Samsung SYNCM.400B User manual

SERVICE MANUAL
SAMSUNG SYNCM.400B
MODEL

CKA42*7L/5227L 2-1
2 Product Specifications
2-1 Specifications
Picture Tube: CKA42*7L: 14-Inch (36 cm); 13.2-Inch (33.5 cm) viewable, 90° Deflection,
CKA5227L: 15-Inch (38 cm); 13.8-Inch (35 cm) viewable, flat-face tube, 90° Deflection,
0.28 mm Dot pitch, Semi-tint, Non-glare, Antistatic silica coating, Invar shadow mask
Scanning Frequency Horizontal : 30 kHz to 55 kHz (Automatic)
Vertical : 50 Hz to 120 Hz (Automatic)
Display Colors Unlimited colors
Maximum Resolution Horizontal : 1024 Dots
Vertical : 768 Lines
Input Video Signal Analog, 0.714 Vp-p positive at 75 Ω, internally terminated
Input Sync Signal Separate Sync : TTL level positive/negative
Maximum Pixel Clock 65 MHz
Active Display CKA42*7L CKA5227L
Horizontal 255 mm ± 3 mm (4:3 ratio) 267 mm ± 3 mm (4:3 ratio)
Vertical 191 mm ± 3 mm 200 mm ± 3 mm
Input Voltage AC 90 to 264 Volts, 60 Hz/50 Hz ± 3 Hz
Power Consumption 73 Watt (max)
Dimensions CKA42*7L CKA5227L
Unit (W x D x H) 13.7 x 15.2 x 14.3 Inches (348 x 385 x 362.5 mm) 14.6 x 15.6 x 14.8 Inches (370 x 395 x 377 mm)
Carton (W x D x H) 16.6 x 18.1 x 15.4 Inches (422 x 460 x 390 mm) 17.9 x 19.6 x 17.0 Inches (454 x 497 x 433 mm)
Weight (Net/Gross) CKA42*7L : 23.1 lbs (10.5 kg) / 27.3 lbs (12.4 kg)
CKA5227L : 27.6 lbs (12.5 kg) / 30.9 lbs (14.0 kg)
Environmental Considerations Operating Temperature : 32°F to 104°F (0°C to 40°C)
Humidity : 10 % to 80 %
Storage Temperature : -4°F to 113°F (-20°C to 45°C)
Humidity : 5 % to 95 %
CRT Code No.
• CKA42*7L/5227L complies with SWEDAC (MPR II) recommendations for reduced electromagnetic fields.
• Designs and specifications are subject to change without prior notice.
Item Description

2 Product Specifications
2-2 CKA42*7L/5227L
2-2 Pin Assignments
Sync
Type
Pin No.
15-Pin Signal Cable Connector (Figure 2-1)
Separate
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Red
Green
Blue
GND
DDC Return
GND-R
GND-G
GND-B
Reserved
GND-Sync/Self-raster
GND
DDC Data
H-Sync
V-Sync
DDC Clock
5
15
Figure 2-1. Male Type

2 Product Specifications
CKA42*7L/5227L 2-3
fH (kHz)
A µsec
B µsec
C µsec
D µsec
E µsec
fV (Hz)
O msec
P msec
Q msec
R msec
S msec
Clock
Frequency
(MHz)
Polarity
H.Sync
V.Sync
Remark
IBM VESA
800/85 Hz
800 x 600 1024/60 Hz 1024 x 768
640/60 Hz
640 x 480
720/70 Hz
720 x 400
31.469
31.777
3.813
1.907
25.422
0.636
70.087
14.268
0.064
1.080
12.711
0.413
28.322
Negative
Positive
Separate
31.469
31.778
3.813
1.907
25.422
0.636
59.940
16.683
0.064
1.048
15.253
0.318
25.175
Negative
Negative
Separate
37.500
26.667
2.032
3.810
20.317
0.508
75.000
13.333
0.080
0.427
12.800
0.027
31.500
Negative
Negative
Separate
43.269
23.111
1.556
2.222
17.778
1.556
85.008
11.764
0.069
0.578
11.093
0.023
36.000
Negative
Negative
Separate
46.875
21.333
1.616
3.232
16.162
0.323
75.000
13.333
0.064
0.448
12.800
0.021
49.500
Positive
Positive
Separate
53.674
18.631
1.138
2.702
14.222
0.569
85.061
11.756
0.056
0.503
11.179
0.019
56.250
Positive
Positive
Separate
48.363
20.677
2.092
2.462
15.754
0.369
60.004
16.666
0.124
0.600
15.880
0.062
65.000
Negative
Negative
Separate
800/75 Hz
800 x 600
640/75 Hz
640 x 480 640/85 Hz 640 x 480
2-3 Timing Chart
This section of the service manual describes the timing that the computer industry recognizes as standard
for computer-generated video signals.
QRS
P
O
Video
Sync Sync
Horizontal Vertical
CDE
P
O
B
A
Video
Sync Sync
Separate Sync
Table 2-1. Timing Chart
Mode
Timing
C D
AO
E
BP
Video
Sync Sync
Video
Q R S
A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width
C : Back porch D : Active time Q : Back porch R : Active time
E : Front porch S : Front porch
VIDEO
A
BO
P
QRS
Horizontal Vertical
H/V Composite Sync

Memo
2 Product Specifications
2-4 CKA42*7L/5227L

BD101 306 167.8 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD102 252 157.5 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD103 252.5 230 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD104 254 197 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD105 302.8 154.5 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD401 32.5 157 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD402 134.8 198.5 3301-000012 CORE-FERRITE BEAD AA,3.5x1x9mm,1000,3000G
BD403 73 146.8 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD404 128 208 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD502 98.5 136.8 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD602 175.8 90.5 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD603 222.3 41 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD604 180 72 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD605 279.5 49.3 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD608 296.5 31 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD609 190 121.5 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD610 318 36 3301-000011 MAG-CORE,FERRITE,BEAD 1.2UH,3.5_5.7MM,10 OHM
BD611 220.3 44 3301-000012 CORE-FERRITE BEAD AA,3.5x1x9mm,1000,3000G
C101B 300.8 137 2401-000028 C-AL 10uF,20%,50V,GP,5x11mm,5mm,TP
C101G 294.8 137 2401-000028 C-AL 10uF,20%,50V,GP,5x11mm,5mm,TP
C101R 278.3 137 2401-000028 C-AL 10uF,20%,50V,GP,5x11mm,5mm,TP
C102B 317.8 142.5 2202-002008 C-CERAMIC,MLC-AXIAL 10nF,+80-20%,50V,Y5V,2.3X3.0
C102G 317.8 148 2202-002008 C-CERAMIC,MLC-AXIAL 10nF,+80-20%,50V,Y5V,2.3X3.0
C102R 317.8 153.5 2202-002008 C-CERAMIC,MLC-AXIAL 10nF,+80-20%,50V,Y5V,2.3X3.0
C103B 294.3 205.5 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C103G 284 205.5 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C103R 304 232.5 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C104B 318.5 187 2401-000043 C-AL 1uF,20%,160V,GP,6.3x11mm,5mm,T
C104G 317 202 2401-000043 C-AL 1uF,20%,160V,GP,6.3x11mm,5mm,T
C104R 316.5 220.8 2401-000043 C-AL 1uF,20%,160V,GP,6.3x11mm,5mm,T
C110 253.3 222 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C111 252.5 237.5 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C112 249.5 186.5 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C113 249.8 201.3 2401-000033 C-AL 100uF,20%,100V,GP,13x20mm,5mm
C114 269.8 153 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C115 280.8 153 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C116 285 157.5 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C117 275.3 153 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C118 316 164 2201-000526 C-CERAMIC,DISC 4.7nF,10%,1KV,Y5P,5x4,10,BK
C119 265 166.5 2201-000019 CAP-CERAMIC,103Z,2H,DISC 10NF,500V,80-20%,Y5V,RADIAL
C120 296.5 152 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C121 289 152 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C122 306 154.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C123 282.8 138.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C124 287 137 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C125 253.5 191 2201-000021 C-CERAMIC,DISC 100nF,+80-20%,50V,Y5V,8x3,5,TP
C126 263.5 145.3 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
!
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-3
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks
10-1-3 Main PCB Parts

