Polar Refrigeration CD080-A User manual

600 / 400 / 150 litre series
Refrigerators/Freezers
Instruction manual
Models:
CD080-A/CD081-A/CD082-A/CD083-A/CD084-A/CD085-A/CD610-A/CD611-A/
CD612-A/CD613-A/CD614-A/CD615-A/CD086-A/CD087-A/CD088-A

Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out installation and any repairs if required. Do not
remove any components or service panels on this product.
• Consult Local and National Standards to comply with the following:
• Health and Safety at Work Legislation
• BS EN Codes of Practice
• Fire Precautions
• IEE Wiring Regulations
• Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g. heaters, ice-cream makers etc.).
• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean
immediately if contact occurs.
• DO NOT store products on top of the appliance.
• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the
refrigerator.
• Always carry, store and handle the appliance in a vertical position and move by holding the base of the
appliance.
• Always switch off and disconnect the power supply to the unit before cleaning.
• Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of
local authorities.
• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified
technician in order to avoid a hazard.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilites, or lack of experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible for their safety
• Children should be supervised to ensure that they do not play wth the appliance
Product Description
• CD080-A - 150 litre Refrigerator
• CD081-A - 140 litre Freezer
• CD082-A - 400 litre Refrigerator
• CD083-A - 365 litre Freezer
• CD084-A - 600 litre Refrigerator
• CD085-A - 600 litre Freezer
• CD086-A - 150 litre Glass-Door Refrigerator
• CD087-A - 400 litre Glass-Door Refrigerator
• CD088-A - 600 litre Glass-Door Refrigerator
• CD613-A - 365 litre Freezer
• CD614-A - 600 litre Refrigerator
• CD615-A - 600 litre Freezer
• CD610-A - 150 litre Refrigerator
• CD611-A - 140 litre Freezer
• CD612-A - 400 litre Refrigerator

Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are supplied
fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.
2. Maintain a distance of 2cm (0.7 inches) between the unit and walls or other objects for ventilation.
Increase this distance if the obstacle is a heat source.
Operation
Control Panel
The control panel is located on the front of the appliance.
Tu r n O n
1. Close the door of the appliance.
2. Connect the appliance to a mains power supply.
3. Set the temperature to the desired setting: 0 (Off), 1 (Cool) to 7 (Cold)
Storing Food
To get the best results from your POLAR appliance, follow these instructions:
• Only store foodstuffs in the appliance when it has reached the correct operating temperature.
• Do not place uncovered hot food or liquid inside the appliance.
Note: If the unit has not been moved or stored in an upright position, let it stand upright
for approximately 12 hours before operation. If in doubt allow the appliance to stand.
Note: Before using the appliance for the first time, clean the shelves and interior with
soapy water.
• POLAR Refrigerator / Freezer
• Shelves - Refrigerator only
CD610-A/ CD080-A x 3/ CD086 x 3
CD612-A/ CD082-A x 4 / CD087 x 4
CD614-A x 4 / CD084-A / CD088 x 4
•Keysx2
•Spacersx2
• Instruction manual

• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods of time.
Lock/Unlock the Doors
A lock is fitted to the doors to ensure foodstuffs are kept secure within your POLAR appliance.
Use the keys provided to lock/unlock the door.
Cleaning, Care & Maintenance
• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Clean the door seal with water only.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
• A POLAR agent or qualified technician must carry out repairs if required.
Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance.
POLAR recommend that a POLAR agent or qualified technician clean the condenser.
Replacing the Lamp (CD086-A,CD087-A,CD088-A)
1.) Switch Off and disconnect the appliance from the power supply
2.) Remove the plastic cover
3.) Twist the lamp in its socket and release
4.) Remove the lamp and replace the new one of the same power rating
5.) Replace the plastic cover

