoftheapplianceorventsystem.
• InstallationotherthanasinstructedbyHearth&Home
Technologies.
• Improper positioning of the gas logs or the glass
door.
• Installation and/or use of any component part not
approvedbyHearth&HomeTechnologies.
Any such action may cause a re hazard.
WARNING

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 7
B
A
G
E
Note: If this surface is
inside the building’s
warm air envelope... ...then this surface
must be an exterior
wall system.
C
D
FF
C
D
G
F
E
57-3/4 in.
(1467 mm)
81-3/4 in.
(2076 mm)
Note:
• Illustrations reect typical installations and are FOR
DESIGNPURPOSESONLY.
• Illustrations/diagramsarenotdrawntoscale.
• Actual installation may vary due to individual design
preference.
Fire Risk
Provideadequateclearance:
• Aroundairopenings.
• Tocombustibles.
• Forserviceaccess.
Locateapplianceawayfromtrafcareas.
WARNING
A. Select Appliance Location
When selecting a location for your appliance it is important to
considertherequiredclearancestowalls(SeeFigure3.1).
Note: For actual appliance
dimensionsrefertoSection13.
Figure 3.1 Appliance Locations
3 Framing and Clearances
A B C D E F G
in. 24-3/4 24-1/8 48 49 5/8 1/2 1-1/2
mm 629 613 1219 1245 16 13 38
Fire Risk
Odor Risk
• Installapplianceonhardmetalorwood
surfaces extending full width and depth
of appliance.
• Do NOT install appliance directly on
carpeting,vinyl,tileoranycombustible
material other than wood.
WARNING
Fire Risk
• Locate and install appliance to all
clearancespecicationsinmanual.
WARNING

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 8
Fireplace Structure
Mantel
B
A
If Ais:
Then B
must be at
least:
in. 6 - 36 26
mm 152 - 914 660
in. 36 or more 18
mm 914 or more 457
84 in.
(2134 mm)
minimum
height
Additional Structure
or Sidewall
Roof or
Overhang
12 in. (305 mm)
max. combustible
mantel depth
B. Clearances
Figure 3.3 Clearances to Mantels or Other Combustibles Above Appliance
BD
Header height.
Use only noncombustible
material below the top of
the top standoffs.
A
C
84 in.
(2134 mm)
to ceiling
0 in.
0 in. to level
of standoffs
Combustible Object
36 in.
(914 mm)
Combustible flooring may be installed next
to the front of the appliance.
1-1/2 in. (38 mm)
Drywall
0 in.
1/2 in. (13 mm)
1-1/2 in.
(38 mm)
Upper front can be
covered with
non-combustible
material or removed
and replaced with
non-combustible
material.
Figure 3.2 Framing Dimensions
C. Mantel Projections
Framing Dimensions
A B C D
in. 24-1/8 43-7/8 49 43-7/8
mm 613 1114 1245 1114
Fire Risk
• Complywith allminimum
clearances to combustibles
asspecied.
• Framing or finishing
material used on the
frontof,orinfrontof,the
appliance closer than the
minimums listed, must
be constructed entirely of
noncombustible materials
(i.e.,steelstuds,concrete
board,etc.).
Failure to comply may cause
re.
WARNING

