Peak PKC01MB User manual

1,000,000 Rechargeable
Spotlight
Model No.: PKC01MB
Owner’s Manual
and Warranty Information
Read these instructions completely before using this product.
Retain this Owner’s Manual for future reference.

All safety messages that follow have NOTICE level hazards. Failure to comply
could result in personal property damage.
• Always turn the Spotlight off when not in use.
• Do not disassemble the Spotlight or remove any parts. This Spotlight contains no serviceable or
replaceable parts.
• Clean the Spotlight and charging accessories regularly.
INTRODUCTION
Read and understand this Instruction Manual before using the Spotlight. Recharge and operate the
Spotlight only as described in this Instruction Manual.
FEATURES
1
2
Legend
1. Spotlight Power Switch
2. 110/120-volt Charging Adapter

SPOTLIGHT CHARGING
This Spotlight is shipped in a partially charged state. BEFORE first use, charge the
Spotlight battery using the 110/120-volt AC charging adapter for 20 hours. Failure to follow
this procedure may permanently damage the battery.
Charger Features
A standard two-prong 110/120-volt AC adapter is located on the back of the Spotlight behind the
protective cover for connection of an AC extension cord. The charging adapter allows charging from a
household wall outlet (110/120-volt AC).
Charging Guidelines and Precautions
• Only use the charging adapter that is built in to this Spotlight. Use of any other chargers or
adapters may void any warranty, cause Spotlight damage, increase risk of fire and/or result in
personal injury.
• Do not overheat or overcharge the battery.
110/120-Volt AC Charging
Never connect the 110/120-volt AC charging adapter to an ungrounded AC power
supply.
Never connect the 110/120-volt AC charging adapter to any AC voltage other than
60 MHz - 110/120-volt AC supply.
Never turn the Spotlight on while charging, as this will damage the Spotlight and
void any warranty.
Charging performance may vary depending on local AC voltage and the type and
length of the AC extension cord used.
Once the unit is discharged, future recharging will take 10 to 12 hours using the
110/120-volt AC charging adapter to reach full charge.
Do not charge the battery for more than 20hours using the 110/120-volt AC charging
adapter.
1. Make sure the power switch is in the OFF position.
2. Open the 110/120-volt AC charging adapter protective cover and connect the extension cord to
the 110/120-volt AC charging adapter.
3. Plug the extension cord into an approved outlet.
Charging Tips
• Recharge the Spotlight as soon as possible once the Spotlight starts to dim and after each use.
• Disconnect the charger cord and wait 5 minutes before use once charging is complete.
• Never leave the battery discharged or completely discharge the battery, as this will decrease
battery life. Recharge every 2 months in periods of non-use. Frequent charging will improve the
performance of the battery.
• Disconnect the power from the charging adapter and Spotlight when not in use.
SPOTLIGHT OPERATION
• Be sure the Spotlight battery is completely charged. See SPOTLIGHT CHARGING on page 4.
• Before operating the Spotlight, disconnect the charging adapter. Disconnect the extension cord
from the power supply before disconnecting the extension cord from the Spotlight.
1. Press the power switch to turn on the Spotlight.
2. Press the power switch to turn off the Spotlight.

CARE AND MAINTENANCE
Due to inherent self-discharge, lead-acid batteries should be charged at least every
2 months, especially in a warm environment. Leaving a battery in a discharged state, or if not
recharged every 2 months, may result in permanent battery damage.
• Read CHARGING GUIDELINES AND PRECAUTIONS on page 4 and CHARGING TIPS on
page 4.
• Charge the Spotlight battery using the 110/120-volt AC charging adapter after every use.
• Charge the Spotlight every 2 months during periods of non-use.
• Unplug the unit and allow to cool before attempting to clean.
• Only use a soft cloth moistened with a mild solution of water and detergent on the outer surface of
the Spotlight when cleaning.
Battery Replacement / Disposal
The Spotlight is designed to provide years of service. However, when the internal battery reaches the
end of its service life, the Spotlight itself is no longer of use. The internal battery is not designed to be
user replaceable.

FREQUENTLY ASKED QUESTIONS
How long will the Spotlight work after a full charge?
The Spotlight will function up to 25 minutes on a full charge.
Why doesn’t the Spotlight work when the charger is being used?
Due to circuit design, charger capacity and product safety, the Spotlight will not illuminate while it is being
charged.
Are replacement parts available?
No, the light bulb and battery are not designed to be interchanged or replaced. There are no authorized
service or parts providers available.
The Spotlight did not come with a separate AC or DC charger. How do you charge the Spotlight?
Separate AC and/or DC chargers do not come with the unit. Every Spotlight is equipped with an internal AC
charger. The Spotlight can be charged by plugging an extension cord into the two-prong plug in the back of
the Spotlight case.
How long of a time period should the Spotlight be charged?
Follow the instructions within the manual for this unit. Typical charging periods are between 10 and 12 hours.
Do not charge the Spotlight for more than 20 hours when recharging. In addition, we recommend charging
the unit at least every 2 months if it is not used. Periodically charging the Spotlight will help prevent battery
failure.
DO NOT EXPOSE ANY PEAK ELECTRONIC DEVICES TO MOISTURE DURING STORAGE OR
OPERATION. USE PEAK ELECTONIC DEVICES IN WELL-VENTILATED AREAS. IF YOUR QUESTION IS
NOT ADDRESSED OR ANSWERED, PLEASE CONTACT PEAK AUTOMOTIVE TECHNICAL SERVICES
AT 1-800-477-5847 OR EMAIL TO: [e-mail]. THANK YOU FOR YOUR INQUIRY.
SPECIFICATIONS
1. Lumens 345
2. Operation on time (primary bulb) Up to 25 minutes in one full charge
3. Battery 6-volt 2.3Ah rechargeable sealed lead-acid battery
(non-replaceable)
4. Main bulb H3 6-volt 35W halogen bulb (non-replaceable)
5. Reflector 3.5" diameter
6. Initial charge time AC charger – 20 hours
7. Subsequent charge time AC charger – 10-12 hours
8. AC charger Input 110/120-volt; output 6-volt 200 mA
PEAK HAND TOOLS