Rodgers W-5000 User manual

INSTRUMENTS LLC
W-5000
Contemporary Keyboard
User’s Guide

ATTENTION: RISQUE DE CHOC ELECTRIQUE NE PAS OUVRIR
The lightning flash with arrowhead symbol, within an equilateral
triangle, is intended to alert the user to the presence of
uninsulated “dangerous voltage” within the product’s enclosure
that may be of sufficient magnitude to constitute a risk of
electric shock to persons.
CAUTION: TO REDUCE THE RISK OF ELECTRIC SHOCK, DO NOT REMOVE
COVER (OR BACK). NO USER-SERVICEABLE PARTS INSIDE. REFER
SERVICING TO QUALIFIED SERVICE PERSONNEL.
!
The exclamation point within an equilateral triangle is intended
to alert the user to the presence of important operating and
maintenance (servicing) instructions in the literature
accompanying the product.
INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK, OR INJURY TO PERSONS.
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
WARNING: When using electric products, basic precautions should always be followed, including the following:
1. Read all the instructions before using the product.
2. Do not use this product near water — for example, near a
bathtub, washbowl, kitchen sink, in a wet basement, or near
a swimming pool, or the like.
3. This product should be used only with a cart or stand that is
recommended by the manufacturer.
4. This product, either alone or in combination with an amplifier
and headphones or speakers, may be capable of producing
sound levels that could cause permanent hearing loss. Do
not operate for a long period of time at a high volume level
or at a level that is uncomfortable. If you experience any
hearing loss or ringing in the ears, you should consult an
audiologist.
5. The product should be located so that its location or position
does not interfere with its proper ventilation.
6. The product should be located away from heat sources such
as radiators, heat registers, or other products that produce
heat.
7. The product should be connected to a power supply only of the
type described in the operating instructions or as marked on the
product.
8. The power-supply cord of the product should be unplugged from
the outlet when left unused for a long period of time.
9. Care should be taken so that objects do not fall and liquids are
not spilled into the enclosure through openings.
10. The product should be serviced by qualified service personnel
when:
A. The power-supply cord or the plug has been damaged; or
B. Objects have fallen, or liquid has been spilled onto the
product; or
C. The product has been exposed to rain; or
D. The product does not appear to operate normally or exhibits
a marked change in performance; or
E. The product has been dropped, or the enclosure damaged.
11. Do not attempt to service the product beyond that described in
the user/maintenance instructions. All other servicing should
be referred to qualified service personnel.
This product may be equipped with a polarized line plug (one blade wider than the other). This is a safety feature. If you are unable
to insert the plug into the outlet, contact an electrician to replace your obsolete outlet. Do not defeat the safety purpose of the plug.
CAUTION: TO PREVENT ELECTRIC SHOCK, MATCH WIDE BLADE OF PLUG TO WIDE SLOT, FULLY INSERT.
ATTENTION: POUR EVITER LES CHOCS ELECTRIQUES, INTRODUIRE LA LAME LA PLUS LARGE DE LA FICHE DANS LA
BORNE CORRESPONDANTE DE LA PRISE ET POUSSER JUSQU’ AU FOND.
IMPORTANT: THE WIRES IN THIS MAINS LEAD ARE COLOURED IN ACCORDANCE WITH THE FOLLOWING CODE.
BLUE: NEUTRAL
BROWN: LIVE
As the colours of the wires in the mains lead of this apparatus may not correspond with the coloured markings identifying the terminals in
your plug, proceed as follows:
The wire which is coloured BLUE must be connected to the terminal which is marked with the letter ‘N’ or coloured BLACK.
The wire which is coloured BROWN must be connected to the terminal which is marked with the letter ‘L’ or coloured RED.
For the USA
For Canada
For the U.K.
CAUTION
RISK OF ELECTRIC SHOCK
DO NOT OPEN
!

