Raypak Raytherm H-182 User manual

Catalog No.: 2000.205D Effective: 1-1-08 Replaces: 4-1-05
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor
EFFICIENT
82% efficiency – highest of any atmospheric boiler
available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum operating temperature: 230°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby and
radiation losses normal to other boilers and
tank-type water heaters are eliminated
LOW WATER OPERATING TEMPERATURE
Operates with water temperature as low as
105°F without condensing
Heat Exchanger
ASME Inspected and Stamped
160 PSIG
National Board Approved
Headers
Cast Iron Glass-lined – Standard
Bronze – Option A-1
Finned Tubing
Copper – Standard
Cupro Nickel – Option A-3
ASME Steel Tube Sheet
Silicone O-Rings
ASME Pressure Relief Valve
45 PSIG – Standard
PSIG ASME – Optional
Temperature and Pressure Gauge,
Shipped Loose
Water Connections
Left Hand – Standard
Right Hand – Option A-6
Flow Configuration – Two-pass
Pump – Optional
Mounted, 1/8 HP, 120 Volt, 1∅,60 Hz
Controls
120V, 60Hz, 1 Ph Power Supply
120/24V Transformer
100% Pilot Shut-off/Lockout
Electronic, Intermittent Ignition (IID) Pilot
High Limit Control, Manual Reset
On/Off Switch
Flow Switch
Economaster II Pump Time Delay
Gas Control Train
Manual Main Gas Shut-off Cock
Main Gas Pressure Regulator
Redundant Safety Shut-off Valve
Control Valve
Firing Mode
On/Off (H4)
Two-stage Firing (H3)
Mechanical Modulation,
110-170°F (H5)
Mechanical Modulation,
150-210°F (H1)
Fuel
Natural Gas
Propane Gas
Design Certified ANSI Z21.13
Construction
Front Controls
Stainless Steel Burners
Polytuf Powder Coat Finish
Vent Selection
Draft Diverter – Option D-10
Power Vent, Loose – Option D-2
Base (Optional)
Combustible Floor Shield –
Option J-1
Temperature Controls
Note: H1 and H5 do not require a
controller
B-6 Two-stage – 100-200ºF
Y-241 Electronic Sequencer,
1-4 Stages
Y-281 Electronic Sequencer,
1-8 Stages
Additional Safety Controls
F-10 Low Water Cut-off Probe
I-1 High Limit Control, Auto
Reset, 240°F
S-1 Low Gas Pressure Switch,
Manual
S-2 High Gas Pressure Switch,
Manual
Regulatory Agency Requirements
Raytherm
®
- Type H
Hydronic Heating Boilers
Models 182-400 - Indoor

Catalog No.: 2000.205D Effective: 1-1-08 Replaces: 4-1-05
Raytherm - Type H
Hydronic Heating Boilers - Indoor Model
K
(C)
INDOOR
DRAFT
38"
13-1/4"
GAS
CONNECTION
26-1/2" 10-1/4
3-7/8
3-7/8
26-1/2"
40"
21-1/4"
ELECT.
CONN
STACKLESS
OUTDOOR TOP
PUMP
(OPTIONAL)
PUMP COVER
(OPTIONAL)
J
3/4 NPT
GAS CONNECTION
(OUTDOOR
MODELS ONLY)
11"
Dimensions (Inches) Shipping Weight
(Lbs.) – Approx.
Model
No. MBTU
Input MBTU Output AFUE* (%) Width A Height C J Flue Dia. K No Pump w/ Pump
H-182 181 148 82.6 18-1/4 62-5/8 12-1/16 6 191 221
H-260 264 216 82.7 22-3/8 62-7/8 11-1/8 7 214 244
H-330 334 274 N/A 25-3/4 63-3/4 10-3/4 8 234 264
H-400 399 327 N/A 29-1/4 65-3/8 12-1/2 9 253 283
* With Vent Damper
NOTE: Ratings shown are for elevations up to 2,000 feet. For elevations over 2,000, reduce ratings at the rate of 4% for each
1,000 feet above sea level.
BOILER RATE OF FLOW AND PRESSURE DROP
10° ∆T 20° ∆T 30° ∆T
Model
No. GPM ∆P FT GPM ∆P FT GPM ∆P FT
H-182 30 4.2 N/A N/A N/A N/A
H-260 43 8.5 22 2.2 N/A N/A
H-330 N/A N/A 27 3.4 N/A N/A
H-400 N/A N/A 33 5.2 22 2.3
N/A – Not Applicable
Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 [phone] Fax [phone] www.raypak.com