Philips DVP4000MKI/69 User manual

Published by KC-TE 0604 AV System Printed in the Netherlands Subject to modification 3139 785 31720
DVD PLAYER
CLASS 1
LASER PRODUCT
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.
All rights reserved. No part of this publication may be reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronic,
mechanical, photocopying, or otherwise without the prior permission of Philips.
Version 1.0
DVP4000MKI/69/78/93 & DVP4000MKII/69/78/93
Table of Content
DVP4000MKI
Service Hints (DVD4000MKI & MKII) ........................ 2
Block Diagram ......................... 3
Wiring Diagram ......................... 4
Mono Board Circuit Diagram ......................... 5
Mono Board Layout ......................... 10
Front Board Circuit Diagram ......................... 12
Front Board Layout ......................... 13
DVP4000MKII
Block Diagram ......................... 15
Wiring Diagram ......................... 16
Mono Board Circuit Diagram ......................... 17
Mono Board Layout ......................... 22
Front Board Circuit Diagram ......................... 24
Front Board Layout ......................... 25
Firmware Upgrading and
Diagnostic Software ......................... 27
Testing Instructions ......................... 28
DVP4000 Exploded View ......................... 30
DVP4000MKI & MKII
Spare Parts List ......................... 31
All manuals and user guides at all-guides.com
all-guides.com

EN 2 3139 785 3172x
Service Hints (DVP4000MKI & DVP4000MKII)
CAUTION
CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE DRIVE
ELECTRONICS WHEN CONNECTING A NEW DRIVE.THAT’S WHY, BESIDES THE SAFETY
MEASURES LIKE
• SWITCH OFF POWER SUPPLY
• ESD PROTECTION
ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN.
The following steps have to be done when replacing the defective loader :
1. Dismantling of the loader to access the ESD protection point if necessary.
2. Solder the ESD protection point*.
3. Disconnect flexfoil cable from the defective loader.
4. Put a paper clip on the flexfoil to short-circuit the contacts (fig.1)
5. Replace the defective loader with a new loader.
6. Remove paperclip from the flexfoil and connect it to the new loader.
7. Remove solder joint on the ESD protection point.
ATTENTION: The laser diode of this loader is protected against ESD by a solder joint which shortcircuits the laserdiode to ground.
For proper functionality of the loader this solder joint must be remove after connection loader to the set.
Type 1 Type 2
(ESD protection point is accessible from top of loader) (ESD protection point is accessible from bottom of the loader)
*Only applicable for defective loader needed to be sent back to supplier for failure analysis and to support backcharging
evidence.
This is also applicable for all partnership workshops.
DVP4000MKI
All manuals and user guides at all-guides.com

EN 3
3139 785 3172x
DVP4000MKI
DVP4000MKI
Block Diagram
DOOR LOCKING SWITCH
2 X LEDs
POWER
BUTTON
RECEIVER
15 16
L
16
11
A
K
O
J
LOADER MODULE
1402
E
F
A
KHM-310AHC
POWER SUPPLY
FRONT BOARD
MPEG BOARD
H
K
L
J
4Mb FLASH
SST39VF400A
2-CH AUDIO DAC
CS4345
P
P
N
20
12
17 191812
18
14
B
C
D D
345
MOTOR DRIVER
AM5868
16Mb SDRAM
IS42S16100
10 11
C
B
ANALOG VIDEO OUTPUT
CVBS/Y/C/Y/Pb/Pr
ZR36862
MPEG DECODER IC
632
G
H
87
F
17
G
E
10
2015 191413
113
1
M
I
2 6789
I
M
N
O
495
3139 249 2755
All manuals and user guides at all-guides.com

EN 4
3139 785 3172x
DVP4000MKI
CN202
CN201
1601
1712
1609
1604
1608
124
25
26
1 F-
2 F+
3 T+
4 T-
5 C
6 D
7 CD/DVD
8 RF
9 A
10 B
11 F
12 GND-PD
13 Vc
14 VCC
15 E
16 NC
17 VR-CD
18 VR-DVD
19 LD-CD
20 MD
21 HFM
22 NC
23 LD-DVD
24 GND-LD
25 GND
26 GND
1609
Screw Post
Note:
The cable 1902 will be damaged by the
screw if to lay it on the screw post during
assembling bottom and top cabinet.
