Quantum Rehab 6000 XL User manual

Owner’s Manual
1-800-800-8586 (Exeter, PA) • 1-888-570-1113 (St. Catharines, ON) • www.quantumrehab.com

www.quantumrehab.com Quantum 6000 XL
SAFETY GUIDELINES
Copyright©2006
PrideMobilityProductsCorp.
INFMANU3205/RevA/February06
Thesymbolsbelow areusedthroughoutthis owner'smanualandon thepowerchair toidentifywarningsand important
information.Itisveryimportant foryoutoreadthem andunderstandthemcompletely.
WARNING! Failure to follow designated procedures can cause either personal injury, component
damage, or malfunction (black symbol on yellow triangle with black border).
MANDATORY! These actions should be performed as specified. Failure to perform mandatory
actions can cause injury to personnel and/or damage to equipment (white symbol on blue dot).
PROHIBITED! These actions should be prohibited. These actions should not be performed at any
time or in any circumstances. Performing a prohibited action can cause injury to personnel and/
or damage to equipment (black symbol with red circle and red slash).

Quantum 6000 XL www.quantumrehab.com 3
I. INTRODUCTION.................................................................................................................................4
II. SAFETY .................................................................................................................................................6
III. YOUR POWER CHAIR....................................................................................................................15
IV. ASSEMBLY.........................................................................................................................................21
V. COMFORT ADJUSTMENTS........................................................................................................24
VI. BATTERIES AND CHARGING ....................................................................................................30
VII. OPERATION.......................................................................................................................................34
VIII.CARE AND MAINTENANCE ........................................................................................................42
IX. WARRANTY........................................................................................................................................48
CONTENTS
Thisowner’smanualiscompiledfromthelatestspecificationsandproductinformationavailableatthetimeofpublication.
Wereservetherighttomake changesastheybecomenecessary.Anychanges to ourproductsmaycause slight variations
betweentheillustrationsandexplanationsin this manualandtheproductyou have purchased.

4 www.quantumrehab.com Quantum 6000 XL
I. INTRODUCTION
SAFETY
WELCOMEto QuantumRehab, adivision of PrideMobility ProductsCorporation (Pride).The power chair you have
purchasedcombines state-of-the-artcomponents withsafety, comfort,and stylingin mind.Weareconfident thatthese
designfeatureswillprovideyouwiththeconveniencesyouexpect during yourdailyactivities.Onceyouunderstandhow
tosafely operate andcare for your power chair, it should giveyou years oftrouble free operationand service.
Readandfollowallinstructions, warnings, andnotesinthismanualbeforeattemptingtooperateyour power chairforthe
first time. Inaddition, your safetydepends upon you, as wellas your provider, caretaker, or healthcare professionalin
usinggoodjudgement.
Ifthereisany information inthismanualwhich youdonotunderstand, orifyourequire additionalassistanceforsetup or
operation,pleasecontact your QuantumRehabSpecialist. Failuretofollowtheinstructionsinthismanualandthose
locatedonyourpowerchaircanleadtopersonalinjuryand/ordamagetothepowerchair,includingvoidingthe
warranty.
PURCHASER’S AGREEMENT
Byaccepting delivery ofthis product, youpromise that youwill not change,alter, or modify this product or remove or
renderinoperableorunsafeanyguards,shields,orothersafetyfeaturesofthisproduct;fail,refuse,orneglecttoinstallany
retrofitkits fromtime totime providedby Prideto enhanceor preservethe safeuse ofthis product.
INFORMATION EXCHANGE
Wewanttohearyourquestions,comments,andsuggestionsaboutthismanual.Wewouldalsoliketohearaboutthesafety
andreliabilityofyour newpowerchair,and abouttheservice you receivedfromyour QuantumRehabSpecialist.
Please notify us of any change of address, so we can keep you apprised of important information about safety, new
products,and new optionsthat canincrease yourability touse andenjoy yourpower chair. Pleasefeel freeto contactus
atthe addressbelow:
PrideMobilityProductsCorporation
Attn:CustomerCareDepartment
182SusquehannaAvenue
Exeter, PA18643-2694
[e-mail]
800-424-8205
NOTE: If you ever lose or misplace your product registration card or your copy of this manual, contact us and
we will be glad to send you a new one immediately.

