Philips CE130/55 User manual

CE130/55,CE130X/78
TABLE OF CONTENTS
Page
Technical specification .............................................1-2
Version variation ......................................................1-2
Service measurement setup.....................................1-3
Service aids ............................................................1-4
Instructions on CD playability ..................................2-1..2-2
Disassembly diagram...............................................2
Set Block diagram....................................................3
Set Wiring diagram..................................................4
Circuit diagram
Main board.........................................................5,6
Panel board........................................................7
Tuner board........................................................8
Layout diagram
Main board..........................................................9,10
Panel board........................................................11,12
Tuner board........................................................13,14
Mechanical Exploded view ......................................15
©Copyright 2011Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without
the prior permission of Philips.
Published by LX 1145 Service Audio
Printed in The Netherlands Subject to modication
Car audio system
Version 1.1
3141 785 35401

TECHNICAL SPECIFICATION
Display
• Type: High contrast B/W LCD (8 characters)
• Key illumination: Red
Audio Playback
• Playback Media: USB flash drive, SD Card
• Compression format: MP3, WMA
• ID3 Tag support: Song title, artist, album
• MP3 bit rates: 32-320kbps and variable bit rate
• USB Direct / SD Modes: Play/Pause, Fast
Backward/Fast Forward, Previous/Next, Repeat,
Shuffle
Tuner/Reception/Transmission
• Tuner Bands: AM, FM Stereo
• Auto digital tuning
• Tuner Enhancements: Auto search and store
• No. of preset stations: 18(FM), 12(AM)
Sound
• Equalizer: 2-bands
• Equalizer settings: Classic, Jazz, Pop, Rock, Flat,
Optimal, Techno, User defined
• Sound Enhancement: MAX Sound, Dynamic Bass
Boost
• Output power (MAX): 45Wx4 channels
• Output power (RMS): 22Wx4 channels (4 ohms,
10% T.H.D.)
Connectivity
• USB: USB 2.0 Host
• Memory card: SD, SDHC
• MP3-Link: For portable MP3 music playback
• Preamp output: 2 pairs RCA(L/R)
Security/Anti-thief
• Front panel: Detachable
• Display blackout: 10/20 sec selectable
Accessories
• Remote control: Not included
• User Manual: Brazilian Portuguese
• Quick start guide: Brazilian Portuguese
Power
• Power supply: 12V DC
Dimensions
• Product dimensions (W x H x D):
188 x 58 x 140 mm
• Chassis: 1 Din
•
1 - 2
Type /Versions:
Features
Board in used:
CE130
Service policy
Tuner BOARD
Main BOARD
Panel BOARD
* TIPS : C -- Component Lever Repair.
M -- Module Lever Repair
-- Used
/05 /12 /55 89/16/85/
Feature diffrence
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK
Type /Versions:
CE130
/05 /12 /55 89/16/85/
VERSION VARIATION
39/
39/
C&M
C&M
C&M

1-3
LF Generator
e.g. PM5110
Recorder
Use Universal Test Cassette CrO2 SBC419 4822 397 30069
LEVEL METER
e.g. Sennheiser UPM550
with FF-filter
S/N and distortion met
e
e.g. Sound Technology ST170
L
R
DUT
or Universal Test Cassette Fe SBC420 4822 397 30071
LEVEL METER
e.g. Sennheiser UPM550
with FF
-
filter
S/N and distortion meter
e.g. Sound Technology ST1700B
L
R
DUT
CD
Use Audio Signal Disc
(replaces test disc 3)
SBC429 4822 397 30184
Bandpass
250Hz-15kHz
e.g. 7122 707 48001
LF Voltmeter
e.g. PM2534
DUT
S/N and distortion meter
e.g. Sound Technology ST1700B
Frame aerial
e.g. 7122 707 89001
Tuner AM (MW,LW)
To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.
Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).
RF Generator
e.g. PM5326
Ri=50:
Bandpass
250Hz-15kHz
e.g. 7122 707 48001
LF Voltmeter
e.g. PM2534
DUT
RF Generator
e.g. PM5326
S/N and distortion meter
e.g. Sound Technology ST1700B
Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).
Ri=50:
Tuner FM
MEASUREMENT SETUP

1-4
SERVICE AIDS
GB WARNING
All ICs and many other semi-conductors are
susceptible to electrostatic discharges (ESD).
Careless handling during repair can reduce life
drastically.
When repairing, make sure that you are
connected with the same potential as the mass
of the set via a wrist wrap with resistance.
Keep components and tools also at this
potential.
ESD
CLASS 1
LASER PRODUCT
GB
Safety regulations require that the set be restored to its original
condition and that parts which are identical with those specified,
be used
Safety components are marked by the symbol !.
Lead free