1
1
1
1
4
12
1 VCC (5V)
2 GND
3 -12V
4 GND
1601
1 STBYLED
2 OPEN/CLOSE
3 RC
4 GND
5 VCC
6 STOP
7 PLAY
8 LED
1608
1 SP-
2 SP+
3GND
4HSW
5SL-
6SL+
1712
1901
1902
1903
1405
1406
1906
1409
1904
PSU
MPEG Board
Front Board
Door Locking Switch
1905
The ferrite ring is only for provision only
1
KHM310AHC
KHM310AHC
Wiring Diagram
All manuals and user guides at all-guides.com

EN 5
3139 785 3172x
Mono Board Circuit Diagram
DVP4000MKI
J
I
H
G
F
E
D
C
B
A
17 65432 1312111098
1312111098
7
654321
J
I
H
G
F
E
D
C
B
A
DOWN_LOAD_I/F
SW DEBUG
Low =
Standby
DSPVCC18
SPDIF
Y_R_V/OUT#
IR
+5VD
CTR_STBY
CTR_STBY
+3.2V
+2.5V
STB
COAX_SPDIF
CVBS_G_Y/OUT#
DSPVCC33
VCC33
CVBS_C/OUT# CVBS_G_Y/OUT#
VCC33
Y_R_V/OUT#
CTR_STBY
CVBS_C/OUT#
C_B_U_OUT#
C_B_U_OUT#
GND
CTR_STBY
D+5V
COAX_SPDIF
DUPTD0
DUPTD1
DUPRD0
DUPRD1
SPDIF
DSPVCC33
RF33V
DSPVCC33
CVBS_C/OUT CVBS_G_Y/OUT
C_B_U/OUT
STB
Y_R_V/OUT
MAIN_R
OP/CL
IRRCV
STOP
STBY
LED
MAIN_L
PLAY
SGND VGND AFEGNDRFGND DSPVCC18
RFA5V
A+5VL
DSPVCC33
A+12V
D+5V
RF33V
M5V
D+5V
VCC33
VCC33VCC33
DSPVCC33
VCC33
VCC33
D+5V
A+5VL
D+5V
D+5V
3743
91R
3777
NM
7723
PSS8050
2
13
5611 FB220R
TP74
1.
2844
0.1uF
6616
9.1V
3748
NM
H2
H2
1
2
3 4
5
6 7 8 9
1
2
34
5
6 7 8 9
+
2707
47uF/16V
12
1631
NM
1
2
3
4
2675 1nF
5608
FB75R
TP70
1
.
5609 FB220R
2703
0.1uF
3742
68R
TP71
1
.
3769
1K
+
2834
100uF/16V
TP30
1.
6605
1N4148
12
2738 1nF
5607 FB75R
TP31
1.
5612 FB220R
+
2715
100uF/16V
12
5613 FB220R
TP32
1
.
6617
1N4001
1 2
5610
FB75R
TP33
1
.
6618
1N4001
1 2
6612
1N4148
1 2
TP75
1.
TP34
1.
5628 FB220R
+
2709
47uF/16V
12
6615
1N4148
12
1601
Power
1
2
3
4
6614
1N4148
1 2
+
2853
10uF/16V
1 2
TP36
1
.
3739
33R
TP37
1
.
3733 NM
3772
3.3K
3740 0R
TP39
1
.
3773
10K
2739 1nF
1606
VIDEO OUT
5
1
6
8
7
3
9 10
2
4
11
5606 FB75R
TP40
1.
2645 1nF
TP41
1.
5614 FB220R
3774
33R/1%
6611
1N4148
12
TP42
1.
3775
120R/1%
6613
1N4148
12
TP43
1.
TP72
1.
TP44
1.
2646 1nF
+
2712
220uF/16V
12
3721 100R
TP45
1.
+
2722
100uF/16V
12
TP46
1.
5618 FB220R
TP47
1.
2705
0.1uF
+
2839
100uF/16V
12
7614
TL431 1
2 3
Ref
AC
2704
11pF
6610
1N4148
1 2
3770
NM
2836
0.1uF
3741
150R
TP76
1.
2837
0.1uF
3768
1K
6604
1N4148
1 2
7715 NM
1
2 3
5615 FB220R
2698
0.1uF
3749
NM
7615
NM
1 2 3
ADJ/GND
OUT2
IN
1614
AUDIO OUT
1
5
3
4
6
2
7 8
H1
H1
1
2
3 4
5
6 7 8 9
1
2
34
5
6 7 8 9
3778
10K
3771
33R
+
2708
220uF/16V
12
7714
BC858
1
2 3
TP73
1.
TP50
TEST POINT
12
TP51
TEST POINT
12
7721
BC848
1
2 3
5616 FB220R
7726
BC848
1
2 3
TP35
1.
