Royal 4250VCT User manual

This information has been compiled by the Vacuum Cleaner Manufacturer's Associa-
tion working with government and private sources, concerned with product safety.
These basic guidelines are for your protection and convenience.
THIS CLEANER IS INTENDED FOR HOUSEHOLD USE ONLY
IMPORTANT SAFETY INSTRUCTIONS
When you use an appliance, basic precautions should always be followed, including the
following:
READ ALL INSTRUCTIONS BEFORE YOU USE THE APPLIANCE
ALWAYS FOLLOW THESE SAFETY INSTRUCTIONS
WARNING: TO REDUCE THE RISK OF
FIRE, ELECTRIC SHOCK OR INJURY:
Look on your vacuum cleaner and follow all
label and marking instructions.
Electric shock could occur if used outdoors or
on wet surfaces.
Do not let children play with the vacuum clean-
er. Watch closely when the vacuum cleaner is
used by or near children.
Do not use the vacuum cleaner to pick up flam-
mable or combustible liquids or fumes, such as
gasoline, or use in areas where they may be
present.
Keep the vacuum cleaner on the floor. Only the
hand-held vacuum cleaners may be set on
furniture.
Unplug the vacuum cleaner if you leave the
room. Unplug it when it is not in use and before
you service it.
Keep end of hose, wands and other openings
away from your face and body. Keep your hands,
feet, hair and clothing away from moving parts.
Only use attachments and hoses recommended
by the manufacturer. Use the vacuum cleaner only
as stated in this manual.
Turn all controls to "OFF", before unplugging
the vacuum cleaner.
Do not use an extension cord with this vacuum
cleaner.
Do not touch the plug or the vacuum cleaner
with wet hands.
Do not use the power cord to pull or carry the
vacuum cleaner. Do not use the power cord as a
handle. Do not shut any door on the cord or pull
the cord around sharp edges or corners. Keep the
cord away from heated surfaces. Do not run the
vacuum cleaner over the cord.
Do not use vacuum cleaner with a damaged
cord or plug. Do not use vacuum cleaner if work-
ing improperly, dropped, damaged, left outdoors
or dropped in water. First, send to service center
for check and repair.
Do not use the vacuum cleaner without dustbag
or filters in place.
Store the vacuum cleaner indoors. Put the vac-
uum cleaner away after use to prevent tripping
accidents.
Do not pull on the cord to unplug the vacuum
cleaner. Grasp the plug instead.
Be most careful when vacuum cleaning on
stairs.
Do not put any object into the vacuum cleaner
vent or other openings. Do not turn the vacuum
cleaner on if something is blocking an opening.
Keep vents free of things that slow air flow, such
as dust, lint and hair.
Do not pick up anything that is hot, smoking or
burning. Do not pick up cigarettes, hot ashes or
matches.
Always turn off the vacuum cleaner before con-
necting or removing either the hose or the mo-
torized nozzle.
Using improper voltage may result in damage to
motor and possible injury to user. Proper voltage
is listed on the cleaner plate.
Approved by the Vacuum Cleaners Manufacturer's Association Executive Committee,
April
29, 1987.

GROUNDING INSTRUCTIONS
(only for 3-wire models, those that include 2 blades and 1 grounding pin)
This appliance must be grounded. If it should malfunction or breakdown, grounding
provides a path of least resistancefor electric current to reduce the risk of electric
shock. This appliance is equipped with a cord having an equipment-groundingcon-
ductor andgroundingplug.The plug must be pluggedintoan appropriateoutletthat is
properly installed and grounded in accordance with all local codes and ordinances.
DANGER - Improperconnection of the equipment-groundingconductor
can result in a risk of electric shock. Check with a qualified electrician or service
personifyouare indoubt as towhether theoutlet is properlygrounded.Do not modify
the plug provided with the appliance
- if it will not fit the outlet, have a proper outlet
installed by a qualified electrician.
This applianceisfor useon a nominal 240-volt circuit. Makesure that the applianceis
connectedto an outlet havingthe same configurationsas the plug. Noadaptershould
be used with this appliance.
Ifthe supplycord of this applianceisdamaged,itmustbe replacedbythespecialcord
Part
#I -425436-000.
WARNING:
Electricalshock could occur if used outdoors or on wet surface.
TABLE OF CONTENTS
Features .......................................................... 4
Using your Tank Vacuum Cleaner .................................... 5
Attachments ................................................... 6-7
Using the Power Nozzle ........................................ 8
Paper Bag Removal and Replacement ................................ 9
MICRO FRESH Filtration System (Optional) ........................ 10-11
Using the Blower Feature .......................................... 12
Warranty ......................................................... 13