Quantum 6000 XL www.quantumrehab.com 5
I. INTRODUCTION
PRIDE OWNERS CLUB
Asanowner ofa Prideproduct, youare invited toregister yourproduct’swarrantyand enrollin thePride OwnersClub.
You may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at
www.pridemobility.com.Asaregisteredmember,eachtimeyouvisitoursite,youwillhaveaccesstothe most interactive
andhonesteducationalvenueavailabletodayforpeoplewithmobilityneeds,theirfamilies,and friends.
Fromourhome page, select“OwnersClub” toentera pagededicatedto currentandpotential Pride productowners.You
willgainaccesstointerviews, stories,recreationideas,dailyliving tips,productandfundinginformation, andinteractive
messageboards.Thesemessage boardsinviteyou to communicatewithother Pridecustomersaswell asPriderepresen-
tativeswhoare availabletoassist youwithany questionsorconcerns youmayhave.
MyQuantum Rehab Specialist:
Name:_____________________________________________________________________________________
Address:___________________________________________________________________________________
Phone Number:______________________________________________________________________________
Purchase Date:_______________________________________________________________________________

6 www.quantumrehab.com Quantum 6000 XL
II. SAFETY
Corrosive chemicals contained in battery. Use only AGM or Gel-Cell batteries to
reduce the risk of leakage or explosive conditions.
This product has been tested and passed at an immunity level of 20 V/m.
Read and follow the information in the owner’s manual.
Maximum seating weight.
Locked and in drive mode.
Place unit on level ground and stand behind or to one side when changing from
drive mode to freewheel mode or freewheel mode to drive mode.
Unlocked and in freewheel mode.
Battery Configuration:
TT
TT
T = Terminal Post
Connect Red wire to TT
TT
T with ++
++
+
Connect Black wire to TT
TT
T with ––
––
–
PRODUCT SAFETY SYMBOLS
Thesymbolsbelowareusedonthe powerchairtoidentifywarnings,mandatoryactions, andprohibitedactions.Itisvery
importantforyouto readandunderstand themcompletely.

Quantum 6000 XL www.quantumrehab.com 7
II. SAFETY
Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while
operating.
Avoid exposure to rain, snow, ice, salt, or standing water whenever possible.
Maintain and store in a clean and dry condition.
Removal of grounding prong can create electrical hazard. If necessary, properly
install an approved 3-pronged adapter to an electrical outlet having 2-pronged
plug access. Failure to heed could result in personal injury and/or property
damage.
Prevent personal injury and equipment damage. Do not connect an extension
cord to the AC/DC converter or the battery charger.

8 www.quantumrehab.com Quantum 6000 XL
II. SAFETY
SAFETY
MANDATORY! Do not operate your new power chair for the first time without completely reading
and understanding this owner’s manual.
Your powerchair isastate-of-the-artlife-enhancementdevice designed toincreasemobility.Prideprovides anextensive
varietyof products to best fit the individual needs of the power chair user.Please be aware that the final selection and
purchasing decision regarding the type of power chair to be used is the responsibility of the power chair user, who is
capableofmakingsuch adecision,and his/herhealthcareprofessional(i.e., medicaldoctor,physical therapist, etc.).
Thecontentsofthis manualarebased on theexpectationthat amobilitydevice expert hasproperlyfitted thepowerchair
totheuserandhasassistedtheprescribinghealthcare professional and/ortheQuantumRehabSpecialistintheinstruction
processfor the use ofthe product.
Therearecertainsituations, including somemedicalconditions,wherethepowerchairuserwillneedtopracticeoperating
the power chair in the presence of a trained attendant.Atrained attendant can be defined as a family member or care
professionalspeciallytrainedinassistingapowerchairuserinvariousdailylivingactivities.
Asyoubeginusingyourpowerchairduringdailyactivities,youwillprobablyencountersituationsinwhichyouwillneed
somepractice.Simplytakeyourtimeandyouwillsoonbeinfullandconfidentcontrolasyoumaneuverthroughdoorways,
onand offof elevators, upand down ramps, and overmoderate terrain.
Belowaresomeprecautions,tips, and othersafetyconsiderationsthatwill helptheuserbecomeaccustomed to operating
thepowerchairsafely.
Modifications
Pridehasdesigned and engineeredyourpowerchairtoprovidemaximummobilityandutility.Awiderangeof accessories
isavailable from yourQuantum RehabSpecialist tofurther customizeyour powerchair tobetter suityour needs and/or
preferences.However,under no circumstancesshould you modify,add, remove, ordisable any feature,part, or function
ofyourpower chair.
WARNING! Do not modify your power chair in any way not authorized by Pride. Unauthorized
modifications may result in personal injury and/or damage to your power chair.
Pre-Ride Safety Check
Getto knowthe feelof yourpower chair and its capabilities.Pride recommendsthat youperform a safety check before
eachuse tomake sureyour powerchair operatessmoothly andsafely.
Performthefollowinginspectionspriortousingyourpowerchair:
!Checkforpropertireinflation.Maintainbutdonotexceed35psi(2.4bar)ineachtire(ifequippedwithpneumatictires).
!Checkall electrical connections. Make surethey aretight andnot corroded.
!Checkall controller connections to thepower base. Makesure they are secured properly.
!Checkthe brakes. See VIII. “Care and Maintenance.”
!Checkbattery charge. SeeVI. “Batteriesand Charging.”
NOTE: If you discover a problem, contact your Quantum Rehab Specialist for assistance.

