Polar Refrigeration G620-A User manual

Model:
G620-A
17kg Ice Maker
Instruction manual
G620-A_A5_v6_20200116.indb 1 2020/1/16 17:40

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT immerse in water, or use steam/jet washers to clean
the unit.
• DO NOT cover the appliance when it is operating.
• Always carry, store and handle the appliance in a vertical
position.
• ONLY use drinking or potable water when making ice cubes.
• For indoor use only.
• Replace any unused water in the tank at least once every 24
hours.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Polar recommends that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity (Class I equipment), Insulation
Continuity and Functional Test.
G620-A_A5_v6_20200116.indb 2 2020/1/16 17:40

3
AU
Telephone Helpline: 1300225960
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
Warning: Risk of Fire / flammable materials
• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
• Ice Maker
• Removable ice basket
• Ice scoop
• Instruction manual
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
Note: If the unit has not been stored or moved in an upright position, let it stand
upright for approximately 12 hours before operation. If in doubt allow to stand.
G620-A_A5_v6_20200116.indb 3 2020/1/16 17:40

4
AU Telephone Helpline: 1300225960
1. Remove the appliance from the packaging and
remove the protective film from all surfaces.
2. When positioning the ice maker, maintain a
distance of 10cm between the appliance and
walls or other objects for ventilation. NEVER
LOCATE NEXT TO OR NEAR A HEAT
SOURCE.
3. If necessary, adjust the screw legs of the ice
maker to make it level. The efficiency of the
ice maker can be reduced if the appliance is
unevenly located.
Operation
Control Panel
Ice cube size indicator
Power switch: This switch can control the
mains power supply of the appliance.
Making Ice
Note: Before using for the first
time, clean the water tank, ice
basket and ice basket shelf.
Each time the appliance is refilled, the first
ice making cycle is used to reduce the water
temperature. This results in uneven ice cube
production which is perfectly normal. You may wish
to discard ice created in the first production cycle.
1. Lift the access lid and fill the water tank up the
level of the ice basket shelf.
2. Connect the appliance to the power and press
the START button.
3. Press the SELECT button repeatedly to scroll
through the ice cube sizes. Stop when the
required size is illuminated.
Note: Each ice making cycle
takes between 6-12 minutes,
depending on the size of cube
selected.
4. The appliance will run a start-up routine and
then begin ice production.
Note: If the water level is too
low, the Water Low indicator
lights up and the appliance
stops working. Fill the water
tank and the appliance will
restart automatically.
5. When the cubes reach the ice sensor the
appliance will stop production. Production
resumes once ice has been removed.
6. Press the STOP button at any time to halt the
ice making process.
G620-A_A5_v6_20200116.indb 4 2020/1/16 17:40

5
AU
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
• Always switch off and disconnect the power supply before cleaning.
• Warm, soapy water is recommended for cleaning. Cleaning agents may leave harmful residues. DO
NOT wash the base unit, instead wipe the exterior with a damp cloth.
• A POLAR agent or qualified technician should carry out repairs if required.
• Clean the water filter regularly with a small brush, particularly in hard water areas. The water filter is
located in the pump inlet at the bottom of the water tank, remove by pulling out with fingers.
• If the appliance is to be left unused for longer than 24 hours, loosen the drain screw and drain the
water from the tank.
• The inner removable parts and water tank should be cleaned regularly.
Troubleshooting
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly
and switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the plug fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
Appliance is noisy or
works intermittently
Power fluctuations Turn off the ice maker and restart after 3
minutes
Water
indicator is lit
Water level is low or tank is empty Refill water tank and restart
Water filter is blocked Clean water filter and restart appliance
Ice Full
indicator is lit
Ice basket full Empty the ice basket
Room temperature is too low Move the appliance to a warmer position
+
Water and Ice
Full indicators
flash together
Water box is blocked and cannot
tilt
Disconnect from the power supply.
Remove some of the ice cubes and
gently tilt the water box by hand. Restart
the appliance after 3 minutes
Ice cubes are sticking
together
Ice making cycle is too long Reset the ice cube size and restart the
appliance
Water tank temperature is too low Empty water tank and refill
Compressor runs but no
ice is made
Refrigerant leak or block in the
refrigerant system
Call POLAR agent or qualified technician
G620-A_A5_v6_20200116.indb 5 2020/1/16 17:40

6
AU Telephone Helpline: 1300225960
Technical Specifications
Model Voltage Power Current
Water
Tank
Volume
Bin
Storage
Maximum
Ice Making
Capacity
Refrigerant Dimensions
H x W x D mm Weight
G620-A 220-240V
50Hz
126W 1.0A 3.9 litres 2 kg 17kg/24 hours R600a 28g 415 x 3365 x 420 17.2 kg
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
G620-A_A5_v6_20200116.indb 6 2020/1/16 17:40

DECLARATION OF CONFORMITY
Equipment Type
Manual Fill Ice Cube Maker -15kg
Model
G620-A
Legislation
Electrical Safety
Electromagnetic Compatibility
Standards
IEC 60335.1:2011 +A1:2013
IEC 60335.2.24:2010 +A1:2012
EN55014-1:2006 +A1:2009 +A2:2011
EN55014-2:2015
EN61000-3-2:2014
EN61000-3-3:2013
Producer Name
Polar
Producer Address
15 Badgally Road,
Campbelltown,
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Legislation and Standard(s).
Date
28th June 2019
Signature
Full Name
Ashley Hooper
Position
Technical & Quality Manager/ Responsible Supplier
G620-A_A5_v6_20200116.indb 7 2020/1/16 17:40

G620-A_A5_v6_20200116
http://www.polar-refrigerator.com/
G620-A_A5_v6_20200116.indb 8 2020/1/16 17:40