7722
SI2301BDS
3
1
2
7725
PSS8050
2
13
1604
NM
1
2
3
4
3767 1K
2643 1nF
1608
TO VFD
1
2
3
4
5
6
7
8
+
2711
47uF/16V
12
3779
470R
2740 1nF
GND
3139 243 3177
All manuals and user guides at all-guides.com

EN 6
3139 785 3172x
Mono Board Circuit Diagram
J
I
H
G
F
E
D
C
B
A
17 65432 1312111098
1312111098
7
654321
J
I
H
G
F
E
D
C
B
A
JP2,JP3 settings:
1)Play mode: All Jumps off
2)Download mode: JP3's 1-2 short only
3)SW Debug mode: JP2's 1-2 short only
reset button
Low =
Standby
SDRAM speed <=7ns
PCLK
OSCIN
DEFECT
I2CDAT
I2CCLK
MEMDA8
DUPTD1
MEMDA7
RAMADD1
MEMDA15
DUPRD0
RAMDAT14#
MEMAD4
RAMDAT4# RAMADD3
MEMCS1-
RAMADD7
MEMDA9
MEMAD20
MEMDA13
MEMAD16
MEMAD5
OSCOUT
RAMDAT2# RAMDAT8#
MEMDA2
MEMDA11
MEMCS0- MEMAD2
RAMWE-
RAMBA
RESET-
RAMDAT0# RAMRAS- RAMADD0
MEMDA4
MEMDA12
MEMAD12 PLLCFGA
STOP
RAMDAT13# RAMDAT11#
RAMADD4
MEMAD6
MEMDA3
DUPRD1
LDON
MEMDA14
MEMAD10
RAMDAT15#
RAMDAT9# RAMADD2
MEMAD17
MEMAD9
MEMAD11 PLLCFGP
MEMAD13
MEMAD3
RAMDAT10#
MEMDA0
SPDIF
RAMDAT7# RAMADD8
MEMAD8
MEMDA6
MEMAD14
MEMAD15
STBY
IRRCV
INSW
RAMDAT5#
RAMDQM RAMADD10
RAMADD5
DUPTD0
DRVSB
RAMCS0-
MEMRD-
RAMDAT12#
MEMDA1
MEMAD18
MEMDA10
MEMWR-
RAMDAT1#
MEMAD7
MEMDA5
PLAY
MEMAD19
HOMESW
SPDL_SENS
OSCOUT
RESET
F33V
DSPVCC33
RAMCAS-
MIRR
RAMADD9
MEMAD0
RAMDAT6# RAMDAT3#
MEMAD1
RAMADD6
RAMDAT13 RAMDAT11
RAMADD2
RAMADD8
RAMDAT10
RAMWE- RAMADD10 RAMBA
RAMCS0-
RAMADD5
RAMDAT12
RAMDAT9
RAMDAT3
RAMDQM
RAMDAT14
RAMADD3 RAMDAT7 RAMDQM RAMADD0
RAMDAT15
RAMRAS-
RAMDAT6 RAMDAT0 RAMADD1
RAMADD9 RAMADD4 PCLK
RAMDAT1 RAMDAT2
RAMDAT8 RAMADD7
RAMCAS-
RAMDAT4 RAMDAT5
RAMADD6
DSPVCC18
VDDA VDDA
RAMCS1-
OSCIN
RAMDAT1
RAMDQM
RAMDAT4
RAMDAT6
RAMDAT10
RAMBA
RAMCAS-
RAMADD8
RAMADD9
RAMDAT5
RAMADD10
RAMDAT0
RAMADD4
RAMDAT9
RAMDAT8
RAMCS1-
RAMWE-
RAMDAT3
RAMCS0-
RAMRAS-
RAMADD11
PCLK RAMDAT15
RAMDAT13
RAMADD3
RAMDAT12
RAMADD5
RAMDAT7
RAMDAT11
RAMDAT2
RAMADD1
RAMADD7
RAMADD2
RAMADD0
RAMADD6
RAMDAT14
RAMADD11
OP/CL
F33V
RAMDAT15#
RAMDAT0# RAMDAT1#
RAMDAT14#
RAMDAT15
RAMDAT0 RAMDAT1
RAMDAT14
RAMDAT2#
RAMDAT13#
RAMDAT3#
RAMDAT12#
RAMDAT2
RAMDAT13
RAMDAT3
RAMDAT12
RAMDAT4#
RAMDAT11#
RAMDAT5#
RAMDAT10#
RAMDAT6# RAMDAT9# RAMDAT7# RAMDAT8#
RAMDAT4
RAMDAT11
RAMDAT5
RAMDAT10
RAMDAT6 RAMDAT9 RAMDAT7 RAMDAT8
SPDL_SENS
DEFECT
MIRR
IRRCV
STBY
OP/CL
STOP
PLAY
MEMCS1-
MEMWR-
MEMRD-
MEMCS0-
MEMAD[20:0]
MEMDA[15:0]
RFA_SDEN
RFA_SDATA
RFA_SCLK
SLED_PWM
SPINDLE_PWM
TRACK_DAC FOCUS_DAC
C_B_U
Y_R_V
CVBS_C
CVBS_G_Y
DUPTD1
VR_SEL
DRVSB
HOMESW
LDON
I2CCLK
AMCLK
ABCLK
ALRCLK
AOUT0
SPDIF
SVREF15
AAF_PI
AAF_TE
AAF_FE AAF_CE LINK VBIASS1
RFINN
RFINP
DUPRD1
DUPTD0
DUPRD0
I2CDAT
RESET
LED
DSPVCC33
AMUTE
STB
AOUT3 VGND AFEGND SGND
VGND
DSPVCC18
DSPVCC18
DSPVCC33
DSPVCC33
DSPVCC33
DSPVCC33
DSPVCC33
DSPVCC33
DSPVCC18
DSPVCC33
3614 1K
+ 2608
4.7uF/16V
2803
0.1uF
+ 2609
100uF/16V
2811
0.1uF
2810
0.1uF
2644 0.1uF
5603 FB220R
2813
0.1uF
3601
75R
3611 33R
3618 4.7K
3619 91R
2819
0.1uF
2670
10pF
+ 2701
47uF/16V
5631
FB220R
3610 33R
+ 2702
47uF/16V
7603
IC42S16100-TC/L70
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26
VDD DQ0 DQ1 VSSQ DQ2 DQ3 VDDQ DQ4 DQ5 VSSQ DQ6 DQ7 VDDQ LDQM WE
CAS RAS CS BA A10/AP A0 A1 A2 A3 VDD
VSS
DQ15 DQ14
VSSQ
DQ13 DQ12
VDDQ
DQ11 DQ10
VSSQ
DQ9 DQ8
VDDQ
NC
UDQM
CLK
CKE
NC
A9 A8 A7 A6 A5 A4
VSS
3600
10K
2815
0.1uF
3608 4.7K
2606 24pF
2809
0.1uF
1627
1
2
2602 24pF
5602 FB220R
3801
33Rx4
12 34 56 78
3609 0R
+ 2607
100uF/16V
5604
FB220R
TP77
1.