C127 305.3 141.5 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C129 266.5 146 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C201 36 41 2401-001166 CAP-AL.ELEC,336M,1C (T)16V 33M
C202 36.3 27 2202-002008 C-CERAMIC,MLC-AXIAL 10nF,+80-20%,50V,Y5V,2.3X3.0
C203 30 71 2201-000017 C-CERAMIC,DISC 1nF,10%,50V,Y5P,4x3.5,5,TP
C204 30 67.5 2201-000146 C-CERAMIC,DISC 100pF,5%,50V,SL,5x3.5,5,TP
C205 46.8 36.5 2201-000011 C-CERAMIC,DISC 47pF,5%,50V,NPO,6.5x3.0,5,TP
C206 41.8 36.5 2201-000011 C-CERAMIC,DISC 47pF,5%,50V,NPO,6.5x3.0,5,TP
C207 19 47.3 2401-000050 C-AL 10uF,20%,16V,GP,5x11mm,2mm,TP
C208 28 31.3 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C209 19 40 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C210 71.8 43 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C211 75 43 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C212 79.5 64.5 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C213 43.8 17 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C214 66 14.5 2401-000050 C-AL 10uF,20%,16V,GP,5x11mm,2mm,TP
C215 68.5 17 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C216 71 108.5 2401-000050 C-AL 10uF,20%,16V,GP,5x11mm,2mm,TP
C217 65 109.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C219 210.5 102.3 2201-000011 C-CERAMIC,DISC 47pF,5%,50V,NPO,6.5x3.0,5,TP
C220 77.8 85.8 2401-000050 C-AL 10uF,20%,16V,GP,5x11mm,2mm,TP
C221 14 57.3 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C222 41.5 88.3 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C301 109 89.5 2305-001009 C-FILM,MPEF 39nF,5%,250V,13x9x4.5mm,7.5mm
C304 107 74 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C305 106.5 41.8 2305-000280 CAP-MPETP,224K,1J,5P (T)63V 224K
C306 141 22.8 2401-000037 CAP-AL.ELEC,477M,1 (T)470UF,16V,20%C,8x11.5,R-RADIAL
C307 106 66.3 2401-000849 CAP-AL.ELEC,227M,1V (T)35V 220M
C308 126 10.5 2401-000037 CAP-AL.ELEC,477M,1C (T)470UF,16V,20%C,8x11.5,R-RADIAL
C309 102.5 54 2201-000013 C-CERAMIC,DISC 470pF,10%,50V,Y5P,4x3.5,5,TP
C310 106.5 56 2301-000228 C-FILM,PEF 3.3nF,10%,100V,5.8x12.5mm,5mm
C311 101.5 47.8 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C312 92.8 19.5 2305-000001 C-FILM,MPEF 470nF,10%,63V,6.0X15.5X7.5,5mm
C313 125.5 27 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C314 130 44.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C401 52 138.5 2401-000027 C-AL 4.7uF,20%,50V,GP,5x11mm,5mm,TP
C403 52 130 2301-000015 C-FILM,PEF 10nF,5%,100V,7x3.2x7mm,5mm,TP
C404 63 142.3 2401-000031 C-AL 47uF,20%,16V,GP,6.3x11mm,5mm,T
C405 63.5 134.3 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C406 56.3 137.3 2301-000257 C-FILM,PEF 4.7nF,10%,100V,5.8x12.5mm,5mm
C407 69 142.5 2201-000471 C-CERAMIC,DISC 330pF,10%,50V,Y5P,4x3.5,5,TP
C408 43.8 138 2301-000016 C-FILM,PEF 22nF,5%,100V,7.2x4.5x9.0mm,5mm
C409 53.3 143 2202-002026 C-CERAMIC,MLC-RADIAL 1nF,5%,50V,X7R,TP,5.1x6.4x3.2
C410 83.8 224.3 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,8.5x5MM,5,TP
C411 100.5 229.8 2401-000876 CAP-AL.ELEC,227M,1H (T)50V 220M
C412 83 199 2401-000048 CAP-AL.ELEC,476M,1E (T)25V 47M
C413 62.8 178.5 2301-000012 CAP-MYLAR,222J,2A,5P (T)100V 222J
10 PCB Diagrams and Electrical Parts List
10-4 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

C414 108 236 2303-000305 C-FILM,PPF 3nF,5%,1.6KV,29x13.5x8mm,25mm
C415 114.5 236 2303-000305 C-FILM,PPF 3nF,5%,1.6KV,29x13.5x8mm,25mm
C416 62 230.5 2305-000179 C-FILM,MPEF 10nF,5%,250V,14.5x8.8mm,10mm,B
C417 132.8 229 2301-000133 C-FILM,PEF 10nF,10%,100V,6.5x12.5mm,5mm,T
C420 48 180.5 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C421 75 137.5 2201-000643 C-CERAMIC,DISC 680pF,10%,50V,Y5P,4x3.5,5,TP
C422 43 218 2306-000171 C-FILM, MPPF 270nF,5%,250V,21.5x12.5mm,7.5mm 14”
2306-000137 C-FILM, MPPF 180nF,5%,250V,19x16.5x8mm,7.5mm 15” SDD
2306-000171 C-FILM, MPPF 270nF,5%,250V,21.5x12.5mm,7.5mm 15” Philips
C423 53.5 211 2306-000007 C-FILM,MPPF 470nF,5%,250V,26.5x14mm,22.5mm 15” Philips
2306-000249 C-FILM,MPPF 680nF,5%,250V,26x20.5x12mm,20mm 14”
2306-000197 C-FILM,MPPF 390nF,5%,250V,20x19x12mm,17.5mm 15” SDD
C424 33.5 211 2306-000234 C-FILM,MPPF 560nF,5%,250V,26.5x15mm,22.5mm 15” Philips
2306-000249 C-FILM,MPPF 680nF,5%,250V,26x20.5x12mm,20mm 14”
2301-001159 C-FILM,MPPF 540nF,5%,250V 15” SDD
C425 33 161.5 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C426 36.5 163 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C427 60 167.5 2301-000168 C-FILM,PEF 150nF,5%,100V,11.5x19mm,7.5mm
C428 26 222.5 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C429 15.5 222.5 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C430 61.5 161.5 2305-000001 C-FILM,MPEF 470nF,10%,63V,6.0X15.5X7.5,5mm
C431 33 168.8 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C432 39.5 163 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C433 69.5 169 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C434 73.5 168.8 2401-001509 C-AL 47uF,20%,16V,GP,6.3x7mm,2.5mm
C435 152.5 117 2401-001012 C-ALUMINUM 3.3UF,20%,50V,BP,16+26.7,7.5mm,T
C436 129 188 2303-001029 C-FILM,PPF 5.2nF,5%,630V,19x7x13,7.5,TP
C437 155.5 147 2301-000012 CAP-MYLAR,222J,2A,5P (T)100V 222J
C439 154 137.8 2201-000010 CAP-CERAMIC,330J,1H,NPO 33PF,50V,5%,NPOPPM,NPO,DISC
C440 80.5 134.5 2301-000016 C-FILM,PEF 22nF,5%,100V,7.2x4.5x9.0mm,5mm
C441 185 135.5 2301-000012 CAP-MYLAR,222J,2A,5P (T)100V 222J
C442 84 116 2201-000326 C-CERAMIC,DISC 2.2nF,10%,50V,Y5P,6.3X3.0,5,TP
C443 36 141.5 2301-000016 C-FILM,PEF 22nF,5%,100V,7.2x4.5x9.0mm,5mm
C445 50.8 171.8 2401-000050 C-AL 10uF,20%,16V,GP,5x11mm,2mm,TP
C501 92.5 168.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C502 98.8 150 2401-000966 C-AL 22uF,20%,50V,GP,6.3x11mm,5mm,T
C503 170.5 119.5 2305-000004 C-FILM,MPEF 220nF,10%,100V,12.7x16,5mm,TP
C504 85.5 174.5 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C505 170.5 126 2305-000004 C-FILM,MPEF 220nF,10%,100V,12.7x16,5mm,TP
C507 219 205.3 2201-000017 C-CERAMIC,DISC 1nF,10%,50V,Y5P,4x3.5,5,TP
C508 207.5 144.5 2401-000046 CAP-AL.ELEC,106M,2E (T)250V 10M
C509 203.5 241 2401-001334 C-AL 470nF,20%,50V,GP,5x11mm,2mm,TP
C511 117.5 149 2201-000469 C-CERAMIC,DISC 330pF,10%,500V,Y5P,6x3.5,5,TP
C512 130 137.5 2306-000007 C-FILM,MPPF 470nF,5%,250V,26.5x14mm,22.5mm
C515 186.8 125.8 2201-000017 C-CERAMIC,DISC 1nF,10%,50V,Y5P,4x3.5,5,TP
C516 186.8 129.5 2201-000471 C-CERAMIC,DISC 330pF,10%,50V,Y5P,4x3.5,5,TP
C517 140 91 2401-000033 C-AL 100uF,20%,100V,GP,13x20mm,5mm
!
!
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-5
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