Quantum 6000 XL www.quantumrehab.com 9
II. SAFETY
Weight Limitations
Yourpower chairisratedfor amaximumweightcapacity. Please refertothespecifications table forthislimit.
WARNING! Exceeding the weight capacity voids your warranty and may result in personal injury
and/or damage to your power chair. Pride will not be held responsible for injuries and/or property
damage resulting from failure to observe weight limitations.
WARNING! Do not carry passengers on your power chair. Carrying passengers on your power
chair may result in personal injury and/or property damage.
Tire Inflation
Ifyourpowerchairis equippedwithpneumatictires,you shouldcheckorhavethe air pressurecheckedregularly.Proper
inflationpressureswillprolongthe lifeofyourtiresand helpensurethesmoothoperation of yourpowerchair.
WARNING! It is important that 35 psi (2.4 bar) tire pressure be maintained in pneumatic tires at all
times. Do not underinflate or overinflate your tires. Low pressure may result in loss of control, and
overinflated tires may burst. Failure to maintain 35 psi (2.4 bar) tire pressure in pneumatic tires at
all times may result in tire and/or wheel failure, causing serious personal injury and/or damage to
your power chair.
WARNING! Inflate your power chair drive tires from a regulated air source with an available pressure
gauge. Inflating your tires from an unregulated air source could overinflate them, resulting in a
burst tire and/or personal injury.
Incline Information
Moreandmorebuildingshaverampswithspecifieddegreesofinclination,designedforeasyandsafeaccess.Someramps
mayhaveturning switchbacks(180-degreeturns) thatrequireyou tohavegood corneringskillson yourpowerchair.
!Proceedwith extremecaution asyou approachthe downgradeof aramp orother incline.
!Takewideswingswithyourpowerchair’s frontwheelsaroundanytightcorners.Ifyoudo that, thepowerchair’srear
wheelswillfollow awide arc, notcut thecornershort, andnot bump intoor gethungup onany railing corners.
!Whendriving down a ramp, keepthe power chair’s speedadjustment set to the slowestspeed setting toensure a
safelycontrolleddescent. SeeVII.“Operation.”
!Avoid sudden stopsand starts.
Whenclimbinganincline,try to keep your power chairmoving.Ifyoumuststop,startupagainslowlyandthenaccelerate
cautiously.Whendriving down an incline, set yourpower chairto theslowest settingand drivein theforward direction
only. If your power chair starts to move down the incline faster than you anticipated or desired, allow it to come to a
completestopbyreleasing thejoystick,then pushthejoystickforward slightlytoensure asafelycontrolleddescent.
WARNING! When climbing an incline, do not zigzag or drive at an angle up the face of the incline.
Drive your power chair straight up the incline. This greatly reduces the possibility of a tip or a fall.
Always exercise extreme caution when negotiating an incline.
WARNING! You should not travel up or down a potentially hazardous incline (i.e., areas covered
with snow, ice, cut grass, or wet leaves).
WARNING! When on any sort of an incline or decline, never place the power chair in freewheel
mode while seated on it or standing next to it. Doing so may result in personal injury and/or
damage to your power chair.
WARNING! Never travel down an incline backwards. This may result in personal injury.