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 9
FP = FIREPLACE OPENING X = AIR SUPPLY INLET = AREA WHERE FIREPLACE IS NOT PERMITTED
O
N
P
R
Q
FP
(See Note 2)
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
Q
MIN R MAX
Dakota 10 feet 2 x Q
ACTUAL
1 additional termination cap Q + 3 feet 1 x Q
ACTUAL
2 additional termination caps Q + 6 feet 2/3 x Q
ACTUAL
3 additional termination caps Q + 9 feet 1/2 x Q
ACTUAL
R
MAX
= (2 / # caps plus fireplace ) x Q
ACTUAL
D
E
L
FP
A
H
M
X
J or K
I
A
G
F
FP
FP
FP
FP
FP
B
B
B
A = 0 in. . . . . . . . . . clearances above grade,
veranda, porch, deck or
balcony.
B = 12 in. . . . . . . . . . clearances to window or door
that may be opened, or to
permanently closed window.
36 in. . . . . . . . . . vinyl windows or siding.
D** = 47 in. . . . . . . . . . vertical clearance to unventi-
lated soffit or to ventilated soffit
located above the terminal.
60 in. . . . . . . . . . vinyl clad soffits.
F = 9 in. . . . . . . . . . clearance to outside corner.
G* = 6 in. . . . . . . . . . clearance to inside corner.
48 in. . . . . . . . . . vinyl windows or siding.
H = 3 ft. (Canada) . not to be installed above a gas
meter/regulator assembly within
3 ft (914 mm) horizontally from
the center line of the regulator.
I = 3 ft. (USA)
6 ft. (Canada) . clearance to service regulator
vent outlet and electric service.
J = 9 in. (USA)
12 in. (Canada) . clearance to non-mechanical air
supply inlet to building or the
combustion air inlet to any other
appliance.
K = 3 ft. (USA)
6 ft. (Canada) . clearance to a mechanical air
supply inlet.
L*** = 54 in. . . . . . . . . . clearance above paved sidewalk
(See note 1) or a paved driveway located on
public property.
M****= 47 in. . . . . . . . . . clearance under veranda, porch,
deck, balcony or overhang.
Not allowed: . . . . . . vinyl
N = 6 in. . . . . . . . . . non-vinyl siding.
P = 84 in.
* 48 in. minimum for vinyl windows or vinyl siding.
** Not allowed for vinyl clad soffits.
*** a fireplace shall not open directly above a sidewalk or paved
driveway which is located between two single family dwellings
and services both dwellings.
**** only permitted if veranda, porch, deck or balcony is fully open
on a minimum of 2 sides beneath the floor, or if the screened
porch guidelines are followed.
Note 1: Local codes or regulations may require different clearances.
Note 2: Termination in an alcove space (spaces open only on one
side and with an overhang) are permitted with the dimensions
specified for vinyl or non-vinyl siding and soffits. 1) There must
be a 3 ft minimum between terminations or between the
fireplace and termination. 2) All mechanical air intakes within 10
ft of a termination must be a minimum of 3 ft below the fireplace
hood. 3) All gravity air intakes within 3 ft of the fireplace hood
must be a minimum of 1 ft below the termination.
This fireplace is approved for installation onto screen porches with the
following guidelines:
Minimum porch area: 96 sq ft
Minimum ceiling height: 84 in.
Minimum of two walls must be screened
Minimum top of screen height, side walls: 6 ft 8 in.
Minimum screen area: 64 sq ft
Note 2: There may be some odor and small amounts of soot associated
with burning the Dakota on a screened porch. Ensuring good cross
draft ventilation and routine maintenance of the fireplace will maximize
comfort and cleanliness.
A. Vent Termination Minimum Clearances
Figure 4.1 Minimum Clearances
4 Termination Locations

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 10
5 Appliance Preparation
SharpEdges
• Wear protective gloves
and safety glasses during
installation.
CAUTION
A. Remove Logs and Shipping Cover
Removelockingscrewatthetopofthedoors(showninFig-
ure5.1).
Open the doors by sliding the handles toward the outside
edgesofthedoors.Removethecartonsoflogsfromtheir
shipping location in the appliance.
Setthelogsanddoorlockbracketscrewasideforlaterre-
installation.
Open Open
Locking Screw
Figure 5.1 Door Operation
Do NOT notch into the framing around the appliance
spacers.
CAUTION
NAILING TABS
Upper front can be
covered with
non-combustible
material or removed
and replaced with
non-combustible
material.
Figure 5.2 Proper Positioning, Leveling and Securing of an
Appliance
B. Securing and Leveling Appliance
Thediagramshowshowtoproperlyposition,level,andse-
cure the appliance (see Figure 5.2). Nailing tabs are pro-
videdtosecuretheappliancetotheframingmembers.
• Placetheapplianceintopositiononeitheracombustible
ornon-combustiblecontinuousatsurface.
Note:Removethetopstandoffsbeforeslidingappliance
intopositionifusinganFPSprefabenclosure.
• Leveltheappliancefromsidetosideandfronttoback.
• Shimtheappliancewithnon-combustiblematerial,such
assheetmetal,asnecessary.
• Bendoutnailingtabsoneachside.
• Keepnailingtabsushwiththeframing.
• Secure the appliance to the framing by using nails or
screws through the nailing tabs.
Fire Risk
• Prevent contact with sagging, loose
insulation.
• DoNOTinstallagainstvaporbarriersor
exposed insulation.
WARNING

