rba BENEFIT LEVER RBA1015-600 Manual

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
SYDNEY | MELBOURNE | BRISBANE | PERTH | AUCKLAND
Australia 1300 788 778 www.rba.com.au | New Zealand 0800 722 111 www.rbagroup.co.nz1 of 4
‘GOOSENECK’
RBA1047-600
Sourced/ Supplied under QMS
As improvements in the design and performance of RBA products are continuous, specications may be subject to change without notice.
The illustrations and descriptions herein are applicable to production as of the date of this Installation Instructions Sheet. Revised 03/22 © 2022 by RBA Group II/Model RBA1015, RBA1043,RBA1044 & RBA1047-600/0322
‘RIO’
RBA1044-600
‘BENEFIT LEVER’
RBA1015-600
‘ALPHA’
RBA1043-600
RBA1015-600 ‘Benet Lever’ Tap
RBA1043-600 ‘Alpha’ Self Closing Tap
RBA1044-600 ‘Rio’ Self Closing Tap
RBA1047-600 Self Closing ‘Gooseneck’ Tap
MODELS SELF CLOSING PILLAR TAPS
green
rba

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
SYDNEY | MELBOURNE | BRISBANE | PERTH | AUCKLAND
Australia 1300 788 778 www.rba.com.au | New Zealand 0800 722 111 www.rbagroup.co.nz2 of 4
Technical Data
Inlet 1/2” BSP [G1/2”]
Operating pressure 200 – 500 kPa
Flow Time 7 seconds nominal [ALPHA & RIO] 15 seconds [GOOSENECK]
Maximum Temp. 55ºC
Flow Rate 4.5L per minute/5.5L per minute
Warranty 2 years
Dimensions
Ø44mm
129mm
101mm
G1/2"
80.5mm
62mm
93mm
51mm
112mm
Ø34.5mm
20º
Ø34,5mm
Ø44mm
G1/2 "
20º
110mm
125mm
51mm
110mm
52mm
58mm
147mm
185mm
261mm
22°
G1/2" 52mm
75mm
51mm
34mm
34mm 192mm
113mm
123mm
54mm
112mm
20°
G1/2"
RBA1043-600 ‘Alpha’ RBA1044-Series ‘Rio’
RBA1047-600 ‘Gooseneck’ RBA1015-600 ‘Benet HD’

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
SYDNEY | MELBOURNE | BRISBANE | PERTH | AUCKLAND
Australia 1300 788 778 www.rba.com.au | New Zealand 0800 722 111 www.rbagroup.co.nz3 of 4
Description
Self closing pillar taps are designed for public areas, available in bright chrome nish cast from dezincication
resistant brass alloy. Single connection to water supply line, to either cold or pre-mixed water.
RBA1015-600 ‘Benet Lever’ Basin Pillar Tap - 6 Star WELS, 4.5Lpm
RBA1043-600 ‘Alpha’ Basin Pillar Tap DR - Chrome - 6 Star WELS, 5.5Lpm
RBA1044-600 ‘RIO’ Basin Pillar Tap DR - Chrome - 6 Star WELS, 4.5Lpm
RBA1047-600 ‘Gooseneck’ Basin Pillar Tap DR - Chrome - 6 Star WELS, 5.5Lpm
Installation
1. Installation must be carried out in accordance with local authority requirements.
2. Flush the line thoroughly, and remove all dirt and grit from the line before connecting the tap.
3. Install the tap in the basin, tightening lightly with spanner or grips.
4. Connection may be made with either exible S/S braided hose, or copper tube and compression ttings.
5. Before turning on the water remove the aerator and ush the tap.
6. Replace the aerator and check for leaks.
7. Fit appropriate coloured indicator to the handle.
Troubleshooting
*To remove the aerator and cartridge, see “Spare Parts” to choose appropriate tool. [Not supplied with the product].
Problem Probable Cause Solution
No ow or low volume Water turned off
Water outlet blocked
Turn on
Remove the blockage
Water ows continuosly
or Short / long ow time
Cartridge blocked with dirt
Cartridge damaged
Valve direction incorrect
Remove and clean*Remove and clean*
Replace the cartridge*Replace the cartridge*
Leak under knob Cartridge damaged Replace the cartridge*Replace the cartridge*

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
SYDNEY | MELBOURNE | BRISBANE | PERTH | AUCKLAND
Australia 1300 788 778 www.rba.com.au | New Zealand 0800 722 111 www.rbagroup.co.nz4 of 4
Note: This product should be installed, by suitably qualied persons, in a t for purpose application, to suitable materials,
using suitable xings and comply with any relevant codes. It should be inspected periodically for signs of wear and tear that
may affect performance or safety.
Dimensions are subject to manufacturer’s tolerance of +/-10mm. Rough-in should be completed with each xture.
Important: Installation Instructions are subject to change without notice.
Please visit our websites for latest revision.
RBA Code No. Description
RBA1015-999-001 Cartridge and Handle
RBA1043-999-002 Cartridge with Coloured Plugs 7 seconds
RBA1047-999-001 Cartridge with Coloured Plugs 15 seconds
RBA1083-999-001 Spanner
RBA1083-999-010 Anti-Rotational Heavy Duty Locknut
Spare Parts
RBA1047-600 RBA1015-600
RBA1043-600 RBA1044-600
RBA1083-999-001
5L RBA1083-999-002
8L RBA1083-999-003
RBA1015-999-001