10 www.quantumrehab.com Quantum 6000 XL
II. SAFETY
Figure 1. Maximum Safe Slope (Ascending and Descending)
WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in
figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications
presented in this manual. Doing so could cause instability in your power chair, resulting in personal injury
and/or damage to your power chair.
Incompliancewith theAmericanswith DisabilitiesActof 1990, allhandicap publicaccessramps arerequired tohavea
maximumslopeof 5°(8.7%). Therefore,Priderecommends thatthe maximumslopeof anincline youattemptto safely
ascend or descend on your power chair does not exceed 5° (8.7%). See figure 1.
WARNING! Any attempt to climb or descend a slope steeper than 5° (8.7%) may put your power
chair in an unstable position and cause it to tip, resulting in personal injury.
Braking Information
Yourpower chairis equippedwithtwo powerfulbrakesystems:
1. Regenerative —useselectricity to rapidlyslowthe vehicle whenthejoystick returnstothecenter/stop position.
2. DiscParkBrake—activatesmechanicallyafterregenerativebrakingslowsthe vehicle tonearstop,orwhenpoweris
removedfromthe system forany reason.
Cornering Information
Whileyour powerchairisequippedwithfourcasterwheels,excessivelyhighcorneringspeedscanstillcreatethepossibil-
ityoftipping.Factorswhichaffectthepossibilityoftipping include, butarenotlimitedto:corneringspeed,steeringangle
(howsharplyyouareturning), unevenroadsurfaces,inclined road surfaces,ridingfroman areaoflowtraction to anarea
ofhigh traction(such as passing from a grassy area to apaved area– especiallyat highspeed whileturning), andabrupt
directionalchanges. Highcornering speedsare not recommended. If youfeel thatyou may tip over ina corner, reduce
your speed and steering angle (i.e., lessen the sharpness of the turn) to prevent your power chair from tipping.
WARNING! When cornering sharply, reduce your speed. This greatly reduces the possibility of a
tip or fall. To avoid personal injury and/or property damage, always exercise common sense when
cornering.
Public Streets and Roadways
WARNING! You should not operate your power chair on public streets and roadways. Be aware
that it may be difficult for traffic to see you when you are seated on your power chair. Obey all
local pedestrian traffic rules. Wait until your path is clear of traffic, and then proceed with extreme
caution.
5 (8.7%)

Quantum 6000 XL www.quantumrehab.com 11
II. SAFETY
Freewheel Mode
Yourpowerchairisequippedwithtwo manualfreewheelleverstoallowformanualmaneuverabilitybyatrainedattendant.
Formoreinformationabouthowtoplaceyourpowerchairintoandoutoffreewheelmode, see III.“YourPowerChair.”
WARNING! Do not use your power chair in freewheel mode without an attendant present. Personal
injury may result.
WARNING! Do not attempt to personally place your power chair in freewheel mode while seated
on it. Personal injury may result. Ask an attendant for assistance if necessary.
WARNING! Do not place your power chair in freewheel mode while on an incline. The chair could
roll uncontrollably on its own, causing personal injury.
Outdoor Driving Surfaces
Yourpowerchairisdesignedtoprovideoptimumstabilityundernormaldrivingconditions—dry,levelsurfacescomposed
ofconcrete,blacktop,orasphalt. However,Priderecognizesthattherewillbetimeswhenyouwillencounterothersurface
types.For thisreason, yourpower chairis designedto perform admirably on packedsoil, grass,and gravel.Feel freeto
useyour powerchair safelyon lawnsand inpark areas.
!Reduceyourpower chair’sspeedwhen drivingonuneven terrainand/or soft surfaces.
!Avoidtall grass thatcanentangletherunninggear.
!Avoid looselypacked graveland sand.
!Ifyoufeelunsure about adrivingsurface,avoid thatsurface.
Stationary Obstacles (Steps, Curbs, etc.)
Proceedwith extreme cautionwhen driving near raised surfaces, unprotected ledges and/or drop-offs (curbs, porches,
stairs,etc.).The correctmethodfor approachinga curbisillustrated infigure2.
WARNING! Do not attempt to have your power chair climb or descend an obstacle that is higher
than 2 inches unless you have the assistance of an attendant.
WARNING! Do not attempt to have your power chair proceed backwards down any step, curb, or
other obstacle. This may cause the power chair to tip and cause personal injury.
Figure 2. Correct Curb Approach Figure 3. Incorrect Curb Approach
Stairs and Escalators
Powerchairs are not designed to travel up ordown stairs orescalators. Always use anelevator.
WARNING! Never use your power chair to negotiate steps or escalators. You may cause injury to
yourself and to others and/or damage your power chair.