Powerful Royal Tanks are versatile tanks for you
Get acquainted with your tank vacuum cleaner
Take full advantage of all the special
accessory tools for the Royal tank.
They'll work hard for you.
CordWrap
-
12 Extra-long Power Cord
Exhaust Filtering Vent
- Disperses
dust-freeair.
Rear End Bell
1 Tip Toe Switch - Conveniently lo-
cated
ON/OFF switch.
16 Heavy duty, Vinyl Handle - Com-
fortableto the grip.
Outlet for Power Nozzle Plug
Front End Bell
191 Hose Insert
1101 Bell Clamps on both sides -
Secures front end bell.
111] 360" Swivel Front Wheels - For
maximum maneuverability.
Load-bearing Wheels
Bleed valve
- Rotate open to reduce
suction when cleaning fragile items. It is
necessaryfor the bleedvalve to be kept
completely closed when cleaning floors
since maximum suction is required for
floor cleaning.
114( Two CleaningWands - Made of
chrome-platedtubular steel.
Crevice Tool - Narrow, smoothly
pointedtool concentratessuction in hard-
to-reach places.
1161 RoundDusting Brush - Long, soft
flexible bristles.
1171 10 Floor and Wall Brush - Soft
bristlesfor vacuuming barefloors, walls
and ceilings.
6 Upholstery Nozzle - Idealfor
cleaning furniture and drapes.
1191 Power Nozzle - separate motor and
revolving brush system.
Crush Proof Hose - Light, pliable,
durable vinyl for ease of use.
11" Rug Nozzle - cleans all types of
rugs and carpets.
1221 Cord Straps - 6 straps used to se-
cure external hose cord to flexible hose.
1231 External HoseCord

USING YOUR ROYAL TANK VACUUM
IS AS EASY AS
1-2-3 ...
ATTACH THE FLEXIBLE HOSE
Insert the slotted connector end of the hose into the front end bell.
Twist clockwiseto lock securely.
SELECT THE ATTACHMENT
Determinewhat vacuuming you will bedoing, then insertthe desired
tool into the pistol grip or wand.
PLUG IN THE TANK AND TURN ON
Plugthe power cord into your most convenient wall outlet.
The 40-foot total cleaning radius lets you clean without constantly
replugging.

HOW TO USE THE ATTACHMENTS
Your tank's assortment of cleaning tools lets you vacuum almost every-
thing around your home.
NOTE: Disconnect cleaner from electrical outlet during assembly
ASSEMBLE THE CLEANING WANDS:
The wand with the vinyl seal is the lower section which attaches to the
Power nozzleand cleaning tools. The other metalwand attachestothe grip.
To join wands together, pushin pinof lowerwandand lock intoholeof upper
wand.
VINYL SEAL d!Y
FLOOR AND WALL BRUSH:
Cleans linoleum, tile, bare wood or concrete floors, papered or painted
walls and ceilings.
This 10-inch brush has long, soft bristles that dust and buff at the same
time. Inserted into the lower wand section, the brush will lock into place
and then swivel conveniently as you clean.

ROUND DUSTING BRUSH:
Cleans bookcases, lampshades, screens, televisions, picture frames,
baseboards,and allmetal, wood, or moldedplasticfurniture
... any place
around your home.
The long soft bristles won't mar your furniture but will delicately lift the
surface dust and whisk it away.
UPHOLSTERY NOZZLE:
Cleans furniture, curtains, stairways, bedding, clothing, and car interiors.
Nozzle may be used with either both cleaning wands to reach drapery
valances, the back of the sofa, and other hard-to-cleanplaces.
NOTE: To clean the brushes,just apply suction from thehose directly
to the bristles.
CREVICE TOOL:
Cleans all hard-to-reach places including deep furniture crevices, button
cushions, bookcases,baseboard corners, and automobileupholstery. It's
also easier to clean behind ranges and refrigerators.
To attach, pushthe end of the selectedtool intothe opening of the wand.
Pull apart to remove.
To remove FLOOR TOOL ONLY, depress vinyl collar to release pin. Pull
apart.

Transformsthe tank into an upright-typevacuum. With its separate motor
and revolving brush system, the Power Nozzle actually lifts your carpet.
The revolving brush gently sweeps the carpet clean of dust and dirt
particlesdeep in carpeting.
To attach, press down on wand until pin snaps into placeand locks.The
flat area of thetube sealshouldfacetowardsthefront of the powernozzle.
Plug the external hose cord into the outlet on the top of the tool caddy
(Refer to
#7, page 4) and the power nozzle. Use the straps to securethe
external hose cord to the flexible hose.
To disconnect, unplug the external hose cord from the power nozzle.
Positionflat area of the tube seal toface toward the front of the pin. Push
in on flat area of the tube seal to release locking pin and pull.
When ordering a Power Nozzle, refer to the following:
Power Nozzle Grid
Tank
I Model / Required Power Nozzle /

PAPER BAG REMOVAL
AND REPLACEMENT
NOTE: Disconnect cleaner from electrical outlet for maintenance.
Replace the paper bag when approximately one-half full.
Set the tank on end with the exhaust vent (rear bell) on the floor.
Grasp the bell clamps in each hand. Holding your hands toward the
rear of the clamp, pull outward.
Grasp the.front end bell (the hose may still be connected), gently pull
outward.Take care not to spillany dirt. Pulloff paper bagand discard.
The cloth bag in the tank does not always have to be removed for
cleaning. If cleaning is required,remove the bag and shake dirt into a
suitable container.
Replacewith a new paper bag. Place the hole in the paper bag over
the metal fitting inside the front end bell.
Place the front end bell back onto the tank by sliding the paper bag
into the tank. The chrome end plate must slide over the edges of the
tank. Hold in placeand fasten the bell clamps to both sides. Clamps
will "snap" into placewhen fully seated.
Continue normal operation of your vacuum cleaner.