User’s Guide
iii
INTRODUCTION
Thank you and congratulations on your choice of the Rodgers W-5000! The W-5000 is a contemporary
keyboard instrument which combines the very best of current organ tone-generation and leading-edge
synthesizer technology. As a players’ instrument, the W-5000 will satisfy the needs of the most demanding
professional, yet is easy enough to operate for the novice player to enjoy.
This User’s Guide contains all of the ‘nuts and bolts’ of W-5000 operation. Refer to this guide when you
need specific information about particular operations or functions. The W-5000 Quick Start guide, on the
other hand, provides a very brief, step-by-step description of playing the instrument. If you want to get
playing right away, work through the Quick Start guide. When you need more detailed information, however,
the User’s Guide is where you should look.
Note: This edition of the W-5000 User’s Guide refers specifically to software version 2.970604.
To determine which version of the operating software is currently installed in your W-5000, refer to
Chapter 10 (Utility Parameters; Software Version).
Rodgers instruments are built in Hillsboro, Oregon, USA. Through the most advanced technology available,
Rodgers Instruments LLC, a member of the Roland Group, delivers proven reliability, design innovation and
a tradition of musical excellence. Rodgers ... The Sound Choice!
FEATURES
•The W-5000 features a two-manual plus pedalboard design in the tradition of great players’instruments!
•Sounds are produced by three independent tone generators; a Drawbar/Tone-Wheel generator for
contemporary organ sounds, a Classic Organ generator for church and
•classical organ sounds, and a Synth generator for synthesized instrument and percussion sounds.
•The W-5000 utilizes specially designed LED-lit Tone buttons and authentic drawbars to control the Tone-
Wheel organ sounds.
•A160 watt, multi-speaker sound system delivers full, rich sounds without any additional amplifiers or
speakers. However, the W-5000’s extensive output array can handle virtually any sound output
configuration you might require.
•The W-5000 features full MIDI (Musical Instrument Digital Interface) capability, with the internal Synth
generator available for control via an external instrument.
•The on-board disk drive can be used to record and playback your keyboard performances. The drive can
also be used to play commercially available Standard MIDI File (SMF), General MIDI (GM), and
Roland/Rodgers GS Format data (on 3.5” disks).

Rodgers W-5000
iv
Copyright © 1997 RODGERS INSTRUMENTS LLC
All rights reserved. No part of this publication may be reproduced in any form
without the permission of Rodgers Instruments LLC.
Information in this publication is subject to change without prior notice.

User’s Guide
v
TABLE OF CONTENTS
Introduction...........................................................................................................................................................iii
Features..................................................................................................................................................................iii
Customer Support ............................................................................................................................................. viii
Conventions Used In This Manual................................................................................................................... viii
The General MIDI (GM) System......................................................................................................................... ix
The GS Format...................................................................................................................................................... ix
Standard MIDI Files (SMF)................................................................................................................................... ix
Important Notes....................................................................................................................................................x
CHAPTER 1 Introduction & Installation
Front Panel Description .....................................................................................................................................12
Rear Panel Description......................................................................................................................................14
Setup And Installation........................................................................................................................................16
Basic Assembly.....................................................................................................................................16
Installing The Pedalboard/(Model W-5000A) .................................................................................17
Opening The Lid ..................................................................................................................................19
The Music Rest......................................................................................................................................19
Connecting The Power Cord, Expression Pedal and Speakers...................................................20
CHAPTER 2 Performance Basics
Powering Up........................................................................................................................................................24
LCD Contrast........................................................................................................................................24
Panel / Pedalboard Lighting.............................................................................................................25
Performance Basics ...........................................................................................................................................26
Drawbar Tones.....................................................................................................................................26
Classic Organ Tones............................................................................................................................29
Synth Tones...........................................................................................................................................31
Layering Tones ....................................................................................................................................................33
The Solo Function................................................................................................................................................35
Bass Tones............................................................................................................................................................37
Pedalboard .........................................................................................................................................37
Keyboard Bass .....................................................................................................................................37
Bass Sustain/Solo..................................................................................................................................38
Manual Drums.....................................................................................................................................................39
CHAPTER 3 Advanced Performance Features
Advanced Performance Features..................................................................................................................42
Tone Mapping......................................................................................................................................42
More Performance Functions...........................................................................................................................44
[DRAWBAR PRESET] Buttons................................................................................................................44
[OCTAVE +/-] Button...........................................................................................................................45
[HOLD] Button ......................................................................................................................................46
[ORGAN TREM] Button........................................................................................................................46
[SUSTAIN] Button (BASS)......................................................................................................................47
[MIDI] Buttons (UPPER/LOWER/BASS)................................................................................................47