Set remains closed!
N
Y
Play a CD
for at least 10 minutes
Y
playability
ok ?
N
playability
ok ?
add Info for customer
"SET OK"
check playability
N
Y
playability
ok ?
check playability
check playability
return set
Customer complaint
"CD related problem"
"fast" lens cleaning
1
2
3For flap loaders (= access to CD drive possible)
cleaning method 4is recommended
INSTRUCTIONS ON CD PLAYABILITY
2 - 1
Exchange CDM
1-4For description - see following pages

1
PLAYABILITY CHECK
For sets which are compatible with CD-RW discs
use CD-RW Printed Audio Disc ....................7104 099 96611
TR 3 (Fingerprint)
TR 8 (600µ Black dot) maximum at 01:00
• playback of these two tracks without audible disturbance
playing time for: Fingerprint 10seconds
Black dot from 00:50 to 01:10
• jump forward/backward (search) within a reasonable time
For all other sets
use CD-DA SBC 444A..................................4822 397 30245
TR 14 (600µ Black dot) maximum at 01:15
TR 19 (Fingerprint)
TR 10 (1000µ wedge)
• playback of all these tracks without audible disturbance
playing time for: 1000µ wedge 10seconds
Fingerprint 10seconds
Black dot from 01:05 to 01:25
• jump forward/backward (search) within a reasonable time
2
CUSTOMER INFORMATION
It is proposed to add an addendum sheet to the set which
informs the customer that the set has been checked
carefully - but no fault was found.
The problem was obviously caused by a scratched, dirty or
copy-protected CD. In case problems remain, the customer
is requested to contact the workshop directly.
The lens cleaning (method 3) should be mentioned in the
addendum sheet.
The final wording in national language as well as the printing
is under responsibility of the Regional Service Organizations.
4
LIQUID LENS CLEANING
Because the material of the lens is synthetic and coated
with a special anti-reflectivity layer, cleaning must be done
with a non-aggressive cleaning fluid. It is advised to use
“Cleaning Solvent
The actuator is a very precise mechanical component and
may not be damaged in order to guarantee its full function.
Clean the lens gently (don’t press too hard) with a soft and
clean cotton bud moistened with the special lens cleaner.
The direction of cleaning must be in the way as indicated in
the picture below.
Before touching the lens it is advised to clean the
surface of the lens by blowing clean air over it.
This to avoid that little particles make scratches on
the lens.
INSTRUCTIONS ON CD PLAYABILITY
2 - 2

2
1）Detach the the panel by press push button on it.
2）Remove screw on cover "A"
3）Remove cover on unit
4）Remove 6pcs 2X6BTP screw on panel button cover'B'
5）Detach the button cover
Note:put on static belt during operation and keep yourself from electronic screw driver static.
A
Main
B
123
4
面咀+KB板
面咀+KB板
Panel
Handy back
5
DISMANTLING INSTRUCTIONS