12 www.quantumrehab.com Quantum 6000 XL
II. SAFETY
Transfers
Transferring onto and off of your power chair requires a
goodsenseofbalance.Alwayshave an attendant or health-
careprofessionalpresent whilelearningto properlytrans-
feryourself.
Toeliminatethepossibilityofinjury,Priderecommendsthat
youor atrained attendantperform thefollowing tasksbe-
foreattempting atransfer:
!Turnoffthepowertothecontroller.SeeVII.“Operation.”
!Ensureyourpowerchairisnotinfreewheel mode.See
III.“YourPower Chair.”
!Turnthe casterwheels towardthe transfer destination
toimprovepowerchairstabilityduringtransfer.
!Make sure both armrests are flipped up or removed
fromyourpowerchair.
!Flip up the foot platform or move the leg rests aside;
thiswill helpto keepyour feetfrom gettingcaught on
thefootriggingduringthetransfer.
!Reducethedistancebetweenyourpower chair andthe
objectyouare transferringonto.
WARNING! Before transferring, position yourself as far back as possible in the power chair seat
to prevent the power chair from tipping forward during transfer and causing injury.
WARNING! Avoid using your armrests for weight bearing purposes. Such use may cause the power
chair to tip and cause personal injury.
WARNING! Avoid putting all of your weight on the foot riggings. Such use may cause the power
chair to tip and cause personal injury.
Doors
!Determineif thedoor opens toward or away from you.
!Driveyourpowerchairgentlyandslowly forward topushthedooropen.Or drive yourpowerchairgentlyandslowly
backwardsto pull the door open.
Elevators
Modernelevators havea dooredge safetymechanism that,when pushed,reopens theelevator door(s).
!Ifyou are inthe doorway ofan elevator whenthe door(s) beginto close, pushon the rubberdoor edge orallow the
rubberdoor edge to contactthe power chair andthe door will reopen.
!Usecare that pocketbooks, packages, orpower chair accessories do not become caught in elevator doors.
Lift/Elevation Products
Ifyouwillbetravelingwithyourpowerchair,youmayfinditnecessarytousea lift/elevationproducttoaidintransporta-
tion.Pride recommendsthat you closelyreview the instructions, specifications, andsafety information set forth bythe
manufacturerofthelift/elevationproductbeforeusingthatproduct.
Figure 4.IdealTransfer Position