Rodgers W-5000
vi
CHAPTER 4 Effects
EFFECTS Section ..................................................................................................................................................50
[MANUAL DRUMS] Button...................................................................................................................50
[UPPER DB VIB] + [LOWER DB VIB] Buttons.......................................................................................51
[DRAWBAR DISTORT] Button...............................................................................................................51
[DRAWBAR CLICK] Button..................................................................................................................52
[CROSSFADE] Button...........................................................................................................................52
[AFTERTOUCH] Button .........................................................................................................................53
[GENERAL REVERB] Button .................................................................................................................54
[SYNTH CHORUS] Button.....................................................................................................................54
[TRANSPOSE] Button............................................................................................................................55
[ROTARY] + [FAST/SLOW] Buttons......................................................................................................55
CHAPTER 5 General Presets
General Presets...................................................................................................................................................58
Globals..................................................................................................................................................59
Preset Storage......................................................................................................................................60
CHAPTER 6 Voicing & Controller Settings
Voicing & Controller Settings............................................................................................................................66
Keyboards............................................................................................................................................................66
Controllers............................................................................................................................................................67
Controller Destinations ......................................................................................................................................67
Setting The Controllers.......................................................................................................................................69
Voicing …….........................................................................................................................................................70
CHAPTER 7 The Floppy Disk Drive
The Floppy Disk Drive .........................................................................................................................................74
Handling Floppy Disks.........................................................................................................................74
Handling The Disk Drive......................................................................................................................75
Formatting A Floppy Disk ...................................................................................................................76
Using The Sequencer .........................................................................................................................................77
Listening To A Song On Disk...............................................................................................................77
Playback Controls...............................................................................................................................78
Recording Your Performances.........................................................................................................................80
Storing W-5000 Data On Disk............................................................................................................................81
Registrations .........................................................................................................................................81
CHAPTER 8 Audio
The Audio System ...............................................................................................................................................86
Outputs..................................................................................................................................................86
Inputs .....................................................................................................................................................88
Speaker And Line Mixes....................................................................................................................................88
The Speaker Mix...................................................................................................................................88
Auxiliary Inputs .....................................................................................................................................89
The Line Mix ..........................................................................................................................................90
Auxiliary Inputs .....................................................................................................................................91
Audio System Configurations...........................................................................................................................92
Basic Audio Setup ...............................................................................................................................92
Mid-Sized Audio Setup.......................................................................................................................93
Large Audio Setup ..............................................................................................................................94

User’s Guide
vii
CHAPTER 9 Using MIDI
Using MIDI ............................................................................................................................................................96
Using External Sound Modules .........................................................................................................................96
Using The W-5000 As A Sound Module ...........................................................................................................98
External Sequencing........................................................................................................................................100
Master Channel Sequencing..........................................................................................................100
Native Mode Sequencing...............................................................................................................104
Multi-Track Recording.......................................................................................................................105
Synchronizing .....................................................................................................................................106
Controlling Another Rodgers Organ.............................................................................................................108
CHAPTER 10 Appendix
Parameter Lists..................................................................................................................................................110
UPPER / LOWER / BASS Sections.....................................................................................................................111
[TONE] Parameters............................................................................................................................111
[TONE 1] + [TONE 2] Parameters.....................................................................................................111
[SOLO] Parameters............................................................................................................................111
[OCTAVE +/-] Parameter..................................................................................................................113
[ORGAN TREM] Parameters.............................................................................................................113
Drawbar Parameters ([CURRENT DRAWBAR] + [DRAWBAR PRESET]) .......................................113
[MIDI] Parameters..............................................................................................................................115
[KEYBD BASS] Parameter..................................................................................................................116
Bass [SUSTAIN] Parameters...............................................................................................................116
EFFECTS Section ................................................................................................................................................117
[MANUAL DRUMS] Parameters........................................................................................................117
[UPPER DB VIB] + [LOWER DB VIB] Parameters .............................................................................117
[DRAWBAR DISTORT] Parameters....................................................................................................118
[DRAWBAR CLICK] Parameter ........................................................................................................118
[CROSSFADE] Parameters................................................................................................................119
[AFTERTOUCH] Button .......................................................................................................................120
[GENERAL REVERB] Parameters ......................................................................................................120
[SYNTH CHORUS] Parameters ..........................................................................................................120
[TRANSPOSE] Parameter ..................................................................................................................121
General Controls ..............................................................................................................................................122
[ROTARY] Parameters.......................................................................................................................122
[FAST/SLOW] Parameters..................................................................................................................123
[MEMORY] (General Preset) Parameter........................................................................................123
FUNCTIONS Section..........................................................................................................................................124
[CONTROLS] + [VOICING] Parameters..........................................................................................124
[PRESETS] Parameters........................................................................................................................127
[SEQ] Parameters...............................................................................................................................128
[AUDIO] Parameters .........................................................................................................................130
[MIDI] Parameters..............................................................................................................................133
[UTILITY] Parameters ..........................................................................................................................136
Synth Tone Map................................................................................................................................................139
PR-300 Tone Map..............................................................................................................................................142
CM-64/MT-32 (PR-300 Subsets)........................................................................................................144
Classic Organ Tone Map ................................................................................................................................145
Synth Drum Sets.................................................................................................................................................146
PR-300 Drum Sets..............................................................................................................................................147
General Preset Parameters.............................................................................................................................151
Global Parameters...........................................................................................................................................152
Software Updates.............................................................................................................................................153
MIDI Implementation.......................................................................................................................................154
Audio Block Diagram ......................................................................................................................................160
Specifications....................................................................................................................................................161