Tro u b l e s h o o ti n g
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline.
Fault Probable Cause Action
The appliance is not
working
The unit is not switched
on
Check the unit is plugged in correctly and switched on
Plug and lead are
damaged
Call POLAR agent or qualified Technician
Fuse in the plug has
blown
Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance turns
on, but the
temperature is too
high/low
Too much ice on the
evaporator
Defrost the appliance
Condenser blocked with
dust
Call POLAR agent or qualified Technician
Doors are not shut
properly
Check doors are shut and seals are not damaged
Appliance is located near
a heat source or air flow
to the condenser is being
interrupted
Move the refrigerator to a more suitable location
Ambient temperature is
too high
Increase ventilation or move appliance to a cooler position
Unsuitable foodstuffs are
being stored in the
appliance
Remove any excessive hot foodstuffs or blockages to the fan
Appliance is overloaded Reduce the amount of food stored in the appliance
The appliance is
leaking water
The appliance is not
properly levelled
Adjust the screw feet to level the appliance (if applicable)
The discharge outlet is
blocked
Clear the discharge outlet
Movement of water to the
drain is obstructed
Clear the floor of the appliance (if applicable)
The water container is
damaged
Call POLAR agent or qualified Technician
The appliance is
unusually loud
Loose nut/screw Check and tighten all nuts and screws
The appliance has not
been installed in a level or
stable position
Check installation position and change if necessary

Technical Specifications
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed, using a dedicated earthing circuit.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any
emergency disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must not be
disposed of as household waste. To help prevent possible harm to human health and/or the
environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly,
contact the product supplier, or the local authority responsible for waste disposal in your
area.
POLAR parts have undergone strict product testing in order to comply with regulatory standards and
specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
Model Voltage Power Current Temperature
Range
Capacity
(litres) Refrigerant Dimensions H x W x D (mm)
Weight
(Kg)
CD080-A 220-240V 50Hz 150 1.0A -2°C to 8°C 150 R134a (75g) 850x600x600 44
CD081-A 220-240V 50Hz 150 1.0A -10°C to -25°C 140 R134a (75g) 850x600x600 44.5
CD082-A 220-240V 50Hz 185 1.5A -2°C to 8°C 400 R134a (170g) 1850x600x600 69
CD083-A 220-240V 50Hz 210 2A -10°C to -25°C 365 R134a (185g) 1850x600x600 71
CD084-A 220-240V 50Hz 185 1.5 -2°C to 8°C 600 R134a (210g) 1890x777x695 90
CD085-A 220-240V 50Hz 350 3.5 -10°C to -25°C 600 R134a (290g) 1890x777x695 94
CD610-A 220-240V 50Hz 150 1.0A -2°C to 8°C 150 R134a (75g) 850x600x600 44
CD611-A 220-240V 50Hz 150 1.0A -10°C to -25°C 140 R134a (75g) 850x600x600 44.5
CD612-A 220-240V 50Hz 185 1.5A -2°C to 8°C 400 R134a (170g) 1850x600x600 69
CD613-A 220-240V 50Hz 210 2A -10°C to -25°C 365 R134a (185g) 1850x600x600 71
CD614-A 220-240V 50Hz 185 1.5 -2°C to 8°C 600 R134a (210g) 1890x777x695 90
CD615-A 220-240V 50Hz 350 3.5 -10°C to -25°C 600 R134a (290g) 1890x777x695 94
CD086-A 220-240V 50Hz 150 1.0A -2°C to 8°C 150 R134a (75g) 850x600x600 47
CD087-A 220-240V 50Hz 185 1.5A -2°C to 8°C 400 R134a (170g) 1850x600x600 72
CD088-A 220-240V 50Hz 185 1.5A -2°C to 8°C 600 R134a (290g) 1890x777x695 93

All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means,
electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right
to change specifications without notice.

DECLARATION OF CONFORMITY
I, the undersigned, hereby declare that the equipment specified above
conforms to the above Legislation and Standard(s).
Equipment Type Glass Door Refrigerator
Model CD086-A, CD087-A, CD088-A, CD080-A,
CD081-A, CD610-A, CD611-A, CD612-A,
CD613-A, CD614-A, CD615-A
Legislation C-Tick
AS/NZ 3820 Essential Safety Requirements for
Low Voltage Electrical Equipment
Standards AS/NZS CISPR 14.1:2010
AS/NZS 60335.2.89:2010
Producer Name POLAR
Producer Address 15 Badgally Road
Campbelltown,
NSW 2560
Date 13/11/12
Signature
Full Name Richard Cromwell
Position Marketing Director

CD610-A-CD615-A_CD080-A-CD088-A_v5