Q-Optics Radiant RADSYSC1 User manual

Have a better look.
®
Radiant™
LIGHT SYSTEM
Cordless Headlight

11Contents
Before you begin, verify light system kit contents:
Welcome
to Q-Optics Radiant™Light System Cordless Headlight RADSYSC1
Headlight w/Battery Tray
RADHUC1
Anti-Curing Filter
Power Supply & USB-C Cable
5V - 550mA DC power supply
2 Batteries
RADBLC1

22Assembly Features
System Features
The Q-Optics RADSYSC1 Radiant™Cordless Headlight features an
ergonomic and easy to understand control integrated with the battery
pack. Note the location and function of the interface below.
System Assembly
Assembling the Radiant™Cordless
Headlight is quick and easy. For use,
simply slide the battery onto the
battery tray until it clicks in.
To charge the battery pack,
simply plug the power supply
cord USB-C interface into the
charger interface on the side
of the battery as shown later in
these instructions.
On/Off
Activation Area
Battery tray
Power supply USB-C
connection interface Battery Status LED

33Using the Cordless Headlight
Headlight Operation
Operating the system is simple and
intuitive; power the light on and off with a
simple touch of the logo area.
Suggestions
Anti-curing – Use included anti-curing
filter to prevent fast curing of composite
material.
1
Become familiar with the safety symbols presented in this
section. These symbols will alert you to safety hazards
and conditions that may result in personal injury, death, or
property and equipment damage.
WARNING: Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of electrical shock. Failure to
observe this warning may result in personal
injury, death, or equipment damage.
WARNING: Disconnect equipment from line
voltage. Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of explosion or fire. Fire, open
flames, and smoking prohibited.
WARNING: Wear protective clothing, safety
goggles, and approved respiratory protection.
Failure to observe may result in serious injury.
WARNING: Hot! Risk of burns. Wear
heat-protective clothing, safety goggles with side
shields and/or heat-protective gloves depending
on the symbol shown.
WARNING: System or material pressurized.
Relieve pressure. Failure to observe this
warning may result in serious injury or death.
1. Safety Symbols
RED
RED
Green
Voltage {V}
Charge Current
Current {A}
Charge
termination
Current
80-95%
Fast charge
Indication:
Final charge
Charge voltage
Charging Diagram
Charge completed
GREENREDRED
100% Capacity
1
Become familiar with the safety symbols presented in this
section. These symbols will alert you to safety hazards
and conditions that may result in personal injury, death, or
property and equipment damage.
WARNING: Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of electrical shock. Failure to
observe this warning may result in personal
injury, death, or equipment damage.
WARNING: Disconnect equipment from line
voltage. Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of explosion or fire. Fire, open
flames, and smoking prohibited.
WARNING: Wear protective clothing, safety
goggles, and approved respiratory protection.
Failure to observe may result in serious injury.
WARNING: Hot! Risk of burns. Wear
heat-protective clothing, safety goggles with side
shields and/or heat-protective gloves depending
on the symbol shown.
WARNING: System or material pressurized.
Relieve pressure. Failure to observe this
warning may result in serious injury or death.
1. Safety Symbols
RED
RED
Green
Voltage {V}
Charge Current
Current {A}
Charge
termination
Current
80-95%
Fast charge
Indication:
Final charge
Charge voltage
Charging Diagram
Charge completed
GREENREDRED
100% Capacity
Warnings
• Do not disassemble battery pack
• Do not dispose of battery pack in fire
• Do not heat battery pack above 60oCelsius (140oFahrenheit)
Low Battery Warning:
If the headlight is powered on it will toggle from
bright to dim for about 1 second five times to
indicate a low battery (indicating approximately
15-25 minutes of use remaining). When the battery
is too low to run the headlight, the LED indicator
will flash RED while it is installed on the tray. (A
completely dead battery cannot flash the red light).
* If the headlight does not turn on with a known
good battery, remove and re-seat the battery to
make sure you have a proper connection.
On/Off
Using sterile technique gently touch
the logo area with a vertical motion
to turn ON or OFF the headlight.

44Using the Cordless Headlight
1
Become familiar with the safety symbols presented in this
section. These symbols will alert you to safety hazards
and conditions that may result in personal injury, death, or
property and equipment damage.
WARNING: Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of electrical shock. Failure to
observe this warning may result in personal
injury, death, or equipment damage.
WARNING: Disconnect equipment from line
voltage. Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of explosion or fire. Fire, open
flames, and smoking prohibited.
WARNING: Wear protective clothing, safety
goggles, and approved respiratory protection.
Failure to observe may result in serious injury.
WARNING: Hot! Risk of burns. Wear
heat-protective clothing, safety goggles with side
shields and/or heat-protective gloves depending
on the symbol shown.
WARNING: System or material pressurized.
Relieve pressure. Failure to observe this
warning may result in serious injury or death.
1. Safety Symbols
RED
RED
Green
Voltage {V}
Charge Current
Current {A}
Charge
termination
Current
80-95%
Fast charge
Indication:
Final charge
Charge voltage
Charging Diagram
Charge completed
GREENREDRED
100% Capacity
Warning
• Headlight heats up during use
Touch with Caution
RADSYSC1 Cordless Headlight
The Q-Optics Radiant™Cordless Headlight mounts easily via
the “Quick Connect Mount” enabling use with the Q-Optics
Headband, most brands of custom TTL style loupes, most
brands of flip style loupes, eyeglasses, and safety glasses.
Attach mounting clip (if necessary) using instructions included
with clip. Headbands and some loupes come with clip already
mounted.
Remove name plate (if necessary) by pressing upward from the
bottom and off to reveal the mounting screws as shown above.
Mounting clip styles will vary.
Attach the headlight by sliding the quick
disconnect onto the mounting screws as shown.
Install anti-curing filter using the steps below.
1. Align filter with front
of headlight as shown.
2. Snap filter onto
front of headlight.