Rodgers W-5000
viii
CUSTOMER SUPPORT
The Customer Service Department of Rodgers Instruments LLC is available to answer any of your questions.
Before you call, however, please try the following steps:
•Check your documentation
•Contact your local Rodgers dealer
•Call the Rodgers Field Service Department
If you are unable to resolve your problem, please feel free to call the Customer Service Department between
the hours of 7:00 AM and 5:00 PM Pacific Time, Monday through Friday (excluding holidays). Weekend
support hours are 5:00 to 9:00 PM Friday, 7:00 AM to 5:00 PM Saturday, 7:00 AM to 12:00 PM Sundays.
Call [phone] of fax [phone]. Before you call, please have the following information in front
of you:
•Model number
•Serial number
•Date of installation
•Adescription of the problem and steps taken to correct it
RODGERS INSTRUMENTS LLC
1300 N.E. 25th Avenue
Hillsboro, OR 97124
Telephone: [phone]
CONVENTIONS USED IN THIS MANUAL
•Panel buttons are indicated within square brackets. For example; Press the [UTILITY] button in the
FUNCTIONS section, and then the [+] button in the EDIT section.
•Whenever a panel button is pressed, the LCD will instantly display relevant information; a Program
Number and name, a parameter name and setting value and so on. Generally, to navigate through the
options and to set parameter values you will:
Ê Press the relevant panel button.
Ë Use the [NEXT] and [PREVIOUS] buttons in the EDIT section to select the desired
parameter.
Ì Use the [+] and [-] buttons in the EDIT section to set a numeric value (e.g. 0—127) or select
an option (e.g. High, Low or Off). (Using the [++] and [--] buttons allow you to change
numeric values in large jumps.)
•Due to space limitations, many parameter, Tone and function names are abbreviated. For example, ‘chorus’
is abbreviated as ‘Cho’. Where necessary, the abbreviations will be explained.
•Where possible, actual LCD screens will be used in explaining the instrument’s functions. Keep in mind,
however, that screens presented by your W-5000 may differ depending on its settings.

User’s Guide
ix
THE GENERAL MIDI (GM) SYSTEM
The General MIDI System is a universal set of specifications for sound generating devices which hasbeen
agreed upon by the Japanese MIDI Standards Committee and the American MMA (MIDI Manufacturer’s
Association). These specifications seek to allow for the creation of music data which is not limited to
equipment by a particular manufacturer or to specific models.
The GM System defines such things as the minimum number of voices that should be supported, the MIDI
messages that should be recognized, which sounds correspond to which Program Change Numbers, and the
layout of rhythm sounds on the keyboard. Thanks to these specifications, any device that is equipped with
sound sources supporting the GM System will be able to accurately reproduce GM Scores (music created
under the GM System), regardless of the manufacturer or model.
THE GS FORMAT
The GS Format is the Roland/Rodgers standardized set of specifications for Roland/Rodgers sound sources
which defines the manner in which multi-timbral sound generating units will respond to MIDI messages. The
GS Format also complies with the GM System. The GS Format, however, defines a number of additional
items. These include unique specifications for sounds, the functions available for Tone editing and effects
(e.g. chorus and reverb), and other specifications concerning the manner in which sound sources will
respond to MIDI messages.
Any device that is equipped with GS Format sound sources can faithfully reproduce GS Music Data (music
data created under the GS Format).
The W-5000 supports both the General MIDI System and the GS Format. Song data (on 3.5 inch
floppy disks) which carries either of these logos can be accurately reproduced.
STANDARD MIDI FILES (SMF)
The W-5000 can also playback Standard MIDI Files (720 Kbyte or 1.2 Mb format, 3.5 inch floppy disks)
such as the data on any commercially available SMF music disk.