Quantum 6000 XL www.quantumrehab.com 13
II. SAFETY
Inclement Weather Precautions
Exposureofyourpower chairtoinclementweather conditionsshouldbeavoided wheneverpossible.Ifsuddenly caught
up in rain, snow, severe cold or heat while operating your power chair proceed to shelter at the earliest opportunity.
Thoroughlydryyourpower chairbeforestoring,charging,oroperating yourpowerchair.
WARNING! Operating in rain, snow, salt, mist/spray conditions, and on icy/slippery surfaces can
cause personal injury and/or damage to the power chair and electrical system. Maintain and store
your power chair in a dry and clean condition.
Motor Vehicle Transport
Priderecommendsthatyou do notremainseated in yourpowerchairwhile travelinginamotor vehicle.Thepowerchair
shouldbe stowed inthe trunk of a car or inthe back ofa truck or van with the batteriesremoved and properlysecured.
WARNING! Do not sit on your power chair while it is in a moving vehicle. Personal injury and/or
property damage may result.
WARNING! Always be sure your power chair and its batteries are properly secured when it is being
transported. Failure to do so may result in personal injury and/or damage to your power chair.
Positioning Belts
YourQuantum RehabSpecialist, therapist(s), andother healthcare professionals are responsible for determiningyour
requirementfora positioningbeltin ordertooperate yourpowerchair safely.
WARNING! If you require a positioning belt to safely operate your power chair, make sure it is
fastened securely. Serious personal injury may result if you fall from the power chair.
WARNING! The positioning belt is not designed for use as a seat belt in a motor vehicle. Nor is
your power chair suitable for use as a seat in any vehicle. Anyone traveling in a vehicle should be
properly belted into seats approved by the vehicle manufacturer.
Reaching and Bending
Neverreach,lean,orbendwhiledriving your powerchair.Ifitisabsolutelynecessarytoreach, lean,orbendwhileseated
onyour power chair, itis important to maintaina stable center ofgravity and keep thepower chair from tipping.Pride
recommendsthat the powerchair user determinehis/her personal limitationsand practice bendingand reaching inthe
presenceofaqualifiedhealthcareprofessional.
WARNING! Do not bend, lean, or reach for objects if you have to pick them up from the floor by reaching
down between your knees. Movements such as these may change your center of gravity and the weight
distributionof thepowerchair.This may causeyourpowerchairto tip,possiblyresulting in personalinjury.
WARNING! Prevent personal injury! Keep your hands away from the tires when driving. Be aware
that loose fitting clothing can become caught in drive tires.
Batteries
In addition to following the warnings below, be sure to comply with all other battery handling information. For more
informationaboutyourpower chair’sbatteries,seeVI.“Batteries andCharging.”
WARNING! Power chair batteries are heavy. See specifications table. If you are unable to lift that
much weight, be sure to get help. Lifting beyond your capacity can result in personal injury.
WARNING! Battery posts, terminals, and related accessories contain lead and lead compounds.
Wash hands after handling.
WARNING! Always protect the batteries from freezing and never charge a frozen battery. Charging
a frozen battery may result in personal injury and/or damage to the battery.

14 www.quantumrehab.com Quantum 6000 XL
II. SAFETY
Removable Parts
WARNING! Do not attempt to lift or move a power chair by any of its removable parts. Personal
injury and/or damage to the power chair may result.
Preventing Unintended Movement
WARNING! If you anticipate being seated in a stationary position for an extended period of time,
turn off the power. This will prevent unexpected motion from inadvertent joystick contact. This
will also eliminate the possibility of unintended chair movement from electromagnetic (EM) sources.
Failure to do so may result in personal injury.
Prescription Drugs/Physical Limitations
Usersmustexercisecareandcommonsensewhenoperatingapowerchair.Thisincludesawarenessofsafetyissueswhen
takingprescribedorover-the-counter drugs orwhentheuser hasspecificphysicallimitations.
WARNING! Consult your physician if you are taking prescribed or over-the-counter medication or
if you have certain physical limitations. Some medications and limitations may impair your ability
to operate your power chair in a safe manner.
Alcohol
Thepowerchairusermustexercisecareand commonsensewhenoperatinghis/herpowerchair.This includesawareness
ofsafetyissues while undertheinfluenceofalcohol.
WARNING! Do not operate your power chair while you are under the influence of alcohol, as this
may impair your ability to operate your power chair in a safe manner.
Electromagnetic and Radio Frequency Interference (EMI/RFI)
WARNING! Laboratory tests have shown that electromagnetic and radio frequency waves can
have an adverse affect on the performance of electrically-powered mobility vehicles.
Electromagneticand Radio Frequency Interference can come from sources such as cellular phones, mobile two-way
radios(suchas walkie-talkies),radio stations,TV stations,amateur radio (HAM)transmitters, wirelesscomputer links,
microwavesignals, paging transmitters, and medium-range mobile transceivers usedby emergency vehicles.In some
cases,thesewavescancauseunintendedmovementordamagetothecontrolsystem.Everyelectrically-poweredmobility
vehiclehasanimmunity(orresistance)toEMI.Thehighertheimmunitylevel,thegreatertheprotectionagainstEMI.This
producthas beentested andhas passedat animmunity levelof 20V/m.
WARNING! Be aware that cell phones, two-way radios, laptops, and other types of radio transmitters
may cause unintended movement of your electrically-powered mobility vehicle due to EMI.
Exercise caution when using any of these items while operating your mobility vehicle and avoid
coming into close proximity of radio and TV stations.
WARNING! The addition of accessories or components to the electrically-powered mobility vehicle
can increase the susceptibility of the vehicle to EMI. Do not modify your power chair in any way
not authorized by Pride.
WARNING! The electrically-powered mobility vehicle itself can disturb the performance of other
electrical devices located nearby, such as alarm systems.
NOTE: Forfurther informationon EMI/RFI,go to the Resource Center onwww.pridemobility.com.If unintended
motion or brake release occurs, turn your power chair off as soon as it is safe to do so. Call Pride at 800-424-8205 to
report the incident.