3606
330R
3803
33Rx4
12 34 56 78
1625
NM
1 2
1624
NM
1 2
+ 2603
100uF/16V
+ 2605
100uF/16V
1611
SWITCH
3
4
1
2
+ 2610
47uF/16V
3616
NM
2820
1uF
2802
0.1uF
2849
5P
3603 392R/1%
2601
NM(220pF)
+ 2604
100uF/16V
2823
0.1uF
2818
0.1uF
570127.000MHz
5601 FB220R
2806
0.1uF
TP78
1.
3612 4.7R
2847
0.1uF
5620 NM(2.7uH)
1623
NM
1 2
2848
0.1uF
2816
0.1uF
2817
1uF 2808 0.1uF
+ 2663
47uF/16V
TP48
1.
2812
0.1uF
7601
ZR36762
12
1
2
3
4
5
6
7
8
9
10
11
50
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
51
52
53 54 55 62 56 57 58 59 60 61 72 63 64 65 66 67 68 69 70 71 83 73 74 75 76 77 78 79 80 81 82 91 84 85 86 87 88 89 90 101 92 93 94 95 96 97 98 99 100 102 103 104
105
156
155
154
152
151
145
136
144
143
142
141
140
139
138
127
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
205 204 202 192 190 200 187 195 197 186 185 184 175 174 173 172 171 157 169 160 167 165 164 163 162 161 159 158
39
40
41
42
43
44
45
46
47
48
49
106
107
108
109
126
128
129
130
131
132
133
134
135
137
146
147
148
149
150
153
166 168 170 183 182 181 180 179 178 177 176 188 189 191 193 194 196 198 199 201 203 206 207 208
GNDP
SSCRXD/GPCIO[17]
MEMCS[1]#/GPCIO[18]
VDDP
MEMAD[15]/PLLPROG[0]
MEMAD[16]/PLLPROG[1]
MEMAD[14]/PLLPROG[2]
MEMAD[13]/AFETESTEN
MEMAD[12]/[PLLCFGA]
MEMDA[15]
MEMAD[11]/[PLLCFGP]
MEMDA[7]
GNDP
MEMAD[10]/[TESTMODE]
MEMDA[14]
MEMAD[9]
MEMDA[6]
MEMAD[8]
MEMDA[13]
MEMDA[5]
MEMAD[20]/[GPCIO19]/[MEMCS#2]
VDDP
MEMDA[12]
MEMWR#
MEMDA[4]
VDDC
MEMDA[11]
MEMDA[3]
MEMAD[19]/[PLLSEL]
GNDC
MEMDA[10]
MEMAD[18]
GNDP
MEMDA[2]
MEMAD[17]
MEMDA[9]
MEMAD[7]
MEMDA[1]
MEMAD[6]
VDD-IP
VDDP
RAMADD[4] RAMADD[3] RAMADD[5] GNDP RAMADD[2] RAMADD[6] VDDP RAMADD[1] RAMADD[7] RAMADD[0] GNDP RAMADD[8] VDDC RAMADD[10] GNDC RAMADD[9] VDDP RAMADD[11] RAMCS[0]#/RAMBA[1] RAMBA[0] GNDP RAMCS[1]# RAMRAS# RAMCAS# VDDP RAMWE# RAMDQM GNDPCLK PCLK VDDPCLK RAMDAT[8] GNDP RAMDAT[7] RAMDAT[9] RAMDAT[6] VDDP RAMDAT[10] RAMDAT[5] RAMDAT[11] GNDP RAMDAT[4] VDDC RAMDAT[12] GNDC RAMDAT[3] VDDP RAMDAT[13] RAMDAT[2] RAMDAT[14] RAMDAT[1] RAMDAT[15] RAMDAT[0]
VDDP
DUPTD1/GPCIO38
DUPRD1/GPCIO37
VDD-IP
DUPRD0/GPCIO35
GNDP
GPCI/O[32]
GPCI/O[31]
VDDP
GCLKA
GCLKP
XO
VDDA
RESET#
GNDA
VDDP
GNDP
HSYNC/GPCIO25/[CJTDO]
VDDC
VSYNC/GPCIO24/[CJTDI]
GNDC
AIN/[GPCIO23/CJTCK]
VDDP-A2
AMCLK
GNDP-A2
ABCLK
ALRCLK
GPAIO/[AOUT3]
AOUT[0]
AOUT[1]/[GPCIO22]
AOUT[2]/[GPCIO21]
SPDIF
SLEDPULSE/IDGPCIO6
VDDP
GNDP
VDDC
GNDC
DEFECT/IDGPCIO5
PWMACT[0]/GPCIO39
GNDPWM
VDDPWM
GNDAFES
VBIASS1 VBIASS0
VDDAFES
GNDAFERF
RFINN
RFINP
VDDAFERF
GNDDACD
DACDRIVE[1]