Rodgers W-5000
x
IMPORTANT NOTES
In addition to the Important Safety Instructions inside the front cover, please read and observe the following:
POWER SUPPLY
•Before connecting the instrument to other devices, be sure the power to all units is off; this will help
prevent damage or malfunction.
•Be sure the voltage in your installation meets the requirement of your instrument. Check the back panel of
your instrument for power requirements.
•Do not use this instrument on the same power circuit with any device that may generate line noise; an
electric motor or variable lighting system for example.
•Unplug the AC cord when the instrument will not be used for an extended period of time. When
disconnecting theAC cord, always pull on the plug itself; never pull on the cord.
•Avoid damaging the power cord; do not step on it or place heavy objects on it.
PLACEMENT
•Be sure to install this instrument on a very solid and stable floor or stage; its size and weight demand that
safety be an important consideration.
•This device may interfere with radio and/or television reception.Avoid using this instrument in the vicinity
of such receivers. (See inside back cover for more information.)
MAINTENANCE
•For everyday cleaning wipe the instrument with a soft, dry cloth. To remove stubborn dirt or stains, use a
slightly dampened cloth and a mild, non-abrasive detergent.Afterward, be sure to wipe the instrument with
a soft, dry cloth. (Be very careful not to spill any liquid into the instrument!)
•Never use benzine, thinners, alcohol or solvents of any kind to avoid the possibility of discoloration and/or
deformation of plastic parts.
ADDITIONAL PRECAUTIONS
•Take great care when moving the instrument as it is very heavy. Safety should be foremost in your mind
when you transport the unit. Proper care and a little common sense will ensure that no injuries occur and
that the instrument isn’t damaged.
•Before operating the instrument in a foreign country, be sure to consult with qualified service personnel.
(Voltage incompatibility can seriously damage your instrument.)
•Setting a vase, bottle or glass containing liquid on the instrument is inviting an accident to happen!Any
liquid spilled into the instrument can cause a great deal of damage or electric shock to users. To avoid such
an occurrence, don’t put any containers on the instrument. In the event that liquid is spilled into the
instrument, discontinue use immediately. Unplug the power cord from the wall and contact qualified
service personnel as soon as possible.
•Contact qualified service personnel when:
•The power cord has been damaged
•Objects or liquids have fallen into the instrument
•The instrument has been exposed to rain or weather damage
•The instrument has been dropped or the enclosure has been damaged
•The instrument does not appear to function normally

CHAPTER 1.
Introduction &
Installation

Chapter 1
12
FRONT PANEL DESCRIPTION
1 Power Switch This switch turns the W-5000 on and off.
2 Tweeters These are high-frequency speakers.
1 2 3 4 6 7 8 2
5
9 10 11 12 13 14 15 16 17 18 19
20
21
22