Fl LTRATION SYSTEM (optional)
Royal's filtration system for over 99.9% "fresh" exhaust air. This system
assures you that fine powderydust will not be blown back intothe air you
breathe or onto your furnitureand carpets again.
*Examinethe Five Layersof FiltrationinYour Tank Vacuum
Circulating air lifts dust and dirt from your carpets and transports it
through the hoseto a
175 square inchdouble layer disposable paper bag
(I)*. The second layer of the paper bag contains electrostatically charged
fibers
(2)*. The air passes through the double layered paper bag, depos-
iting dirt and lint. It then passes into a finely woven cotton twill cloth bag
(3) with 160 square inches. The air finally passes through a double-sided
filter pad. The MICRO
FRESH filter pad consists of an electrostatically
charged fiber material
(4) attached to a reticulatedflexible urethane foam
(5). When used as a system, the air expelled at the rear exhaust is over
99.9% "fresh".
*Not includedon all models.

Replaceable Fa-] Filter Pads
NOTE: Unplug tank before changing filter.
The filter padis located betweenthe filter bagand tank motor. Checkyour
filter pad periodicallyfor dirt build-up.The filter padshould bechangedat
least every six monthsor when three paper bags have been used.
TO INSTALL,removefrontendbellandclothbag. Dropfilter intotank with
white sidefacing towards you. Put cloth bag back into place. Attach front
end bell and continue normal operation of your tank.
Replaceable Paper Bags (optional)
MICRO FRESH disposable paper bags are lined with electrostatically
chargedfibers that trap finedust and pollenparticlesdownto
0.1 microns
in size.
To remove and replace, refer to page 9.
Enhance the performanceof your tank vacuum with MICRO FRESH high
filtration paper bags and filter pads. See an Authorized Royal Dealer or a
participatingretailertopurchasean assortmentof MICROFRESHproducts.

HOW TO USE YOUR TANK FOR BLOWING
NOTE: Unplug tank before changing Hose Connection.
(1) Simply connect the hoseto the rear end bell of the tank instead of the
front end bell. You'll be usingthe exhaust end insteadof the suctionend.
Be conscious of
where you'll be blowing the dust. Our suggestion is to
always blow it toward a dampenedsheet or towel which will trap the dust
and not send itflying intothe air. Then, you simply tossthe "dusty" sheet
or towel into your automatic washer for cleaning.
Don't be concerned if the paper filter bag is not empty when you usethe
blower. The tank's MICRO FRESH Filtration System will entrap the dust
and not allow it to recirculate during this use. (MICRO FRESH filter pads
optional.)
When you finish usingyour Royal tank as a blower, unplug your tank and
reconnect the hose to the front end bell for vacuum cleaning.
OPTIONAL ACCESSORIES
When you need replacement parts or are ready to expand your Tank
Cleaning System, consult an authorized Royal Dealer.
Cloth Bag
.......................................... 2-041140-000
Packageof 3 Paper Bags
............................ 3-040447-001
Packageof 10 Paper Bags
........................... 3-041147-001
Package of 3 High Filtration
Paper Bags and 1 MICRO FRESH Filter Pad
.......... 3-467130-001
MICRO FRESH Filter Pad
............................ 1-460030-001
NOTE: Registeryour cleaner to validate warranty.

WARRANTY
RoyalAppliance Mfg. Co. warrants this Royalvacuum cleanerto befree
from defectsin material and workmanship. The periodof the warranty is a
LIFETIMEon the housingand a limitednumber of years (statedon original
carton)on all other components (except two years on the hoseassembly,
accessory tools, and on the power nozzle), depending on model pur-
chased. The warranty commencesuponthe date of originalpurchaseand
receipt of your warranty card.
If the vacuum cleaner should become defective within the warranty
period, completeservice(parts and labor)will be providedfree of charge:
1) at the store where the machine was purchased, if the store is an
AUTHORIZED DEALER and WARRANTY STATION.
2) by RoyalAppliance Mfg. Co. if the store, where the machine was
purchased, is an AUTHORIZED DEALER.
Intheevent of achangeinthe purchaser'sresidenceof
50 or moremiles
from residenceat time of purchasefrom an AUTHORIZED DEALER, such
service will be provided by the nearest warranty station.
This warranty does not cover the following:
1) Parts that normally require replacement such as belts, bags,
brushes. and bulbs.
2) Failure, loss, or deteriorationduetoordinarywear andtear or from
misuse or unauthorized repair.
3) Machines used for other than normal personal, family, or house-
hold purposes.
4) Costs of any transportationto and from any place of repair, all of
which costs are to be paid by the owner.
This warranty gives you specific legal rights and you may also have
other rights which may vary from state to state.

Model No. I I
PLEASE ENTER SERIAL NO.
s
NO.