3
BLOCK DIAGRAM

4
WIRING DIAGRAM

5
CIRCUIT DIAGRAM MAIN BOARD

6
CIRCUIT DIAGRAM MAIN BOARD

CIRCUIT DIAGRAM PANEL BOARD
7
KEY2
KEY1
GND
+5V
REMOTE
SYS_5V
2COLOR
BT_LED
LAMP_VCC
ENCODER
CE
CLK
DATA
INH
GND
GND
DO
CLK
CE
OSC
VSS
VDD
INH
TRACK-UP TRACK-DN
USB_5V
USB_DN
USB_UP
AUX_R
AUX_L
GND
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
IC901
SC75823
R958 47K
C901
680P
R901
180
R902
220
R903
330
R904
470
R905
680
R906
1K
R907
1K5
R908
2K2
R920
680
R921
470
R922
330
R923
220
R924
180
SW1
OPTIONS/CLOCK
SW2
FOLDER- SW3
SONG+
SW4
MAX/DBB
SW5
EQ/AUDIO SW6
SOURCE
SW7
BACK/BAND SW8
TUNE/SEEK-UP SW9
TUNE/SEEK-DN
SW21
TERMINATECALL
SW22
PHONE
SW23
MENU
SW25
DISP
Q902
NC
Q904
NC
R939
NC R938
NC
R963 NC
R936
NC
R935
NC
R937
NC
R934
NC
LED15
R+B
LED16
R+B
LED3
R+B
LED4
R+B
LED5
R+B
LED6
R+B
LED7
R+B
LED8
R+B
LED9
R+B
LED10
R+B
LED11
R+B
LED12
R+B
LED13
R+B
LED14
R+B
R927 82K
R928 47K
1
2
3
IC902
REMOTE
R929
10
R933 22
R932 22
R931 22
R930 22
ZD901
6V8
ZD902 6V8
ZD903 6V8
ZD904
6V8
R940 270
R941 NC
R942 270
R943 NC
R944 390
R945 NC
R946 270
R947 NC
R948 390
R949
NC
R950 390
R951 NC
R952 270
R953 NC
C902
104
LED21
LED
R961 270
R9640R
EN901
EN
SW24
POWER/MUTE
C905
2P
ZR901
22P
ZR902
22P
EC901
10uF
Q905
NC
R965
NC
R966
NC
1
2
3
4
USBIN
USB
C903
2P
C906
2P
C908
2P
R975 270
R976 NC
R955 390
R954 NC
R956 390
R957 NC
R969 270
R970 NC
R971 390
R972 NC
R967 270
R968 NC
R973 270
R974 NC
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63
LCD1
CEM2000-LCD
LED2
R+B
R979 270
R977 NC
Q901
Q903
NC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
CON1
24PIN-CON
1
2
3
AUX1
AUX IN
R901A
4K7
EC904
10uF C907
104
R902A
4K7
LED17
R+B
R981 270
R980 NC
S[0:100]
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
S31
S32
S33 S34 S35 S36 S37 S38 S39 S40 S41 S42 S43 S44 S45 S46 S47 S48 S1
S2 S3 S4 S5 S6 S7 S8 S9
S10 S11 S12 S13 S14 S15 S16
S49
S50
S51
S52
S53
S54
S55
S51 S55 S54 S53 S49 S50
BLUE+8V
RED+8V
RED+8V
BLUE+8V
POWER
POWER
BLUE+8V
RED+8V
S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S1 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S44 S52 S16 S30 S31 S32 S33 S34 S35 S36 S37 S38 S39 S55 S53 S54 S55 S40 S41 S42 S43 S44 S45 S46 S47 S48 S35
USB-GND
USB+5V
USB+5V
USB-GND

TUNER PART
C115
225
C116
225
R112 100R
R110 100R
R116 100R
EC1
NC
C119
104
C43
1UF
R108
100R
C111
22P
C112
22P
12
X101
32.768K
1FMI
2RFGND
3AGC
4CTUNE
5GND
6AMI
7RST
8SEN
9SCLK
10 SDIO 11 RCLK 12 VIO
13
VDD
14
GND
15
ROUT
16
LOUT
17
DO
18
DFS
19
DCLK
20
INT
21
GPO1
22
NC
23
NC
24
NC
U16
SI4740/41
Q101
2SC9018
R102
10M
R105
4K7
R107
10
R106
4K7
R1
10K
R103
10K
C102
33NF
C103
122
C104
104
C106
104
C105
474
C110
474
L104
220UH
C107
1U
L105A
1MH
C109
183
C101
30P
L101
FB/1.5K
S
GDQ102
MF862
S
GDQ103
MF862
L102
220NH
1
2
ANT
ANT
R100
47
R4
10K
C123
47P
L106
33UH
1
2
3
4
Q104
3SK254
C118
15P
C120
15P
L103
220NH
C121
30P
L107
2.7UH
R101
270K
C122
223
C108
104
C1
47uF/16V
C114
2U2
C113
102
R104
NC
12 1234678910 511
CON103
CON-12P
TUNER-CLK
TUNER-DA
TUNER-RES
CHGND
CHGND
XOUT
CHGND
XOUT
CHGND
CHGND
CHGND
AM_LOC2 CHGND
CHGND
AM_LOC2
RDS-INT
TUNER-3V3
ANT
ANT
TUNER-3V3 TUN-LCH
TUN-RCH
TUN-LCH
TUNER-3V3
RDS-INT
TUNER-RES
TUNER-CLK TUNER-DA
TUN-RCH
CIRCUIT DIAGRAM TUNER BOARD
8

MAIN PCB COMPONENT LAYOUT TOP SIDE VIEW
9

MAIN PCB COMPONENT LAYOUT BOTTOM SIDE VIEW
10

PANEL PCB COMPONENT LAYOUT TOP SIDE VIEW
11

PANEL PCB COMPONENT LAYOUT BOTTOM VIEW
PANEL PCB COMPONENT LAYOUT BOTTOM VIEW
12

TUNER PCB COMPONENT LAYOUT TOP SIDE VIEW
13

TUNER PCB COMPONENT LAYOUT BOTTOM IDES VIEW
14

SET EXPLODER VIEW DRAWING
15