Introduction & Installation
13
3 EFFECTS
Section These buttons access a variety of the W-5000's effects, such as reverb, chorus, drawbar
click, aftertouch and so on.
4 UPPER Tone
Select These buttons select Tones and functions for the Upper manual.
5 Music Rest Music rest and panel light intensity can be changed as required.
6 LOWER Tone
Select These buttons select Tones and functions for the Lower manual.
7 BASS Tone
Select These buttons are used to select Tones for the Pedalboard and for the Lower manual when it
is split into two sections (Keybass).
8 Floppy Disk
Drive The drive can be used to record and playback your keyboard performances, as well as to
store instrument data and playback commercial song data.
9 Performance
Controls The [SPKR] knob controls the overall volume of the W-5000 (including headphones when
they're connected). The [LINE] knob controls the level of the Line Out signal. The
[Bender/Modulation] lever raises and lowers the pitch, and adds vibrato to the notes you
play.
10 BALANCE
Section These sliders are used to create the appropriate balance between Tones which you have
layered together. There are separate sliders for the UPPER, LOWER and BASS sections.
11 ROTARY
Buttons The [ROTARY] button activates the W-5000's rotary speaker simulator, and the
[FAST/SLOW] button changes the rotary effect speed.
12 UPPER
Drawbars Drawbars act like tone controls for sounds produced by the Tone-Wheel/Drawbar generator.
They can provide real-time control as you play the Upper manual.
13 PERC/USER
Drawbars The PERC (Percussion) drawbars control the attack portion of the sound (for the Upper
manual only). The USER drawbars can be assigned a variety of different functions as
required.
14 LOWER
Drawbars These drawbars affect the Tone-Wheel sounds for the Lower manual.
15 BASS Drawbars
These drawbars affect the Lower manual and Pedalboard.
16 General Presets
These buttons are used to select and store overall instrument settings.
17 Upper Manual This is a 61 note, velocity sensitive, lightly weighted keyboard.
18 Lower Manual This is a 76 note, velocity and aftertouch sensitive, lightly weighted keyboard.
19 LCD/System
Controls The LCD (Liquid Crystal Display) provides information about selected Tones and
operational status. The system controls (EDIT and FUNCTIONS) allow you to custom
configure and control your instrument.
20 Speaker
Enclosure This box contains the W-5000's speakers.
21 Expression
Pedal This pedal functions as a kind of volume control, but different functions can be assigned to
it. The 'kick' switches offer additional control.
22 Pedalboard This is a 25 note, velocity sensitive pedalboard.

Chapter 1
14
REAR PANEL DESCRIPTION
1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18
Internal Speaker/Expression
Pedal/Pedalboard
Ct

Introduction & Installation
15
1 MIXED LINE These XLR connectors allow you to connect your W-5000 to a mixing console BALANCED
INPUT (using long cables if necessary). The signal from these connectors is a Line level mix
of the individual outputs (SYNTH, DRAWBAR and CLASSIC).
2 RODGERS This is the standard Rodgers connector for the main individual outputs MAIN
OUTPUT(SYNTH, DRAWBAR and CLASSIC) and the MIXED LINE or SPKR OUTPUT.
It also sends a 'power on' signal to any connected amplifier(s).
3 AUX INPUT These XLR inputs accept connection of microphones, external keyboards etc. Sensitivity and
other controls are accessible through the [AUDIO] button in the FUNCTIONS section.
4 RODGERS This is the standard Rodgers connector for MIXED LINE Output. It also sends a
ANTIPHONAL OUTPUT 'power-on' signal to any connected amplifier(s).
5 AUX INPUT These 1/4" inputs accept connection of microphones, sound modules, external keyboards etc.
Sensitivity and other controls are accessible through the [AUDIO] button in the
FUNCTIONS section.
6 SYNTH
OUTPUT These 1/4" jacks provide an individual, line-level output for sounds from the Synth tone
generator. For the best results, use both jacks.
7 DRAWBAR
OUTPUT These 1/4" jacks provide an individual, line-level output for sounds from the Tone-Wheel
generator. For the best results, especially when the Rotary simulator is active, use both jacks.
8 CLASSIC
OUTPUT These 1/4" jacks provide an individual, line-level output for sounds from the Classic Organ
tone generator. For the best results, use both jacks.
9 MIXED SPKR These 1/4" jacks provide a line-level output for the same signals going to the OUTPUT
internal amplifier and speakers (the Speaker mix).
10 MIXED LINE These 1/4" jacks provide an option for connection to a mixing console (an OUTPUT optional
Line mix output).
11 MIDI 1 These MIDI ports allow you to connect your W-5000 to external MIDI devices (such as
sound modules, sequencers etc.). Control of these ports is accessed through the [MIDI]
buttons found in each section (UPPER/LOWER/BASS) and the [MIDI] button in the
FUNCTIONS section.
12 MIDI 2 Same as MIDI Port 1 without the THRU connector.
13 SW1 This 1/4" jack accepts connection of an external, switched (on/off) controller. The function
of this controller is user defined.
14 PEDAL This 1/4" jack accepts connection of an external controller (such as an Expression pedal).
The function of such a controller is user defined.
15 ACC POWER This is a general purpose 12v DC power outlet. It can be used to power an external piece of
equipment (like a Rodgers PR-300, for example).
16 ROTARY TONE
CABINET This multi-pin connector is used to connect a rotary tone cabinet to your W-5000.
17 SPEAKER/
EXPRESSION
PEDAL
This multi-pin connector is used to connect the on-board speakers and Expression pedal
(both integrated into the stand) to the keyboard.
18 MAIN POWER Connect the included AC power cord to this inlet.