55Charging the battery
1. Plug power supply USB-C cable
into bottom of the battery pack.
NOTE: The light will not run when
the USB cable is plugged into a
power source.
2. Plug power supply into
electrical outlet.
3. Battery LED will be RED to
indicate battery is charging.
When Battery LED turns GREEN
battery is fully charged.
Battery Storage: If stored OFF the tray the battery will last
significantly longer than if stored ON the tray.
Using the Power Supply
READ THESE INSTRUCTIONS BEFORE USING POWER SUPPLY

66Cleaning and Care
Cleaning and Care
The Q-Optics Radiant™Cordless Headlight is a fine optical
instrument and should be handled with care.
1. Do not submerge headlight into water or any type
of sterilization fluid. The headlight is not water proof
and should not be washed or submerged in water.
2. Basic cleaning may be done with a clean dry
micro fiber cloth or the lens can be sprayed lightly
with Q-Optics Optical Lens Cleaner. Use a light
pressured circular motion to clean or dry the
headlight lens.
3. It is OK to disinfect headlight using alcohol, Lysol®
spray, Cavi-Wipes or other surface disinfectant.
4. Do not use solvents or cleaning solutions other than
those listed above on the headlight or battery pack.
Disposal Instructions
1. Do not throw headlight, battery pack or charger in the trash.
2. Contact your local authorities for disposal or return to Q-Optics for free disposal.
Do not spray cleaning or disinfecting solutions into open
electrical areas on the battery pack. Damage may occur.
1
Become familiar with the safety symbols presented in this
section. These symbols will alert you to safety hazards
and conditions that may result in personal injury, death, or
property and equipment damage.
WARNING: Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of electrical shock. Failure to
observe this warning may result in personal
injury, death, or equipment damage.
WARNING: Disconnect equipment from line
voltage. Failure to observe this warning may
result in personal injury, death, or equipment
damage.
WARNING: Risk of explosion or fire. Fire, open
flames, and smoking prohibited.
WARNING: Wear protective clothing, safety
goggles, and approved respiratory protection.
Failure to observe may result in serious injury.
WARNING: Hot! Risk of burns. Wear
heat-protective clothing, safety goggles with side
shields and/or heat-protective gloves depending
on the symbol shown.
WARNING: System or material pressurized.
Relieve pressure. Failure to observe this
warning may result in serious injury or death.
1. Safety Symbols
RED
RED
Green
Voltage {V}
Charge Current
Current {A}
Charge
termination
Current
80-95%
Fast charge
Indication:
Final charge
Charge voltage
Charging Diagram
Charge completed
GREENREDRED
100% Capacity

Q-Optics / Quality Aspirators
1419 Godwin Lane
Duncanville, Texas 75116 USA
972-298-2669 Local
800-858-2121 US & Canada only
972-298-6592 Fax
© 2020 Q-Optics. All rights reserved. Product specifications are subject to change at any time without prior notice.
www.q-optics.com
UI-317-10017-01 ECN 2020
WarrantyTechnical Data
Weight of Battery Pack 20.14 grams
Weight of Headlight 7.96 grams
Battery Type Li-Ion battery, 3.7 V / 450 mAh
Battery Charge Time 1 hour 45 minutes
New Battery Life 2.5 hours (each battery)
Operation Mode Continuous
Operation and Storage
Temperature -20º to 135º F (-29 to 57 C)
Quality Aspirators guarantees material, construction
and design to be free of deficiencies from the time
of first purchase.
The warranty goes into effect from the time of
purchase by the original purchaser. In the event of
change of ownership from the original purchaser, the
warranty will last for the remainder of the warranty
period from the original date of purchase. Units that
are repaired or any replacement units do not receive
an extended warranty.
Defective units will be repaired or replaced by
Quality Aspirators or its authorized representative.
Quality Aspirators has the sole and final decision in
determining if a unit is defective or whether the unit
will be repaired or replaced with similar equipment.
The Headlight is covered under a 24 month warranty.
Batteries are an expendable part and are not
considered defective by simply exhibiting diminished
capacity. Batteries are under warranty for a period of
12 months.
Mistreatment, misuse, or tampering with the unit
voids all warranty rights. Water damage is not
covered and will void warranty. Manual instructions
and warnings must be observed at all times.
For initiation of a warranty claim in the USA please
contact:
Quality Aspirators
1419 Godwin Ln
Duncanville, TX 75116
P 800-858-2121
support@q-optics or
[email protected]
Outside the USA – please contact your local
distributor.
No changes may be made to this warranty without
being first written, printed, and published by Quality
Aspirators Inc.