VDDDAC
DACDRIVE[0]
GNDDACBS2
GNDDACP
RSET C/B/U
Y/R/V/[C]
CVBS/C/[Y]
CVBS/G/Y
MEMDA[8]
MEMAD[5]
VDDP
MEMDA[0]
MEMAD[4]
MEMRD#
MEMAD[3]
MEMAD[2]
MEMCS[0]#
MEMAD[1]/[BOOTSEL2]
MEMAD[0]/[A]PLLSEL/[BOOTSEL1]
CPUNMI/GPCIO[20]
GNDP
[A]GPCIO110/BOOTSEL1/[AOUT3/ICGPCIO0]
[A]GPCIO111/BOOTSEL2/[IDGPCIO0]
COSYNC/GPCIO120/[ICGPCIO1/CJTMS]
GPCIO26/ICETMS/[DJTMS]
ICETDI/GPCIO122/[ICGPCIO2/DJTDI]
ICETDO/GPCIO123/[IDGPCIO1/DJTDO]
ICETCK/GPCIO27/[DJTCK]
GPCIO28/DJTMS
GPCIO29/DJTDI
GPCIO30/DJTDO
GPCIO128/DJTCK/[ICGPCIO3]
GPCI/O[130]/[IDGPCIO2]
GPCI/O[135]/[ICGPCIO4]
GPCI/O[33]
GPCI/O[137]/[ICGPCIO5]
GPCI/O[34]
GPCI/O[139]/[IDGPCIO3]
DUPTD0/GPCIO36
GNDDACPS
VDDDACS
GNDDACDS
ADCIN0 ADCIN1 ADCIN2 ADCIN3 ADCIN4 ADCIN5 ADCIN6 ADCIN7
PWMACT[1]/GPCIO40
PWMCO[0]/GPCIO41 PWMCO[1]/GPCIO42 PWMCO[2]/GPCIO43 PWMCO[3]/GPCIO44 PWMCO[4]/GPCIO45 PWMCO[5]/GPCIO46
PWMCO[6]/GPCIO152/[IDGPCIO4]
ICGPCIO6
GPCIO159/[ICGPCIO7]
SPINDLEDPULSE/IDGPCIO7
SSCCLK/GPCIO47
SSCTXD/GPCIO16
3615
NM
3804
33Rx4
12 34 56 78
2805
0.1uF
2804
0.1uF
+ 2600
47uF/16V
3602
330K
2801
0.1uF
2851
0.1uF
2822
1uF
2814
0.1uF
3802
33Rx4
12 34 56 78
2807
0.1uF
3605
NM
3692 NM
7607
NM
1
2
4
6
5
7
3
8
10
12
11
13
9
15
16
17
18
19
35
22
23
24
25
26
14
28
29
30
31
32
33
34
36
37
38
39
40
43
42
44
46
45
47
49
48
50
52
51
53
41
20
21
27
54
VCC
DQ0
DQ1
VSSQ
DQ2
DQ3
VCCQ
DQ4
DQ5
VSSQ
DQ6
DQ7
VCCQ
DQML
WE
CAS
RAS
CS
A11
A10
A0
A1
A2
A3
VCC
VSS
A4
A5
A6
A7
A8
A9
NC
CKE
CLK
DQMH
NC
VCCQ
DQ8
DQ9
VSSQ
DQ10
DQ11
VCCQ
DQ12
DQ13
VSSQ
DQ14
DQ15
VSS
BA0
BA1
VCC
VSS
GND
3139 243 3177
DVP4000MKI
All manuals and user guides at all-guides.com
all-guides.com

EN 7
3139 785 3172x
Mono Board Circuit Diagram
J
I
H
G
F
E
D
C
B
A
17 65432 1312111098
1312111098
7
654321
J
I
H
G
F
E
D
C
B
A
A19
NC
NC
RY/BY#
BYTE#
JP1 :
a)Flash memory(U5) : 1-3 short only
b)External SRAM( J16) : 1-2 and 3-4 short
Flash speed <= 70 nS
EXTERNAL SRAM PORT
Remove JP5 and install 3727 with 0R resistor
for MP
EXTERNAL SRAM PORT
MEMAD14
MEMAD13
MEMAD12
MEMAD11
MEMAD10
MEMAD9
MEMAD8
MEMAD18
MEMAD17
MEMAD7
MEMAD6
MEMAD4
MEMAD3
MEMAD2
MEMAD1
MEMAD16
MEMDA7
MEMDA14
MEMDA6
MEMDA13
MEMDA5
MEMDA12
MEMDA4
MEMDA11
MEMDA3
MEMDA10
MEMDA2
MEMDA9
MEMDA1
MEMDA8
MEMDA0
MEMRD-
MEMAD0
MEMDA15
AMEMAD19
FLASHCS-
RESET-
MEMDA[15:0]
MEMAD15
MEMAD20
MEMAD5
MEMCS0-
MEMCS1-
SSRAMCS-
FLASHCS-
DSPVCC33#
MEMWR-
DSPVCC33#
MEMRD-
MEMWR-
IMEMAD19
MEMAD[20:0]
MEMAD19
DSPVCC33#
I2CDAT
I2CCLK
GND
MEMAD14
MEMWR-
SSRAMCS-
MEMAD16
MEMAD7
MEMAD4
MEMDA8
MEMAD19
MEMDA0
MEMDA12
MEMAD10
MEMAD13
MEMDA10
MEMDA3