C518 175 139 2401-000027 C-AL 4.7uF,20%,50V,GP,5x11mm,5mm,TP
C519 235.3 162.3 2401-000010 C-AL 220uF,20%,16V,GP,6.3x11mm,2.5m
C520 215.5 224.8 2202-002008 C-CERAMIC,MLC-AXIAL 10nF,+80-20%,50V,Y5V,2.3X3.0
C601 60 11 2401-000037 CAP-AL.ELEC,477M,1C (T)470UF,16V,20%C,8x11.5,R-RADIAL
C602 51 18.3 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C604 282.5 45.3 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C605 269 45.3 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C606 267.5 36.5 2501-000203 CAP-MPAPER,474K,250VAC 470NF,250VAC,10%,X2,RE-RAD
C607 296.3 16.5 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C608 290 19 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C610 168 14 2301-000012 CAP-MYLAR,222J,2A,5P (T)100V 222J
C611 177.5 24 2301-000287 CAP-MYLAR,562J,2A,5P (T)100V 562J
C612 163.5 83.5 2401-000033 C-AL 100uF,20%,100V,GP,13x20mm,5mm
C613 226 15.5 2301-000018 C-FILM,PEF 47nF,5%,100V,8.5x12.5mm,5mm,TP
C614 220.5 15.5 2305-000004 C-FILM,MPEF 220nF,10%,100V,12.7x16,5mm,TP
C615 162.5 23 2401-000039 CAP-AL.ELEC,108M.1C,10x16 (T)1000UF,16V,20%,R-RADIAL
C616 169.5 28 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C617 245.8 91.8 2401-000052 CAP-AL.ELE,227M,2G,30X35 (B)220UF,400V,20%,R-RADIAL
C618 255.8 16.6 2201-000020 C-CERAMIC,DISC 10nF,10%,1KV,Y5P,20x5,10,BK
C619 150 28.5 2201-000016 C-CERAMIC,DISC 2.2nF,10%,500V,Y5P,8x4,5,TP
C620 147 37.5 2401-000033 C-AL 100uF,20%,100V,GP,13x20mm,5mm
C621 162.5 59.5 2201-000291 C-CERAMIC,DISC 1nF,10%,500V,Y5P,8.5x5MM,5,TP
C622 160 68 2401-000038 C-AL 470uF,20%,25V,GP,10x12.5mm,5mm
C623 251.5 64 2401-001195 CAP-AL.ELEC,336M,1H (T)50V 33M
C624 251.8 48.5 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C625 251.5 36.8 2201-000365 C-CERAMIC,DISC 220pF,10%,2KV,Y5P,6.3X3.0,5,TP
C626 233.3 72.3 2401-000023 CAP-AL.ELEC,105M,1H (T)50V 1M
C627 176 52.5 2401-000039 CAP-AL.ELEC,108M.1C,10x16 (T)1000UF,16V,20%,R-RADIAL
C628 28.3 177.3 2202-002009 C-CERAMIC,MLC-AXIAL 100nF,+80-20%,50V,Y5V,2.3X3.0
C629 48 187.3 2401-000042 C-AL 100uF,20%,16V,GP,6.3x7mm,2.5mm
C630 202.8 72 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C631 196.5 79.3 2201-000024 C-CERAMIC,DISC 4.7nF,20%,250VAC,Y5U,16x7,7.5
C632 159.5 41.5 2401-000039 CAP-AL.ELEC,108M.1C,10x16 (T)1000UF,16V,20%,R-RADIAL
C633 147.5 59.5 2401-000031 C-AL 47uF,20%,16V,GP,6.3x11mm,5mm,T
C634 219.5 71 2301-000010 CAP-MYLAR,104J,2A,5P (T)100V 104J
C636 168 47 2201-000469 C-CERAMIC,DISC 330pF,10%,500V,Y5P,6x3.5,5,TP
CN101 247 134 3711-003240 CONNECTOR-HEADER BOX,15P,1R,2.5mm,STRAIGHT,SN
CN102 265 179.5 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN103 323 165 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN201 224 115.8 3711-003594 CONNECTOR-HEADER BOX,13P,1R,2mm,STRAIGHT,SN
CN202 224 124.3 3711-003240 CONNECTOR-HEADER BOX,15P,1R,2.5mm,STRAIGHT,SN
CN301 118.5 184.5 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN302 118.5 176.5 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN303 91.5 13.5 3711-000024 CONNECTOR-HEADER BOX,3P,1R,2.5mm,STRAIGHT,SN
CN502 118.5 203 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN503 118.5 192.5 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN504 185 238 3711-000024 CONNECTOR-HEADER BOX,3P,1R,2.5mm,STRAIGHT,SN
!
!
!
!
!
!
10 PCB Diagrams and Electrical Parts List
10-6 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