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 11
A. Fuel Conversion
Beforemakinggasconnectionsensureappliancebeingin-
stallediscompatiblewiththeavailablegastype.
Anynaturalorpropanegasconversionsnecessarytomeet
the appliance and locality needs must be made by a quali-
edtechnicianusingHearth&HomeTechnologiesspecied
andapprovedparts.
Pressure requirements for  appliance are shown in  table
below.
Note: Have the gas supply line installed in accordance
with local building codes, if any. If not, follow ANSI
223.1.Installationshouldbedonebyaqualiedinstaller
approved and/or licensed as required by the locality. (In
theCommonwealthofMassachusettsinstallationmustbe
performedbyalicensedplumberorgastter.)
Note: A listed (and Commonwealth of Massachusetts
approved)1/2in.(13mm)T-handlemanualshut-offvalve
and exible gas connector are connected to the 1/2 in.
(13mm)controlvalveinlet.
• If substituting for these components, please consult
local codes for compliance.
Note: The gap between supply piping and gas access hole
maybepluggedwithnon-combustibleunfacedinsulation
topreventcoldairinltration.
B. Gas Pressure
Properinputpressuresarerequiredforoptimumappliance
performance.Gaslinesizingrequirementsneedtobemade
following NFPA51.
WARNING
Gas Leak Risk
• Supportcontrolwhenattachingpipeto
preventbendinggasline.
Fire Risk
Explosion Risk
Verifyinletpressures.
• High pressure may cause overfire
condition.
• Lowpressuremaycauseexplosion.
Install regulator upstream of valve if line
pressureisgreaterthan1/2psig.
WARNING
6 Gas Information
Fire Risk
Explosion Risk
Highpressurewilldamagevalve.
• DisconnectgassupplypipingBEFORE
pressure testing gas line at test pressures
above1/2psig.
• ClosethemanualshutoffvalveBEFORE
pressure testing gas line at test pressures
equaltoorlessthan1/2psig.
WARNING
Note: Gas line MUST be run from right side of appliance.
Thesepressurescanbeveriedthroughtheinternalvalve
accesspanelsasshowninSectionE.ValveAccess.
Pressure Natural Gas Propane
MinimumInletPressure 5.0inchesw.c. 11.0inchesw.c.
MaximumInletPressure 7.0inchesw.c. 14.0inchesw.c.
ManifoldPressure 3.5inchesw.c. 10.5inchesw.c.
C. Gas Connection
Optional:A5ftexiblegaslineisavailabletothoseregions
which do not require black pipe to be used. See Service
PartsList(Section13).
• Ensurethatgaslinedoesnotcomeincontactwithouter
wrap of appliance. Follow local codes.
• Incoming gas line should be piped into the valve
compartmentandconnectedtothe1/2in.connectionon
themanualshutoffvalve.
• Removethetwofactory-installedscrewsholdingtheouter
shellvalvecovertotherightsideoftheappliance.
• Liftthecoveroffandsetitandthetwoscrewsaside.
• Installthegasline.
• Replacethevalvecoverusingthetwoscrewsremoved
andsixmorefromthefastenerpack.


 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 12
WARNING
Fire Risk
Explosion Risk
• Gas build-up during line purge may
ignite.
• Purgeshouldbeperformedbyqualied
technician.
• Ensureadequateventilation.
• Ensuretherearenoignitionsourcessuch
assparksoropenames.
WARNING
CHECK FOR GAS LEAKS
Fire Risk
Explosion Risk
Asphyxiation Risk
• Checkallttingsandconnections.
• Donotuseopename.
• Afterthegaslineinstallationiscomplete,
all connections must be tightened and
checked for leaks with a commercially
available, non-corrosive leak check
solution.Besuretorinseoffallleakcheck
solution following testing.
Fittingsandconnectionsmayhaveloosened
during shipping and handling.
D. High Altitude Installations
U.L.listedgasappliancesaretestedandapprovedwithout
requiringchangesforelevationsfrom0to2000ftintheUSA
andCanada.
Wheninstallingthisapplianceatanelevationabove2000ft,
it may be necessary to decrease the input rating by chang-
ing the existing burner orice to a smaller size. Input rate
shouldbereducedby4%foreach1000ftabovea2000ft
elevationintheU.S.A.,or10%forelevationsbetween2000
and4500ftinCanada.Iftheheatingvalueofthegashas
beenreduced,theserulesdonotapply.Toidentifytheprop-
eroricesize,checkwiththelocalgasutility.
Ifinstallingthisapplianceatanelevationabove4500ft(in
Canada),checkwithlocalauthorities.
WARNING
Fire Risk
Explosion Risk
DoNOTchangethevalvesettings.
• This valve has been preset at the
factory.
• Changingvalvesettingsmayresultinre
hazardorbodilyinjury.
• Asmallamountofairwillbeinthegassupplylines.When
rstlightingappliance itwilltakea short timeforair to
purgefromlines.Whenpurgingiscomplete,theappliance
will light and operate normally.