Quantum 6000 XL www.quantumrehab.com 15
III. YOUR POWER CHAIR
THE QUANTUM 6000 XL
TheQuantum6000XLhas twomainassemblies:theseatassemblyand thepowerbaseassembly.Seefigure 5.Typically,
theseat assembly includes the armrests, seatback,and seat base. The power base assembly includes two motor/brake
assemblies,two drivewheels, fourcaster wheels, two batteries, and wiring harnesses. See figures 5, 6, and 7.
SEATBACK
DRIVE WHEEL
CASTER WHEEL
Figure 5.The Quantum 6000 XL
POWERBASE
ASSEMBLY
SEAT ASSEMBLY
JOYSTICK
FOOTRIGGING
(FOOT PLATFORM SHOWN)
SEATBASE
CONTROLLER
(REMOTE PLUS SHOWN)
CASTER WHEEL
MANUALFREEWHEELLEVER
ARMREST
ARMREST

16 www.quantumrehab.com Quantum 6000 XL
QQ
QQ
QUU
UU
UANTUM 6000 XL SANTUM 6000 XL S
ANTUM 6000 XL SANTUM 6000 XL S
ANTUM 6000 XL SPECIFICAPECIFICA
PECIFICAPECIFICA
PECIFICATIONSTIONS
TIONSTIONS
TIONS
Suspension: FrontandRear
DriveWheels: 14 in., solid
CasterWheels: 6in.solid(rear);5in.solid(front)
MaximumSpeed:¹Upto6.5mph
Brakes: “IntelligentBraking”electronicregenerative,discparkbrake
GroundClearance:² 3.5in.
MaximumSafeSlope: 5°(8.7%)
TurningRadius:² 22 in.
OverallSize:² Length:46in.(withswing-awaylegrests)
Width:25.75in.
SeatingOptions: SynergySeat
High-backSeatwithSolidSeatPan
ManualReclineHigh-backSeatwithSolidSeatPan
TRU-BalancePowerTilt
Drivetrain: Twomotor, Mid-wheel-6drive
Batteries: TwoGroup24batteries(standard)(AGMorGel-Celltyperecommended)
TwoGroup34batteriesrequiredwithTRU-BalancePowerPositioning(AGMorGel-Celltyperecommended)
Range:¹Upto25miles
BatteryCharger: 8-amp,off-board
Electronics: 100-ampRemotePlus
100-ampMicrodrive
WeightCapacity: 400lbs.
ComponentWeights: Base:170 lbs.
SynergySeat:58.5lbs.
Batteries:51.5lbs.each
¹Varieswithuser weight,terraintype,battery amp hourrating(AH),battery charge,batterycondition,and tirecondition.
²Dueto manufacturingtolerances and continuedproduct improvement,this specification canbe subjectto variance of
(+ or – ) 3%.
NOTE: All specifications subject to change without notice.
III. YOUR POWER CHAIR

Quantum 6000 XL www.quantumrehab.com 17
III. YOUR POWER CHAIR
ELECTRICAL COMPONENTS
Theelectrical components consist ofthe controller assembly, the batteries, andthe motors.The batteries, motors, and
controller power module (if equipped) are located on the power base assembly. The controller is located on the seat
assembly.Connectivity between the controller and the motors, batteries, and the battery charger isprovided by one or
morewiringharnesses.Seefigure 7.
ControllerConnector:Thecontroller connectoriswhere thecontrollerplugs intothepower base.Eachcontroller uses
adifferenttypeofcable.Regardlessofwhichtypeofcontrolleris used, thecablemustbesecuredtotheseatassemblyand
notallowed todrag onthe floor.
Figure 6.The Quantum 6000 XL Power Base
MANUALFREEWHEELLEVER
REAR SEAT MOUNT CONNECTORS
FRONT SEAT MOUNT CONNECTORS
FRONT COVER
REARSHROUDFASTENER
(FASTENER ON OPPOSITE
SIDE NOT SHOWN)
REARSHROUD