CN601 305 97 3711-000217 CON-WALL HEADER,3P,3.96 STRAIGHT,1WALL
CN602 272.5 77 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN603 265 77 BH71-40300A PIN-HINGE BRASS,D2.36,SN,HEAT/SINK
CN604 311.5 74.8 3722-001100 JACK-DIN 4P/2C,6mm,AG,BLK,NO
CN606 300.3 82 3711-000178 CONNECTOR-HEADER 1WALL,2P,1R,3.96mm,STRAIGHT,SN
CRT1 282.8 188 BH03-10301G CRT,COLOR,14 M34KUK35X01
D101 258.5 153 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D101B 274 219.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D101G 269 219.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D101R 266.5 219.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D102B 281.5 230.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D102G 286.5 230.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D102R 291.5 230.5 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D103B 313.5 194 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D103G 312 210.3 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D103R 313.3 230.8 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D205 228.5 130 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D206 231 130 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D207 233.5 130 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D208 237.5 126.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D209 237.5 124 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D210 237.5 121.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D211 214.5 109.5 0403-000005 DIODE-ZEN,UZ-5.1B,DO-35 0.5W,10MA
D213 227.5 107 0403-000005 DIODE-ZEN,UZ-5.1B,DO-35 0.5W,10MA
D214 259.5 117.3 0403-000005 DIODE-ZEN,UZ-5.1B,DO-35 0.5W,10MA
D215 259.5 114.8 0403-000005 DIODE-ZEN,UZ-5.1B,DO-35 0.5W,10MA
D216 66.5 134.3 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D301 130.5 41 0402-000128 DIODE-REC,1N4002,DO-41 70V,1A,1.1V,1A,2000NS,0.5A
D401 80 230 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D402 72.5 232.1 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D403 135.5 207.8 0404-000001 DIODE-SCHOTTKY FMP-G2FS,1500V,5A,TO-220,ST
D404 66.5 221.3 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D405 71.3 178.8 0402-000128 DIODE-REC,1N4002,DO-41 70V,1A,1.1V,1A,2000NS,0.5A
D406 26.5 206 0402-000006 DIODE-RECTIFIER 1N4007GP,1000V,1A,DO-41
D407 16 206 0402-000006 DIODE-RECTIFIER 1N4007GP,1000V,1A,DO-41
D408 121 232 0402-001112 DIODE-RECTIFIER MDV04-600,600V,4A,DO201,BK
D409 127.3 234.3 0402-001025 DIODE-RECTIFIER ERD07-15,1500V,1.5A
D410 40.5 139 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D411 61 188.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D412 61 134.3 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D413 58.5 126.3 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D414 138.5 186.5 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D418 58.3 206.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D501 116 133.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D502 187 120.3 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D503 187 122.8 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D507 213 155.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-7
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

D509 210.5 155.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D510 225.8 173.8 0402-000006 DIODE-RECTIFIER 1N4007GP,1000V,1A,DO-41
D513 212.8 137.8 0401-000006 DIODE-SWITCHING BAV21,200V,250mA,400mW,50nS,DO
D514 176.5 232.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D515 118.5 152.5 0402-000014 DIODE-RECTIFIER RG2,400V,1.2A,DO-201
D516 197 135 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D517 190 125 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D518 203.5 231.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D519 95 157.8 0403-000337 DIODE-ZENER UZ24BH,24V,24.2-25.7V,500mW,DO
D602 286 117 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D603 220.5 18.5 0403-000351 AM DIODE-ZEN,UZ-4.7B ST 02169-403-420
D604 292.3 79 0402-000008 DIODE-REC,1N5399GP,DO-15 1000V,1.4V,1.5A,2US
D605 260 58 0402-000008 DIODE-REC,1N5399GP,DO-15 1000V,1.4V,1.5A,2US
D606 260 51.3 0402-000008 DIODE-REC,1N5399GP,DO-15 1000V,1.4V,1.5A,2US
D607 288 74.8 0402-000008 DIODE-REC,1N5399GP,DO-15 1000V,1.4V,1.5A,2US
D608 173 28 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D609 271 64 0402-000008 DIODE-REC,1N5399GP,DO-15 1000V,1.4V,1.5A,2US
D610 169.5 31.5 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D611 185 31.5 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D612 186 68.3 0402-000005 DIODE-RECTIFIER 31DF4,400V,3A,DO-201AD
D613 222.3 33.8 0402-000017 DIODE-RECTIFIER RGP02-12,1200V,0.5A,DO-204AL
D614 222.5 53 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
D615 186 62.8 0402-000005 DIODE-RECTIFIER 31DF4,400V,3A,DO-201AD
D616 185.5 36.5 0402-000014 DIODE-RECTIFIER RG2,400V,1.2A,DO-201
D617 182.5 41.5 0402-000247 DIODE-RECTIFIER RG2Y,70V,1.5A,DO-201
D618 231 79.5 0401-000005 DIODE-SIG,1N4148,DO-35 75V,150MA,1V,10MA
D619 256.8 44.8 0402-000017 DIODE-RECTIFIER RGP02-12,1200V,0.5A,DO-204AL
D620 167 57.5 0402-000007 DIODE-REC,1N4937,DO-41 420V,1A,1.2V,1A,200NS,1A
EY101 298.4 229.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY102 247.6 229.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY103 247.6 211.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY104 298.4 211.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY14 303.3 36 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY301 114.4 23.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY302 132.6 23.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY401 108 236 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY402 114.5 236 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY403 33.5 211 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY404 53.5 211 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY405 134.3 168.8 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY406 92.5 220.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY501 150 150.9 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY502 198 150.9 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY503 223.4 231.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY504 146.5 236.9 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY505 176.8 166.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY506 202.3 182.8 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
10 PCB Diagrams and Electrical Parts List
10-8 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

EY507 176.7 195.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY508 188 166.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY509 135.5 202.7 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY510 110.5 117.3 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY511 197.5 204.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY512 175.5 204.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY601 217.5 31.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY602 192.5 56.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY603 192.5 36.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY604 217.5 46.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY605 225 67.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY606 132.6 70.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY607 143 127.5 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY608 243.2 67.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY609 114.4 70.6 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY610 225 20.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY611 278.5 27 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY612 243.2 20.4 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY613 292.3 55.8 6042-000002 EYELET EYELET 1.5 HOLE 2.2 PAD 4.0
EY614 245.8 91.8 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
EY615 245.8 81.8 6042-000001 EYELET EYELET 2.2 HOLE 3.0 PAD 5.0
FG601 295 10 3601-000004 FUSE-FERRULE 250V,3.15A,SLOW BLOW,CERAMIC,5
FH601 305.3 9.8 3602-000001 FUSE-CLIP,5.2X20,30MOHM 800GF,400-800GF
HS102 BH62-30410A HEAT/SINK A6063S,T2.5
HS301 BH62-30411A HEAT/SINK A6063S,T2.0
HS501 BH62-30417A HEAT/SINK-FBT A1050S,T1.0,CKA42*7/5227
HS508 BH62-30015A HEAT/SINK-TR SCP-1,T1,SN
HS602 BH62-30411A HEAT/SINK A6063S,T2.0
IC101 274.5 141 1201-001184 IC-VIDEO AMP 2141,DIP,20P,300MIL,SINGLE,P
IC102 281.5 241 1204-000010 IC-CHANNEL SELECTOR LM2406,T0-220,11P,PLASTIC,85
IC201 38 32 1203-001274 IC-VOL. DETECTOR 7545,TO-92,3P,PLASTIC,4.35/4
IC202 34 48.5 BH09-10303T IC-MICOM MASKING CKA,LSC442839B,SYNC-PROCESSOR
IC203 80 19.5 1103-001020 IC-EEPROM 24LC04,4Kx8BIT,DIP,8P,300MIL
IC204 63.5 122 1103-001009 IC-EEPROM 24LC21,128X8BIT,DIP,8P,300MIL
IC301 112 50.8 1204-000013 IC-VERTICAL PROCESSO TDA9302H,TO-220,9P,PLASTIC,3
IC302 92.5 25.5 1201-001034 IC-AMPLIFIER L272M,DIP,8P,28V,1A,1W,STICK
IC401 40 146.8 1204-001231 IC-DEF. PROCESSOR TDA9109,DIP,32P,300MIL,PLASTIC
IC601 183 9.5 1203-000002 IC-LIN,431,REGULATOR TO-92,3,36V(T)-SIMPLE
IC602 246 38 BH13-10334H IC G-PROJECT, KA2H0880, SIP, 5P, FET
IC603 73.8 8 1203-000001 IC-POSI.ADJUST REG. 7805,TO-220,3P,PLASTIC,4.8/5
IC604 31 177.5 1203-000165 IC-LIN,KA78R12,REGULATOR TO-220,4,5V
IS601 303.3 29 3721-001006 PLUG-AC POWER 3P,10/24mm,SN
J14 BH39-40305U JUMPER-WIRE JUMPER-WIRE 14”
J15 BH39-40305U JUMPER-WIRE JUMPER-WIRE 15” SDD
JP209 BH39-40305U JUMPER-WIRE JUMPER-WIRE 14”
L101B 287 200.8 2701-001036 INDUCTOR-AXIAL 1.2uH,10%,9.8x4.2mm
L101G 274.3 206.5 2701-001036 INDUCTOR-AXIAL 1.2uH,10%,9.8x4.2mm
!
!
!
!
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-9
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