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 13
E. Valve Access After Installation
Washer
Figure 6.1 Lift Out Doors
Figure 6.3 Loosen Refractory Retaining Strip
Figure 6.4 Remove Valve Access Panel
Figure 6.5 Remove Exterior Valve Access Panel
Figure 6.6 Connect Manometer
• The gas valve can be accessed after installation from
behind the cement refractory panel on the right side of
thereplace.
• Liftdoorsoutandsetaside.Thereisawasherundereach
door.Becarefulnottolosethosewashers.
• Useaphillipsscrewdriverto remove the exteriorvalve
accesspanel(removefourscrews).
• Useamanometeronthe lower out pressuretap.Start
up the replace to verify the pressure and adjust as
necessary.Reversethesestepstoreassemblebeforelog
positioning.
• Removelogsifaccessisnecessaryafterinstallationis
complete.SeeSection9.C.Removelogsinreverseorder
of set up.
• Removegrateifaccessisnecessaryafterinstallationis
complete.(RefertoSection9.B.)
• Removetwoscrewsonsideofpilotshieldandremove
shield.
• Removetheinsidevalveaccesspanelbyliftingitupand
out.
Figure 6.2 Remove Pilot Shield
• Use a phillips screwdriver to remove the two screws
securing the refractory retaining strip. Remove the
refractory side panel and set aside.


 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 14
Battery polarity must be correct or module damage will
occur.
CAUTION
A. Intellire Ignition System Wiring
• ThisapplianceisequippedwithanIntellirecontrolvalve
whichoperatesona3voltsystem.
• Thisapplianceis suppliedwithabattery packwhichis
located in the ON/OFF switch terminal box. A wiring
diagramisshowninFigure7.1.
• The battery pack requires two D cell batteries (not
included).SeeSection12.B.forbatteryreplacement.
7 Electrical Information
Label all wires prior to disconnection when servicing
controls. Wiring errors can cause improper and dangerous
operation.Verifyproperoperationafterservicing.
CAUTION
Shock Risk
• Replacedamagedwirewithtype105°C
rated wire.
• Wire must have high temperature
insulation.
WARNING
IGNITION MODULE
3 VAC
GRN
ORG
INTERMITTENT
PILOT
IGNITOR
IGNITION
MODULE
(3V)
ON/OFF
WALL
SWITCH
LOW VOLTAGE
BATTERY
PACK
FLAME SPARKER/
SENSOR
SEE NOTE 1
ORG
WHT
PIGGYBACK
ON/OFF SWITCH
BRN
BRN
VALVE
VALVE
GROUND TO
FIREPLACE
CHASSIS
I
S
BLACK
RED
BATTERY
PACK
Figure 7.1 Intellere Pilot Ignition (IPI) Wiring Diagram

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 15
A. Mantel Projections
Figure8.1showstheminimumverticaldimensionofappliancemantelsorothercombustibleprojectionsabovethetopfront
edge of the appliance.
Fireplace Structure
Mantel
B
A
If
A
is:
Then B
must be at
least:
in. 6 - 36 26
mm 152 - 914 660
in. 36 or more 18
mm 914 or more 457
84 in.
(2134 mm)
minimum
height
Additional Structure
or Sidewall
Roof or
Overhang
12 in. (305 mm)
max. combustible
mantel depth
Figure8.1 ClearancestoMantelsorotherCombustiblesaboveAppliance.
8 Finishing

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 16
Sealant Material
0 in.
0 in.
0 in.
Upper front can be covered
with non-combustible
material or removed and
replaced with non-
combustible material.
Finish wall material
may be combustible,
top & sides.
Fire Risk
DoNOTobstructairinletoroutletgrilles.
DoNOTmodifygrilles.
• Modifyingorcoveringgrillescouldcause
temperatureriseandrehazard.
Finishing materials must not interfere with:
• Airowthroughgrillesorlouvers.
• Operationoflouversordoors.
• Accessforservice.
WARNING
B. Facing Material
Figure8.2 NoncombustibleFacingDiagram
Fire Risk
Finish all edges and fronts to clearances and
specicationslistedinmanual.
WARNING
• Metal appliance front may be covered with non-
combustible material only.
• DoNOToverlapcombustiblematerialsontoappliance
front.
• Installcombustiblematerialsuptospeciedclearances
on top front and side edges.
• Sealjointsbetweenthenishedwallandappliance
topandsidesusingonlya300°Fminimumsealant.