MEMDA15
MEMAD15
MEMAD3
MEMDA13
MEMAD2
MEMAD1
MEMDA9
MEMAD11
GND
MEMAD17
MEMAD9
DSPVCC33#
MEMDA11
MEMDA5
MEMDA14
DSPVCC33#
GND
MEMDA7
MEMDA2
MEMDA4
MEMAD5
MEMDA1
GND
MEMAD6
MEMDA6
MEMAD0
MEMAD12
MEMAD18
MEMAD8
MEMRD-
MEMDA[15:0]
MEMAD[20:0]
RESET
MEMRD-
MEMWR-
MEMCS0-
MEMCS1-
I2CDAT
I2CCLK
DSPVCC33
DSPVCC33#
DSPVCC33#
DSPVCC33#
DSPVCC33
7611
24C02
1
2
3
4
8
7
6
5
A0
A1
A2
GND
VCC
WP
SCL
SDA
3729
4.7K
+
2830
47uF/16V
7610
39VF400A
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
A15
A14
A13
A12
A11
A10
A9
A8
NC
A20
WE#
RP#
VPP
WP#
A19
A18
A17
A7
A6
A5
A4
A3
A2
A1
A16
VCCQ
GND
DQ15
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
DQ4
VCC
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
OE#
GND
CE#
A0
3725 0R
2833
0.1uF
3727 0R
3726 NM
2700
0.1uF
1610
NM
3
4
1
2
3728
NM
3730
4.7K
5630 FB220R
1628
NM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
3139 243 3177
DVP4000MKI
All manuals and user guides at all-guides.com

EN 8
3139 785 3172x
Mono Board Circuit Diagram
J
I
H
G
F
E
D
C
B
A
17 65432 1312111098
1312111098
7
654321
J
I
H
G
F
E
D
C
B
A
HIGH--MUTE LOW--OPERATE
NOTICE:WHEN LAYOUT,78L05 NEAR 2684
MUTEL
MUTER
A+12V
MUTE
MUTE
AOUTR
AOUTL
AOUT0#
AOUT0
AOUT3
ABCLK#
AMCLK#
ABCLK
AMCLK
ALRCLK#ALRCLK
AOUTR
MUTE
VQ+
VQ+
VQ+
AOUTL
MAIN_L
MAIN_R
AOUT0
AOUT3
ABCLK
ALRCLK
AMCLK
C_B_U/OUT
Y_R_V
CVBS_G_Y C_B_U CVBS_G_Y/OUT
CVBS_C
Y_R_V/OUT
CVBS_C/OUT
AMUTE
A+12V
A12V
A12V
A+12V
D+5V
A+12V
3693 3.3K
+
2838
47uF/16V
+
2669
220uF/16V
12
2684
47uF/16V
2688
150pF
+
-
7606A
JRC4558
3
21
8 4
2857
47uF/16V
12
2689
160pF
7710
BC848
1
23
7724 BC858
1
2 3
2664 120pF
6609 1N4148
1 2
2695 11pF
2696
150pF
2683
0.1uF
7712
BC848
1
2 3
3713
2K
3710 33R
3761 33R
2686
160pF
3714 4.7K
3762 33R
2694
160pF
+ 2840
220uF/16V
3715
75R 1%
2858
0.1uF
2678
47uF/16V
12
2691 11pF
2697
160pF
2665
22uF/16V
12
3701 10K
2671
0.1uF
3691 18K
2674
22uF/16V
12
2667
47uF/16V
12
3711 33R
2693
150pF
2677
22uF/16V
1 2
3712 NM
3702 47K
6608 1N4148
12
3690
10K
7727
BC858
1
2 3
3684 330R
3723
75R 1%
3796
10K
2855
1nF
+ 2831
47uF/16V
3703 47K
2687 11pF
3716
4.7K
2673
0.1uF
3700 330R
3724
75R 1%
7728 1.1uH
3689
470R
2668
1nF
2666 22uF/16V
1 2
2679
1nF
3719
75R 1%
3687
10K
2685
150pF
3717 33K
7729 1.1uH
2856
1nF
3707
10K
7609
CS4345
10
5
2
1
9
3
7
8
6
4
AOUTL
VQ
SCLK
DATA
VA
LRCK
AOUTR
AGND
FILT+
MCLK
+
-
7606B
JRC4558
5
67
8 4
2680
0.1uF
3786
10K
7711
BC848
1
23
66401N4148 12
3683 3.3K
3763 33R
2682 11pF
+ 2692
220uF/16V
3709
470R
3797
100R
7731 1.1uH
+ 2832
220uF/16V
2672 120pF
TP79
1.