L101R 303.8 227.5 2701-001036 INDUCTOR-AXIAL 1.2uH,10%,9.8x4.2mm
L401 92.5 220.5 BH27-20003A COIL-LINEARITY 0.06OHM,0.15,DR-1415,IVORY,35M 15” Philips
BH27-20309T COIL-LINEARITY 0.06OHM,16.5*16.5*30 14”
BH27-20334K COIL-LINEARITY 6.2UH 15” SDD
L402 143 138.5 BH27-20343L COIL-CHOKE 170UH,10%,DR14*20,BULK
L403 44.3 119.5 2701-000154 INDUCTOR-AXIAL 220uH,10%,4.2x9.8mm
L501 110.5 117.3 BH27-20342V COIL-CHOKE 200UH,15%,DR14*20,BULK
L502 66.3 210 BH27-20342U COIL-CHOKE 7.1MH,10%,DR8*11,BULK
L503 194.3 119.5 2701-000154 INDUCTOR-AXIAL 220uH,10%,4.2x9.8mm
L601 279.8 55.8 BH27-20022A COIL-LINE FILTER 0.3OHM,-,B,1UEW0.40,5T,3
L602 266 27 BH26-30008A TRANS-LINE FILTER 15MH,8P,EE,SB-5S,15MH,EE-222
OP201 14.3 31.8 0601-001147 LED ROUND,GRN,4.75mm,565nm
OP601 199.5 17.5 0604-001018 PHOTO-COUPLER DAR-TR,63-125%,200mW,DIP-4,ST
Q101 244.5 172.8 0501-000412 TR-SMALL SIGNAL KSP42,NPN,625mW,TO-92,40
Q102 251.5 180.3 0501-000277 TR-SMALL SIGNAL KSA1013-Y,PNP,-900mW,TO-92L,TP
Q201 16 12 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q202 70.5 120 0501-000122 TR-NPN,2N3904,TO-92,EBC 0.625W,60V,40V,6V,0.2A
Q203 35.5 88.5 0501-000303 TR-SMALL SIGNAL KSA733-Y,PNP,250mW,TO-92,120
Q301 100.5 84.8 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q402 134.3 174.3 0502-001001 TR-POWER KSC5088,NPN,1500V,1500V,8A,50W
Q403 68.5 198 0501-000369 TR-NPN,KSC2331,TO-92L,ECB
Q404 23 229.5 0505-000011 FET-N,IRF630,TO-220,GDS 75W,200V,9A
Q405 15 228.8 0505-001102 FET-SILICON IRFR/U230A,N,200V,7.5A,400mohm
Q406 44.5 198.5 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q407 55.5 200.3 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q408 158.5 130 0501-000303 TR-SMALL SIGNAL KSA733-Y,PNP,250mW,TO-92,120
Q409 163 134.5 0501-000303 TR-SMALL SIGNAL KSA733-Y,PNP,250mW,TO-92,120
Q410 171.8 148.8 0503-000001 TR-DARLINGTON KSE800, NPN,60V,60V,4A,40W,TO-126
Q413 77 198 0501-000369 TR-NPN,KSC2331,TO-92L,ECB
Q501 207.5 226.5 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q502 214 227.5 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q504 169.5 134.5 0501-000143 TR-SMALL SIGNAL 2N6520,PNP,625mW,TO-92,30-20
Q506 219 222 0501-000303 TR-SMALL SIGNAL KSA733-Y,PNP,250mW,TO-92,120
Q507 101.5 180 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q508 109.3 150 0505-000011 FET-N,IRF630,TO-220,GDS 75W,200V,9A
Q509 101.5 174 0501-000303 TR-SMALL SIGNAL KSA733-Y,PNP,250mW,TO-92,120
Q510 201.5 132.5 0501-000492 TR-SMALL SIGNAL MPS3646,NPN,625mW,TO-92,30-1
Q601 277.5 115.5 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
Q602 36 199 0501-000122 TR-NPN,2N3904,TO-92,EBC 0.625W,60V,40V,6V,0.2A
Q603 143.5 67.5 0502-000249 TR-POWER KSB772-Y,PNP,10W,TO-126,160-
Q604 141.8 77.5 0501-000586 TR-NPN,KSC945,TO-92,EBC 0.25W,60V,50V,5V,0.15A
R100 310.5 127.5 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R101B 311.3 145.3 2001-000089 REF-CF,150K,5%,1/6W 150V,-1300 TO + 350PPM/C,R-
R101G 311.3 150.8 2001-000090 R-CARBON 180Kohm,5%,1/6W,AA,TP,1.8x3.2m
R101R 311.3 156.3 2001-000089 REF-CF,150K,5%,1/6W 150V,-1300 TO + 350PPM/C,R-
R102B 260.5 136.5 2001-000665 R-CARBON 33ohm,5%,1/6W,AA,TP,1.8x3.2mm
R102G 260.5 134 2001-000665 R-CARBON 33ohm,5%,1/6W,AA,TP,1.8x3.2mm
!
!
10 PCB Diagrams and Electrical Parts List
10-10 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