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 17
A. Clean the Appliance
Clean/vacuumanysawdustthatmayhaveaccumulatedin-
sidethereboxorunderneathinthecontrolcavity.
Shock Risk
Fire Risk
Use ONLY optional accessories approved
for this appliance.
• Using non-listed accessories voids
warranty.
• Usingnon-listedaccessoriesmayresult
inasafetyhazard.
• Only Hearth & Home Technologies
approved accessories may be used
safely.
WARNING
Back Legs in Grate Brackets
Figure9.1 BackLegsinGrateBrackets
9 Appliance Setup
B. Grate Assembly Placement
• Ensuregrateassemblyisoverburnerassembly,centered
fromlefttoright,andbacklegsareingratebrackets(see
Figure9.1)
Figure 9.2 Right Rear Log (SRV720)
Figure 9.4 Left Side Log (SRV723)
Figure 9.3 Left Rear Log (SRV728)
C. Positioning the Logs
• SeeSection13.B.forlogdescriptionsandillustrations.
• Placerightrearlogonthegrateagainsttheapplianceright
side wall.
• Placetheforkoflogontotheleftfrontbarandrestitsback
on right rear log.
• Placetheleftrearlogonthegrateagainsttheleftwalland
rest it on log.

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 18
Figure 9.6 Front Left Log (SRV722)
Figure 9.5 Front Log (SRV727)
• Placefrontleftlogbetweenlocatingbarssoitrestsagainst
log left side log and on top of front log.
• Placefrontloginfrontofthemaingratewithitsleftend
resting on left rear log as shown.
Figure 9.7 Front Right Log (SRV724)
• Placerightcenterlog between the 4thand5thvertical
barsontheloggrate,restingthebackonrightrearlog.
Figure 9.8 Right Side Log (SRV740)
• Placerightlogagainsttherightmostfrontgratebarand
restitsrearonrightrearlog,angledtowardsthecorner
as shown.
Figure 9.9 Right Front Corner Log (SRV742)
• Placerightfrontcornerlogbetweentherighthandside
wall and right hand side grate bar as shown.

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 19
Handle glass with care.
• Inspect the glass for cracks, chips or
scratches.
• DoNOTstrike,slamorscratchglass.
• Do NOT operate appliance with glass
door removed, cracked, broken or
scratched.
• Replace glass door assembly as a
complete assembly.
WARNING
D. Glass Assembly
• Theglassdoorsareincludedwithandpre-installedinthe
appliance.
• To adjust doors, open them and loosen screws on top
andbottompivotpins.Slideeachdoorasnecessaryand
tighten screws.
• To adjust handle, loosen screws to move handles as
necessary and tighten screws.
Glass Specications
 Dakota42-B: Tempered
 Dakota42L-B: Tempered
 Dakota42H-B: Tempered
 Dakota42HL-B: Tempered
Ashlip
Rock Pan
Figure9.10 PlacementofLavaRocks
E. Placing Lava Rock
• After logs have been placed spread part of the lava
rock (included) between the rock pan and ashlip (see
Figure9.10).
F. Reinstall Door Lock
Whenlogsandlavarockhavebeeninstalled,oriftheglass
assembly has been adjusted, reinstall the door lock by
insertingthescrewatthetopofthedoor.Tightenscrew.You
mayrefertoSection5.A.ifneeded.
Open Open
Locking Screw
Figure 9.11 Reinstall Door Lock

 OutdoorLifestylesbyHearth&HomeTechnologies•Dakota42-B/Dakota42H-B•4036-909•RevP•11/4/13 20
Improper installation, adjustment, alteration, service or
maintenancecancauseinjuryorpropertydamage.Refer
to the owner’s information manual provided with this
appliance. For assistance or additional information consult
aqualiedinstaller,serviceagencyorthegassupplier.
WARNING
DoNOTusethisapplianceifanyparthasbeenunder
water. Immediately call a qualied service technician
to inspect the appliance and to replace any part of the
control system and any gas control which has been
under water.
WARNING
10 Operating Instructions
A. Before Lighting Appliance
Before operating this appliance, have a quali ed
technician:
• Remove all shipping materials from inside and/or
underneaththerebox.
• Reviewproperplacementoflogs,rockwool,lavarockand
vermiculite.
• Checkthewiring.
• Checktheairshutteradjustment.
• Ensurethattherearenogasleaks.
• Ensurethattheowofcombustionandventilationairis
not obstructed (front grilles).
HOT SURFACES!
Glass and other surfaces are hot during
operation and cool down.
WARNING
• CAREFULLY SUPERVISE children in same room as
appliance.
• Alert children and adults to hazards of high
temperatures.
High temperatures may ignite clothing or other
fl ammable materials.
• Keepclothing,furniture,draperiesandothercombustibles
away.
Hot glass will cause burns.
• Donottouchglassuntilitiscooled
• NEVERallowchildrentotouchglass
• Keepchildrenaway