3681
10K
7730 1.1uH
7608
78L05 1
2
3OUT
GND
IN
66411N4148 12
3682 18K
3139 243 3177
DVP4000MKI
All manuals and user guides at all-guides.com

EN 9
3139 785 3172x
Mono Board Circuit Diagram
E
D
C
B
A
17 65432 1312111098
1312111098
7
654321
J
I
H
G
F
J
I
H
G
F
E
D
C
B
A
VR_SEL Logic:
CD=LOW
DVD=HIGH
CD/DVD_SW Logic:
CD=HIGH
DVD=LOW
HFE>300
HFE>300
KHM310 OPU
The vaule out of () is used for
AM5868S.
The vaule in () is used for
BA5954.
AAF_CE
AAF_FE
VC25
AAF_PI
FACT+
FACT-
OPU_D RFA_FE
SVREF15
RFA_LDON
RFA_MIRR
OPU_A
RFA_SDEN
FNP
AAF_TE
AAF_CE
RF-SIGNAL
OPU_B RFA_TE
RFA_SDATA
RFA_PI
RFINP
OPU_E
OPU_C
+5VL
FNN RFINN
RFA_DEFECT
LaserMD
OPU_F
TACT+
SLED_PWM1
SLED-
VC2
SEN_OPMO
SEN_OPM-
TRACK_DAC1
DSPVCC33
SEN_OPM+
FOCUS_DAC1
TACT-
FACT-
FACT+
MOT_SPDL+
DRVSB
MOT_SPDL-
SLED+
SEN_OPMO
MOT_SPDL+ MOT_SPDL-
SEN_OPM-
SEN_OPM+
DVDLD
CDLD
TACT+
TACT-
RFINN
LDON
AAF_TE
AAF_PI
RF33V
RFA_SCLK
RFA_SDEN
SVREF15
LINK
RFA_SDATA
RFINP
DEFECT
AAF_FE
AAF_CE
VR_SEL
MIRR
HOMESW
VBIASS1
FOCUS_DAC
TRACK_DAC
SLED_PWM
DRVSB
SPDL_SENS
RFA5V
SGND
RF33V
RFGND
RFA5V
RFGND
RFGND
RFGND
RF33V
RFA5V
RFA5V
RFGND
RFGND
RFA5V
RFGND
MGND
RFGND
RFGND
RFA5V
RFA5V
MGND
RFGND
MGND
MGND
MGND
RF33V
MGND
MGND
MGND
M5V
MGND
MGND
MGND
RF33V
M5V
RF33V
MGND
M5V
MGNDMGND MGND2649
0.1uF
2648
0.1uF
3780 NM(0R)
2611
0.1uF
7702
BC848
1
2 3
3781 10K(NM)
3648
100R/1%
7704 BC858
1
23
3624
10K
TP9
1
.
1712
TO DRIVE
1
2
3
4
5
6
2626 470pF/10%
2647
NM
2657 560pF
TP23
1
.
3645
4.7K
3632 1.3K
TP8
1.
3784 NM(0R)
3676 NM(1R)
2656 NM(100pF)
TP11
1
.
7732
FB220R
3785
NM(0R)
3671 NM(6.8K)
3622
NM(0R)
3628
11K
TP24
1
.
2825 0.1uF
36300R(NM)
3629
1M
TP21
1.
3631 2.7K
3656 5.6K
3789 4.7K(NM)
2827
0.1uF
3792
390R
3640 NM(0R)
TP71
.
3650
100R/1%
3788 0R(NM)
3638 0R(NM)
TP10
1
.