R102R 260.5 131.5 2001-000665 R-CARBON 33ohm,5%,1/6W,AA,TP,1.8x3.2mm
R103B 256.8 138.5 2001-000025 R-CARBON 75ohm,5%,1/4W,AA,TP,2.4x6.4mm
R103G 254 138.5 2001-000025 R-CARBON 75ohm,5%,1/4W,AA,TP,2.4x6.4mm
R103R 251.3 138.5 2001-000025 R-CARBON 75ohm,5%,1/4W,AA,TP,2.4x6.4mm
R104B 279 230.5 2001-000021 R-CARBON 27ohm,5%,1/4W,AA,TP,2.4x6.4mm
R104G 284 230.5 2001-000021 R-CARBON 27ohm,5%,1/4W,AA,TP,2.4x6.4mm
R104R 289 230.5 2001-000021 R-CARBON 27ohm,5%,1/4W,AA,TP,2.4x6.4mm
R105B 287 215 2001-000084 R-CARBON 100Kohm,5%,1/4W,AA,TP,2.4x6.4m
R105G 312 213 2001-000084 R-CARBON 100Kohm,5%,1/4W,AA,TP,2.4x6.4m
R105R 313.3 233.8 2001-000084 R-CARBON 100Kohm,5%,1/4W,AA,TP,2.4x6.4m
R107B 305 201 2001-000028 R-CARBON(S) 100ohm,5%,1/2W,AA,TP,2.4x6.4mm
R107G 263.5 175.3 2001-000028 R-CARBON(S) 100ohm,5%,1/2W,AA,TP,2.4x6.4mm
R107R 310 183 2001-000028 R-CARBON(S) 100ohm,5%,1/2W,AA,TP,2.4x6.4mm
R108B 317.8 176.5 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R108G 323 191.5 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R108R 322.3 225.3 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R109B 314.5 183 2001-000495 R-CARBON 20Kohm,5%,1/4W,AA,TP,2.4x6.4mm
R109G 323 207.5 2001-000495 R-CARBON 20Kohm,5%,1/4W,AA,TP,2.4x6.4mm
R109R 324.3 227.8 2001-000495 R-CARBON 20Kohm,5%,1/4W,AA,TP,2.4x6.4mm
R110 271.5 219.5 2001-001070 R-CARBON(S) 120ohm,5%,1/2W,AA,TP,2.4x6.4mm
R111 270.3 150 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R112 252.3 225.3 2001-000835 R-CARBON 51Kohm,5%,1/4W,AA,TP,2.4x6.4mm
R113 264.5 153 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R114 285 167.3 2001-000511 R-CARBON 220ohm,5%,1/2W,AA,TP,3.3x9mm
R115 255.5 163.3 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R116 267 153 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R117 278 153 2001-000039 R-CARBON 390ohm,5%,1/6W,AA,TP,1.8x3.2mm
R118 272.5 153 2001-000039 R-CARBON 390ohm,5%,1/6W,AA,TP,1.8x3.2mm
R119 294 152 2001-000039 R-CARBON 390ohm,5%,1/6W,AA,TP,1.8x3.2mm
R120 254.8 194 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R121 252 176.8 2001-000090 R-CARBON 180Kohm,5%,1/6W,AA,TP,1.8x3.2m
R122 247 183.5 2001-000077 R-CARBON 47Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R201 69 33 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R202 66.5 33 2001-000077 R-CARBON 47Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R205 59 33 2001-000496 R-CARBON 20Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R206 56.5 33 2001-000496 R-CARBON 20Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R208 27.5 17 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R210 33 17 2001-000035 REF-CF,220,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R212 62.5 86 2001-000562 R-CARBON 27Kohm,5%,1/6W,AA,TP,1.8x3.2mm 15
R213 37.5 67.3 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R214 32.5 67.3 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R215 26.5 36 2001-000108 R-CARBON 18Kohm,5%,1/6W,AA,TP,1.8x3.2mm 15
2001-000069 R-CARBON 12Kohm,5%,1/6W,AA,TP,1.8x3.2mm 14”
R216 80 77.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R217 29 36 2001-000101 R-CARBON 11Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R218 31.5 35.9 2001-000367 R-CARBON 15Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R219 42.5 68 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-11
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

R220 48 39.5 2001-000097 R-CARBON 1Mohm,5%,1/6W,AA,TP,1.8x3.2mm
R221 51.5 33 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R222 54 33 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R223 65 68 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R224 67.5 68 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R225 25 27 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R226 51.3 96.8 2001-000040 R-CARBON 470ohm,5%,1/6W,AA,TP,1.8x3.2mm
R227 44.3 101.5 2001-000077 R-CARBON 47Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R228 46.8 101.5 2001-000077 R-CARBON 47Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R229 32.5 11 2001-000042 R-CARBON 1Kohm,5%,1/4W,AA,TP,2.4x6.4mm
R230 60 109.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R231 54.3 17 2001-000053 R-CARBON 3.3Kohm,5%,1/6W,AA,TP,1.8x3.2m
R232 56.8 17 2001-000053 R-CARBON 3.3Kohm,5%,1/6W,AA,TP,1.8x3.2m
R233 65.8 27 2001-000029 R-CARBON 100ohm,5%,1/6W,AA,TP,1.8x3.2mm
R234 54 109.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R235 61.8 17 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R236 56.5 109.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R237 48.3 25 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R238 59.3 17 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R239 77.5 81 2001-001099 REF-CF,2.7K,5%,1/2W(S 300V,-200 TO +200PPM/C,R-AX
R240 62.5 109.5 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R241 25 119.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R242 25 109.8 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R243 25 107.3 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R244 25 94.8 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R245 37 117 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R246 37 114.5 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R247 37 104.8 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R248 37 102.3 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R249 22.5 116 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R250 22.5 109.3 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R251 22.5 104.5 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R252 13 67 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R253 15 119 2001-000367 R-CARBON 15Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R254 13.5 136.5 2001-000367 R-CARBON 15Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R256 222.5 107 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R257 222.5 104.5 2001-000553 R-CARBON 270ohm,5%,1/6W,AA,TP,1.8x3.2mm
R258 222.5 102 2001-000553 R-CARBON 270ohm,5%,1/6W,AA,TP,1.8x3.2mm
R259 224 98.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R260 247.3 109.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R262 40 67.3 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R264 21.5 20.5 2001-000652 R-CARBON 330ohm,5%,1/6W,AA,TP,1.8x3.2mm
R266 40.8 115.5 2001-000053 R-CARBON 3.3Kohm,5%,1/6W,AA,TP,1.8x3.2m
R267 30.5 27 2001-000072 R-CARBON 22Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R268 17.3 53 2001-000367 R-CARBON 15Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R269 18 74 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R270 45 68 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
10 PCB Diagrams and Electrical Parts List
10-12 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

R271 227.5 109.5 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R301 132 109.7 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R302 94 89.5 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R305 93.5 68 2001-000059 REF-CF,5.6K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R306 93.5 70.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R307 133.5 17.5 2008-000003 R-FUSIBLE 0.22ohm, 5%, 1/2W, AT, TP, 3.5x9.4mm
R308 149.5 11.8 2008-000003 R-FUSIBLE 0.22ohm, 5%, 1/2W, AT, TP, 3.5x9.4mm
R309 125.5 35.5 2001-000245 REF-CF,1.5,5%,1/2W 350V,-350 TO +350PPM/C,R-AX
R310 136.5 75.3 2003-000650 R-METAL OXIDE(S) 330ohm,5%,2W,AA,TP,4x12mm
R311 121.5 55 2004-001022 REF-MF,5.6K,1%,1/4W 250V,-100 TO +100PPM/C,R-AX
R312 121.5 80 2003-000412 R-METAL OXIDE(S) 0.9ohm,5%,2W,AA,TP,4x12mm
R313 101.5 59.5 2001-000069 R-CARBON 12Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R314 101.5 45 2001-000104 R-CARBON 1.2Kohm,5%,1/6W,AA,TP,1.8x3.2m
R315 101.5 50.8 2001-000064 R-CARBON 7.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R316 88 21 2001-000075 R-CARBON 39Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R317 85.5 39.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R318 104.5 28.5 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R319 88 30.5 2001-000064 R-CARBON 7.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R320 100.5 17 2003-000807 R-METAL OXIDE(S) 82ohm,5%,2W,AA,TP,4x12mm
R321 85.5 28 2001-000083 R-CARBON 82Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R322 111.3 84.3 2001-000066 R-CARBON(S) 10Kohm,5%,1/2W,AA,TP,2.4x6.4mm
R401 185.5 132.8 2001-000072 R-CARBON 22Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R403 28.5 144.5 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R404 28.5 147 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R405 72 143 2001-000097 R-CARBON 1Mohm,5%,1/6W,AA,TP,1.8x3.2mm
R406 47.8 128 2004-001136 R-METAL 6.8Kohm,1%,1/4W,AA,TP,2.4x6.4m
R407 81 137.5 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R408 55.8 134.3 2001-000048 REF-CF,2.2K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R409 44.5 163 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R410 78.5 178.8 2003-000587 R-METAL OXIDE(S) 22ohm,5%,1W,AA,TP,3.3x9mm
R412 69.5 221.3 2001-000020 REF-CF,22,5%,1/2W(S 300V,-200 TO +200PPM/C,R-AX
R414 111.3 220.5 2001-000016 R-CARBON(S) 1ohm,5%,1/2W,AA,TP,2.4x6.4mm
R415 135.5 218 2001-000525 R-CARBON 22ohm,5%,1/4W,AA,TP,2.4x6.4mm
R416 75.5 215 2003-000009 R-METAL OXIDE(S) 220ohm,5%,1W,AA,TP,3.3x9mm
R417 68 178.8 2001-001107 REF-CF,220,5%,1/2W(S 300V,-200 TO +200PPM/C,R-AX
R418 58.5 183.5 2001-000404 R-CARBON 180ohm,5%,1/6W,AA,TP,1.8x3.2mm
R419 63.5 198.5 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R420 29.8 192 2001-000048 REF-CF,2.2K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R421 27 192 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R422 19.5 217.1 2001-000097 R-CARBON 1Mohm,5%,1/6W,AA,TP,1.8x3.2mm
R423 9.5 217 2001-000097 R-CARBON 1Mohm,5%,1/6W,AA,TP,1.8x3.2mm
R424 51 179.3 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R425 53.5 179.3 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R427 23 216.9 2001-000076 REF-CF,47K,5%,1/4W 250V,-600 TO -150PPM/C,R-AX
R428 12.5 217 2001-000076 REF-CF,47K,5%,1/4W 250V,-600 TO -150PPM/C,R-AX
R430 163 114 2001-000721 R-CARBON 4.3Kohm,5%,1/4W,AA,TP,2.4x6.4m
R431 168 151.5 2001-000089 REF-CF,150K,5%,1/6W 150V,-1300 TO + 350PPM/C,R-
!
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-13
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