Chapter 1
16
SETUP AND INSTALLATION
Because of the W-5000's size and weight, setup and installation are somewhat more involved than with a
smaller instrument. Your Rodgers dealer will very likely assist with the delivery and initial setup of your
new instrument, and this provides a good opportunity to gain first-hand experience with the process.
BASIC ASSEMBLY
Your Rodgers dealer may deliver your W-5000 in one piece, or it may be necessary to assemble the two
main sections; the keyboard itself and the stand. The information provided here will also be useful should
you need to disassemble the instrument for future transport.
SPKR LINE
- +
- +
UPPER USER LOWER BASS
PERC
UPPER
EFFECTS BASS
3456789
LOWER
NEXT
+ + +
VOICING
CONTROLS
MIDI
PREVIOUS
STOP REC PLAY
- - -
SMF
SMF FUNCTIONS
Ë Insert and
tighten the screws
provided
(three per side).
To disassemble
the unit, remove
these screws first.
Ê Slide the locking grooves of
the brackets until they sit tightly
against the pins on the stand. To
disassemble, slightly raise the
front of the keyboard to clear the
alignment pins and then slide the
keyboard forward to disengage
the groves from the rear pins. Be
sure to disconnect the
speaker/Expression
pedal/Pedalboard cable first!
Alignment pin
(both sides)

Introduction & Installation
17
INSTALLING THE PEDALBOARD
Once the instrument is secured to the stand, it will be necessary to install the Pedalboard.
First, however, free the two pedal cables that are temporarily secured by a fastener to the underside of the
stand. (Do not remove this fastener from the base of the instrument. Before moving the W-5000, be sure that
these cables are carefully bundled (without any slack) and secured to the base using the fastener.) [NOTE:
Refer to the following page for information on pedalboard installation for the "A" version of the W-
5000.]
SPKR LINE
- +
- +
1
NOTE: If your W-5000 is sitting on a very thick carpet, it may be difficult to slide the Pedalboard into place.
If that is the case, very carefully lift one side of the instrument and rotate the adjustable feet to provide more
clearance. Then lift the other side and do the same. Take great care when making this adjustment; this
500 pound instrument could cause severe injury if it were to pinch fingers or toes!
Ê Connect the pedal cables to the
receptacles on the right side of the
Pedalboard assembly; one is a 5-
pin cable for the Pedalboard) and
the other is an 8-pin cable (for the
Expression pedal).
Ë Push the pedalboard (from the
center of the heelpad) so it slides
all the way into the stand.
5-pin 8-
i

Chapter 1
18
INSTALLING THE PEDALBOARD (W-5000 Version "A" Only)
Once the instrument is secured to the stand, it will be necessary to install the Pedalboard.
The Pedalboard unit contains two metal hooks which simply hook over top of the short metal bars on the
bottom of the stand. (It's very important to make sure the Pedalboard is straight while you firmly push it into
its latched position):
If you like, you can also adjust the height of the Pedalboard.
Note: If you are installing the unit on thick carpet, raise the console by rotating its adjustable feet so the
Pedalboard is relatively parallel to the floor:
¶ Place the Pedalboard
against the metal hanger
pins on the bottom of the
stand.
· Push the Pedalboard
from the center of the
heelboard.

Introduction & Installation
19
OPENING THE LID
The instrument's lid may have been locked for transit. Find the key and unlock the lid. To open the
instrument lid, simply lift the handle and fold back. When the lid is folded, push it straight back into the
instrument case. To close the lid, pull it straight out, unfold, and gently lower over the keyboards:
USER LOWER
PERC
THE MUSIC REST
The plexiglass music rest slides easily into the deep groove on top of the keyboard:
ÊË
ÌÍ

Chapter 1
20
CONNECTING THE POWER CORD,
EXPRESSION PEDAL AND SPEAKERS
Be sure the [Power] switch (on the far left-hand side of the panel) is in the OFF position. Also be sure the
[SPKR] knob (main volume) (just below the Power switch) is at the minimum position and that the
Expression pedal is in the full-up (minimum) position:
Connect the included AC power cord to the MAIN POWER inlet on the rear panel of the instrument; tuck
the power cord into the channel in the leg of the stand (but don't close the cover just yet):
Ê MAIN POWER connection
Ë Speaker / Expression Pedal /
Pedalboard connection.