3651
10K/1%
3643 220R
TP13
1
.
3621
4.7K
3623 12K/1%
3649
10K/1%
TP5
1
.
3677 NM(1R)
TP19
1
.
3647 11R
2634560pF
2654 0.1uF
7605
AM5868(BA5954)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
28
27
26
25
24
23
22
21
20
19
18
17
16
15
29 30
VINFC
CFCERR1(OP2IN-)
CFCERR2(OP2IN+)
VINSL+
VINSL-(OP2OUT)
VOSL(CLOSE)
VNFFC(OPEN)
VCC
PVCC1(LOAD-)
PGND(LOAD+)
VOSL-
VOSL+
VOFC-
VOFC+
STBY
BIAS
VINTK
CTKERR1(OP1IN+)
CTKERR2(OP1IN-)
VINLD
PREGND
PVCC2
VNFTK(OP1OUT)
PGND(VCC2)
VOLD-
VOLD+
VOTK-
VOTK+
GND GND1
TP2
1
.
2638
0.1uF/10%
2637 220pF/10%
3652
10K/1%
2615
1nF/10%
2640
2.7nF
2623 2.2nF/10%
TP6
1
.
7701
BC848
1
23
+ 2621
100uF/16V
2660
27nF
TP15
1
.
7703
BC848
1
23
2659
27nF
TP16
1.
3674 0R(1R)
TP17
1.
2629 0.1uF/10%
TP20
1
.
+
-
7602B
NM(TL3472)
5
67
84
2661
220uF/16V
7734
10uH
2627 2.2nF/10%
3795
NM
3607
NM
7604
ZR36707
1
2
3
4
5
6
7
8
9
10
11
12
13
14
31 20 29 23 24 28 26 19 25 18
33
27 22 21 17
44
45
46
37
30
40
42
43
35
48
47
38
41
39
36
32
52 53 54 61 58 64 63 51 50 49 59 57 62 60 55 56
15
16 34
DVDRFP
DVDRFN
A2
B2
C2
D2
CP
CN
D
C
B
A
CD_D
CD_C
MIN VC MB DVDPD CDPD MP LDON VPB VNB CD_E
LINK
MIRR CDLD DVDLD CD_F
LCP
V33
SCLK
V25
MLPF
FE
MNTR
LCN
TPH
SDEN
SDATA
PI
CE
TE
V125
MEVO
FNN
FNP
DIP
ATON
VPA
RFDC
RFSIN
VNA
MEV
RX
AIP
RFAC
ATOP
AIN
DIN
BYP
CD_B
CD_A DFT
3659 NM(47K)
3668 11k
3662 5.6K
TP1
1
.
3625
1.2K
1609
24P-HEAD/bottom
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
25 26
GND-LD
DVD-LD
NC
HFM
MD
CD-LD
VR-DVD
VR-CD
NC
E
VCC
VC(VREF)
GND/PD
F
B
A
RF
CD/DVD_SW
D
C
T-
T+
F+
F-
GND GND
2650
0.1uF
3793 NM(0R)
TP61
1.
3667 0R(NM)
TP62
1.
2616 1nF/10%
2658 NM(4.7nF)
3627
10K
TP64
1.
2828
0.1uF
3639 4.7K
3620
4.7K
TP63
1
.
26315.6nF
7705
BC858
1
2 3
TP65
1.
3790
91R
2829
0.1uF
+
2641 100uF/16V
3660 22K(10K)
3626
3.3K
+
2651 100uF/16V
26335.6nF
2639 0.1uF
3634
3.3K
TP3
1
.
TP4
1
.
2624 2.2nF/10%
2628 33pF/10%
3663 5.6K
TP18
1.
2612 33nF/10%
6603
1N4148
12
3644 13K
2614 1nF/10%
26191nF/10%
2642
NM
3658 5.6K
2613 1nF/10%
3666 NM(10K)
3661 5.6K
3675 0R(1R)
6602
1N4148
1 2
7733
10uH
26325.6nF
3794 0R
3655 5.6K
3664 11K
2826
0.1uF
3617 0R
2620 1nF/10%
2652 2.7nF
3635
22K
+ 2630
4.7uF/16V
2653 NM(100pF)
3665 NM(10K)
3641
9.1K
2824
0.1uF
2662
0.1uF
3657 5.1K(0R)
2617 1nF/10%
2636 22nF/10%
2622
0.1uF
3791
91R
2655 0.1uF
3646 220R
26181nF/10%
3636
22K
3642 11R
3633 1.3K
2625 2.2nF/10%
2635 6.8nF/10%
GND
SPINDLE_PWM
3139 243 3177
DVP4000MKI
All manuals and user guides at all-guides.com

EN 10
3139 785 3172x
DVP4000MKI
17 65432 1312111098
1312111098
7
65
J
I
H
D
C
B
A
G
F
E
D
C
B
A
4321
J
I
H
G
F
E
3139 243 3177
Mono Board Layout (Topview)
All manuals and user guides at all-guides.com