R432 80.5 119.3 2001-000090 R-CARBON 180Kohm,5%,1/6W,AA,TP,1.8x3.2m 15”
2001-000086 R-CARBON 100Kohm,5%,1/6W,AA,TP,1.8x3.2m 14”
R434 166.5 102.8 2001-000538 R-CARBON 24Kohm,5%,1/6W,AA,TP,1.8x3.2mm 15”
2001-000562 R-CARBON 27Kohm,5%,1/6W,AA,TP,1.8x3.2m
R435 163 143.5 2001-000053 R-CARBON 3.3Kohm,5%,1/6W,AA,TP,1.8x3.2m
R436 165.5 143.5 2001-000836 R-CARBON 51Kohm,5%,1/6W,AA,TP,1.8x3.2mm 15”
R437 55.5 161 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R438 74 115 2001-000088 R-CARBON 120Kohm,5%,1/6W,AA,TP,1.8x3.2m
R439 18.8 88 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R440 18.8 90.5 2001-000868 R-CARBON 56ohm,5%,1/6W,AA,TP,1.8x3.2mm
R441 47.5 115 2001-000367 R-CARBON 15Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R442 78 143 2001-000531 R-CARBON 240Kohm,5%,1/8W,AA,TP,1.8x3.2m
R443 75 154.8 2001-000547 R-CARBON 270Kohm,5%,1/6W,AA,TP,1.8x3.2m
R444 216.5 189.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R445 98.3 126.5 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R447 75.1 193.8 2003-000276 R-METAL OXIDE 33ohm,5%,1W,AA,TP,4.3x12mm
R448 131.5 197 2001-000246 R-CARBON 1.5ohm,5%,1/4W,AA,TP,2.4x6.4mm
R502 92.5 165.5 2001-000069 R-CARBON 12Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R503 81.5 160 2001-000079 R-CARBON 56Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R504 198.5 231.5 2001-000562 R-CARBON 27Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R505 210.5 226.5 2001-000104 R-CARBON 1.2Kohm,5%,1/6W,AA,TP,1.8x3.2m
R506 95 153.3 2004-000216 R-METAL 10Kohm,1%,1/4W,AA,TP,2.4x6.4mm
R507 81 140 2001-000075 R-CARBON 39Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R508 95 162.5 2004-000284 R-METAL 12Kohm,1%,1/4W,AA,TP,2.4x6.4mm
R509 82.5 177.5 2004-004095 R-METAL 2.36Kohm,1%,1/4W,AA,TP,2.4x6.4
R510 184.5 230 2001-000836 R-CARBON 51Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R511 219 209 2001-000057 REF-CF,5.1K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R512 180.3 144 2001-000547 R-CARBON 270Kohm,5%,1/6W,AA,TP,1.8x3.2m
R513 227.3 167.3 2008-000106 REF-FUSIBLE,0.56,5%,1/2W -350 TO +350PPM/C,R-AXIAL
R515 158 114 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R516 224 189.5 2001-000688 R-CARBON 390Kohm,5%,1/6W,AA,TP,1.8x3.2m
R518 212.5 211.5 2001-000090 R-CARBON 180Kohm,5%,1/6W,AA,TP,1.8x3.2m
R520 180.3 141.5 2001-000115 R-CARBON 82Kohm,5%,1/4W,AA,TP,2.4x6.4mm
2001-000078 R-CARBON 56Kohm,5%,1/4W,AA,TP,2.4x6.4mm 14” ORION
R521 207.5 156.5 2001-000107 R-CARBON(S) 150Kohm,5%,1/2W,AA,TP,2.4x6.4m
R522 206.5 159 2001-000096 R-CARBON(S) 1Mohm,5%,1/2W,AA,TP,2.4x6.4mm
R523 216 218 2001-000688 R-CARBON 390Kohm,5%,1/6W,AA,TP,1.8x3.2m
R524 213.3 215.5 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R525 212.8 135.3 2001-000100 R-CARBON 2.2Mohm,5%,1/6W,AA,TP,1.8x3.2m
R527 105 182.3 2001-001099 REF-CF,2.7K,5%,1/2W(S 300V,-200 TO +200PPM/C,R-AX
R528 124 167.8 2003-000007 REF-MO,82,5%,3W(S 350V,-350 TO +350PPM/C,R-AX
R529 108 182.3 2001-000110 REF-CF,10,5%,1/4W 250V,-350 TO +350PPM/C,R-AX
R530 102.5 129 2005-000401 R-WIRE WOUND 0.47ohm,5%,2W,AA,TP,4x12mm
R531 122.5 147.5 2003-000386 REF-MO,910,5%,2W 350V,-200 TO +200PPM/C,R-AX
R532 221.5 189.5 2001-000091 R-CARBON 220Kohm,5%,1/6W,AA,TP,1.8x3.2m
R534 74 157.3 2001-000097 R-CARBON 1Mohm,5%,1/6W,AA,TP,1.8x3.2mm
R536 190 130 2001-000048 REF-CF,2.2K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
!
!
!
!
10 PCB Diagrams and Electrical Parts List
10-14 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