18 www.quantumrehab.com Quantum 6000 XL
III. YOUR POWER CHAIR
MotorConnectors:This iswhere thecontroller connectsto the motors.
BatteryConnector:Thisis wherethe controllerconnects tothe batteries.
ControllerPowerModule:This enablesthe controller tocommunicate with thebatteries and themotors.
MainCircuit Breaker(locatedon the rearmainframe): The maincircuit breaker is a safety feature builtinto your
powerchair.Whenthe batteriesandthe motorsareheavily strained(e.g.,from excessiveloads),the maincircuitbreaker
tripstopreventdamage tothemotorsand theelectronics.If the circuittrips,allow your powerchairto “rest”forapproxi-
matelyoneminute.The circuitbreakerwillresetitself.Turnon thecontroller, andcontinuenormaloperation.If themain
circuitbreakercontinues to triprepeatedly, contactyourQuantum RehabSpecialist.
Figure 7. Quantum 6000 XL Electrical Components
QUICKRELEASE
BATTERY CONNECTORS
MAINCIRCUITBREAKER
CONTROLLER
POWERMODULE
TO MOTOR
CONNECTOR
CONTROLLER
CONNECTOR

Quantum 6000 XL www.quantumrehab.com 19
III. YOUR POWER CHAIR
Figure 9. Drive Mode (Drive Engaged)Figure 8. Freewheel Mode (Drive Disengaged)
MANUAL FREEWHEELLEVER
Dual Manual Freewheel Levers
Foryour convenience,your powerchair isequipped with dual manual freewheellevers. Thelevers arelocated oneach
motor,andallowyouto disengagethedrivemotorsand maneuver thechairmanually.
WARNING! In freewheel mode, the braking system is disengaged. Only engage the freewheel
mode when on a level surface. Failure to comply could result in injury and/or damage to your
product.
WARNING! Prevent personal injury and/or equipment damage. Do not use the freewheel lever
handles as tie-down points to secure this product.
Tooperatethedualmanual freewheellevers:
1. Push downbothmanual freewheel leversforfreewheel mode (drivemotordisengaged). See figure8.
2. Pull upbothmanual freewheel leversfordrive mode (drivemotorengaged). See figure9.
NOTE: You must turn off the power before disengaging the drive motors, otherwise you may get an error code
on the controller. To clear this code, turn off the controller and place the power chair in drive mode. Then turn
on the controller. The error message should be cleared. If it isn’t, contact your Quantum Rehab Specialist.
NOTE: The power chair will be significantly easier to push with the power off.
!Avoidapplying excessive forcetothemanualfreewheellevers.
WARNING! Do not use your foot to operate the manual freewheel levers. Do not stand on the
manual freewheel levers. Applying excessive force to the manual freewheel levers may result in
damage to the freewheel levers, motors, and brakes.
MANUAL FREEWHEELLEVER

20 www.quantumrehab.com Quantum 6000 XL
III. YOUR POWER CHAIR
Hammer Motor Package
Yourpower chairisequippedwithtwopowerful Hammermotors.Theseareright angle motorscapableofproducingone
horsepowerof peakoutput each.Follow thesuggestions belowto helpensure peakmotor performance.
!Maintainaneven speedwhen negotiatingobstacles. Ifyouencounter asituation whereyou havestalledthe motors,
immediatelyreleasethejoystick.Adjustthecontroller toahigherdriveprofileand attempt tomoveovertheobstacle.
Ifyoustillencounterastallcondition,backawayfromtheobstacle,thendriveforward,maintainingmomentumasyou
negotiateoverthe obstacle.
WARNING! Prevent motor damage! Immediately release the joystick if the motors stall. Failure to
release the joystick within 5 seconds of motor stall may cause the motors to overheat, resulting
in damage to the motors, lack of motor performance, and/or increased motor noise.