R537 190 127.5 2001-000053 R-CARBON 3.3Kohm,5%,1/6W,AA,TP,1.8x3.2m
R538 196 137.5 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R539 201.3 122.5 2001-000069 R-CARBON 12Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R540 190 132.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R542 219.8 143.5 2001-000064 R-CARBON 7.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R543 178.5 138.5 2001-000074 R-CARBON 33Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R544 169.5 115.8 2001-003105 R-CARBON 1ohm,5%,1/6W,AA,TP,1.8x3.2mm
R545 170 122.8 2001-003105 R-CARBON 1ohm,5%,1/6W,AA,TP,1.8x3.2mm
R546 181 226.5 2001-000067 REF-CF,10K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R602 286 114.5 2001-000027 R-CARBON 100ohm,5%,1/4W,AA,TP,2.4x6.4mm
R603 267.3 114.5 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R604 184.5 18.8 2001-000111 R-CARBON 150ohm,5%,1/4W,AA,TP,2.4x6.4mm
R605 172 9 2004-001060 R-METAL 51Kohm,1%,1/4W,AA,TP,2.4x6.4mm
R606 195.5 12.5 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R607 175 9 2001-000889 REF-CF,6.8K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R609 178 9 2004-004095 R-METAL 2.36Kohm,1%,1/4W,AA,TP,2.4x6.4
R611 174.5 87 2003-000006 R-METAL OXIDE 47ohm,5%,1W,AA,TP,4.3x12mm
R612 250.5 10 2003-000741 REF-MO,56K,5%,3W(S 500V,-200 TO +200PPM/C,RE-R
R613 164 56 2001-000432 R-CARBON 1Mohm,5%,1/4W,AA,TP,2.4x6.4mm
R614 284.8 14 2001-000642 REF-CF,330K,5%,1/2W 350V,-600 TO -150PPM/C,R-AX
R615 247.5 53.5 2001-000374 R-CARBON 15ohm,5%,1/4W,AA,TP,2.4x6.4mm
R616 266 68.3 2003-000771 REF-MO,68K,5%,2W(S 500V,-200 TO +200PPM/C,R-AX
R617 34.5 175 2001-000987 REF-CF,820K,5%,1/4W 250V,-1000 TO -500PPM/C,R-A
R618 258.5 40.5 2003-000010 REF-MO,8.2K,5%,3W(S 350V,-350 TO +350PPM/C,R-AX
R619 39 187 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R620 204 92 2003-000432 R-METAL OXIDE(S) 1.5Kohm,5%,3W,AA,TP,6x16mm
R621 150 78 2001-000056 REF-CF,4.7K,5%,1/6W 150V,-1300 TO +350PPM/C,R-A
R622 163 52.8 2003-000631 R-METAL OXIDE(S) 3.3ohm,5%,3W,AA,TP,6x16mm 15”
2003-000005 R-METAL OXIDE(S) 1ohm,5%,2W,AA,TP,4x12mm 14”
R623 222 76.5 2001-001163 R-CARBON(S) 560ohm,5%,1/2W,AA,TP,2.4x6.4mm
R624 144 71.5 2001-000077 R-CARBON 47Kohm,5%,1/6W,AA,TP,1.8x3.2mm
R625 151 74 2001-000043 REF-CF,1K,5%,1/6W 150V,-1300 TO +350PPM,R-AXI
R626 195.5 15 2001-000106 R-CARBON 1.5Kohm,5%,1/6W,AA,TP,1.8x3.2m
R628 181.5 39.5 2001-000019 R-CARBON(S) 10ohm,5%,1/2W,AA,TP,2.4x6.4mm
RL601 286.3 85 3501-000266 RELAY-POWER 12V,720m/W,5A,2FormA,3mS
RL602 290 106 3501-000136 RELAY-MINIATURE 12V,360mW,5A,1FormA,10mS,10mS
SK101 305.3 159 4715-000001 SURGE ABSORBER 1KV,+50-10%
SK102 281.5 171.3 4715-000106 SURGE ABSORBER 300V,CHIP
SK103 295 178.5 3704-001015 SOCKET-CRT 8P,15.24PI,25.6PI,SN
SW201 7 189.5 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW202 7 175.5 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW203 7 161.5 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW204 7 20 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW205 7 104.4 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW206 7 90.4 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW207 7 76.4 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW208 7 62.4 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
!
!
!
10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-15
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

SW209 7 120.2 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW210 7 131.7 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW211 7 147.5 3404-000244 SWITCH-TACT,7.3X7.1X4 12V,50MA,SPST,160G,MECH
SW401 86.5 237 3406-000002 SWITCH-TOGGLE,SP3T ON-ON-ON,STRAIGHT
T401 95 187.5 BH26-30336A TRANS-HOR.DRIVE 9.6MH,6P,EE2017,SB-5S,9.6MH/10
T501 188 181 BH26-10335A TRANS-FBT 1.22mH,12P,FKD-15A001
T601 217.5 26.5 BH26-20335T TRANS-POWER 430uH,16P,EER3541,PL-3/PM-2,7.
T602 214.5 79 BH26-30302S TRANS-SYNC,250UH C/MONITOR,CVL 4951
TCO 172 242 BH39-40305U JUMPER-WIRE JUMPER-WIRE
TH601 263.5 95.5 1404-000002 THERMISTOR-NTC NTC,9OHM,20%
TH602 272.5 77 1404-001020 THERMISTOR-NTC 8ohm,15%,17mW/C,BK
TILT 175.3 242 BH39-40305U JUMPER-WIRE JUMPER-WIRE
VR101B 322.8 141 2103-000007 vr3 1/10W
VR101G 322.8 149.5 2103-000007 vr3 1/10W
VR101R 322.8 158 2103-000007 vr3 1/10W
VR102B 322.8 182.5 2103-000291 vr3 1/10W
VR102G 322.8 201.5 2103-000291 vr3 1/10W
VR102R 322.8 221.5 2103-000291 vr3 1/10W
VR401 228.3 236.8 2103-000005 vr3 1/10W
VR501 193 237 2103-000005 vr3 1/10W
X201 47.5 43.5 2801-003033 CRYSTAL-UNIT 4MHz,30ppm,28-AAM,20pF,100ohm
!
!
!
10 PCB Diagrams and Electrical Parts List
10-16 CKA42*7L/5227L
Loc. No. Coordinates (X,Y) New Code No. Description Specification Remarks

10 PCB Diagrams and Electrical Parts List
CKA42*7L/5227L 10-17
C622 2401-000038 C-AL 470UF,20%,25V,GP,TP,10X12.5
CN604 3722-001100 JACK-DIN 4P/2C,6MM,AG,BLK
D612 0402-000005 DIODE-RECTIFIER 31DF4,400V,3A,DO-201AD
Loc. No. Code No. Description Specification Remarks
C212 2401-000023 C-AL,ELEC,50V,1UF 1UF,20%,50V,GP,TP,5X11,5MM
C312 2305-000001 C-FRLM,MPEF 470NF,10%,63V,TP,6.0X15.5X7.5MM
CN303 3711-000024 CONNECTOR-HEADER BOX,3P,1R,2.5MM,STRAIGHT
IC302 1201-001034 IC-AMPLIFIER 272,DIP,8P,150MIL,DUAL,PLAST
JP207 BH39-40305U JUMPER-WIRE JUMPER-WIRE
R216 2001-000067 R-CF,10K,5%,1/6W 10KOHM,5%,1/6W,AA,TP,1.8X3.2MM
R316 2001-000075 R-CF,39K,5%,1/6W 39KOHM,5%,1/6W,AA,TP,1.8X3.2MM
R317 2001-000067 R-CF,10K,5%,1/6W 10KOHM,5%,1/6W,AA,TP,1.8X3.2MM
R318 2001-000043 R-CF,1K,5%,1/6W 1KOHM,5%,1/6W,AA,TP,1.8X3.2MM
R319 2001-000064 R-CF,7.5K,5%,1/6W 7.5KOHM,5%,1/6W,AA,TP,1.8X3.2MM
R320 2003-000807 R-MO,82,5%,2W 5.6KOHM,2%,1/8W,AD,TP,1.8X3.2MM
R321 2001-000083 R-CF,82K,5%,1/6W 82KOHM,5%,1/6W,AA,TP,1.8X3.2MM
Loc. No. Code No. Description Specification Remarks
10-1-4 USB OPTION
CN606 3711-000178 CONNECTOR-HEADER 1WALL,2P,1R,3.96mm,STRAIGHT,SN
JP203 BH39-40305U JUMPER-WIRE JUMPER-WIRE
RL601 3501-000266 RELAY-POWER 12V,720mV,5A,2formA,8mS,3mS
Loc. No. Code No. Description Specification Remarks
10-1-5 TCO OPTION
10-1-6 TILT OPTION